2022 Chevrolet Bolt EV

2022 Chevy Bolt, less than 10,000 miles. Problem began 11/24/23. Steering wheel locks up at low speeds, gives warning "Steering Assistance reduced" at higher speeds. At low speeds, steering wheel turns only a small amount before it clicks and stops. Very dangerous in tight parking lots or trying to turn left or right from a stop - takes multiple tries to get steering wheel to turn, and sometimes it jerks back in the opposite direction. Took it to dealer, they said steering column needs to be replaced. Did not have an accident or hit anything prior - I think the column is defective.

Incident Nov 24, 2023

When I use the windshield washer fluid some of the vapors gets in the cabin. The fluid contains methanol and it is highly toxic.

Incident Dec 5, 2023

The contact owns a 2022 Chevrolet Bolt EV. The contact stated while attempting to charge the vehicle, the charging system failed to charge the vehicle adequately. The contact stated that shortly after beginning to charge the vehicle, the vehicle overheated after 30 minutes, and the charging light turned from blue to red. The contact then had to disconnect the charger. The vehicle was taken to the dealer who was unable to determine the cause of the failure with the charging unit. The vehicle had not been repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 200.

Incident Aug 20, 2023

Vehicle stopped while driving down the road lost power threw up multiple codes and was stuck in the middle of the roadway!

Incident Oct 3, 2023

The contact owns a 2022 Chevrolet Bolt EV. The contact received notification of NHTSA Campaign Number: 23V567000 (Air Bags, Electrical System) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.

Incident Sep 15, 2023

While waiting to make a left turn, the car lurched forward about a foot and went into park.It would not shift into any gear. A warning briefly showed up on drivers display which said DO NOT SHIFT UNTIL ???? RESETS. I turned car off but it immediately came back on automatically, and for twenty minutes I was in the intersection blocking traffic (police called to protect me from traffic). On drivers display a car symbol with exclamation point through the car was showing. After twenty minutes I turned it off again and it stayed off until I turned it on. The display of car with exclamation point was still showing. I could then shift into another gear and drive home less than a mile. When I checked car later car with exclamation point display was gone. Everything seemed. I was driving in one pedal mode.

Incident Sep 7, 2023

Complete transmission failure shortly after seeing "Service Transmission" message in 2022 Chevy Bolt EV Drivers Information Center. When message first appeared selected option to dismiss message and continued to drive as normal. After turning vehicle off and then back on the message appeared again and all attempts to change gear into neutral, reverse, or drive resulting in all doors unlocking and the vehicle shifting back into park. Was unable to put car in neutral and move vehicle off road therefore blocking traffic until a tow truck arrived 90 minutes later.

Incident Aug 30, 2023

The contact owns a 2022 Chevrolet Bolt EV. The contact received notification of NHTSA Campaign Number: 21V650000 (Electrical System) however the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

Incident Jun 27, 2023

I purchased this car last year and now already General Motors has discontinued making them. Is there something wrong with car and why did they quit making them so soon? Is there a safety problem with my car? Is the battery a fire hazard? [XXX], [XXX] [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

Incident May 25, 2023

Backup camera keeps going out screen turns black

Incident Mar 23, 2023

Not necessarily a failure or malfunction. When making right/left turns vehicle will accelerate for apparently no reason. Each time entering a parking lot or making a standard right/left turn. Each time this has happened during this acceleration it has almost caused a vehicle crash with another car in front or in another incident almost hit pedestrian. Found that the Rocker switch for Cruise control is being hit accidentally causing Cruise control to become activated causing the vehicle to accelerate.

Incident Apr 13, 2023

The contact owns a 2022 Chevrolet Bolt EV. The contact received notification of NHTSA Campaign Number: 21V650000 (Electrical System) and 22V930000 (Structure, Seat Belts) however, the parts to do the recall repairs were not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

Incident Apr 1, 2023

The contact owns a 2022 Chevrolet Bolt EV equipped with Michelin Tires, Tire Line: Energy Saver A/S, Tire Size: 215/50/R17, And DOT Number: N/A. The contact stated that while driving over a pothole the front driver's side tire sidewall failed causing the tire to go flat. The contact stated upon inspecting the vehicle tires, he noticed a bubble on the rear driver's side tire. The vehicle taken to the local dealer who replaced the tire; however, while driving over a pothole, the replacement tire experienced a sidewall failure. The contact stated that the same tire sidewall had failed on three separate occasions. The manufacturer was not notified of the failure. The cause of the failure were not determined. The failure mileage was 5,000.

