1992 Chevrolet Cavalier

VEHICLE REAR SHOCK MOUNTS RUSTED OUT AND THE SHOCKS BROKE FREE OF WHAT REMAINED OF THE WHEEL WELL. *MR *SCC *JB

Incident Sep 1, 2003

DRIVER'S SIDE SEAT BELT BUCKLE WILL NOT LOCK. DT

Incident Nov 18, 2002

TRANSMISSION LOCK-UP TORQUE CONVERTER WILL NOT RELEASE WHEN VEHICLE WARM. VEHICLE STARTS, BUT WILL ABRUPTLY STALL WHEN PLACED IN GEAR. WHEN VEHICLE COOLS, TRANSMISSION OPERATIONAL UNTIL VEHICLE WARMS BACK UP. THIS IS THE 5TH GM VEHICLE THAT I HAVE OWNED THAT EXHIBITS THIS PROBLEM. IT USUALLY OCCURS AT OR NEAR 100,000 MILES. THIS COULD POTENTIALLY BECOME A SAFETY HAZARD IF VEHICLE STALLS IN MIDDLE OF INTERSECTION AS THERE IS NO WAY TO MOVE THE VEHICLE. I HAVE HAD 1 VEHICLE STALL ON THE INTERSTATE WHEN I HAD TO STOP FOR TRAFFIC. AFTER 5 VEHICLES IT SEEMS TO BE A COMMON PROBLEM AND NOT JUST RELATED TO 1 VEHICLE. ACQUAINTANCES WITH DIFFERENT MANUFACTURER VEHICLES HAVE REPORTED NO SIMILAR PROBLEMS. DT

Incident Aug 10, 2001

WHILE DRIVING AT ANY SPEED AND APPLYING BRAKES REAR BRAKES WILL LOCK UP. ANTI-LOCK BRAKING SYSTEM WILL ENGAGE, WHICH AFFECTS VEHICLE STOPPING. DEALER CONTACTED.PLEASE ADD VIN. *AK

Incident Apr 21, 2001

VEHICLE WAS SITTING IN ATTACHED GARAGE FOR THREE HOURS WHEN NOISE WAS HEARD IN GARAGE. WHEN LOOKED IN GARAGE WAS FILLED WITH SMOKE AND FIRE WAS COMING OUT OF BOTH SIDES OF WINDSHIELD ON PASSENGER SIDE. PUT OUT FIRE WITH FIRE EXTINGUISHER AND PUSHED OUT OF GARAGE. LARGE HOLE IN DASH ON PASSENGER SIDE WHERE FIRE CAME OUT, STRONG ORDOR OF BURNT PLASTIC AND ELECTRICAL FIRE SMELL.*AK

Incident Dec 5, 2001

VEHICLE WAS SITTING IN ATTACHED GARAGE FOR THREE HOURS WHEN NOISE WAS HEARD IN GARAGE. WHEN LOOKED IN GARAGE WAS FILLED WITH SMOKE AND FIRE WAS COMING OUT OF BOTH SIDES OF WINDSHIELD ON PASSENGER SIDE. PUT OUT FIRE WITH FIRE EXTINGUISHER AND PUSHED OUT OF GARAGE. LARGE HOLE IN DASH ON PASSENGER SIDE WHERE FIRE CAME OUT, STRONG ORDOR OF BURNT PLASTIC AND ELECTRICAL FIRE SMELL.*AK

Incident Dec 5, 2001

INTAKE MANIFOLD IS DEFECTIVE AND VEHICLE WILL STALL AT ANY SPEED. VEHICLE WILL START BACK UP ONCE IT SHUTS OFF. CONTACTED DEALER AND DEALER WAS NOT WILLING TO DO ANYTHING, CONSUMER HAD ANOTHER DEALERSHIP INSTALL NEW INTAKE MANIFOLD GASKET. *AK *TT

Incident Oct 20, 2001

WHILE DRIVING DRIVER'S SEATBACK COLLAPSED. DEALER HAS BEEN NOTIFIED.*AK DRIVER WAS LEFT IN A PRONG POSITION AND HAD TO FIND THE BRAKE PEDAL, CONSUMER WAS ADVISED BY DELAER THAT THIS IS NOT A DEFAULT.*JB

Incident May 9, 2001

THIS IS A PROBLEM IN THE FUEL MANAGEMENT SYSTEM,CAUSING THE ENGINE TO SURGE THEN MISS.I HAD THE CAR IN THE SHOP 6 WEEKS EARLIER,IT RAN FINE TILL TODAY,THIS TIME IT RESULTED IN A FIRE .THE CAR IS A TOTAL LOSS.*AK

Incident Apr 21, 2001

WHILE APPROACHING A STOP SIGN ON A BUMPY ROAD ABS ENGAGED AND CAUSED EXTENDED STOPPING DISTANCE. THIS RESULTED IN AN ACCIDENT WITH A LARGE AMOUNT OF DAMAGE DONE TO BOTH VEHICLES. *AK *JB

