2001 Chevrolet Cavalier
Recalls, consumer complaints and crash ratings from NHTSA
Recalls6
Exterior lightingApr 7, 2009, Campaign 09E012000
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Risk
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Remedy
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
SteeringOct 17, 2008, Campaign 08E063000
DORMAN PRODUCTS IS RECALLING 3,900 INTERMEDIATE STEERING SHAFTS DORMAN PART NOS. 425-151, 425-152, AND 425-153, (SOLD UNDER DORMAN'S "OE SOLUTIONS" BRAND NAME), BALKAMP #'S 7-3057, 7-3058, 7-3059 (SOLD UNDER THE "NAPA" BRAND NAME), AND PLATINUM PARTS #'S 2425151, 2425152, AND 2425153 MANUFACTURED DURING THE MONTH OF SEPTEMBER 2007. THESE REPLACEMENT STEERING SHAFTS CAN BE USED ON THE VEHICLES LISTED ABOVE. THE WELD CONNECTING THE INNER TUBE TO THE OUTER TUBE MAY BE DEFECTIVE.
Risk
IF THE WELD FAILS, LOSS OF STEERING COULD RESULT, POSSIBLY RESULTING IN A VEHICLE CRASH.
Remedy
DORMAN WILL NOTIFY OWNERS AND REPLACE THE STEERING SHAFTS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 16, 2008. OWNERS MAY CONTACT DORMAN TOLL FREE AT 1-800-523-2492.
Exterior lightingHeadlightsAug 11, 2008, Campaign 08E050000
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Risk
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
Remedy
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Fuel system, otherStorage, tank assembly, pressure relief devicesMar 12, 2007, Campaign 07E021000
CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.
Risk
FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.
Remedy
DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.
Exterior lightingMar 23, 2006, Campaign 06E026000
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Risk
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Remedy
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Electrical systemIgnition, switchJan 27, 2004, Campaign 04V036000
ON CERTAIN PASSENGER VEHICLES. IF THE ENGINE FAILS TO START AND THE DRIVER HOLDS THE KEY IN THE "START" POSITION FOR AN EXTENDED PERIOD, HIGH CURRENT FLOWS THROUGH THE IGNITION SWITCH, AND SOMETIMES PRODUCES ENOUGH HEAT TO MELT INTERNAL SWITCH PARTS.
Risk
IF THE SWITCH IS DAMAGED, A FIRE COULD OCCUR IN THE STEERING COLUMN, EVEN WITH THE ENGINE OFF AND THE KEY REMOVED. THE FIRE COULD SPREAD TO THE INTERIOR OF THE CAR, WHICH COULD INJURE OCCUPANTS OR CAUSE DAMAGE TO ADJOINING STRUCTURES.
Remedy
DEALERS WILL INSTALL A RELAY KIT IN THESE VEHICLES TO PREVENT HIGH CURRENT FROM FLOWING THROUGH THE IGNITION SWITCH, AND CHECK THAT YOUR CAR WILL START WITH A PROPERLY CHARGED BATTERY AND, IF NECESSARY, REPLACE THE IGNITION SWITCH. OWNER NOTIFICATION WILL BEGIN ON MARCH 1, 2004. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-630-2438, PONTIAC AT 1-800-620-7668, BUICK AT 1-866-608-8080, OR OLDSMOBILE AT 1-800-630-6537. CUSTOMERS CAN ALSO CHECK THEIR VEHICLE ONLINE BY GOING TO WWW.MYGMLINK.COM AND ENTERING THE VEHICLE'S IDENTIFICATION NUMBER.
All recalls issued for this model year. To see whether any are still unrepaired on a specific vehicle, check its VIN at NHTSA.
