2002 Chevrolet Astro

RECENTLY I TOOK MY VAN TO A DEALER BECAUSE THE KNOB ON THE A/C FAN MELTED OFF IT COST 600 DLRS IN REPAIRS THE HVAC KNOB HAD MELTED OFF ALSO THE CONNECTOR AND RESISTOR HAD BURNED OUT . THE ENTIRE WIRING HARNESS WAS MELTED TOGETHER. NO FUSE BLEW TO PREVENT HIS FORM HAPPENING WE ARE NOT SURE WHAT CAUSED THIS TO OCCUR. MY CONCERN IS THAT THIS COULD HAVE CAUSED A FIRE IN THE DASH WHILE I WAS DRIVING RESULTING IN SEVERE INJURY ACCIDENT OR EVEN DEATH. PLEASE CONTACT ME IF THERE WAS A RECALL I MISSED OR IF THERE IS ANY INFORMATION AS TO WHY THIS HAPPENED. THANK YOU FOR YOUR TIME CONCERN CHEVY OWNER. *TR

Incident Jul 5, 2012

ABS WAS ACTIVATED AT SLOW SPEEDS CAUSING A SUBSTANTIAL DROP IN BRAKING POWER. *TR

Incident Jul 28, 2012

TL* THE CONTACT OWNS A 2002 CHEVROLET ASTRO VAN. THE CONTACT STATED WHEN THE VEHICLE WAS SHIFTED INTO PARK SHE NOTICED THERE WAS SMOKE AND FIRE BEHIND THE STEERING WHEEL. THERE WAS ALSO A MINOR EXPLOSION. THE FIRE DEPARTMENT WAS NOTIFIED AND STATED THAT AN ELECTRICAL WIRE STARTED THE FIRE. A REPORT WAS FILED AND THE FAILURE WAS NOT DIAGNOSED NOR TOWED FROM THE CONTACTS RESIDENCE. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE AND THE CURRENT MILEAGE WAS 170,000. UPDATED 8/23/12

Incident May 6, 2012

ABS COMING ON AT VERY LOW SPEEDS ON DRY PAVEMENT (UNDER 5MPH/8KMH). IT DOESN'T DO IT EVERY TIME, BUT QUITE OFTEN AT LOW SPEEDS, LIKE COMING TO A RED LIGHT, STOP SIGN OR PARKING. OF COURSE, THERE IS NO NEED FOR THE ABS COME ON AT SUCH LOW SPEEDS AND ESPECIALLY NOT ON DRY PAVEMENT. *TR

Incident Oct 13, 2011

TL* THE CONTACT OWNS A 2002 CHEVROLET ASTRO. THE CONTACT STATED THAT THE FRONT BRAKE LINES WERE RUSTED. THE ABS UNIT WAS NOT WORKING PROPERLY AND THE REAR BRAKES HAD ALREADY FAILED. THE VEHICLE WAS NOT INSPECTED BY THE DEALER BUT WAS REPAIRED BY THE CONTACT. THE CURRENT MILEAGE WAS 79,000 AND THE FAILURE MILEAGE WAS UNKNOWN.

Incident Oct 13, 2011

I HAVE A 02'CHEVY IMPALA WHEN I TURN IT ON ALL ELECTRIC COMES ON AND THE ENGINE RUNS FOR A SPLIT SECOND AND DIES THEN THE BATTERY LIGHT AND SERVICE TRACTION SYSTEM COMES ON I GOT THE FUEL PUMP AND SENSOR REPLACED STILL THE SAME PROBLEM OCCURS. I WAS ABLE TO DRIVE IT FOR A FEW MILES AFTER READING THE MANUAL AND PUSHING THE GAS TO THE FLOOR WHILE HOLDING THE KEYS ON FOR THREE SECONDS BUT EVENTUALLY IT DIED AGAIN. PLEASE HELP!!!!! *TR

Incident Sep 4, 2010

THIS IS A GENERAL POINT OF INFORMATION MESSAGE: FOR THE LAST DECADE OR MORE, GM VEHICLES HAVE A PROPENSITY TO BURN OUT THEIR LAMPS DUE TO AN OVERCHARGE CONDITION (CAUSE UNKNOWN TO ME); THIS CONDITION CAN AFFECT ANY OF THE LAMPS OR BULBS, MOST NOTICABLY HEADLAMPS, TAIL LIGHTS, AND RUNNING (PARKING) LAMPS. COULD YOU PLEASE INVESTIGATE THIS ELECTRICAL DEFECT IN ALL GM VEHICLES.*TR

Incident May 19, 2010

TL* THE CONTACT OWNS A 2002 CHEVROLET ASTRO VAN. WHEN DRIVING AT LOW SPEEDS THE ANTI-LOCK BRAKING SYSTEM WOULD ACTIVATE WITHOUT WARNING, INCREASING THE VEHICLE'S STOPPING DISTANCE. THE VEHICLE HAS NOT BEEN DIAGNOSED BY THE DEALER. THE CURRENT AND FAILURE MILEAGES WERE 76,000. UPDATED 5/12/10 *CN UPDATED 06/18/10.*JB

