2005 Chevrolet Aveo

TL* THE CONTACT OWNS A 2005 CHEVROLET AVEO. WHILE DRIVING 25 MPH, THE VEHICLE STALLED WITHOUT WARNING. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO STATED THAT THE TIMING BELT, ENGINE, AND VALVES WERE MELTED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 53,000.

Incident Oct 1, 2016

AIR BAG FAULT INDICATOR HAS COME ON AND REMAINS ON. MECHANIC CAN NOT DIAGNOSE TO REPAIR. AIRBAGS ARE CRITICAL TO THE SAFETY OF PERSONS IN THIS SMALL LIGHTWEIGHT VEHICLE. NORMAL DRIVING, COMMUTER.

Incident Aug 19, 2016

TL* THE CONTACT OWNS A 2005 CHEVROLET AVEO. WHILE DRIVING APPROXIMATELY 60 MPH, THE VEHICLE EXPERIENCED A COMPLETE LOSS OF POWER. THE FAILURE OCCURRED WITHOUT WARNING. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 128,000.

Incident Jan 24, 2016

WHEN I WENT OUT TO START THE VEHICLE I HAD NO DASH BOARD LIGHTS. EVERY OTHER LIGHT SYSTEM WORKED BUT I COULD NOT SEE THE SPEEDOMETER OR THE TACHOMETER. ALL THE FUSES WERE INTACT. I THEN BOUGHT NEW BULBS FOR THE ENTIRE GAGE CLUSTER AND THEY STILL ARE NOT FUNCTIONING. I HAVE LOOKED UP THIS PROBLEM ON MULTIPLE FORUMS AND THIS IS A VERY COMMON ISSUE WITHOUT A SOLUTION OTHER THAN "RIGGING" THIS SYSTEM! THIS IS UNACCEPTABLE PRACTICE TO ALLOW THIS TO GO ON WITHOUT SOME SORT OF RECALL OR REPLACEMENT PART AVAILABLE!

Incident Sep 15, 2015

TL* THE CONTACT OWNS A 2005 CHEVROLET AVEO. WHILE REVERSING, A GRINDING NOISE WAS HEARD COMING FROM THE REAR BRAKES. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO DISCOVERED THAT THE REAR BRAKES WERE RUSTED AND CORRODED. THE BRAKES WERE REPLACED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 100,000. MA 10/21/15 THE CONSUMER STATED THE REAR BRAKES LOCKED UP. THEY WERE NOT GETTING ANY LUBRICANT. UPDATED 01/15/16.*JB

Incident Dec 17, 2014

TL* THE CONTACT OWNS A 2005 CHEVROLET AVEO. THE CONTACT STATED THAT THE DAYTIME RUNNING LIGHTS FAILED. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V261000 (EXTERIOR LIGHTING). THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS REPAIRED UNDER THE RECALL REMEDY HOWEVER IT FAILED TO REPAIR THE VEHICLE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 70,000.

Incident Sep 1, 2011

TL* THE CONTACT OWNS A 2005 CHEVROLET AVEO. WHILE DRIVING AT AN UNKNOWN SPEED, THE INTERIOR LIGHTING AND HEADLIGHTS SUDDENLY SHUT OFF. THE FAILURE RECURRED MULTIPLE TIMES. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN WAS UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS NOT NOTIFIED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V261000 (EXTERIOR LIGHTING). THE APPROXIMATE FAILURE MILEAGE WAS 22,000.