Recent complaints254 total
Most reported, across all 254 complaints
- Electrical system22%
- Power train14%
- Service brakes, hydraulic13%
Power train, electrical system, engineFiled Mar 18, 2019
TL* THE CONTACT OWNS A 2001 CHEVROLET CAVALIER. THE CONTACT STATED THAT THE GEAR SHIFT WAS DIFFICULT TO MOVE AND THE LEVER BECAME STUCK. OCCASIONALLY, THE KEY BECAME STUCK IN THE IGNITION AND THE GEAR SHIFT WOULD NOT GO INTO GEAR. ALSO, THE HOOD WAS HOT, THE ENGINE OVERHEATED, AND THE VEHICLE EXPERIENCED ELECTRICAL FAILURES. THERE WERE ALSO MULTIPLE UNKNOWN WARNING INDICATORS ILLUMINATED. THE DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT SCHEDULED A DIAGNOSTIC APPOINTMENT WITH AN INDEPENDENT MECHANIC. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURES. THE FAILURE MILEAGE WAS 138,000.
Incident Mar 13, 2019
Electrical system, interior lightingFireFiled May 21, 2018
TL* THE CONTACT OWNS A 2001 CHEVROLET CAVALIER. UPON EXITING THE VEHICLE AND CLOSING THE DOORS, THE INTERIOR DOME LIGHT REMAINED ILLUMINATED. THE CONTACT ALSO NOTICED A BURNING ODOR COMING FROM THE LIGHT BULB WIRING IN THE ROOF. THE VEHICLE WAS NOT TAKEN TO A DEALER FOR DIAGNOSTIC TESTING OR REPAIRS. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 100,000. *LN
Incident May 18, 2018
Electrical systemFiled Nov 6, 2016
IGNITION SWITCH AND THE IGNITION LOCK CYLINDER MALFUNCTIONED IN 2009, ROUGHLY FIVE YEARS AFTER GM'S RECALL. THE ORIGINAL OWNER OF THE VEHICLE TOOK ADVANTAGE OF THE IGNITION SWITCH'S SERVICE. IN ADDITION TO THE RECALL, GM INSTALLED AN IGNITION WIRING HARNESS. BACK IN 2009, THE VEHICLE'S IGNITION WOULD OVERTURN, AND THEN, THE ENGINE WOULD AUTOMATICALLY SHUT-OFF. TO REPAIR THE PROBLEM, BOTH THE IGNITION SWITCH AND LOCK CYLINDER WERE REPLACED AT A COST OF $492. IN 2014, THE IGNITION SWITCH MALFUNCTIONS. THIS TIME, IT APPEARS THE IGNITION LOCK CYLINDER TO BE WORKING PROPERLY. THE IGNITION SWITCH BECAME DAMAGE DUE TO CURRENT FLOW TO THE IGNITION WHEN HOLDING THE KEY IN THE START POSITION. THE HEAT MELTED THE INTERNAL SWITCH. I HAD NOT KNOWN IN 2014 THAT THE PROBLEM WAS THE IGNITION SWITCH. IN THE SAME YEAR, HOWEVER, GM RECALLED A MASSIVE NUMBER OF VEHICLES FOR IGNITION SWITCH DEFECT. CHEVROLET CAVALIER WAS NOT ON THE LIST. TODAY, IT COSTS $180.00, EXCLUDING TAXES AND FEES, TO GET THE IGNITION SWITCH INSTALLED BY A CHEVROLET TECHNICIAN. A LOCKSMITH RATE STARTS AT $90 BUT DOES NOT INCLUDE SERVICE FEE, AND LABOR. BASED ON FEW ONLINE REPORTS, THE INSTALLATION TAKES A MINIMUM OF 20 MINUTES. WOULD INSTALLED THE IGNITION SWITCH MYSELF BUT CANNOT LOCATE STEP BY STEP INSTRUCTIONS. ALL THE CHEVROLET MANUALS OWNED DO NOT PROVIDE INSTRUCTIONS ON REPLACING THE IGNITION SWITCH. IF I DO INSTALL THE IGNITION SWITCH, I AM UNSURE IF THE VEHICLE'S COMPUTER WILL NEED REPROGRAMMING. A FEW REPORTS MADE REFERENCE TO REPROGRAMMING THE VEHICLE'S COMPUTER FOLLOWING THE CHANGING OF THE IGNITION SWITCH. SOLUTION: I THINK GM NEEDS TO ADD CHEVROLET CAVALIER TO THE "RECALL" LIST. THE ALTERNATIVE, IGNITION WIRING HARNESS DOES NOT SUPPORT THE ELECTRICAL SYSTEM ENTIRELY WHEN THE CHARGING SYSTEM LIGHT REMAINS ON THE DASHBOARD.