Incident Mar 2, 2001

WHILE DRIVING ABS BRAKING SYSTEM FAILED, CAUSING A CRASH. PLEASE PROVIDE FURTHER INFORMATION.*AK

Incident Jan 20, 2001

DRIVER'S SEAT BACK BROKE IN REAR END COLLISION, SENDING DRIVER INTO BACK SEAT, PICTURES AVAILABLE

Incident Jul 20, 1999

SIR: I PURCHASED 2 FIRESTONE TIRES, STYLE "FR410" AND 2 DAYS LATER ON A BUSY I-95 FLORIDA HIGHWAY, AT 65 MPH I GOT A TWO WHOLE BLOWOUT ON A BRAND NEW TIRE. I WAS VERY LUCKY I DID NOT GET KILLED BY THE SPEEDING CARS. I JUST WANT TO REPORT THAT THE "FR410" TIRE IS ALSO DEFECTIVE AND IT SHOULD BE TAKEN OFF THE ROAD. TO TELL YOU THE TRUTH, I AM STILL SHAKING FROM THE ORDEAL. WHAT DO YOU SUGGEST? THEY REPLACED THE DEFECTIVE TIRES WITH ANOTHER 2 FIRESTONE TIRES. I HOPE I DONT HAVE ANY TROUBLE WITH THESE. NEW TIRES IS FT70C. *AK( DOT NUMBER: )

Incident Aug 26, 2000

THE FUSE MARKED "ACC" HAS BEEN CHANGED OUT 3 TIMES AND IT KEEPS BLOWING. ABOUT THE SAME TIME THE A/C QUIT WORKING AS WELL AS THE POWER LOCKS. (SAME SIZE FUSE USED EACH TIME) WHEN I GO TO PUT THE FUSE IN IT SPARKS, I ALSO AM ABLE TO HEAR THE CHIME FOR THE KEY (IF IN THE IGNITION), *AK

Incident Sep 10, 2000

CONSUMER WAS SITTING IN THE PARKING LOT AND BUCKLING SEATBELT. DRIVER'S SIDE SEAT HINGE GAVE WAY AND SEAT BROKE. CONSUMER CONTACTED DEALERSHIP. MECHANIC TOLD HIM THAT THE VEHICLE WAS TOO OLD.*AK

Incident Aug 24, 2000

ABS WILL NOT ENGAGE OR DISENGAGE WHEN STEPPING ON BRAKES. SOMETIMES HAS TO STEP HARDER TO MAKE BRAKES WORK.*AK

Incident Jun 22, 2000

PUSH RODS BENT, MECHANIC TOLD CONSUMER THAT THIS WAS VERY UNUSUAL. NLM

Incident Apr 1, 2000

NONE

Incident Nov 25, 1999

HAD A FRONT BRAKE REALIGNMENT JOB DONE. HEARD NOISES WITH THE BRAKES ANYTIME WHEN DRIVING. CONTACTED LOCAL MECHANIC WHO DETERMINED THAT THE COMPLETE UNIT NEEDED TO BE REPLACED. *AK

Incident Oct 1, 1997

ABS LIGHT IS WORKING INTERMITTENTLY. WHEN DRIVING AT ANY SPEED AND APPLYING THE BRAKES, THERE IS SOME VIBRATION WITHIN THE BRAKE PEDAL. *AK

Incident Sep 1, 1999

INTERMITTENTLY WHENEVER BRAKE ARE APPLYED THE VEHICLE WOULD MAKE LOUD NOISE BEFORE STOPPING; DEALER NOTIFED ON TWO OCCASION AND NOTHING COULD BE FOUNED.

Incident Aug 15, 1997

HEARD A LOUD NOISE WITH THE BRAKES. HAD THE FRONT BRAKES REALIGNED. CONTACTED DEALER, AND THEY CHECKED OUT FINE. LOCAL MECHANIC DETERMINED THAT THE UNIT NEEDED TO BE REPLACED. *AK

Incident Sep 1, 1997

WHEN APPYLING THE BRAKES PEDAL NEARLY GOES TO THE FLOOR. INSTEAD OF THE VEHICLE STOPPING, VEHICLE ACCELERATES FORWARD, CAUSE UNKNOWN. PLEASE GIVE ANY FURTHER DETAILS. *AK

WHEN APPLYING THE BRAKE PEDAL THE VEHICLE ACCELERATED FORWARD. PROBLEM FIRST OCCURED APPROXIMATELY SIX MONTHS AFTER VEHICLE PURCHASED. DEALER STILL NOT FIND THE CAUSE. HOWEVER, BRAKES HAVE BEEN REPLACED. *AK

ENGINE HEAD GASKET BLEW OUT, CAUSING FLUIDS TO SPRAY ALL OVER THE ENGINE AND TRANSMISSION. COOLANT LEAKED OUT OF RADITOR. *AK