Incident May 2, 2005

THE MILEAGE AND SPEED ARE APPROXIMATE. I WAS BACKING OUT OF MY ICE AND SNOW COVERED DRIVEWAY IN FEBRUARY 2015. THERE IS A SMALL DIP WHERE MY DRIVEWAY MEETS THE STREET SO I ACCELERATED SO AS NOT TO GET MY TIRES STUCK IN THE ICY DIP. AS I WAS BACKING MY CAR INTO THE STREET, AND MY CAR WAS IN THE LANE OF TRAFFIC THE CAR SHUT OFF. I WAS UNABLE TO RESTART THE CAR. MY NEIGHBOR, AND ANOTHER GENTLEMAN WHO STOPPED TO HELP, PUSHED MY CAR BACK INTO MY DRIVEWAY. I ATTEMPTED TO START THE CAR SEVERAL TIMES AFTER THE INCIDENT. THE CAR NEVER AGAIN STARTED. I BORROWED A VEHICLE UNTIL I HAD ENOUGH MONEY TO HAVE THE CAR TOWED TO A MECHANIC FOR REPAIRS. A MECHANIC LOOKED AT MY VEHICLE AND TOLD ME ON MAY 11, 2015 THAT THE CAR NEEDS A NEW ENGINE, THE PRICE OF WHICH IS $4,823.00. THE MECHANIC FURTHER TOLD ME THAT THE AFTERMARKET/REMANUFACTURED ENGINES COMPANY THEY DEAL WITH DOES NOT HAVE AN ENGINE FOR THIS MAKE AND MODEL CAR BECAUSE THIS ENGINE HAS SO MANY PROBLEMS THAT THE COMPANY WILL NOT TOUCH IT. I BELIEVE THAT THE OEM ENGINE HAS SERIOUS DEFECTS THAT HAVE BEEN OVERLOOKED DUE TO THE LACK OF REPORTING AND LACK OF SERIOUS INJURY ASSOCIATED WITH THE DEFECT/FAILURE. MY CAR HAS SHUT OFF ON ME ON THREE DIFFERENT DAYS WITHIN AN APPROXIMATE SIX MONTH PERIOD. I HAD A MECHANIC LOOK AT THE CAR TO FIGURE OUT WHY IT WAS SHUTTING OFF ON ME IN TRAFFIC AND THERE WAS NO INDICATOR OF ANY ISSUE. MY CHECK ENGINE LIGHT NEVER CAME ON, EVEN AFTER THE RECENT ENGINE FAILURE. PLEASE INVESTIGATE THIS ENGINE. *TR

Incident Feb 21, 2015

TL* THE CONTACT OWNS A 2005 CHEVROLET AVEO. THE CONTACT STATED THAT THE HEADLIGHTS FAILED. THE CONTACT INSPECTED THE VEHICLE AND FOUND THAT THE WIRING HARNESS CONNECTORS SHORTED DUE TO OVERHEATING, WHICH BURNED AND MELTED THE WIRES. THE DEALER ADVISED THAT NHTSA CAMPAIGN NUMBER: 14V261000 (EXTERIOR LIGHTING) WOULD ONLY REPAIR THE DRL MODULE AND IT WOULD NOT REPLACE ANY ADDITIONAL FAILURE CAUSED BY THE RECALL. THE CONTACT ALSO STATED THAT THE ENGINE VALVE COVER GASKET WAS DEFECTIVE AND CAUSED THE ENGINE FLUID TO LEAK. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 80,000.

Incident Jan 1, 2013

2005 CHEVROLET AVEO. CONSUMER WRITES IN REGARDS TO VEHICLE HOOD LATCH STICKING OR NOT WORK AT ALL, WHEN ITS COLD. *SMD

Incident Mar 2, 2015

I BOUGHT THIS CAR FOR IN 2011 WITH 25,000 MILES, FIRST 6 MONTHS WAS GREAT. BUT THEN THE INSIDE PANEL LIGHTS WERE GOING ON AND OFF. DOOR LOCKS WEREN'T WORKING AND I NOTICED A BURN MARK ON MY PANEL UNDER STEERING WHEELS AND TOOK TO A SHOP AND HE SAID WIRES WERE A MESS UNDER THE DASH. HE FIXED THE DOOR LOCKS FOR ME AND 200 AND SOMETHING DOLLARS STILL NO PANEL LIGHTS. I TRIED TO FIX THIS PROBLEM BUT NO ONE WANTS TO TOUCH THE MESS. I GOT A RECALL FOR THE DAYTIME RUNNING LIGHTS WHICH I NEVER HAD A PROBLEM WITH, SO WHEN I BROUGHT IT IN FOR THAT TOLD THEM ABOUT THE PROBLEM AND NOTHING WAS DONE. *TR

Incident Apr 2, 2012

TL*THE CONTACT OWNS A 2005 CHEVROLET AVEO. THE CONTACT STATED THAT THE HAZARD LIGHTS, THE TAIL LIGHTS, THE MARKER LIGHTS AND THE INSTRUMENT PANEL LIGHTS FAILED. THE VEHICLE WAS SERVICED UNDER NHTSA CAMPAIGN NUMBER: 14V261000 (EXTERIOR LIGHTING) HOWEVER, THE FAILURES PERSISTED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO DIAGNOSED THAT THE S101 SPLICE BOX BURNED OUT AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 80,000.

