2004 Audi A6 Avant

2004 Audi A6Avant 4-DR. w/SAB

Overall

Not Rated

Front Crash

Not Rated

Side Crash

Not Rated

Rollover

Not Rated

FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY

VOLKSWAGEN IS RECALLING CERTAIN MODEL YEAR 2001-2004 AUDI A6, MODEL YEAR 2002-2003 S6 AND MODEL YEAR 2003 RS6 VEHICLES EQUIPPED WITH 4.2L ENGINES AND MANUFACTURED FROM JUNE 19, 2001, THROUGH JUNE 8, 2004. THE AGING OF THE PLASTIC MATERIAL IN THE FUEL TANK ROLLOVER VALVE COMBINED WITH BENDING STRESS FROM THE ALUMINUM VENTILATION LINE TO THE ROLLOVER VALVE NIPPLE MAY LEAD TO CRACKING OF THE NIPPLE. IF THIS HAPPENS, A FUEL LEAK MAY RESULT.

Campaign: 11V267000

FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY

VOLKSWAGEN IS RECALLING 68,240 MY 2001-2004 AUDI A6 QUATTRO VEHICLES EQUIPPED WITH 2.7L, 2.8L, OR 3.0L ENGINES AND MY 2001-2005 ALLROAD QUATTRO VEHICLES EQUIPPED WITH 2.7L OR 4.2L ENGINES. THE AGING OF THE PLASTIC MATERIAL IN THE FUEL TANK ROLLOVER VALVE COMBINED WITH BENDING STRESS FROM THE ALUMINUM VENTILATION LINE TO THE ROLLOVER VALVE NIPPLE MAY LEAD TO CRACKING OF THE NIPPLE. IF THIS HAPPENS, A FUEL LEAK MAY RESULT.

Campaign: 08V157000

ELECTRICAL SYSTEM

ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH HALOGEN LOW BEAM HEADLIGHTS, CERTAIN CONNECTOR PINS IN THE HEADLIGHT SWITCH CONNECTOR COME INTO CONTACT WITH EACH OTHER CAUSING A SHORT CIRCUIT. NOTE: VEHICLES WITH XENON LOW BEAM HEADLIGHTS ARE NOT AFFECTED BECAUSE THE CIRCUIT IN THESE VEHICLES CONTAINS A FUSE, WHICH PRECLUDES EXCESSIVE CURRENT FLOW IN THE CASE OF A SHORT CIRCUIT. AUDI S6 AND S6 AVANT VEHICLES ARE ALL EQUIPPED WITH XENON LOW BEAM HEADLIGHTS AND, THEREFORE, ARE NOT LONGER AFFECTED BY THIS RECALL.

Campaign: 06V198000

ELECTRICAL SYSTEM

ON CERTAIN PASSENGER VEHICLES, IF A DRIVER'S KNEES PUSH AGAINST THE KNEE BOLSTER (CRASH ELEMENT) LOCATED UNDER THE DASHBOARD, IT CAN CONTACT THE HEADLIGHT SWITCH WIRING HARNESS, AND AN ELECTRICAL SHORT COULD OCCUR.

Campaign: 04V133000

SERVICE BRAKES,FORWARD COLLISION AVOIDANCE

- ABS Module has intermittent failures, available for inspection - Anti-lock brakes will not work - Yes, the problem reoccurs and the module loses power and then errors out - Others - VCDS - ABS lights come on and BRAKE light stays illuminated