Incident Dec 17, 2022

The contact owns a 2022 Chevrolet Bolt EV. The contact stated while pulling out of a parking lot, the vehicle stalled, failed to shift into gear and would not turn off. A towing agent disconnected the battery and the vehicle turned off. The vehicle was then towed to the dealer where it was diagnosed that the service disconnect fuse had blown. The vehicle was repaired; however, the failure reoccurred while driving. The vehicle was towed to the dealer where the engine control module (ECM) was replaced, however, the failure reoccurred upon starting the vehicle. The vehicle was towed to the dealer. The vehicle was not repaired. The manufacturer was notified of the failure and a case was opened; however, the manufacturer had not followed up or returned the contact's calls. The failure mileage was approximately 6,612.

Incident Jul 11, 2022

While braking I have had multiple cars almost crash into the rear of my vehicle due to the breaking system of the vehicle. The break lights are too low and people expect the “running lights” on the rear to indicate breaking. I have also had multiple people tell me my break lights are out due to this. This is a safety issue be the design of the breaking system, I have found multiple forums of owners who have been rear ended for this exact issue.

Incident Jan 28, 2023

The contact owns a 2022 Chevrolet Bolt EV. The contact stated while driving 10 MPH, the air bag SRS warning light illuminated. The contact stated that the failure recurred intermittently. The vehicle was taken to the dealer where it was diagnosed that an air bag electrical wire was loosened. The dealer tightened the air bag wire; however, the failure persisted. The vehicle was taken back to the dealer where it was diagnosed that an unknown air bag needed to be replaced; however, the part would not be available for three months. The dealer later informed the contact that the part was available, and the vehicle was taken back to the dealer. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 2,000.

Incident Sep 9, 2022

While driving at highway speed, vehicle lost drive and a message stating to pull over was displayed. Vehicle then shifted into Park (P) and was unable to shifted into Drive (D) or Reverse (R). Vehicle towed to dealer, where it was for 7+ weeks before being repaired.

Incident Nov 6, 2022

The system in question is the Super Cruise hands free driving system. There has been several instances where the system has swerved the vehicle without warning or reason. There have been several instances where the system has failed on mapped road. There have been several instances where the vehicle wouldn't drive in the center of the lane, but instead on the lines or too close to other vehicles. I have dash cam footage and cell phone footage of the system failing and can duplicate it without issue. The vehicle spent over 30 days at the dealer and they were unable to fix it. The message that will appear when the system intermittently won't activate is "super cruise unavailable" I have attempted to work with my dealer, GM, and Onstar and nothing has been done to take my safety seriously or to fix the issue.

Incident Aug 29, 2022

The car was changed for 2022 where the brake lights are no longed displayed with the tail lights and instead lower down in the bumper area on small lights. Cars following me do not notice these lights and end up almost hitting me. The dealer states that this is how GM has changed the lights from the prier year. Last year they would only go to the lower light if the tail gate was open for some reason. Which I thing is a good design but the way my car is now is very dangerous and is an acident waiting to happen.

Incident Nov 19, 2022

The contact owns a 2022 Chevrolet Bolt EV. The contact stated that while his wife was driving 70 MPH, the vehicle inadvertently decelerated to 30 MPH with the transmission warning light and three other unknown warning lights illuminated. The failure nearly caused a collision. The vehicle was towed to the dealer; however, the dealer was unable to duplicate the failure. The dealer determined that the negative battery terminal cable was faulty and replaced the negative battery terminal cable. The failure recurred, and the vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 9,000.

