2003 Audi Allroad

2003 Audi Allroad w/SAB

Overall

Not Rated

Front Crash

Not Rated

Side Crash

Not Rated

Rollover

Not Rated

FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY

VOLKSWAGEN IS RECALLING 68,240 MY 2001-2004 AUDI A6 QUATTRO VEHICLES EQUIPPED WITH 2.7L, 2.8L, OR 3.0L ENGINES AND MY 2001-2005 ALLROAD QUATTRO VEHICLES EQUIPPED WITH 2.7L OR 4.2L ENGINES. THE AGING OF THE PLASTIC MATERIAL IN THE FUEL TANK ROLLOVER VALVE COMBINED WITH BENDING STRESS FROM THE ALUMINUM VENTILATION LINE TO THE ROLLOVER VALVE NIPPLE MAY LEAD TO CRACKING OF THE NIPPLE. IF THIS HAPPENS, A FUEL LEAK MAY RESULT.

Campaign: 08V157000

ELECTRICAL SYSTEM

ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH HALOGEN LOW BEAM HEADLIGHTS, CERTAIN CONNECTOR PINS IN THE HEADLIGHT SWITCH CONNECTOR COME INTO CONTACT WITH EACH OTHER CAUSING A SHORT CIRCUIT. NOTE: VEHICLES WITH XENON LOW BEAM HEADLIGHTS ARE NOT AFFECTED BECAUSE THE CIRCUIT IN THESE VEHICLES CONTAINS A FUSE, WHICH PRECLUDES EXCESSIVE CURRENT FLOW IN THE CASE OF A SHORT CIRCUIT. AUDI S6 AND S6 AVANT VEHICLES ARE ALL EQUIPPED WITH XENON LOW BEAM HEADLIGHTS AND, THEREFORE, ARE NOT LONGER AFFECTED BY THIS RECALL.

Campaign: 06V198000

ELECTRICAL SYSTEM

ON CERTAIN PASSENGER VEHICLES, IF A DRIVER'S KNEES PUSH AGAINST THE KNEE BOLSTER (CRASH ELEMENT) LOCATED UNDER THE DASHBOARD, IT CAN CONTACT THE HEADLIGHT SWITCH WIRING HARNESS, AND AN ELECTRICAL SHORT COULD OCCUR.

Campaign: 04V133000

POWER TRAIN,ELECTRICAL SYSTEM,STRUCTURE

During recent heavy rains, all of a sudden the car's transmission that had been working fine, after having been parked briefly pointing slightly down hill, no longer functioned properly, and had apparently gone into "LIMP Mode". after talking with Mechanics and doing research, we checked the carpet areas and determined and documented the car's interior was very wet, both in front and in the rear areas, with evident moisture and corrosion under the battery and cabin air filter areas and rear wheel well area. The Transmission no longer shifts properly and the car is not able to be safely driven. Apparently there is a well known design flaw in the Audi C5 A6 vehicles where multiple drains frequently fail. apparently there are 2 very hard to access drains under the battery, under the battery tray, and also the cabin air filter seal to the sidewall is prone to failure. I'm told that there is a "soft" NTSB Audi Recall on this. Please advise.

POWER TRAIN

please see prior form submission re transmission...please confirm receipt of earlier entry.

FUEL/PROPULSION SYSTEM

THE GAS TANK OR COMPONENTS OF THE TANK ARE LEAKING GAS WHEN MORE THAN A SMALL AMOUNT OF GAS IS PUT INTO THE TANK. GAS LEAKS ALL OVER THE GROUND FROM THE TANK AND THE CABIN FILLS WITH GAS FUMES. MY 18 SON HAS BEEN DRIVING THIS CAR AND I WILL NOT ALLOW HIM OR ANYONE ELSE TO DRIVE THE CAR NOW. AFTER READING ONLINE THAT MANY PEOPLE HAVE THIS SAME PROBLEM, I AM SHOCKED THAT THIS IS NOT A RECALL WHEN IT COULD BE POTENTIALLY LIFE THREATENING AND THAT AUDI WANTS TO CHARGE 3K TO LOWER THE TANK AND REPAIR.

AIR BAGS

TL* THE CONTACT OWNS A 2003 AUDI ALLROAD. THE CONTACT STATED THAT THE AIR BAG WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED WITH NEEDING CLOCK SPRING TO BE REPLACED. THE VEHICLE WAS REPAIRED HOWEVER, THE FAILURE PERSISTED. THE MANUFACTURER WAS NOT INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 135,000.

