2002 Audi S4 Avant

2002 Audi S4 Avant 4-DR. w/SAB

Overall

Not Rated

Front Crash

Not Rated

Side Crash

Not Rated

Rollover

Not Rated

AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2000-2001 Audi TT Coupe, TT Roadster, 2000-2002 A4, and S4 vehicles equipped with Non-Azide Driver Air Bag Inflators (NADI) that do not contain phase stabilized ammonium nitrate (PSAN) propellant. Due to a manufacturing issue, the NADI inflators may absorb moisture, possibly causing the air bag to deploy improperly in the event of a crash.

Campaign: 21V470000

ELECTRICAL SYSTEM

TL*THE CONTACT OWN A 2002 AUDI S4. THE CENTER INSTRUMENT PANEL DISPLAY INTERMITTENTLY FAILED TO ILLUMINATE. WHEN THE FAILURE OCCURRED HALF OF THE DISPLAY WAS WELL LIT WHILE THE OTHER HALF WAS NOT. OCCASIONALLY THERE WAS ALSO AN ODOR SIMILAR TO ELECTRICAL SMOKE. THE DEALER WAS NOT NOTIFIED OF THE FAILURE SINCE THE LIGHTS ON THE INSTRUMENT PANEL DO NOT REMAIN ILLUMINATED. THE DRIVER STATED THAT A CABLE MAY BE DISCONNECTED WITHIN THE INSTRUMENT PANEL WHICH MAY BE A COMMON PROBLEM. THE FAILURE HAS OCCURRED INTERMITTENTLY FOR ONE YEAR. THE FAILURE MILEAGE WAS 85,000.

ELECTRICAL SYSTEM

TL*THE CONTACT OWNS A 2002 AUDI S4. THE CONTACT STATED THAT THE LCD SCREEN ON THE INSTRUMENT PANEL HAS LINES RUNNING THROUGH THE SCREEN, WHICH PREVENT HIM FROM VIEWING THE INFORMATION. HE HAS NOT YET TAKEN THE VEHICLE TO THE DEALER. THE FAILURE MILEAGE WAS 57,000. UPDATED 5/5/09 *CN UPDATED 05/07/09.*JB

ELECTRICAL SYSTEM

TL*THE CONTACT OWNS A 2002 AUDI S4. WHILE DRIVING APPROXIMATELY 45 MPH ON NORMAL ROAD CONDITIONS, THE INSTRUMENT PANEL DISPLAYED MISSING AND FADED PIXELS, AS WELL AS INCOMPLETE INFORMATION ABOUT THE VEHICLE. THE FAILURE OCCURRED WITHOUT WARNING. THE VEHICLE HAS NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS 60,000 AND CURRENT MILEAGE WAS 120,000.

ELECTRICAL SYSTEM

INSTRUMENT CLUSTER ON MY 2002 AUDI S4 HAS FAILED. WITHOUT THIS DISPLAY, THE POTENTIAL FOR A HAZARDOUS SITUATION INCREASES DUE TO NOT BEING ABLE TO READ THE ERRORS WHICH WOULD NORMALLY BE DISPLAYED. I AM AWARE OF THIS BEING A VERY COMMON FAULTY PART AND WOULD RECOMMEND LOOKING INTO A RECALL. *TR

ELECTRICAL SYSTEM,EQUIPMENT

I BOUGHT MY CAR WITH 36,XXX MILES ON IT. THE CENTER LCD SCREEN DOES NOT WORK. THE CAR IS PRACTICALLY BRAND NEW AND THE CENTER CLUSTER INFORMATION CENTER IS BUSTED. ITS BARELY READABLE, BUT DISPLAY IMPORTANT USER DIAGNOSTIC/INFO ABOUT THE CAR (SERVICE LIGHTS, ETC). THIS IS UNACCEPTABLE AND I WOULD LIKE TO PROMPT A RECALL. IT'S A 2002 AUDI S4, 2.7T THE PREVIOUS OWNER COMPLAINED TO ME WHEN I BOUGHT THE CAR THAT IT NEVER WORKED FOR HIM EITHER. (HE OWNED CAR FOR NEARLY 2 YEARS+). *TR