Incident Jun 2, 2014

TL*THE CONTACT OWNS A 2005 CHEVROLET AVEO. THE CONTACT STATED THAT ALL INTERIOR LIGHTS AND THE INSTRUMENT PANEL LIGHTS FAILED TO ILLUMINATE. AS A RESULT, THE CONTACT WAS UNABLE TO READ THE GAUGES AND THE DRIVER SIDE TAIL LIGHT FAILED TO ILLUMINATE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 108,000.

Incident Jan 6, 2015

TL*THE CONTACT OWNS A 2005 CHEVROLET AVEO. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V261000 (EXTERIOR LIGHTING). HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. UPDATED 7/23/15*CN UPDATED 10/01/15*LJ MA 10/14/15 UPDATED 9/21/2017*CN

Incident Jul 16, 2014

TL*THE CONTACT OWNS A 2005 CHEVROLET AVEO. THE CONTACT STATED THAT WHILE TRYING TO REVERSE, THE LEVER WAS SHIFTED INTO REVERSE BUT THE VEHICLE FAILED TO MOVE. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS INSPECTED BY AN INDEPENDENT MECHANIC. THE TECHNICIAN WAS UNABLE TO DIAGNOSE OR REPAIR THE VEHICLE. HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 14,321.

Incident Jan 21, 2015

TL* THE CONTACT OWNS A 2005 CHEVROLET AVEO. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V261000 (EXTERIOR LIGHTING) HOWEVER, THE PART NEEDED TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

Incident Dec 15, 2014

TL* THE CONTACT OWNS A 2005 CHEVROLET AVEO. THE CONTACT STATED THAT THE LOW BEAM HEADLIGHTS SHORTED WITHOUT. THE CONTACT HAD TO APPLY THE HIGH BEAM HEADLIGHTS DUE TO THE FAILURE. THE CONTACT MENTIONED THAT BURNING WIRES OR METAL FUMES ENTERED THE VEHICLE. THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V261000 (EXTERIOR LIGHTING) AND STATED THAT THE DEALER WAS UNABLE TO DETERMINE WHEN THE PART WOULD BECOME AVAILABLE TO SCHEDULE THE RECALL REPAIR. THE MANUFACTURER WAS UNABLE TO PROVIDE AN INTERIM NOR A PERMANENT REPAIR FOR THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 70,000.

Incident Jul 14, 2014

WITHIN THE FIRST YEAR OF BUYING MY AVEO I HAD TO REPLACE HEADLIGHTS 10X I KEPT TAKING THE CAR IN TO GET CHECKED AND THEY SAID IT WAS FINE, THEN ONE TIME THEY SAID JUST NEEDED A BETTER FUSE (THE CHANGED IT) WORKED FOR ABOUT A YEAR THEN SIGNAL LIGHTS KEPT GOING OUT, THEN TAIL LIGHTS. THOUGHT THERE WAS SHORT TOOK CAR IN FEW TIMES THEY SAID NOTHING WRONG. TIRED OF TAKING THE CAR IN, I AM A VERY BUSY PERSON. SO WE HAVE BEEN DEALING WITH THIS PROBLEM FOR ABOUT 6-7 YEARS NOW THE DASH LIGHTS HAVE COMPLETELY GONE OUT NOW AND WON'T COME BACK ON, LEAVING US WITH 1 HEADLIGHT, 1 TAIL LIGHT AND ONLY OCCASIONAL REAR SIGNALS. AND ALWAYS SMELLS LIGHT WIRES BURNING. IN SEPT OF 2014 WE RECEIVED A LETTER RECALLING THE CAR FOR LIGHTING PROBLEMS AND STILL NOTHING ABOUT GETTING FIXED!!! THIS IS ONLY ONE OF MANY COMPLAINTS FOR THIS CAR. *JS