Incident Feb 2, 1999

REINFORCEMENT PLATE BEHIND THE REAR BUMPER HAS COMPLETELY RUSTED OUT. DEALER SAYS THIS PLATE NEEDS TO BE REPLACED. *AK

WHILE TRAVELING 35-40MPH & APPLYING BRAKES TO SLOW DOWN. COULD FEEL ABS KICKING IN, BUT VEHICLE FAILED TO STOP. FINALLY VEHICLE STOPPED AFTER GOING SOME DISTANCE. HAD TAKEN VEHICLE TO DEALER & WAS INFORMED BY MECHANIC THE ABS SYSTEM WAS DEFECTIVE & NEEDED CORRECTING. *AK

Incident Jun 28, 1999

RADIATOR HOSE LEAK MADE CAR RUN HOT; REPLACED CATYLIC CONVERTER SO WOULD NOT RUN HOT; FUSE SHORTAGE ALMOST CAUGHT CAR ON FIRE; THE BODY SOUNDS SQUEEKY AND RUSTY WHEN GOES OVER BUMPS

WINDSHIELD GETS FOGGY RESIDUE MAKES POOR VISION; SEAT LATCHES DON'T LATCH FIRST ADJUSTMENT; THEY LATCH WHILE DRIVING;

WHILE DRIVING DOWN THE HIGHWAY AT APPROXIMATELY 55MPH ABS LIGHTS CAME AND STAYED ON. CONTACTED THE DEALER, AND THEY TURNED OFF THE ABS LIGHTS. THEY COULDN'T DETERMINE WHAT THE PROBLEM WAS. *AK

Incident Jul 23, 1999

THE DRIVER'S SIDE SEAT REAR (SUPPORT PART) MOVES, CAUSING DISCOMFORT AND POSSIBLE INJURY IF AN ACCIDENT OCCURED. *YC

Incident Aug 11, 1999

IN RAINY OR HOT CONDITIONS ABS BRAKING LIGHT COMES ON AND OFF. ALSO WHILE DRIIVING , BRAKES WILL ACTIVATE UNEXPECTEDLY. DLR CANNOT DETERMINE THE CAUSE OF THE PROBLEM. PLEASE PROVIDE FURTHER INFORMATION. *AK

Incident Jul 2, 1995

ENGINE STALLS OUT ABOUT EVERY 8 MONTHS BECAUSE THE BELT TIGHTNER NEEDS TO BE REPLACED. BELT TIGHTNER HAS BEEN REPLACED 3 TIMES. *AK

WITH SO MANY COMPLAINTS- WHY WON'T THEY RECALL AND FIX THESE CARS? NO SAFETY DEFEC TMENTIONED IN SUMMARY. *AK

Incident Jun 6, 1999

ABS BRAKING SYSTEM MALFUNCTIONED, CAUSING THE ABS LIGHT TO STAY ON WHILE DRIVING. ALSO, UPON BRAKING VEHICLE JOLTS, CAUSING EXTENDED STOPPING DISTANCE WHICH MAY RESULT IN A CRASH. DEALER REPLACED PARTS, BUT PROBLEM STILL EXISTS. PLEASE PROVIDE FURTHER INFORMATION. *AK

Incident Jan 1, 1995

WHEN APPLYING THE BRAKES THEY WILL ACT LIKE THEY ARE SLIPPING, THEN PEDAL WILL GO TO THE FLOOR, THEN ALL OF A SUDDEN THEY WILL CATCH AND THE CAR JERKS TO A STOP. HAVE TO CHANGE BRAKE PADS VERY FREQUENTLY. ALSO HAVE HAD THE CALIPERS COMPLETLY BREAK OFF CAR! *AK

Incident Jul 6, 1998

CONSUMER WAS AT A STOP SIGN WNEN VEHICLE WOULD NOT CHANGE GEARS, ABOUT 2MINUTES AFTERWARD, VEHICLE WAS FILLED WITH SMOKE. THE FIRE DEPARTMENT PUT FIRE OUT. *AK

Incident Mar 26, 1999

SEATBELT/SHOULDER HARNESS RETRACT OR DEPLOY FOR DRIVERS SEAT

Incident Mar 4, 1998

HEADLIGHTS KEEP GOING OUT ON MY CAR. IT DOESN'T MATTER WHAT SPEED, OR HOW LONG I HAVE BEEN DRIVING. I CALLED THE CHEVROLET SERVICE DEPARTMENT IN MORRIS, ILLINOIS AND WAS TOLD NOT TO BRING IT IN UNTIL THE LIGHTS WON'T STAY ON AT ALL. THE SERVICE MANAGER SAID THIS WAS A COMMON PROBLEM WITH CAVALIERS. I TOOK IT TO A CHEVROLET DEALER IN CARBONDALE, ILLINOIS, AND THEY SAID THE LIGHTS WORKED FINE FOR THEM. I AM AFRAID THAT SOMEONE IS GOING TO HAVE AN ACCIDENT, POSSIBLY FATAL, IF I CAN'T GET MY CAR FIXED. WHO DO I GO TO? *AK

Incident Jul 1, 1997

NO SUMMARY

Incident Jan 10, 1999