ELECTRICAL SYSTEM

1. PURCHASED A 2002 AUDI S4 2.7T. 2. THE AUTO CHECK SYSTEM IN THE INSTRUMENT CLUSTER DOES NOT WORK ESPECIALLY WHEN WARM. THE LCD RIBBON CABLE LOOSES CONTACT AND DOESN'T DISPLAY THE INFORMATION IT SHOULD. CRITICAL SAFETY INFORMATION IS NO LONGER DISPLAYED. 3. WAS QUOTED OBSCENE AMOUNTS BY AUDI DEALERS TO REPLACE ENTIRE INSTRUMENT CLUSTER. $250 FOR A USED CLUSTER THAT WOULD NEED THE ODOMETER ADJUSTED FOR AN ADDITIONAL FEE. *TR

ELECTRICAL SYSTEM

TL*THE CONTACT OWNS A 2002 AUDI S4. THE CONTACT STATED THAT THE LED DISPLAY ON THE INSTRUMENT PANEL IS NOT WORKING PROPERLY AND IMPAIRS VISIBILITY. THE DEALER STATED THAT THE DISPLAY NEEDED TO BE REPLACED. THE VEHICLE HAS NOT BEEN REPAIRED AND THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 47,000 AND CURRENT MILEAGE WAS 47,500.

ELECTRICAL SYSTEM

DASHBOARD INSTRUMENT CLUSTER LED DISPLAY IS BURNING OUT. *JB

SERVICE BRAKES, HYDRAULIC

THE BRAKES BOOST/VACUUM ASSIST LINE CHECK VALVE CRACKS APART INTO TWO PIECES. THIS CAUSES THE TOTAL LOSS OF THE POWER ASSISTED BRAKE SYSTEM IN THE CAR AND SUBSEQUENTLY MAKES IT VERY HARD TO STOP THE VEHICLE. THERE IS NO WARNING ABOUT THE PENDING LOSS OF BRAKES. ONE SECOND YOU HAVE BRAKES THE NEXT IT FEELS LIKE YOU ARE TRYING TO PUSH A BRICK THRU THE FLOOR OF THE VEHICLE TRYING TO GET IT TO STOP. *NM

ENGINE AND ENGINE COOLING

CAM COVER OIL LEAKS DISCOVERED AFTER 50,000 MILE SERVICE AT APPROX 48,500 MILES 11/7/05. AUDI TSB 05-03, NOV. 2, 2005 COVERING 2000-2006 MODELS A4, CABRIOLET, TT, A6, S4, ALLROAD, A8, S8, AND RS6 WITH ENGINES 1.8T, 2.8 V6, 2.7 V6T, AND 4.2 V8 STATES THAT IF A CUSTOMER COMPLAINS AND THE AREA IS WET WITH FLUID RESIDUE OR DROPLETS THAT ARE NOT COMING OFF, TO CLEAN THE OIL STAINED AREA AND TELL THE CUSTOMER THAT IT COULD BE THE RESULT OF SPILLAGE WHEN TOPPING OFF OR NORMAL GASKET "SWEATING" AND IS NOT INDICATION OF A MALFUNCTION. IF FOUND AND NO CUSTOMER COMPLAINT, NO ACTION IS TO BE TAKEN. IF FOUND AND ONLY IF A CUSTOMER COMPLAINS, THEN REPLACE GASKETS AND LEAK TEST THE ENGINE. THIS IS AN UNACCEPTABLE POLICY OF HIDING BY LACK OF DISCLOSURE, THE LEAK AND UNFAIRLY SHIFTING THE COST OF A MANUFACTURING OR DESIGN DEFECT TO THE CUSTOMER. AUDI NEEDS TO BE HELD ACCOUNTABLE AND FORCED TO COVER THESE LEAKS FOR AN EXTENDED PERIOD OF TIME AND NOTIFY OWNERS TO BRING THEIR CARS IN FOR INSPECTION AND REPAIR. *JB