Incident Sep 1, 2008

TL* THE CONTACT OWNS A 2005 CHEVROLET AVEO. THE CONTACT STATED THAT THE DAYTIME RUNNING LIGHTS CUT OFF ON SEVERAL OCCASIONS. THE CONTACT RECEIVED A NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V261000 (EXTERIOR LIGHTING) HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 65,000. UPDATED 2/24/15*CN

Incident Jun 9, 2014

CAR WENT TO 500 RPM THEN DROPPED TO 300 RPM THEN DOWN TO 100 RPM; I IMMEDIATELY PULLED OFF THE MAIN ROAD TO A SIDE STREET. LOST POWER STEERING AND WAS UNABLE TO RESTART CAR AGAIN. CAR TAKEN TO LOCAL MECHANIC AFTER RUNNING DIAGNOSTIC TESTS ON THE VEHICLE, DETERMINED THE CAR WAS SAVABLE AND THAT THE TIMING BELT BROKE CAUSING THREE SETS OF VALVES TO BEND. THE TIMING BELT KIT, HEAD GASKET, WATER PUMP AND VALVE KITS NEED TO BE CHANGED. THE ENGINE NEEDS TO BE RECONDITIONED; NEW ENGINE OIL NEEDS TO BE PUT INTO THE CAR ALONG WITH FLUSHING THE FLUIDS. SINCE THIS IS A MASSIVE REWORK OF THE VEHICLE, IT WILL BE OUT OF SERVICE ONE WEEK AND THE REPAIR COST IS $2,100.00. MILEAGE ON THE CAR IS UNDER 60,000, I AM ORIGINAL OWNER. GENERAL MOTORS - CHEVROLET DIVISION CONTACTED BECAUSE I DID NOT TAKE TO A GM DEALER FOR SERVICE (UNABLE TO AFFORD) AND BECAUSE THEY ADVISED ME THIS IS SO FAR OUT OF THE WARRANTY, THEY WOULD NOT OFFER ANY ASSISTANCE. HOWEVER, I DID LOOK UP A SERVICE BULLETIN AND IT DID SAY THE PARTS ARE UNDER WARRANTY. *TR

Incident Dec 16, 2014

TL* THE CONTACT OWNS A 2005 CHEVROLET AVEO. THE CONTACT STATED THAT WHILE DRIVING 40 MPH, THE ENGINE STALLED. THE FAILURE OCCURRED ON SEVERAL OCCASIONS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO WAS UNABLE TO DIAGNOSE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 88,000. UPDATED 02/24/15*LJ UPDATED 9/8/2017*CN

Incident Nov 14, 2014

MY 05 AVEO,IS INCLUDED IN THE GM RECALL#A140093/NHTSA RECALL#14V261(HEADLAMP SWITCH & DRL). I HAVE BEEN EXPERIENCING ISSUES WITH ALL OF MY EXTERNAL LIGHTS (MY GAUGE CLUSTER AND SHIFTER LIGHTS HAVE BEEN OUT). I WAS REPLACING EVERY EXTERNAL BULB EVERY FEW WEEKS TO KEEP THE LIGHTS ON. THAT IS NOT WORKING. I AM DOWN TO ONE HEADLIGHT (DRIVER SIDE) WORKING ' AS FAR AS RUNNING LIGHTS GO. I HAVE NO TAILLIGHTS (BRAKELIGHTS WORK). I COMMUTE APPROX. 40MILES EACH DIRECTION FOR WORK-ALL FREEWAY. I MADE AN APPT W/CHEVY,TOOK THE DAY OFF WORK SO THE CAR COULD BE THERE ALL DAY.AS I ARRIVED TO MY APPT THE SERVICE WRITER TOLD ME THERE IS NOT A REMEDY FROM GM YET SO I WILL NEED TO COVER THE COST. EVENTUALLY WE WENT INTO THE BUILDING TO COMPLETE MY WRITE UP, AT THAT POINT I WAS TOLD THEY WERE BACKED UP ON RECALLS SO THEY MAY NOT GET TO MY VEHICLE DESPITE THE APPT. I REITERATED THE ISSUE,HE SAID OKAY,TOLD ME HE WOULD BE IN CONTACT WITH ME. AT 3:30 HE CALLED,TOLD ME THEY HADN'T HAD A CHANCE TO LOOK AT MY VEHICLE BUT WOULD GET TO IT TOMORROW. I TOOK ANOTHER DAY OFF WORK & LEFT THE CAR WITH THEM.NEXT DAY,I CALLED AT 11AM & I'M TOLD THEY HAVE YET TO TOUCH MY VEHICLE & THERE ARE ABOUT 20 CARS IN FRONT OF ME SO THEY WON'T GET TO IT TODAY EITHER.I COULD NOT LEAVE THE CAR ANOTHER DAY, I TOLD HIM I WOULD PICK IT UP. I IMMEDIATELY CALLED GM EXPLAINED THE SITUATION, THEIR RESPONSE WAS 'WHAT DO YOU WANT US TO DO ABOUT IT'. I TOLD THEM THE CAR WAS UNSAFE AND ILLEGAL TO DRIVE IN THIS CONDITION I NEEDED IT FIXED. THEY TOLD ME THEY WOULD CONTACT ANOTHER DEALERSHIP AND HAVE THEM CONTACT ME. ABOUT 20MINS LATER THE DEALERSHIP CONTACTED ME, GAVE ME THE SAME RUN AROUND AS THE FIRST DEALERSHIP.THIS RECALL IS 7MONTHS OLD, IT TOOK GM 10YRS TO ACKNOWLEDGE IT. THIS IS UNACCEPTABLE, I BOUGHT THIS CAR IN GOOD FAITH THE BASIC FUNCTIONALITY OF THE CAR WOULD WORK AND IT DOES NOT AND GM IS NOT CORRECTING THE ISSUE. *TR