Incident Nov 14, 2022

Around 5 PM on 10/7/22 I was driving on Purcell Road in Manassas VA. The car has a 60% charge on it EV battery showing a range of around 170 miles. As I was driving I felt the Chevrolet Bolt stutter twice, as if it was loosing power. Then, when I stopped at the stop light at Purcell and Hoadly the car shifted into park and would not shift into any other gear, including neutral. Any attempts to shift would give an error warning "Conditions Not Correct for Shift" In addition to being unable to move the car out of the intersection, the car could not be shut down. Pressing the power button would make the screen flicker for a moment and then it would power itself back on with the same "Conditions Not Correct for Shift" error. Onstar was called about the problem and shortly after the police arrived to tow the car. The car was a traffic hazard since it could not be put into neutral to get it out of traffic. The car was taken to Lindsay Chevrolet Service Center (15605 Jefferson Davis Hwy, Woodbridge, VA 22191) for diagnostic and repairs. They have reported that the problem was a wiring harness.

Incident Oct 7, 2022

I was driving the vehicle approx 35mph on a surface street when it suddenly lost propulsion. There was no warning. The display suddenly showed 0 rand and 0% high voltage battery SOC. I had to cross multiple lanes of rush hour traffic with no propulsion to coast to a stop. Once parked the vehicle would not go in gear and would not move. It was towed to a dealer where a blown manual service disconnect lever (high voltage battery fuse) was found to be blown. The dealer determined the root cause to be a faulty level 2 charging station I used earlier in the day. After contacting the charging station vender there was no fault found with the station and no other complaints filed with its operation. The fuse blew 6 miles after being charged, not while it was charging. I asked for the dealer to contact Chevrolet engineering and they declined. I contacted Chevrolet customer service and was not able to speak with anyone that is familiar with their EV products.

Incident Sep 7, 2022

2022 CHEVROLET BOLT. CONSUMER WRITES IN REGARD TO NHTSA SAFETY RECALL 21V-650 BEING INCOMPLETE. THE CONSUMER STATED THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME COMPLETING/DETERMINING A FIX FOR THE RECALL REPAIR.

Incident Sep 19, 2022

The contact owns a 2022 Chevrolet Bolt EV. The contact stated that the computer would intermittently glitch while driving at various speeds. The contact also stated that upon approaching a stop, the brakes failed to operate as needed and the contact was forced to depress the brake pedal to the floorboard. There was no warning light illuminated. The contact called the dealer and an appointment was scheduled to have the vehicle serviced. The manufacturer was not notified of the failure. The vehicle was not repaired. The failure mileage was 635.

Incident Sep 7, 2022

The contact owns a 2022 Chevrolet Bolt EV. The contact received notification of NHTSA Campaign Number: 21V650000 (Electrical System) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

Incident Aug 20, 2021

Vehicle will not charge passed 30%, receiving a reduced propulsion reduced message. Code P0BBD. Also No air conditioning. GM is holding the car till there's a fix and they have NO ETA and NO communication about an ETA. I'm irate and need my car back yesterday.

Incident Aug 8, 2022

While pulling into a parking spot the car made a loud noise and came to a complete stop. Car was able to pull into the spot. When the car was turned on after parking a warning message came up to service transmission, unable to shift soon. Vehicle was driven to dealer for service and would make thud noises when decelerating at low speed.

Incident Aug 12, 2022

As I drove my brand new 2022 Bolt (in use 30 days) into garage, the dash check engine light came on with a notice "reduced power propulsion." The battery was at about 50%. I tried to charge it and the dash indicated "charge complete." The reduced power propulsion message is concerningly similar to the error from the previous Bolt recalls that have resulted in fires. I took the car to my dealer and they have had it for 40 days and counting and say they don't know when it will be fixed nor do they know yet how to fix it.

Incident Jun 8, 2022

My backup camera and surround cameras are not working. I’m getting a triangle icon and camera icon with a line through it. It first appeared when I was backing out of my driveaway then the camera worked again briefly. Now the camera is not turning on at all.

Incident Jul 26, 2022

Bought vehicle 22 jul 2022 new 5 mi on odometer. System displays: service transmission unable to shift soon. Please google it. It's a common issue that isn't safe. Thank you.