FUEL/PROPULSION SYSTEM

RE: SAFETY RECALL 20L8/JY; 08V157000: FUEL TANK ROLLOVER VALVE MODIFICATION; VIN: (XX); 2004 AUDI A6 3.0L QUATTRO AT5 ATTACHED DOCS: 1. 20L8/JY RECALL NOTICE. 2. 7.14.2008 & 11.18.18 AUDI N. SCOTTSDALE, AZ DEALER INVOICES 3. AUDI A6 GAS TANK DIAGRAM. AUDI CORP EMAIL RESPONSE: "AT THIS TIME WE HAVE IDENTIFIED THAT THE 20L8 REPAIR WAS SPECIFIC TO THE DRIVER'S SIDE OF THE VEHICLE. THE DEALERSHIP IS INDICATING THIS CURRENT RECOMMENDED REPAIR IS SPECIFIC TO THE PASSENGER SIDE OF THE VEHICLE." "SINCE WE ARE SHOWING THE 20L8 COMPLETED IN JULY OF 2008 AND THE ORIGINAL 20L8 REPAIR IS SPECIFIC TO DRIVER'S SIDE ROLLOVER NIPPLE VALVES, ACCORDING TO THE DEALERSHIP THIS CURRENT REPAIR IS UNRELATED TO THE RECALL." "CURRENTLY PER THE NHTSA WEBSITE, THE 20L8 IS NOT SHOWING AS AN OPEN RECALL, SO I WOULD BE UNABLE TO SPEAK TO HOW THEY WOULD REACT TO INFORMATION REGARDING A CLOSED RECALL." 'WE HAVE NO EVIDENCE SUPPORTING AN INCORRECT REPAIR BEING PERFORMED IN JULY OF 2008, SO AT THIS TIME WE WOULD BE UNABLE TO PROVIDE ASSISTANCE TOWARDS THIS REPAIR." CURRENT EMISSIONS CHECK ENGINE LIGHT (NOV 18, 2018) IS DIAGNOSED BY THE AUDI DEALER AS A GAS TANK LEAK. ALSO, THERE IS A STRONG ODOR COMING FROM GAS TANK. DEALER QUOTED TO REPLACE THE ENTIRE TANK (SEE ATTACHED #2). THERE ARE SEVERAL ROLLOVER VALVES ON EACH SIDE OF THE GAS TANK ON THE TOP SIDE (SEE ATTACHED #3 GAS TANK DIAGRAM). RECALL (SEE ATTACHED #1) DOES NOT ADDRESS "DRIVERS SIDE OR PASSENGER SIDE" OF GAS TANK. DEALER CLAIMED THAT BACK IN 2008 THAT THEY DID NOT EVEN LOWER THE GAS TANK FOR THE REPAIR. IN SUMMARY: MY VEHICLE CURRENTLY HAS A GAS TANK LEAK ON TOP OF THE GAS TANK COMING FROM THE ONE OR MORE ROLLOVER VALVE NIPPLES ON TOP OF THE GAS TANK. THE SAFETY RECALL ADDRESSES REPAIRING AND REINFORCING THESE LEAKING ROLLOVER VALVE NIPPLES SO A REPAIR REQUEST SHOULD BE COVERED BY THE RECALL. PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

ELECTRICAL SYSTEM

AFTERMARKET RADIO: PIONEER ELECTRONICS AVH-4100 NEX BACKUP CAMERA FAILS AND DISTRACTS DRIVER SIGNIFICANTLY. I HAVE ATTACHED A SCAN OF THE COMPLAINT TO PIONEER ELECTRONICS. THE RADIO LIKELY HAS SOFTWARE DEFECT THAT CAUSES VERY DISTRACTING FAILURES WHEN OPERATING THE BACK-UP CAMERA. PIONEER ADVERTISES THAT THIS BACKUP CAMERA WORKS AS ADVERTISED - IT IS ACTUALLY NOW A DISTRACTION AND HAZARD. AS WELL, OPERATING GOOGLE "ANDROID AUTO" CAUSES MORE SIGNIFICANT DRIVING DISTRACTIONS WHEN USING THE BACKUP CAMERA FUNCTION OF THE AVH-4100. COMPLAINTS TO PIONEER ELECTRONICS HAVE BEEN FRUITLESS. THEY SEEM TO BE ARROGANT AND CLAIM: "ALL OF OUR PRODUCTS ARE THOROUGHLY TESTED." I WOULD LIKE PIONEER ELECTRONICS TO FIX THE SOFTWARE ISSUE AND CREATE A NEW RELEASE THAT ALLOWS THE BACKUP CAMERA TO WORK WITHOUT A DISTRACTION AND SAFTY-HAZARD.

FUEL/PROPULSION SYSTEM

WHEN ENGINE IS COLD, USUALLY BELOW 0 DEGREES FUEL SPRAYS FROM INJECTORS. THIS COULD IGNITE ON EXHAUST MANIFOLDS CAUSING CAR FIRE.

ENGINE

TL* THE CONTACT OWNED A 2004 AUDI A6. WHILE DRIVING AT 20 MPH, SMOKE APPEARED FROM THE ENGINE COMPARTMENT AND THE VEHICLE CAUGHT FIRE. A POLICE REPORT WAS FILED AND THERE WERE NO INJURIES REPORTED. THE VEHICLE WAS DESTROYED. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 06V198000 (ELECTRICAL SYSTEM). THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 103,000.