Incident Dec 9, 2014

TL* THE CONTACT OWNS A 2005 CHEVROLET AVEO. THE CONTACT STATED THAT BURNING WIRES FUMES EMITTED INSIDE THE VEHICLE. THE CONTACT MENTIONED THAT THE KEY RELEASED FROM THE IGNITION WHILE THE VEHICLE WAS ON AND THE RADIO FAILED TO OPERATE INTERMITTENTLY. IN ADDITION, THE HEADLIGHT MALFUNCTIONED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 95,000.

Incident Nov 1, 2013

TIMING BELT IDLER PULLEY FAILURE PLASTIC BREAKS APART. DAMAGING INTERNAL PARTS CAUSING ENGINE TO STOP RUNNING. WITH LOSS OF POWER STEERING POWER BRAKES

Incident Oct 24, 2011

TL* THE CONTACT OWNS A 2005 CHEVROLET AVEO. THE CONTACT STATED THAT THE FUSE BURNED AND CAUSED ALL OF THE WINDOWS TO MALFUNCTION. THE CONTACT REPLACED THE FUSE, BUT THE FAILURE RECURRED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VIN WAS UNAVAILABLE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 86,000.

Incident Sep 7, 2014

WAS DRIVING ON I-94 FROM MILWAUKEE TO CHICAGO, ONCE IN KENOSHA AREA THE CAR CHOKED, HEARD A BIG NOISE AND DIED COMPLETELY WOULD NOT TURN ON AGAIN. PUSHED IT TO THE SHOULDER AND CALLED 911. THE DOT TOWED THE CAR TO SAFETY AND THEN IT WAS BROUGHT TO THE SHOP. THE MECHANIC DESCRIBED THE PROBLEM AS THE IDLER PULLEY AND THE TIMING BELT ARE BROKEN DOWN AND THIS CAUSE THE VALVES AND PISTON TO BE COMPLETELY DAMAGED. THE CAR WAS ALWAYS MAINTAINED ACCORDING TO GM RECOMMENDATION, TIMING BELT PERFORMED BY HALL CHEVROLET DEALER AT 67000 AND OIL CHANGE WAS REGULARLY DONE AT 3000MILES. ALSO THE CAR HAS A COMPLETE 92000 MILES REVIEW WITH HEISER CHEVROLET BACK IN MARCH WITH ALL THE MAINTENANCE RECOMMENDED BY GM (TRANSMISSION, COOLANT, BELTS, HOSES...ETC). THE CAR IS STILL IN GREAT SHAPE. THE TIMING BELT AND THE IDLER PART MUST BE DEFECTIVE. *TR