Incident Feb 1, 2010

TL*THE CONTACT OWNS A 2002 CHEVROLET ASTRO VAN. THE CONTACT STATED THAT WHILE DRIVING IN RESERVE AT APPROXIMATELY 5 MPH, THE BRAKES AND THE POWER STEERING MALFUNCTIONED. THE VEHICLE WAS TOWED TO A LOCAL MECHANIC. THE MECHANIC COULD NOT REMEDY THE PROBLEM. THE CONTACT STATED THAT THE VEHICLE WAS UNSAFE TO DRIVE. THE FAILURE MILEAGE WAS 25,000.

Incident Jan 10, 2009

TL*THE CONTACT OWNS A 2002 CHEVROLET ASTRO VAN. WHILE DRIVING 30 TO 35 MPH, THE VEHICLE BEGAN ACCELERATING ON ITS OWN. THE VEHICLE WOULD NOT SLOW DOWN BY APPLYING THE BRAKES WHICH FORCED THE CONTACT TO SHIFT GEARS INTO NEUTRAL AND THEN INTO THIRD GEAR. WITHIN A FEW MINUTES, THE CONTACT WAS ABLE TO SLOW DOWN THE VEHICLE ENGAGING THE BRAKE PEDAL AND SHUT THE ENGINE OFF. THE CONTACT WAS INFORMED TO ENGAGE THE ACCELERATOR PEDAL TO LOOSEN THE THROTTLE; HOWEVER, WHEN HE RESTARTED THE VEHICLE THE RPM'S INCREASED RAPIDLY. THE POLICE HELPED THE CONTACT PUSH THE VEHICLE ONTO THE EMERGENCY LANE. THE VEHICLE WAS TOWED TO THE DEALER. THE DEALER STATED THAT THE RAPID ACCELERATION WAS DUE TO A FRAYED ACCELERATOR CABLE. THE DEALER REPLACED THE ACCELERATOR CABLE AND ADJUSTED THE IDLE AND THROTTLE PLATE. THE VEHICLE IS DRIVING NORMALLY. THE CONTACT REQUESTED THE PARTS FROM THE DEALER WHO STATED THAT THEY WERE NOT LONGER AVAILABLE. THE CONTACT IS CONCERNED ABOUT THE SAFETY RISK SINCE A CRASH COULD HAVE OCCURRED. THE FAILURE MILEAGE WAS 172,777.

Incident Jan 13, 2010

HAZARD LIGHTS STOP WORKING AND CAUSES THE TRAILER LIGHTS NOT TO WORK( NO LEFT TURN, RIGHT TURN OR BRAKES TO TRAILER HARNESS). SIGNALS AND BRAKES ON VAN WORKS OKAY BUT NO HAZARDS. *TR

Incident Mar 31, 2009

TL. CONTACT OWNS A 2002 CHEVY ASTRO VAN. CURRENT MILEAGE WAS 97,000 AND FAILURE MILEAGE WERE 50,000. CONTACT STATED UPON PURCHASING THE VEHICLE FROM ENTERPRISE CAR RENTAL THE BRAKES HAVE BEEN BAD. CONTACT STATED THAT THE VEHICLE HAS BEEN IN THE SHOP OVER 20 TIME MOST OF THE TIME FOR THE BRAKES. CONTACT HAS CRASH THE DUE TO THE BRAKES ON THE VEHICLE. CONTACT FEELS THATTHE VEHICLE WAS A LEMON UPON PURCHASE AND DOES NOT FEEL THIS VEHICLE SHOULD BE ON THE ROAD. JO

Incident May 22, 2005

2002 CHEVY ASTRO VAN IDLER ARM PULLED THROUGH THE FRAME OF THE FRONT RIGHT PORTION RESULTING IN PARTIAL STEERING FAILURE ON FEBRUARY 1, 2009. UPON INSPECTION BY HALLEEN CHEVROLET SERVICE DEPARTMENT IT WAS DETERMINED THAT NOT ONLY HAD THE FRONT RIGHT IDLER ARM BROKEN THROUGH THE FRAME BUT THE FRONT LEFT IDLER ARM WAS ALSO IN DANGER OF BREAKING THROUGH. THIS WOULD RESULT IN COMPLETE STEERING FAILURE. THE SERVICE DEPARTMENT AT THE DEALERSHIP DETERMINED THAT THE VEHICLE NEEDED A COMPLETE FRAME REPLACEMENT. *TR