ENGINE

TL* THE CONTACT OWNS A 2003 AUDI A6. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT STATED THAT THE FAILURE OCCURRED MULTIPLE TIMES. THE VEHICLE WAS TAKEN TO AN UNKNOWN DEALER AND THE CRANKSHAFT SENSOR WAS REPLACED, BUT THE FAILURE PERSISTED. THE VEHICLE WAS NOT TAKEN BACK TO A DEALER FOR DIAGNOSTIC TESTING OR REPAIRS. THE MANUFACTURER WAS CONTACTED, BUT WAS UNABLE TO ASSIST. THE FAILURE MILEAGE WAS 149,000.

ENGINE

TL* TAKATA RECALL. THE CONTACT OWNS A 2003 AUDI A6. THE CONTACT STATED WHILE DRIVING AT VARIOUS SPEEDS ON THE HIGHWAY, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. A DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOT CONTACTED AND MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 149,000. THE VIN WAS NOT AVAILABLE.

FUEL/PROPULSION SYSTEM

CHECK ENGINE LIGHT ON, VEHICLE WILL NOT PASS EMISSIONS TESTING. AUDI DETERMINED THAT IT WAS DUE TO A FUEL LEAK FROM A CRACK IN THE PASSENGER SIDE REAR ROLLOVER VALVE. VEHICLE HAD BEEN RECALLED IN PAST FOR SIMILAR ISSUE (PERFORMED). TANK HAS 4 ROLLOVER VALVES, ONLY ONE (FRONT DRIVER) INCLUDED IN PRIOR RECALL. INITIAL QUOTED $3,300 TO REPLACE TANK. AUDI OFFERED TO PAY FOR REPLACEMENT TANK WITH THE EXCEPTION OF ~$600 (REPAIR ORDER ATTACHED). REPAIR COMPLETED ON 2/23/2017, CAR PASSES STATE INSPECTION. AS YOU CAN SEE BY THE "STAINING" IN THE ATTACHED PHOTO, THE LEAK WAS SIGNIFICANT DEALER THEN CALLS TO SAY THAT CAR NEEDS TO BE RETURNED TO PERFORM PRIOR RECALL ON THE NEWLY INSTALLED TANK. RECALL TO BE PERFORMED ON ONLY THE ONE ROLLOVER VALVE (DRIVER FRONT) THAT CAN BE ACCESSED WITH OUT REMOVING FUEL TANK. NOT THE VALVE THAT WAS LEAKING AND NECESSITATED THE REPLACEMENT. I REQUESTED THAT AUDI PERFORM RECALL ON ALL 4 ROLLOVER VALVES AS THEY INSTALLED A KNOWINGLY DEFECTIVE PART AND THE RISK OF ANOTHER CRACK/LEAK EXISTS. DEALER SAYS AUDI REFUSES. I HAVE MADE SEVERAL CALLS TO BOTH DEALER AND AUDI WITH NO RESPONSE FROM AUDI BEYOND A CONVERSATION WITH CUSTOMER SERVICE. CHECK ENGINE LIGHT BACK ON 5/08/2017. EMAILED DEALER ON 5/11/2017 (ATTACHED PDF) WITH MY REQUEST (AGAIN), AND HAVE RECEIVED NO CONTACT FROM AUDI. RETURNING CAR TO DEALER FOR RECALL ON THE ONE ROLLOVER VALVE ON 7/12/17. AUDI IS PUTTING THIS CAR BACK ON THE ROAD WITH THE STRONG POTENTIAL OF A FUEL LEAK.

STEERING,SUSPENSION

I WAS DRIVING IN LIGHT RAIN AND SAW A SMALL PUDDLE OF WATER AHEAD SO I SLOWED DOWN AND WENT THROUGH IT AT 10MPH, ALL OF THE SUDDEN MY STEERING WHEEL LOCKS UP AND IS STUCK GOING RIGHT, GRINDING NOISE CAME FROM THE FRONT DRIVERS WHEEL. I SOMEHOW MANAGED TO GET THE VEHICAL TO A FIRE STATION AND PARK IT THERE AFTER 30M AND ONLY GOING 20FT THEN ALL OF A SUDDEN WHILE I'M PRESSING THE GAS PEDDLE THE HORRIBLE GRINDING NOISE COMES BACK AND THE CAR GOES NO WHERE IN DRIVE OR REVERSE.

UNKNOWN OR OTHER

SUNROOF EXPLODED WHILE TRAVELING ON THE FREEWAY.

FUEL/PROPULSION SYSTEM

TL* THE CONTACT OWNS A 2003 AUDI A6. WHILE THE VEHICLE WAS PARKED, THE CONTACT NOTICED A PUDDLE OF FUEL IN THE DRIVEWAY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE ROLLOVER VALVE HAD A CRACK, CAUSING THE FUEL TANK TO LEAK. THE VEHICLE WAS REPAIRED PER A RECALL, BUT THE FAILURE RECURRED. THE VEHICLE WAS NOT REPAIRED AGAIN. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE RECALL INFORMATION WAS NOT PROVIDED. THE FAILURE MILEAGE WAS APPROXIMATELY 180,000.