Incident Aug 30, 2014

TL* THE CONTACT OWNS A 2005 CHEVROLET AVEO. THE CONTACT STATED THAT THE ENGINE OVERHEATED AND THE TEMPERATURE GAGE DISPLAY STATED THAT THE VEHICLE WAS OVERHEATING. THE FAILURE RECURRED ON SEVERAL OCCASIONS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE DRL MODULE NEEDED TO BE REPLACED. THE CONTACT RECEIVED A NOTIFICATION FOR NHTSA CAMPAIGN ID NUMBER: 14V261000 (EXTERIOR LIGHTING), HOWEVER THE PART NEEDED TO PERFORM THE RECALL REPAIR WAS UNAVAILABLE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 32,000.

Incident Jul 16, 2014

TL* THE CONTACT OWNS A 2005 CHEVROLET AVEO. WHILE DRIVING APPROXIMATELY 35 MPH, THE PASSENGER SIDE OF THE VEHICLE WAS HOT TO TOUCH. THE CONTACT RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN NUMBER: 14V261000 (EXTERIOR LIGHTING). HOWEVER, THE PART NEEDED TO REPAIR THE VEHICLE WAS UNAVAILABLE TO PERFORM THE REPAIR. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE APPROXIMATE FAILURE MILEAGE WAS 29,000.

Incident Aug 7, 2012

TL* THE CONTACT OWNS A 2005 CHEVROLET AVEO. THE CONTACT RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN NUMBER: 14V261000 (EXTERIOR LIGHTING: HEADLIGHTS); HOWEVER, THE PART NEEDED FOR THE REPAIR WAS UNAVAILABLE. THE DEALER WAS UNCERTAIN AS TO WHEN THE PART WOULD BECOME AVAILABLE. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE CONTACT EXPERIENCED A FAILURE WITH THE HEADLIGHTS. THE APPROXIMATE FAILURE MILEAGE WAS 33,000.

Incident Jun 19, 2014

SON GOING TO WORK AND STEERING LOCKED UP GOING INTO A TURN CAUSING THE CAR TO GO STRAIGHT INTO A POWER POLE. SON HAD TO BE EXTRACTED OUT OF CAR AND LIFE-BIRD INTO HOSPITAL WITH FACIAL LACERATION, BROKEN AN DISPLACED ELBOW AN SLIGHT CONCUSSION. ACCIDENT WAS IN THE MORNING AND THAT AFTERNOON WAS A RECALL NOTICE ON THE CAR. SON WAS LUCKY, VERY LUCKY JUST TO HAVE THESE INJURIES. CAR TOTALED. *JS

Incident Jul 21, 2014

FOR THE LAST TWO YEARS AT RANDOM TIMES WHEN I START MY CAR, THE BRAKES WILL NOT WORK. THEY CAN NOT EVEN BE PRESSED DOWN. WHENEVER THIS HAPPENS, A CORRESPONDING WEIRD REVVING THAT CAUSES THE CAR TO LUNGE FORWARD IN SUCH A WAY THAT IT DOESN'T USUALLY ALSO HAPPENS. I PARALLEL PARK ON A STREET DAILY, AND ONE MORNING WHEN THIS HAPPENED ENDED UP HITTING THE CAR IN FRONT OF ME. USUALLY THE PROBLEM STOPS HAPPENING AFTER DRIVING FOR ABOUT 1/2 A MILE, BUT IT IS PRETTY SCARY TRYING TO DRIVE WITHOUT BRAKES TO GET TO THAT 1/2 MILE MARK. ESPECIALLY SINCE WHENEVER THE BRAKES WON'T WORK THE CAR ALSO SEEMS TO ACCELERATE ON ITS OWN. I HAVE TRIED TO GET THIS FIXED MULTIPLE TIMES BUT IT ALWAYS STOPS HAPPENING BY THE TIME I GET TO THE MECHANIC AND I'VE LEFT MY CAR OVERNIGHT AT A MECHANIC TWICE AND THEY HAVEN'T BEEN ABLE TO RECREATE THE ISSUE. I CAN'T PART WITH MY CAR FOR AN ENTIRE WEEK SO THAT THIS PROBLEM CAN BE DIAGNOSED. *TR