Incident Feb 1, 2009

BACK DOOR HANDLE BROKE OFF THE VAN CANNOT GET IN THE BACK OF THE 2002 ASTRO VAN. *TR

Incident Dec 17, 2007

ON MARCH 26, 2008, I TOOK MY 2002 CHEVY ASTRO VAN TO BE SERVICED. MILEAGE 93,829,I HAD NO BRAKES. THE MASTER CYLINDER WAS DETERMINED TO BE THE CAUSE OF THE FAILURE AND WAS REPLACED. ON APRIL 12, 2008, ONCE AGAIN I HAD NO BRAKES, THIS TIME IT RESULTED IN ME GETTING INTO AND ACCIDENT. I TOOK THE VAN BACK TO THE SAME REPAIR SHOP. WHEN THEY PUT IT ON THE LIFT THEY SAID THE WHOLE BRAKING SYSTEM WAS MELTED UNTIL THE POINT OF THE HOSE BURSTING. HE SAID HE NEVER SAW ANYTHING LIKE THIS IN HIS 20 YEARS OF SERVICE. THEY DID NOT WANT TO TOUCH IT STATING IT WAS NOW A LIABILITY TO THEM AND DIRECTED ME TO CHEVY. CHEVY CONCURRED, FOUR DIFFERENT PEOPLE SAID THEY HAVE NEVER SEEN OR HAVE A CLUE AT WHAT CAUSED THIS. THEY CALLED IN GM, WHO ALSO NEVER HAD SEEN THIS, BUT BOUNCED THE BLAME ON A QUESTIONABLY INSTALLED MASTER CYLINDER. CHEVY SAID THEY CAN REPLACE THE WHOLE BRAKING SYSTEM BECAUSE THEY DO NOT KNOW WHAT IS WRONG, BUT SINCE THEY DO NOT KNOW WHAT CAUSED THIS OR WHY FUSES DIDN'T BLOW TO PREVENT IT, IT COULD HAPPEN AGAIN. WE HIRED OUR OWN CAR CONSULTANT TO LOOK AT THE VAN, HE TOO HAS NEVER SEEN OR HEARD OF ANYTHING LIKE THIS. THE HEAT AND MELTED BRAKE LINES RAN CLOSER THAN 1/4 INCH AWAY FROM THE GAS TANK. I DO NOT WANT TO TAKE THE RISK OF DRIVING AGAIN WITH MY CHILDREN AND LOOSING BRAKES OR POSSIBLY IGNITING THE GAS TANK. *TR

Incident Apr 12, 2006

TL*THE CONTACT OWNS A 2002 CHEVROLET ASTRO. WHILE THE VEHICLE WAS UNDERGOING A ROUTINE INSPECTION, THE CONTACT WAS INFORMED THAT HIS EXTERIOR LIGHTING/BRAKE LIGHT SWITCHES WERE INOPERATIVE. HE CALLED THE DEALER IN REFERENCE TO NHTSA CAMPAIGN ID NUMBER 05V099000 (EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH). THE DEALER STATED THAT HIS VIN WAS NOT INCLUDED IN THE RECALL ALTHOUGH THE FAILURES WERE IDENTICAL. THE CONTACT WOULD BE RESPONSIBLE FOR THE REPAIR COSTS. THE MANUFACTURER DID NOT PROVIDE ANY ASSISTANCE. THE FAILURE AND CURRENT MILEAGES WERE 70,000.

Incident Jun 5, 2008

DRIVING ON 3 LANE INTERSTATE AT 70 MPH WHEN TRANSMISSION FAILED(SUN GEAR SHELL IN 4L60E TRANSMISSION). EARLY AM WITH LITTLE TRAFFIC SO WAS ABLE TO COAST TO SHOULDER SAFELY. TOWED TO EXIT. HAD TO REPLACE TRANSMISSION VERY LUCKY THAT TRAFFIC WAS LIGHT AS ALL DRIVE POWER WAS LOST. *TR

Incident Oct 5, 2005

4L60E TRANSMISSION SUN GEAR ON 2002 CHEVY ASTRO FAILED WITHOUT WARNING, SHRED EVERYTHING IN TRANSMISSION. TRANSMISSION SHOP SAYS GM KNEW PART WAS FAULTY BUT DID NOT ISSUE ANY RECALLS. THERE WERE NO NOTICEABLE SYMPTOMS PRIOR TO FAILING. FLUID WAS FLUSHED AND CHANGED LESS THAT A YEAR BEFORE. *TR

Incident Feb 12, 2008

I PURCHASED MY 2002 CHEVROLET IMPALA LS IN DECEMBER, 2004. GREAT LOOKING VEHICLE WITH NUMEROUS PROBLEMS. THE MOST RECENT AND SEVERE HAS COME OVER THE LAST FEW DAYS. WHILE ACCELERATING ON AN ENTRANCE RAMP, THE CAR WILL NOT SHIFT PROPERLY; VERY ROUGH AND THE RPM'S GO TO 4000 OR ABOVE BEFORE SHIFTING OR IF I LET OFF THE ACCELERATOR. I AM TERRIFIED THAT THE TRANSMISSION IS GOING TO COME OUT COMPLETELY WHILE DRIVING WITH MY FAMILY IN THE VEHICLE; I AM TAKING THE CAR TO A MECHANIC TO HAVE IT LOOKED AT. I HAVE ALSO BEEN RESEARCHING OTHER COMPLAINTS ABOUT THE CAR, AND TO MY HORROR, I AM EXPERIENCING MUCH OF THE SAME AS OTHER CONSUMERS. HOW CAN SO MANY COMPLAINTS BE ISSUED ABOUT THE SAME VEHICLE AND GENERAL MOTORS NOT FIXING THE PROBLEMS?? *TR