Incident Jun 9, 2014
StructureFiled Jun 14, 2016
THE WHOLE FRONT DASH HAS MANY CRACKS IN IT AND APPEARS TO BE DANGER SINCE PIECES ARE FLYING OFF AS I DRIVE.
Incident Jun 12, 2013
SteeringFiled Nov 18, 2015
TL* THE CONTACT OWNS A 2001 CHEVROLET CAVALIER. WHILE DRIVING APPROXIMATLEY 35 MPH, AN UNUSUAL NOISE EMITTED FROM THE STEERING WHEEL AND THE ENTIRE INSTRUMENT PANEL ILLUMINATED. IN ADDITION, THE VEHICLE BEGAN TO JERK. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE TROUBLE CODE DETECTED A FAILURE WITHIN THE STEERING COLUMN. THE MECHANIC RESET THE STEERING COLUMN SENSOR; HOWEVER, THE FAILURE PERSISTED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 08E063000 (STEERING). THE VEHICLE WAS NOT REPAIRED FOR A SECOND TIME. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 180,000.
Incident Oct 15, 2015
Service brakesFiled Aug 1, 2015
SOMETIMES, DURING REGULAR BRAKING, REAR BRAKES LOCK AND CAR DOES NOT STOP. HAPPENS ON ASPHALT EVEN AT SLOW SPEEDS. ONLINE RESEARCH REVEALS THAT THIS IS A COMMON ISSUE THAT SEEMS TO STEM FROM A FEW CAUSES AT TIME OF PRODUCTION.
Incident Jul 27, 2015
Electrical system, electronic stability control (ESC)Crash4 injuredFiled Mar 8, 2015
MY VEHICLE WAS IN AN ACCIDENT ON 2/15/2012. I HAD MY VEHICLE TOWED TO GREENLEAF COLLISION INC., LOCATED AT 5100 A. KENTUCKY AVENUE, NASHVILLE,TN 37209,615.320.7818, OWNER [XXX]. ON 2/16/2012 MY VEHICLE WAS TOWED IN TO GREENLEAF COLLISION INC, FOR REPAIRS. ONCE I FOUND OUT FROM GREENLEAF COLLISION, INC. THAT MY CHEVROLET CAVALIER 2001 WAS ON RECALL LIST TO BE REPAIRED FOR "IGNITION SWITCH FAILURE", GENERAL MOTORS. THE GREENLEAF COLLISION INC., HAD MY CHEVROLET CAVALIER 2001, TOWED TO FREELAND CHEVROLET 5333 HICKORY HOLLOW PARKWAY, ANTIOCH, TN. 37013, 615.731.3020. MY CHEVROLET CAVALIER, IS IN THE RECALL FOR "IGNITION SWITCH FAILURE", ONCE MY VEHICLE WAS SENT OVER TO FREELAND CHEVROLET FOR REPAIR OF THE "IGNITION SWITCH FAILURE", TO MY UNDERSTANDING BY GREENLEAF COLLISION INC. I WAS INFORMATED THAT MY VEHICLE THE CHEVROLET CAVALIER, WAS NOT REPAIRED FOR "IGNITION SWITCH FAILURE", ON 