Incident Jul 22, 2022

The contact owns a 2022 Chevrolet Bolt EV. The contact received notification of NHTSA Campaign Number: 21V650000 (Electrical System) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

Incident Aug 21, 2021

General Motors is making brand new Bolt ev/Euvs using batteries that are supposed to be used to fix cars that could potential catch fire. They stated that the old vehicles effected by the recall would be given priority. I have had a bolt EUV on reserve that has been waiting on a battery replacement for over a year. GM will not inform me or the dealership of when it might be repaired. Concurrently GM is making and selling new bolts that use the battery pack that could be used to fix the old bolts. It is criminal that they would allow dangerous vehicles to remain in public while they make brand new vehicles for profit using the part that could fix every single old vehicle. Based on GMs public response to the matter they are false advertising their response to “prioritize cars” that are already made that are faulty. Instead they are prioritizing new cars while leaving thousands of hazardous cars in dealer lots and on the street. If GM can make new batteries for new bolts and sell them then they can take care of the recall. I have had extensive conversations with several dealerships confirming that GM is shipping them new bolts while allowing defective bolts to sit for over a year. I have had conversations with GMs concierge desk where they confirm the same behavior. These actions by GM are fraudulent, dishonest, and a danger to the public.

Incident Jul 18, 2022

General Motors is making brand new Bolt ev/Euvs using batteries that are supposed to be used to fix cars that could potential catch fire. They stated that the old vehicles effected by the recall would be given priority. I have had a bolt EUV on reserve that has been waiting on a battery replacement for over a year. GM will not inform me or the dealership of when it might be repaired. Concurrently GM is making and selling new bolts that use the battery pack that could be used to fix the old bolts. It is criminal that they would allow dangerous vehicles to remain in public while they make brand new vehicles for profit using the part that could fix every single old vehicle. Based on GMs public response to the matter they are false advertising their response to “prioritize cars” that are already made that are faulty. Instead they are prioritizing new cars while leaving thousands of hazardous cars in dealer lots and on the street. If GM can make new batteries for new bolts and sell them then they can take care of the recall. I have had extensive conversations with several dealerships confirming that GM is shipping them new bolts while allowing defective bolts to sit for over a year. I have had conversations with GMs concierge desk where they confirm the same behavior. These actions by GM are fraudulent, dishonest, and a danger to the public.

Incident Jul 18, 2022

Euv service soon light came on followed by a propulsion reduced message. Speed was limited and air conditioning was warm. While parked the euv made a pulsating clicking noise. Euv would not go through charging procedure. Euv gave a change complete message with only 81 miles on the display

Incident Jun 10, 2022

Car electrical system is very glitchy at times worse when it rains. Side mirror falls off if road debris hits outside of assembly. Timeline to replace battery taking too long. Car was sent to dealership ahead of schedule and sold with known battery issue.

Incident May 3, 2022

2022 CHEVROLET BOLT. CONSUMER WRITES IN REGARDS TO GM SAFETY RECALL. THE CONSUMER STATED THE VEHICLE HAD A DEFECTIVE BATTERY. THE CONSUMER REQUESTED TO HAVE THE VEHICLE REPAIRED OR REPURCHASED.

Incident Apr 27, 2022

I purchased this vehicle new in August of 2021. Two weeks after purchase, the vehicle's battery was placed on the recall list. I have had a software update installed on my vehicle, which limits my charging capacity to 80% of my capacity. I can't get any information from GM as to when my battery will be replaced or when I will be able to charge my car to 100% for trips. It's been 7 months and I am have not been able to use my vehicle's full range since I have had it.

Incident Aug 9, 2021

The contact owns a 2022 Chevrolet Bolt EV. The contact received notification of NHTSA Campaign Number: 21V650000 (Electrical System) however, the part to do the recall repair was not yet available. The contact stated that there were error codes being sent to the smart charger. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The failure mileage was approximately 7,000. VIN tool confirms parts not available.

Incident Feb 23, 2022

The contact owns a 2022 Chevrolet Bolt EUV. The contact received notification of NHTSA Campaign Number: 21V650000 (Electrical System) however, the part to do the recall repair was unavailable. The local dealer was contacted, and it was confirmed that the part was not yet available. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts are not available.

Incident Sep 1, 2021

The contact owns a 2022 Chevrolet Bolt EV. The contact received a recall notification for NHTSA Campaign number: 21V650000 (Electrical System). The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was notified of the issue. The part was not available for the repair. The contact had not experienced a failure. VIN tool confirms parts not available.

Incident Sep 8, 2021