Incident Nov 20, 2007

OPERATED THE VAN FOR 30 MINUTES. PARKED IT IN A GARAGE AND SHUTOFF ENGINE. TEN MINUTES LATER THE GARAGE SMOKE ALARM SOUNDED. THE VAN HAD FILLED THE GARAGE FULL OF SMOKE. OPENED THE DOOR AND ATTEMPTED TO RESTART THE ENGINE TO REMOVE FROM GARAGE. DISPLAY REPORTED AN ASSORTMENT OF WARNINGS AND ENGINE STARTER FAILED TO ACTIVATE. OPENED HOOD TO DISCOVER FLAMES COMING FROM THE UNDERSIDE ON THE ENGINE. CALLED FOR FIRE DEPARTMENT AND MADE FIRST ATTEMPT TO USE A FIRE EXTINGUISHER TO STOP FLAMES FROM THE ENGINE COMPARTMENT, WAS UNSUCCESSFUL. WENT UNDER THE VAN'S DRIVER-SIDE AND COULD NOW SEE THE SOURCE OF FIRE. EXTINGUISHED THE FIRE, THEN IT SHORTLY ERUPTED AGAIN. EXTINGUISHED AGAIN. PLACED THE KEY INTO THE STEERING COLUMN TO MOVE TRANSMISSION TO NEUTRAL, SO THAT I COULD PUSH THE VEHICLE OUT OF THE GARAGE. SPARKS IMMEDIATELY FLEW FROM THE DRIVER-SIDE UNDERSIDE AND RE-IGNITED THE FIRE. THE TRANSMISSION LEVER WAS NO LONGER ENGAGED TO THE TRANSMISSION (CONTROL WAS LIMP) AND THE KEY SEIZED IN THE COLUMN. WENT UNDERNEATH THE VEHICLE TO EXTINGUISH THE FIRE A THIRD TIME. AFTER THIS I REMOVED THE POSITIVE POWER LEAD FROM THE BATTERY TO STOP ANY FURTHER ELECTRICAL SHORTS. FIRE SUBSIDED. FIRE DEPARTMENT ARRIVED AND ORDERED A WRECKER TO DRAG THE VEHICLE FROM THE GARAGE FOR SAFETY OF THE HOUSE. AT THIS TIME IT WAS DISCOVERED THAT THE FIRE HAD ALSO DESTROYED THE EMERGENCY BRAKE SYSTEM. THE PARKING BRAKE WAS SEIZED IN THE OFF POSITION. CHEVROLET DEALERSHIP REPAIR ORDER STATES AS FOLLOWS: "APPEARS EBCM SHORTED AND CAUGHT FIRE BURNING A HOLE THROUGH THE BRAKE LINE. PARKING BRAKE CABLE. SHIFTER CABLE AND WIRING HARNESS." THE EBCM FIRE NOT ONLY CAUSED THE LOSS OF NORMAL BRAKING OPERATION, THE POOR LOCATION OF UNIT AND SUBSEQUENT FIRE IT STARTED DESTROYED THE EMERGENCY BRAKING SYSTEM AND SEVERED THE CONTROLS TO THE TRANSMISSION. THIS LEAVES A DRIVER WITH A COMPLETE LOSS OF BRAKING FUNCTIONS AND NO MEANS TO SLOW THE VEHICLE THROUGH DOWN SHIFTING THE TRANSMISSION. $6000 OF DAMAGE. *JB

Incident Aug 13, 2007

VEHICLE HAS REPEATEDLY STARTING RUNNING POORLY AND HAS A LACK OF POWER ALONG WITH A MISFIRE. VEHICLE IS THEN HARD TO ACCELERATE AND SLOWS DOWN FLOW OF TRAFFIC. EACH TIME THE DISTRIBUTOR CAP AND ROTOR HAVE BEEN FOUND WITH EXCESSIVE AMOUNT OF CORROSION ON THEM AND WHEN THE CAP & ROTOR ARE REPLACED THE PROBLEM GOES AWAY FOR A WHILE. THE CAP & ROTOR WERE CHANGED 3 TIMES EACH BEFORE 50,000 MILES. *JB

