2003 Audi A4 Avant

2003 Audi A4 Avant 4-DR. w/SAB

Overall

Not Rated

Front Crash

Not Rated

Side Crash

Not Rated

Rollover

Not Rated

ENGINE AND ENGINE COOLING:ENGINE

The Gates Corporation (Gates) is recalling certain aftermarket Tru-Flow Water Pumps, part number TFW 41127, sold at certain NAPA Auto Parts and/or installed by automotive service technicians after November 1, 2013 (and manufactured August 2013 through October 2013) that have a black-colored pulley/sprocket or do not have 'US9377' stamped on the water pump housing. These service replacement parts were sold for use in model year 1999-2005 Audi A4, 2000-2006 Audi TT, 1998-2005 Volkswagen Beetle, 1999-2006 Golf, 1999-2008 and 2011-2013 Volkswagen Jetta, and 2000-2005 Volkswagen Passat. In the affected water pumps, the pulley or sprocket that turns the timing belt may develop microfractures causing the timing belt to fail.

Campaign: 14E007000

EXTERIOR LIGHTING:HEADLIGHTS

ON CERTAIN PASSENGER VEHICLES, THERE IS A POSSIBILITY OF XENON HEADLAMP COATING DEGRADATION OVER TIME. THE LUMINOUS TRANSMITTANCE OF THE HEADLAMP MAY DECREASE OVER A PERIOD OF TIME.

Campaign: 05V096000

FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

ON CERTAIN VEHICLES EQUIPPED WITH 1.8L TURBO, 2.8L V6, OR 3.0L ENGINES, A CHANGE IN THE ELECTRICAL MOTOR COMPONENTS IN THE FUEL PUMP CAN LEAD TO AN INOPERATIVE FUEL PUMP AND, ULTIMATELY, STOPPAGE OF FUEL SUPPLY TO THE ENGINE CAUSING IT TO STALL.

Campaign: 07V375000

FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

ON CERTAIN VEHICLES PRODUCED FROM SEPTEMBER 2002 - MARCH 2003, EQUIPPED WITH 1.8L TURBO, 2.8L V6, OR 3.0L ENGINES, A CHANGE IN THE ELECTRICAL MOTOR COMPONENTS IN THE FUEL PUMP CAN LEAD TO AN INOPERATIVE FUEL PUMP AND, ULTIMATELY, STOPPAGE OF FUEL SUPPLY TO THE ENGINE CAUSING IT TO STALL.

Campaign: 06V017000

ENGINE

Crank case ventilation hose breaks and engine runs poorly part#06C103235B

ELECTRICAL SYSTEM,EXTERIOR LIGHTING,AIR BAGS

Water pump failed inside lights sometimes work and signal lights aren’t accurate

ELECTRICAL SYSTEM

Radio intermediate goes out hitting bumps speedometer stopped working the number ninth digit is not pulling up when I search vehicle information Replaced engine vehicle only had 20,000 miles

ENGINE AND ENGINE COOLING

The contact owns a 2003 Audi A4. The contact stated while driving 65 MPH, the vehicle decelerated, lost motive power and stalled without warning. The contact stated that the vehicle failed to restart and there was steam coming from the vehicle. The vehicle was towed to the residence where an independent mechanic diagnosed the vehicle and determined that the vehicle had experienced a similar failure to NHTSA Campaign Number: 14E007000 (Engine and Engine Cooling). The vehicle was not repaired. The dealer was contacted and notified of the failure. The manufacturer was contacted and stated that the VIN was necessary to check for recalls. The failure mileage was 100,000. The VIN was not available.

ELECTRICAL SYSTEM

Left turn signal works fine. Right turn signal alternates between flashing left and right.

FUEL SYSTEM, GASOLINE

The contact owns a 2003 Audi A4. The contact stated that while driving at an undisclosed speed, a fuel odor was detected. The contact parked the vehicle and noticed there was fuel leaking on the rear driver's side. The vehicle was taken to the dealer and diagnosed that the fuel pump flange and hoses needed to be replaced. The vehicle was not repaired and remained at the dealer. The manufacturer was made aware of the failure and informed the contact that they would cover the part replacement. The failure mileage was 143,839.

ELECTRICAL SYSTEM,ENGINE,FUEL/PROPULSION SYSTEM

The coolant light came on after I replaced coil packs and I stopped to look wasn't leaking anywhere. Drove to work and it caught on fire due to overheating I guess not really sure. I was driving a car on fire down a highway and didn't even know it. I stopped to take a left turn into work and smoke stared billowing out and around the entire car. Other drivers couldn't see me or nothing I could have been in an accident. The fire department checked the car out sort of and it's in a mechanics shop now. Trying to figure it out. Oil light was on and that's it. AN then the coolant light would kick on and off. Nothing else after I changed the coil packs. And it was well after I did that.

POWER TRAIN

2003 AUDI A4 3.0 CABRIOLET CONVERTIBLE STARTED SHIFTING ROUGH AND HESITANT AND SHUT OFF, CRANKED BACK UP WENT INTO LIMP MODE AND ALL THE SHIFTING GEAR LIGHTS CAME ON R N D 2 , BARELY MADE IT BACK HOME, PUT CODE READER ON CAR HAD A LOT OF CODES ON IT I RESET CODES BUT RND2 LIGHTS STILL ON , POSSIBLE BAD TCM?

ELECTRICAL SYSTEM,ELECTRONIC STABILITY CONTROL (ESC)

INITIALLY DROVE CAR HOME FROM GROCERY STORE HIT A BUMP AND NOTICED A SPARK COMING FROM FRONT DRIVER'S SIDE OF CAR. PULLED OVER AND CHECKED FOR SPARK EVIDENT ONCE STOPPED THERE WAS NO SIGN OF SPARK OR ANYTHING. GOT CAR HOME AND PARKED ABOUT AN HOUR LATER MY CAR WAS ON FIRE, AFTER PUTTING THE FIRE OUT MY HUSBAND LIFTED THE HOOD AND TRIED TO INVESTIGATE THE ISSUE WHEN HE DISCOVERED THE BATTERY WAS MELTED TO THE HOOD AND IS WHERE THE FIRE INITIALLY CAUGHT. THE LOCATION OF THE BATTERY WE BELIEVE TO BE THE ISSUE AND WANTED TO MAKE SURE TO REPORT IT IMMEDIATELY. *TR

POWER TRAIN

TRANSMISSION CONTROL MODULE TRANSMISSION SLIPS OUT OF DRIVE WHILE DRIVING INTO LIKE NEUTRAL AND WHEN I ACCELERATE THE CAR DOES NOT MOVE AND COMES TO A FULL STOP AND I HAVE TO STOP AND TURN THE CAR ON AND OFF TILL IT WORKS AGAIN