Incident Jul 18, 2012

TL* THE CONTACT OWNS A 2005 CHEVROLET AVEO. THE CONTACT STATED THAT THE INSTRUMENT PANEL LIGHTING, BRAKE LIGHTS, AND LICENSE PLATE LIGHTS FAILED TO ILLUMINATE. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC. THE CONTACT WAS INFORMED THAT THE WIRING CONNECTED TO THE FUSE BOX UNDER THE HOOD WAS MELTED AND BURNED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 104,802. UPDATED 9/4/14*CN

Incident Feb 3, 2014

TL* THE CONTACT OWNS A 2005 CHEVROLET AVEO. THE CONTACT STATED THAT THE INTERIOR AND EXTERIOR LIGHTING FAILED TO ILLUMINATE. IN ADDITION, THE CONTACT NOTICED THAT THE CENTER CONSOLE IN THE INSTRUMENT PANEL AND THE DAY TIME RUNNING LIGHT MODULE WAS MELTED. AN INDEPENDENT MECHANIC WAS MADE AWARE OF THE FAILURE AND INFORMED THE CONTACT THAT THE VEHICLE WAS NOT SAFE TO DRIVE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE MANUFACTURER INFORMED THE CONTACT THAT NHTSA CAMPAIGN ID NUMBER: 14V261000 (EXTERIOR LIGHTING) REMEDY WAS BEING INVESTIGATED. THE APPROXIMATE FAILURE MILEAGE WAS 90,000.

Incident Sep 6, 2012

TL* THE CONTACT OWNS A 2005 CHEVROLET AVEO. THE CONTACT STATED THAT THE INTERIOR AND EXTERIOR LIGHTING FAILED. IN ADDITION, THE CONTACT NOTICED THAT THE CENTER CONSOLE AND THE DAY TIME RUNNING LIGHT MODULE WAS MELTED. AN INDEPENDENT MECHANIC WAS MADE AWARE OF THE FAILURE AND INFORMED THE CONTACT THAT THE VEHICLE WAS NOT SAFE TO DRIVE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE MANUFACTURER INFORMED THE CONTACT THAT NHTSA CAMPAIGN ID NUMBER: 14V261000 (EXTERIOR LIGHTING) REMEDY WAS BEING INVESTIGATED. THE APPROXIMATE FAILURE MILEAGE WAS 90,000.

Incident Sep 4, 2012

TL* THE CONTACT OWNS A 2005 CHEVROLET AVEO. THE CONTACT STATED THAT THE HEADLIGHT LIGHTS, THE PARKING LIGHTS, AND DAYTIME LIGHTS FAILED TO ILLUMINATE. THE FAILURE RECURRED SEVERAL TIMES. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN DIAGNOSE THAT THE MAIN FUSE BOX AND WIRING HARNESS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 75,000. UPDATED 9/18/14*CN UPDATED 02/05/2015 *JS

Incident Jun 13, 2011

TL* THE CONTACT OWNS A 2005 CHEVROLET AVEO. THE CONTACT STATED THAT THE INSTRUMENT PANEL, INTERIOR AND EXTERIOR LIGHTS WERE ALL INOPERABLE. ALSO, THE CONTACT MENTIONED THAT THE RIGHT SIGNAL LIGHT FAILED TO FUNCTION WHILE THE HEAD LIGHTS WERE ON. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE PROBLEM. THE CONTACT WAS MADE AWARE OF A NOTIFICATION FOR RECALL NHTSA CAMPAIGN NUMBER 14V261000 (EXTERIOR LIGHTING). HOWEVER, THE VIN WAS NOT INCLUDED. THE APPROXIMATE FAILURE MILEAGE WAS 75,000.