Incident Jan 3, 2006

TL*THE CONTACT OWNS A 2002 CHEVROLET ASTRO. THE CONTACT STATED THAT THE FRONT SEAT BELTS DO NOT WORK AT ALL. HE STATED THAT THE SEAT BELTS EXTEND AROUND HIS BODY, BUT FALL TO FASTEN. DURING SUDDEN STOPS, THE SEAT BELT WOULD EXTEND UNTIL IT RAN OUT OF SLACK, BUT FAILED TO PROVIDE ADEQUATE RESTRAINT. GENERAL MOTORS ACKNOWLEDGED THE FAILURE AND STATED THAT THE COST FOR THE REPAIR WOULD BE $200. THE SPEED WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 95,300. UPDATED 01/07/08. *LJ UPDATED 12/12/07

Incident Aug 24, 2007

I HAVE OWNED 3 ASTRO VANS, ?89 AND 92 (MADE IN USA) PREVIOUSLY AND LIKED THEM SO WELL I BOUT ANOTHER ONE 2002 (MADE IN MEXICO). WITHIN 60,000 MILES REAR SEAT FABRIC STARTED TO COME APART, DRIVER DOOR POWER WINDOWS AND LOCKS STOPPED WORKING, WINDSHIELD WASHER HOSES ROTTED, INTERIOR FAN BLOWER SWITCH FAILED (TWICE), DRIVER ARM REST VINYL SPLITTING IN MANY AREAS, STEERING WHEEL MOUNTED HAZARD LIGHT SWITCH CAUSED BREAK AND SIGNAL LIGHTS TO BLOW FUSES (THIS WAS FIXED AS RECALL), REAR CARGO DOOR HANDLE BROKE OFF, FUEL TANK GAS LEVEL INDICATOR FLUCTUATES REGARDLESS OF FUEL LEVEL, ANTILOCK BREAKS ENGAGE UNNECESSARILY AT LOW SPEED SOFT BRAKING, WINDSHIELD LEAKAGE, SIDE DOOR DIFFICULT TO CLOSE AND SOMETIMES CAN NOT BE CLOSED. ALMOST ALL ITEM APPEARED AFTER WARRANTY WAS UP. I WILL NEVER BUY ANOTHER GM PRODUCT AGAIN. *AK

Incident Jan 1, 2005

THE 2002 CHEVROLET TAHOE HAS FAILED INSPECTION BECAUSE OF THE EMERGENCY BRAKE.. IT WAS COMPLETELY USELESS. IT DIDN'T WORK. WHY I DON'T KNOW, BUT THE INSPECTION PLACE STATED THAT THEY HAD FAILED NUMEROUS TAHOES WITH THE SAME PROBLEM. I FELT THAT IT WAS UNSAFE AND CHEVROLET SHOULD RECALL THE FEW THAT HAVE THIS PROBLEM. WHY DID IT HAVE TO BE AN INNOCENT PARTY CONCERNING SEVERAL DEATHS OR THOUSANDS OF PEOPLE REPORTING IT BEFORE IT IS RECALLED. I DIDN''T EVEN USE THE BRAKE HOW COULD IT NOT WORK ANYMORE.

Incident Jun 1, 2007

HIGH SPEED CAR ACCIDENT ON 1/3/07 DRIVER SEAT BELT DID NOT WORK CORRECTLY, BELT DID NOT LOCK UPON HARD BRAKING OR UPON CAR CRASH I HIT MY CHEST ON STEERING WHEEL AND MY KNEES ON DASHBOARD, MY AIRBAG DID NOT DEPLOY EITHER. *JB

Incident Jan 3, 2007

2002 MALIBU. TURN SIGNAL/HAZARD FLASHER FAILURE. *NM

Incident Aug 1, 2006

DT*: THE CONTACT STATED WHILE APPLYING BRAKE PRESSURE AT VARIOUS LOW SPEEDS, THERE WAS AN INCREASED STOPPING DISTANCE, AND THE ANTILOCK BRAKES ACTIVATED WITHOUT WARNING. THERE WAS A NHTSA RECALL, # 05V379000, REGARDING THE ANTILOCK BRAKES. THE VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO THE VIN. THE DEALER AND MANUFACTURER WERE ALERTED. UPDATED 12/15/2006 - THE DEALER TOLD THE CONSUMER THAT THE ASTRO WAS BUILD ON THE SAME FRAME AS THE SILVERADO WHICH WAS BEING RECALLED. *NM

Incident Nov 29, 2006

LOW COOLANT LIGHT ON MY 2002 CHEVY MALIBU HAS BEEN COMING ON. THE CHEVY DEALER CHECKED THE LOW COOLANT LIGHT COMING ON, CHECKED FOR LOW COOLANT. FOUND INTAKE MANIFOLD GASKET LEAKING INTERNALLY. COOLANT MIXING WITH OIL. *NM