3/8/2012 I WAS IN AN ACCIDENT WERE MY CHEVROLET CAVALIER," IGNITION SWITCH FAILURE" . MY WAS TOTALED OUT, THE VEHICLE JUST CUT OFF IN THE MIDDLE OF THE STREET, AND WE WERE HIRE AND TOTALED OUT. MY "IGNITION SWITCH FAILURE" WITH MY CHEVROLET CAVALIER TOTALED OUT, AND WAS NOT REPAIRED, AT FREELAND CHEVROLET ON 3/7/2012 THE" IGNITION SWITCH", WAS NOT REPLACE/NOR REPAIRED. MY VEHICLE WAS TOTALED OUT, AND I WAS LEFT WITHOUT VEHICLE COMPENSATION, AND I WAS INJURED, AND MY GRANDCHILDREN WERE INJURED ALSO. I HAVE AN CLAIM NUMBER WITH GENERAL MOTORS:[XXX]. WHO HAS A THIRD PARTY COMPANY NAMED ESIS/GM CENTRAL CLAIMS UNIT P.O. BOX 300, DETROIT, MI 48265-3000. 800.888.0164. ESIS/GM CENTRAL CLAIMS UNIT HAS NOT PROCESSED MY CLAIM WITH THE" IGNITION SWITCH FAILURE", ON THE CHEVROLET CAVALIER. I REQUEST HELP IN RECEIVING COMPENSATION ON MY TOTALED OUT VEHICLE. YOUR URGENT ASSISTANCE IS GREATLY NEED. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Incident Mar 8, 2012
Electrical systemCrash4 injuredFiled Feb 26, 2015
TL* THE CONTACT OWNED A 2001 CHEVROLET CAVALIER. WHILE DRIVING APPROXIMATELY 25 MPH, THE VEHICLE STALLED WITHOUT WARNING. AS A RESULT, ANOTHER VEHICLE CRASHED INTO THE DRIVER SIDE OF THE CONTACT'S VEHICLE. THE AIR BAGS FAILED TO DEPLOY. THE CONTACT SUSTAINED A BACK INJURY, THE REAR DRIVER SIDE PASSENGER SUSTAINED BODY AND HEAD INJURIES, THE REAR MIDDLE PASSENGER SUSTAINED A HEAD INJURY AND THE REAR MIDDLE PASSENGER SUSTAINED BODY INJURIES. THE INJURIES REQUIRED MEDICAL ATTENTION. A POLICE REPORT WAS FILED. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.
Incident Mar 8, 2012
Electrical systemFiled Jan 26, 2015
TL*THE CONTACT OWNS A 2001 CHEVROLET CAVALIER. THE CONTACT STATED THAT THE VEHICLE FAILED TO START. IN ADDITION, THE CONTACT STATED WHILE DRIVING AT VARIOUS SPEEDS, THE IGNITION KEY WAS SLIPPING IN AND OUT OF THE IGNITION. AS A RESULT, THE INTERIOR LIGHT WAS TURNING ON AND OFF. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHERE IT WAS DIAGNOSED THAT THE IGNITION SWITCH NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 13,000.