Incident Feb 12, 2014

SOMETHING UNDER THE DASH BURNED OUT SPEWING WHITE SMOKE INTO THE PASSENGER COMPARTMENT OF THE CAR. SINCE THAT TIME AVEOS. WONDERING IF GM DAEWOO MAY HAVE BEEN USING MULTIPLE SUBSTANDARD ELECTRICAL COMPONENTS, THE IGNITION KEYS ARE ALWAYS HOT AFTER DRIVING. IS THERE ANY POTENTIAL FOR THE IGNITIONS GOING OUT/SHORTING OUT ON THESE VEHICLES? WOULD HATE TO PARK MY CAR IN THE GARAGE AND CAUSE MY HOUSE TO BURN DOWN. *TR

Incident Jan 15, 2014

RUNNING LIGHTS DON'T WORK HALF THE TIME, CLOCK DOESN'T STAY ON, MILEAGE OD SCRAMBLES, FRONT END ALWAYS HAD A SHIMMY. *TR

Incident Oct 19, 2006

MULTIPLE PROBLEMS, STARTED WITH DAYTIME LIGHTS GOING OUT, CLOCK GOING OUT AND COMING ON WITH CORRECT TIME, DEALER REPLACED CLOCK AND SAID DAYTIME LIGHTS RELATED AND SHOULD BE FIXED, IT WAS NOT. NEXT ALL THE INSTRUMENT PANEL LIGHTS WENT OUT, REPAIRED BY DEALER AGAIN AT MY COSTS. NEXT THE TAIL LIGHTS AND BRAKE LIGHTS WENT OUT. EACH TIME IT WAS THE WIRING IN THE FUSE BOX UNDER THE HOOD. ALL REPAIRED AT MY EXPENSE. THE DEALER ACTED LIKE THEY HAD NO IDEA OF THE MULTITUDE OF ELECTRICAL PROBLEMS WITH THE AVEO BUT I THINK THEY'VE KNOWN, JUST READ SOME OF THE BLOGS-THIS IS A VERY COMMON PROBLEM. IT'S FRIGHTENING TO DRIVE THIS CAR JUST WAITING FOR A FIRE. FROM MAY 2013 TO PRESENT I CONTINUE TO HAVE THESE PROBLEMS. THE DAYTIME LIGHTS AND NOW THE CLOCK AGAIN GOING OUT. THE WHOLE FUSE BOX NEEDS REPLACED AS FAR AS I'M CONCERNED BUT THE DEALERSHIP KEEPS GIVING ME THE RUNAROUND--- NO MORE CHEVYS OR GM FOR ME. *TR

Incident May 6, 2013

WHILE I AM DRIVING I OFTEN SMELL BURNING PLASTIC I COULD NOT TELL WHERE IT WAS COMING FROM. I CALLED GM AND THE REPRESENTATIVE TOLD ME THAT IT WAS COMING FROM MY DASH BEHIND MY STEERING WHEEL. I ALSO HAVE NOTICED THAT AFTER I HAVE DRIVEN ANYWHERE MY KEY, AFTER I HAVE TAKEN IT OUT OF THE IGNITION, IS REALLY HOT. THE LONGER I DRIVE THE HOTTER MY KEY BECOMES. WHEN I CALLED GM ABOUT THIS PROBLEM THE REPRESENTATIVE TOLD ME THAT SHE CAN NOT TELL MY WHY MY KEY GOT HOT. WHEN I ASKED HER ABOUT THE RECALL ON MY CAR THAT I HAD SEEN ON THE NEWS SHE TOLD ME THAT IT IS NOT AN OFFICIAL RECALL AND SHE CAN NOT DO ANYTHING ABOUT IT. THEY ALSO INFORMED ME THAT I CAN TAKE IT INTO A DEALERSHIP TO GET IT LOOKED AT BUT IT WOULD HAVE TO BE OUT OF POCKET. I HAVE TALKED TO GM MULTIPLE TIMES AND THEY HAVE TOLD ME ONLY THAT THE RECALL WOULD BE VIN SPECIFIC, I DON'T UNDERSTAND HOW IT IS VIN SPECIFIC IF I AM TELLING THEM THAT MY CAR IS NOT RIGHT. I REALLY WOULD JUST LIKE MY CAR LOOKED AT FOR THE PARTS THAT ARE SUPPOSED TO BE RECALLED BEFORE SOMETHING BAD HAPPENS TO ME OR MY PASSENGERS. I ALSO BELIEVE THAT SINCE THIS IS A KNOWN ISSUE I SHOULD NOT HAVE TO TAKE IT TO A DEALERSHIP TO GET LOOKED AT AND PAY HUNDREDS OF DOLLARS OUT OF MY POCKET. *TR

Incident May 22, 2014