Incident Dec 23, 2005

RE 2002 CHEVY TAHOE TRANSMISSION PROBLEMS: UP UNTIL THE 34,000 MILE RANGE THE VEHICLE DID JUST THAT, RUN FLAWLESSLY. HOWEVER, AT 34,000 MILES (NOVEMBER OF 2004) THE TRANSMISSION WENT OUT. MY WIFE WAS DRIVING TO WORK AND NEEDED TO ACCELERATE TO MERGE ONTO THE FREEWAY AND INSTANTLY THE TRANSMISSION BEGAN TO WHINE AND STOPPED OPERATING WHICH PLACED HER INTO THE PATH OF A LARGE TRUCK BEARING DOWN ON HER RATHER QUICKLY. THANKFULLY SHE WAS ABLE TO GLIDE OUT OF THE PATH OF THE TRUCK TO THE SIDE OF THE ROAD. WE HAD THE TAHOE TOWED BACK TO OUR DEALERSHIP AND WE DETERMINED THAT THE TRANSMISSION "SUN SHELL" HAD FAILED AND WOULD BE REPLACED. OUR DEALER ASSURED US THAT THIS WOULD SOLVE THE PROBLEM, BECAUSE THE NEW PARTS WERE DESIGNED TO PREVENT THIS FROM OCCURRING IN THE FUTURE. OUR DEALER FURTHER STATED THAT THEY HAVE BEEN REPAIRING A LARGE NUMBER OF VEHICLES WITH THESE FAILURES. OUR TAHOE WENT OFF OF IT'S NEW CAR WARRANTY ON MILEAGE NOT NUMBER OF MONTHS SOMETIME IN APRIL OF 2005 (36 MONTHS WOULD HAVE ENDED THIS AUGUST). JUST THIS PAST MONDAY (SEPTEMBER 19, 2005) MY WIFE WAS AGAIN ON HER WAY TO WORK WHEN AGAIN THE TRANSMISSION FAILED IN OUR 2002 TAHOE. THE MILEAGE WAS APPROX: 41,000 ( TOTAL PERIOD OF MILES AND THE LENGTH OF TIME FROM THE PREVIOUS FAILURE WAS APPROX: 7 MONTHS). THE CIRCUMSTANCES WERE THE SAME, SHE WAS ACCELERATING TO MERGE ONTO THE FREEWAY AND AGAIN THE TRANSMISSION BEGAN TO WHINE AND SLIP. THIS TIME SHE WAS ABLE TO CONTINUE DRIVING TO THE SIDE OF THE ROAD AND RELATIVE SAFETY. WE HAD THE VEHICLE TOWED BACK TO OUR DEALERSHIP AND AGAIN THE DEALER ADVISED THAT THE "SUN SHELL" HAD FAILED. I WENT TO PICK UP THE CAR ON FRIDAY SEPTEMBER 23, 2005 AND WHILE I WAS AT THE DEALERSHIP THE MECHANIC SHOWED ME THE DAMAGED PART AND A BENCH THAT CONTAINED SEVERAL DAMAGED "SUN SHELL". IT OBVIOUSLY DOES NOT TAKE MUCH EFFORT TO REALIZE THAT THERE IS A DESIGN FLAW WITH THIS PARTICULAR TRANSMISSION AND SPECIFICALLY THIS PART. *JB

Incident Sep 19, 2005

DT: 2002 CHEVROLET IMPALA LS. THE CONSUMER STATED CAR DEVELOPED A SPORADIC FAILURE OF TURN SIGNALS. THIS HAS BEEN HAPPENING FOR ABOUT 3 WEEKS. INVOLVED LEFT AND RIGHT TURN SIGNALS. THE CONSUMER CONTACTED CHEVROLET, THEY TOLD THE CONSUMER TO CONTACT THE DEALER, IMPERIAL CHEVROLET. HOWEVER, THE DEALER TOLD THE CONSUMER SHE WOULD HAVE TO PAY $46.00 JUST TO LOOK AT CAR. THE CONSUMER STATED THAT AN ARTICLE IN LOCAL NEWSPAPER STATED THERE HAS BEEN A TREND OF FAULTY IGNITION SWITCHES IN THIS MODEL VEHICLE. WHEN THE CONSUMER CALLED IMPERIAL CHEVROLET THEY STATED THEY WERE WELL AWARE OF THE PROBLEM WITH THE FAULTY IGNITION SWITCHES. *AK