Incident Jan 1, 2003
Power train, service brakes, engineFiled Nov 6, 2014
MY CAR ABRUPTLY SLOWED DOWN AND BEGAN TO DRAG AS THOUGH THE TRANSMISSION WAS GOING INTO A LOW GEAR AND THE BRAKES WERE BEING APPLIED. *TR
Incident Oct 23, 2014
Show the 50 most recentShow fewer
Air bags, structureFiled Sep 25, 2014
THE DASHBOARD CRACKED AND I STILL HAVE NOT BEEN ABLE TO GET IT FIXED I HAVE LEARNED SINCE THEN THAT THIS IS A COMMON PROBLEM FOR THE CHEVROLET CAVALIERS AND I WORRY THAT IF I GET INTO AN ACCIDENT THAT MY AIRBAGS WONT PROPERLY DEPLOY BECAUSE OF THE CRACKED DASHBOARD. NOW MY WINDSHIELD FOGS UP CAUSING VISIBILITY ISSUES BECAUSE OF THE LEAKS CAUSED BY THE CRACKING. *TR
Incident Jan 30, 2008
Steering, electrical system, engineFiled Sep 25, 2014
MY KEY CAME OUT OF THE IGNITION WHILE THE CAR WAS STILL RUNNING AND IN THE ON POSITION, AND ALSO ANOTHER TIME THE CAR KEY TURNED OFF BY ITSELF AND I LOST POWER TO THE VEHICLE AND MY BRAKES LOCKED AND ALMOST CAUSED ME TO GET INTO A CRASH. *TR
Incident Feb 12, 2008
Unknown or otherFiled Sep 9, 2014
KEY COMES OUT IF THE IGNITION WHILE CAR IS RUNNING/ IN RUN POSITION
Incident Aug 26, 2014
Electrical systemFiled Aug 5, 2014
KEY CAN BE REMOVED FROM IGNITION WHILE CAR IS IN GEAR AND IN PARK. AND CANNOT BE PUT BACK IN DURNING VEHICLE RUNNING
Incident Jul 30, 2014
Vehicle speed control, electronic stability control (ESC), service brakesCrashFiled Jul 22, 2014
I,WAS COMING FROM WALMART .ONTO THE THREE LANE HIGHWAY ,I CROSSED OVER INTO THE LANE THEN I SAW THIS CAR ,I HIT MY BRAKES ,THEY FROZE AND MY CAR SLID INTO THE FINDER OF THE OTHER CAR ,I COULD NOT STOP AND IT SLED ONTO THE OTHER LANE AND STOPPED. *TR
Incident Dec 8, 2008
Vehicle speed controlFiled May 27, 2014
TL* THE CONTACT OWNS A 2001 CHEVROLET CAVALIER. THE CONTACT STATED THAT WHILE TRAVELING 40 MPH, A RED LIGHT ON THE INSTRUMENT PANEL ILLUMINATED AS THE VEHICLE DECELERATED TO 25 MPH. ALSO, THE CONTACT MENTIONED THAT THE TRACK LIGHT INDICATOR ILLUMINATED AND THE VEHICLE JERKED VIOLENTLY ONCE THE SPEED STARTED TO INCREASE. THE FAILURE RECURRED NEARLY 12 TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN WAS UNABLE TO DIAGNOSE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE WAS 85, 610 AND THE CURRENT MILEAGE 85,615.
Incident May 24, 2014
Electrical systemFiled May 27, 2014
TL* THE CONTACT OWNS A 2001 CHEVROLET CAVALIER. THE CONTACT STATED THAT THE KEY WAS DIFFICULT TO TURN WHEN INSERTED INTO THE IGNITION SWITCH, PREVENTING THE VEHICLE FROM BEING STARTED. THE VEHICLE WAS STARTED AFTER THE CONTACT ATTEMPTED TO TURN THE KEY TO THE START POSITION SEVERAL TIMES. THE MANUFACTURER WAS NOT CONTACTED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO REPLACED THE IGNITION SWITCH. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. THE FAILURE MILEAGE WAS 85,610 AND THE CURRENT MILEAGE WAS 85,615.