ELECTRONIC STABILITY CONTROL (ESC),SERVICE BRAKES

WITH THE ELEC STABILITY CONTROL BEING INTERMITTENT THIS IS BEING CAUSED BY THE ABS MODULE GOING BAD/INTERMITTENT THE BRAKE PEDAL PRESSURE CHANGES. I HAVE EXPERIENCED THIS WITH MY 2002 RAM 1500 (4X4) AS WELL. THIS COULD BE A PROBLEM IN ALL CARS AND TRUCKS. THE COST THE FIX FOR AN AUDI IS AROUND $2500.00 AND MY RAM WAS $1300.00. *TR

FUEL/PROPULSION SYSTEM

TL*THE CONTACT OWNS A 2004 AUDI A6. THE CONTACT STATED THAT WHILE STARTING THE VEHICLE, A STRONG ODOR OF GASOLINE EMITTED INSIDE AND AROUND THE VEHICLE. THE CONTACT MENTIONED THAT THE CHECK ENGINE LIGHT ILLUMINATED. THE FAILURE RECURRED SEVERAL TIMES. THE VEHICLE WAS TAKEN TO THE DEALER, WHERE IT WAS DIAGNOSED THAT THE FUEL TANK COLLAPSE AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 146,569.

VEHICLE SPEED CONTROL,ELECTRONIC STABILITY CONTROL (ESC)

THE FIRST THROTTLE VALVE MALFUNCTION HAPPENED ON JULY 2013. COST TO REPAIR 1557.95 PART COST 878.00 MILEAGE 66784 THE SECOND MALFUNCTION HAPPENED ON OCT. 14, 2014 TO REPAIR 1200.00 PART COST 913.00, MILEAGE 69202 WHAT HAPPENS HERE IS THE ENGINE SHUTS DOWN. THERE COULD HAVE BEEN E MAJOR ACCIDENT IF SHE WAS REAR ENDED. I CALLED AUDI TO TELL THEM THE PART WAS DEFECTIVE, BUT THEY WOULD NOT LISTEN. THAT IS WHY I THINK THERE SHOULD BE A RECALL, TO SEND THEM A MESSAGE. *TR

FUEL SYSTEM, GASOLINE,EQUIPMENT

SIGNIFICANT GAS LEAK CAUSED BY BROKEN GAS "IN TANK SENDING UNITS" HOUSING AND SEAL. GAS WILL LEAK AND FILL THE INSIDE OF THE CAR WITH FUMS AS WELL AS UNDER THE CAR. REPLACEMENT REQUIRED BUYING A REVISED DESIGN SENDING UNITS THAT INCLUDE ALL THREE SENDING UNITS. THE PRICE IS HIGH ~$500 AND THE CONSEQUENCES VERY DANGEROUS. MY CAR IS: 2004 AUDI A6 [XXX] 2004 A6Q 2.7T INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

ELECTRICAL SYSTEM

TL* THE CONTACT OWNS A 2004 AUDI A6. THE CONTACT STATED THAT WHILE DRIVING 65 MPH, THAT THERE WAS A FAILURE IN THE ELECTRIC HARNESS UNDER THE PASSENGER SEAT. THE CONTACT STATED THAT HE NOTICED A BURNING ODOR AND THEN THE POWER FAILED TO MOVE THE SEAT. UPON FURTHER REVIEW, THE CONTACT DISCOVERED THAT THE CARPET UNDER THE SEAT WAS SINGED AND HAD MELTED SOME PLASTIC UNDER THE SEAT. THE VEHICLE WAS TAKEN TO THE CONTACT'S PERSONAL MECHANIC WHERE HE WAS INFORMED THAT THE VEHICLE POSED A SAFETY HAZARD AND SHOULD NOT BE DRIVEN. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER: 04V133000 (ELECTRICAL SYSTEM) AND CONTACTED THE DEALER AND THE MANUFACTURER TO INQUIRE OF THE RECALL CAMPAIGN. THE DEALER AND THE MANUFACTURER BOTH ADVISED THE CONTACT THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL CAMPAIGN. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGES WERE 94,648 UPDATED 6/1/12 *CN THE CAUSE OF THE FIRE WAS THE SHORTING OF THE SEAT HARNESS WIRING UNDER THE PASSENGER CARPETING FROM MOVEMENT AND THERE WAS A BEND/ KINK IN THE HARNESS WHEN ASSEMBLED AND THERE WAS SUB DAMAGE TO ADJACENT WIRE HARNESS. UPDATED 06/22/12