Incident Sep 1, 2005

I BEGAN HAVING A SITUATION WHERE MY ANTI-LOCK BRAKE SYSTEM WOULD ACTIVATE AT SLOW SPEEDS <10 MPH SUCH AS WHEN PULLING INTO A PARKING SPACE - THIS RESULTS IN THE VEHICLE GOING FORWARD FARTHER THAN IT NORMALLY WOULD - PLEASE NOTE THAT I DID NOT HAVE ANY ACCIDENTS. I TOOK IT TO THE DEALER WHICH INDICATED THAT IT WAS A COMMON PROBLEM AND THEY MAY BE ABLE TO CLEAN THE SENSORS OF CORROSION (THEY DID NOTE THAT THE SENSORS ARE LIGHTLY BUILT AND COULD BREAK REQUIRING REPLACEMENT DURING THE CLEANING PROCESS - WHICH THEY DID). I VOICED MY CONCERN TO GM VIA THERE CUSTOMER SERVICE SYSTEM THAT THIS FAILURE OCCURRED AT 42000 MILES ON A SAFETY RELATED SYSTEM (3 YEARS FROM IN SERVICE DATE - 6000 MILES OUT OF WARRANT). I CLEARLY INDICATED THAT I FELT THIS WAS A FLAW ON WHAT I CONSIDER TO BE A CRITICAL COMPONENT. AS OF THIS POINT - 1 WEEK LATER - GM'S ONLY RESPONSE WAS THAT MY CONCERN WOULD BE MADE KNOWN TO THE MANAGEMENT OF THE COMPANY. NO ACTION TO INFORM ME OF THE RECALL THAT I HAVE RECENTLY READ ABOUT WAS MADE, NOR WAS ANY ACTION TO COVER THE APPROXIMATELY $500 BILL. NOTE THAT THE RECALL THAT HAS BEEN IN THE NEWS DID NOT MENTION CHEVY ASTROS WHICH MY VEHICLE IS - HOWEVER THE PROBLEM SOUNDS IDENTICAL AND MY VEHICLE IS A TRUCK BASED GM VEHICLE WITH ALL WHEEL DRIVE AND ANTILOCK BRAKES - SIMILIAR TO ALL THE MODELS MENTIONED IN THE RECALL. *NM

Incident Aug 26, 2005

A VERY UNNERVING CONDITION IS PRESENT IN OUR 2002 TAHOE. THERE IS A LOOSE/ UNSTABLE FEELING IN THE STEERING WHEN TURNING. MY MECHANIC SAID WE HAVE A WARPED CENTER STEERING SHAFT AND HE CAN NOT REPAIR AS THE PART IS BACK ORDERED BY TENS OF THOUSANDS NATIONWIDE (INDICATING A UNIVERSAL PROBLEM WITH THIS VEHICLE) I HAVE BEEN EXPECTING A RECALL BUT HAVE NOT SEEN ONE. GM HAS NOT REPLIED TO MY INQUIRY.

Incident Jan 1, 2005

THE CONSUMER'S ANTI-LOCK BRAKES DON'T WORK PROPERLY WHEN PULLING INTO A PARKING SPACE OR UNDER 10 MPH. THE CONSUMER HAD TO PUMP THE BRAKES IN ORDER TO GET VEHICLE TO STOP OR FOR WARNING BEFORE SLOWING DOWN. THE VEHICLE HAS ALL WHEEL DRIVE. THE CONSUMER PULLED FUSE FOR ANTI-LOCK BRAKE MANY TIMES, AND IT WORKED FINE WITHOUT THE FUSE. *AK *SB PULLING THE ANTI-LOCK BRAKE FUSE DEACTIVATED THE ANTI-LOCK BRAKES CAPABILITY. WITH THE ANTI-LOCK BRAKE FUSE IN, THE CONSUMER NEARLY RUNS INTO THE BACK OF VEHICLES WHEN STOPPING. THE CONSUMER STATED THAT THE INCIDENTS HAPPENS ONLY WHEN THE FUSE IS IN AND OCCURED THREE TIMES AT LOW SPEED FOR NO REASON.*SB *NM

Incident Oct 15, 2004

DC: HIS BRAKES DO NOT WORK CORRECTLY. WHEN YOU STOP THE ABS SYSTEM KICKS IN, THE PEDAL JERKS BACK AND FORTH. THE VEHICLE DOES NOT WANT TO STOP CORRECTLY. *AK

Incident Oct 1, 2004

DT: SHIFT INDICATOR WAS INDICATING THE WRONG GEAR. WHILE DRIVING THE ROAD THE INDICATOR WAS MOVING, BUT THE SHIFTER ITSELF. EVERY TIME I DROVE THE VEHICLE THIS HAPPENED. IT WAS TAKEN TO DEALER TO FIX AND STATED THERE WERE A LOT OF COMPLAINT. THIS OCCURRED ABOUT A MONTH AGO ANTILOCK BRAKES ARE APPLYING WHEN DRY. WHEN GOING ABOUT 3-4 MPH THE ANTILOCK BRAKES WILL ENGAGED. THIS PROBLEM WAS RANDOM. HAVE NOT TAKEN FOR REPAIRS. *NM

Incident May 5, 2005

WE BOUGHT OUR ASTRO VAN IN 2001, IT HAS BEEN IN THE SHOP ABOUT 22 OR 23 TIMES. MOST OF THEM MAJOR THINGS NEEDING TO BE FIXED OR REPLACED.*AK