Incident May 24, 2014
Power trainFiled May 22, 2014
SES AND DTC P1810 COME UP, THERE IS NO REVERSE, AND P0507 COME UP, RESULTING IN TRACTION CONTROL DISABLED
Incident May 19, 2014
Service brakesFiled Feb 26, 2014
HIT THE BRAKES TO AVOID A REAR END CRASH ANDABS AND TRAC OFF SERVICE LIGHTS ILLUMINATED, THERE WAS NO COLLISION, HAD THE CAR DIAGNOSED WITH BOTH FRONT ABS SENSOR HARNESS WAS WORN-OUT HAD TO FIX AND REPLACE AND COST 398.81$
Incident Dec 9, 2013
Electrical system, visibilityFireFiled Dec 10, 2013
UPON DRIVING VEHICLE AT LOW SPEEDS 20-30 MPH WITH FRONT AND REAR WINDOW DEFROSTER ON,IT BECAME MORE,AND MORE EVIDENT OF A POSSIBLE FIRE. FIRST THERE WAS AN INCREASING BURNING SMELL FOLLOWED BY SMOKE. A CONNECTOR ON THE DRIVERS SIDE KICK PANEL HAS MELTED BEING SO CLOSE TO THE CARPET ITS POSSIBLE THAT IT BEING WINTER MOISTURE FROM MELTED SNOW SOMEHOW MAY HAVE CAUSED THIS TO HAPPEN, A SEARCH ON GOOGLE SEEMS TO PULL MULTIPLE CARS WITH THIS SAME PROBLEM. ALSO I WANT TO NOTE THAT I WAS NOT ABLE TO TURN OFF MY REAR DEFROSTED WITH THE REAR DEFROSTER SWITCH, I HAD TO PULL THE 30 AMP FUSE THAT STILL HAD A COMPLETE CIRCUIT IN IT! *TR
Incident Dec 10, 2013
Suspension, air bags, seat belts, wheelsCrashFiled Jun 3, 2013
2001 CHEVROLET CAVALIER. CONSUMER WRITES IN REGARDS TO VEHICLE PASSENGER SIDE FRONT WHEEL ASSEMBLY COLLAPSED. *SMD THE CONSUMER STATED HIS VEHICLE COLLIDED WITH A PARK CAR. THE SEAT BELT WAS TIGHT, AND THE AIR BAG FAILED TO DEPLOY. THE CONSUMER STATED THE SIDE WHEEL WAS AT A 90 DEGREE PERPENDICULAR ANGLE TO THE SIDE OF THE VEHICLE. THE ENTIRE WHEEL ASSEMBLY LOOKED DESTROYED.
Incident Jun 1, 2013
Fuel system, gasoline, electrical systemFiled Oct 29, 2011
I WAS DRIVING DOWN THE FREE WAY AND ALL OF A SUDDEN THE CAR LOST ALL ACCELERATION POWER. GOT IT TO THE SIDE OF THE ROAD AND TRIED TO RESTART THE CAR. IT TRIES BUT WON'T START. ALL POWER IS WORKING AND STARTER AND ALTERNATOR ARE TRYING TO WORK. *TR
Incident Oct 28, 2011
StructureFiled Oct 6, 2011
TL* THE CONTACT OWNS A 2001 CHEVROLET CAVALIER COUPE. THE CONTACT STATED THAT THE VEHICLE WOULD NOT PASS INSPECTION DUE TO RUSTING OF THE SUB FRAME SUSPENSION UNIT. NEITHER THE DEALER NOR THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 64,400.