Incident Oct 26, 2001

THE CONSUMER'S 2002 CHEVROLET ASTRO CAUGHT ON FIRE DUE TO A TIE ROD RUBBING AGAINST THE POSITIVE BATTERY CABLE. *NM *JB

Incident Feb 11, 2005

I ATTEMPTED TO MAKE A LEFT HAND TURN ACROSS TWO LANES OF ON COMING TRAFFIC (SPEED LIMIT 55 MPH). I PUSH DOWN ON THE ACCELERATOR, THE VAN MOVED INTO THE ON COMING TRAFFIC LANES AND THE ENGINE DIED. CARS HAD TO QUICKLY APPLY BREAKS TO AVOID HITTING MY VAN. IT TOOK ABOUT 20 SECONDS TO GET THE VAN STARTED AND OUT OF THE INTERSECTION. THE VAN WAS TOWED INTO COURTESY CHEVROLET AND THE DISTRIBUTOR CAP AND ROTATOR WERE REPLACE. I WAS TOLD EVERYTHING WAS CORRECTED. THIS WAS NOT THE CASE AS THE SAME PROBLEM HAPPENED TWO ADDITIONAL TIMES (OCTOBER 24, 2004 AND DECEMBER 16, 2004) WITH THE SAME TERRIFYING CONSEQUENCES WITH ON COMING TRAFFIC. I WAS FORTUNATE NOT TO BE KILLED OR KILL SOMEONE ELSE WITH THIS VEHICLE STALLING IN ON COMING TRAFFIC.*AK

Incident Jun 1, 2004

I ONLY DRIVE THIS 2002 CHEVROLET ASTRO VAN IN OUR SMALL TOWN BECAUSE I AM TERRIFIED TO DRIVE IT ON EXPRESSWAYS OR IN HEAVY TRAFFIC BECAUSE THE DISTRIBUTOR CAP COLLECTED MOISTURE AND THE ENGINE STOPPED IN HEAVY TRAFFIC ALMOST CAUSING TERRIBLE ACCIDENTS THREE TIMES IN THE PAST 8 MONTHS. LAST WEEK I DROVE THE VAN INTO TOWN. I KEEP A CLOSE WATCH ON ALL THE GAUGES BECAUSE OF THE PREVIOUS PROBLEMS. WHEN I LEFT THE HOUSE ALL THE GAUGES ON THE DASH WERE WORKING AND THE BATTERY WAS BETWEEN 12-14 VOLTS. I NOTICED WITHIN 5 MILES THE BATTERY VOLTS WERE DECREASING SO I HEADED FOR HOME. BY THE TIME I REACHED HOME (10 MILES ALL TOTAL), THE VOLT METER WAS IN THE RED ZONE, ALL THE GAUGES (EXCEPT FOR OIL PRESSURE) AND SPEEDOMETER WERE NOT WORKING AND, I BELIEVE, THE HEADLIGHTS WERE OUT. I PULLED THE VAN INTO THE DRIVE AND SHUT IT OFF. I HAD DIFFICULTY OPENING THE DOOR (POWER LOCKS) TO GET OUT. THE VAN WOULD NOT START AGAIN. THE VAN IS UNDER WARRANTY SO I CALLED COURTESY CHEVROLET WHO HAD THE VAN TOWED IN FOR SERVICE. THEY CALLED ME THE FOLLOWING MONDAY TO TELL ME THEY REPLACED THE ALTERNATOR, COMPUTER AND BATTERY AND THE VAN WAS READY BUT THEY HAD BROKEN THE RADIO AND WOULD REPLACE IT ON TUESDAY. I SAID FINE AND I WOULD PICK IT UP ON WEDNESDAY (FEBRUARY 9, 2005). COURTESY CHEVROLET CALLED ME ON TUESDAY AND TOLD ME NOT TO COME ON WEDNESDAY BECAUSE THE VOLTAGE PROBLEM WAS NOT CORRECTED AND THEY WOULD CALL ME WHEN THE VAN WAS READY. THEY CALLED ON FEBRUARY 10, 2005 TO SAY THE ALTERNATOR WAS BAD AND HAD BEEN REPLACED A SECOND TIME. *AK

Incident Feb 3, 2005

WHEN THE VEHICLE WAS STARTED IN THE MORNING, THE BRAKES MADE A GRINDING NOISE WHEN DEPRESSED. THE VEHICLE WAS SERVICED BY THE DEALERSHIP TWICE AND THEY REPLACED THE BRAKE DISC, ROTORS AND SHOES. WHILE DRIVING DOWN A HILL WITH THE BRAKE PEDAL DEPRESSED, THE BRAKE SYSTEM OVERHEATED, AND A BURNING ODOR FILLED THE CABIN OF THE VEHICLE. *AK THE BRAKES STARTED TO PULSATE AGAIN WHILE GOING DOWN A MOUNTAIN, A NOISE WAS HEARD COMING FROM THE DRIVELINE BETWEEN SHIFTS AND WAS UNABLE TO BE DUPLICATED, THE TRANSMISSION SLIPPED AND SHIFTED ERRATICALLY, THE ENGINE WOULD BREAK UP ON A SLIGHT ACCELERATION DUE TO THE DISTRIBUTOR CAP AND THE ROTOR BEING CORRODED. *SC *JB

Incident Sep 30, 2003