Incident Sep 13, 2011
StructureFiled Jul 20, 2011
TL* THE CONTACT OWNS A 2001 CHEVROLET CAVALIER. THE CONTACT STATED THAT THE DASHBOARD WAS FRACTURED IN SIX PLACES. HE ALSO NOTICED THAT THE DRIVERS SIDE OF THE DASHBOARD WAS CAVED IN. THE VEHICLE WAS TAKEN TO A DEALER WHO OFFERED NO ASSISTANCE. THE MANUFACTURER WAS CONTACTED AS WELL AND THEY ADVISED HIM THAT THE VEHICLE WAS OVER 10 YEARS OLD AND THE FAILURE WAS JUST WEAR AND TEAR. THE FAILURE MILEAGE WAS APPROXIMATELY 70,000. THE VIN WAS UNAVAILABLE. UPDATED 09/08/2011 *LN *TR
Incident Jul 19, 2009
Engine and engine coolingFireFiled Jun 1, 2011
2001 CHEVROLET CAVALIER, UNIT 1 WAS TRAVELING EASTBOUND ON IR 80 IN THE RIGHT LANE. UNIT 1 CAUGHT ON FIRE IN THE ENGINE COMPARTMENT AREA WHILE DRIVING. *BF (OHIO TRAFFIC CRASH REPORT # 10-0259-90) *JB
Incident Apr 8, 2011
StructureFiled Feb 15, 2011
TL*THE CONTACT OWNS A 2001 CHEVROLET CAVALIER. THE CONTACT STATED THAT THE DASHBOARD HAD THREE CRACKS IN IT WHICH ALLOWED COLD AIR TO ENTER THE VEHICLE. THE FAILURE ALSO CAUSED THE WINDSHIELD TO BECOME FOGGY MAKING VISIBILITY POOR. THERE WAS A CRACK LOCATED ON THE PASSENGER SIDE VENT ON THE DASHBOARD AND THE OTHER TWO CRACKS WERE LOCATED IN THE MIDDLE OF THE DASHBOARD BY THE DEFROST VENT WHICH FAILED TO MINIMIZE THE FOG. THE MANUFACTURER STATED THAT THE REPAIR COST WOULD BE COVERED BUT LATER NOTIFIED THE CONTACT THAT SINCE THE CASE WAS CLOSED, THE COST WOULD NOT BE COVERED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 72,000.
Incident Nov 15, 2010
TiresFiled Dec 27, 2010
TL*THE CONTACT OWNS A 2001 CHEVROLET CAVALIER EQUIPPED WITH DOUGLAS XTRAC-TRAC TIRES (NA), SIZES P185/75/R14. THE CONTACT WAS DRIVING 70 MPH WHEN THE DRIVER SIDE TIRE BLEW OUT SUDDENLY. THE TIRE DID NOT EXHIBIT ANY LEAKS PRIOR TO THE FAILURE AND THERE WAS NO ALIGNMENT NEEDED. THE TIRE WAS SUPPOSED TO BE WARRANTED UP TO 45,000 MILES. THE MANUFACTURER STATED THAT THE TIRES WERE NOT COVERED UNDER WARRANTY. THE VIN WAS UNAVAILABLE. THE FAILURE MILEAGE OF THE TIRE WAS APPROXIMATELY 20,000.
Incident Dec 26, 2010
Electrical system, visibilityFiled Dec 26, 2010
THE DEFROST WOULDN'T WORK WHEN REALLY RAINY OR COLD AND THIS STARTED IN WINTER OF 2009. IN SUMMER OF 2010 THE AC WORKED ONLY WHEN FAN WAS ON MED OR HIGH, BUT FINALLY ONLY ON HIGH. THESE WERE ELECTRICAL WIRING PROBLEMS: AC DUE TO BLOWER RESISTOR BURNED OUT AND DEFROST CAUSED BY A RESISTOR BURNED OUT. AC STARTED TO SMELL LIKE SOMETHING ELECTRICAL WAS BURNING. IF THIS WASN'T FIXED ANY SOONER COULD HAVE CAUSED FIRE I'M SURE. NOW I HAVE TO SEE WHAT NEEDS TO BE FIXED NOW THAT I HAVE SERVICE ENGINE CHECK LIGHT ON. WITH THESE ELECTRICAL ISSUES HAD NO SERVICE ENGINE CHECK LIGHT COME ON. O2 SENSOR REPLACED @ 68,000 AND CATALYTIC CONVERTER CHANGED @ 56,000 AND THE RECALL FOR THIS VEHICLE REPLACED. *TR
Incident Jan 9, 2009
Fuel system, gasolineFiled Sep 13, 2010
TL* THE CONTACT OWNS A 2001 CHEVROLET CAVALIER. WHILE DRIVING APPROXIMATELY 65-70 MPH, THE VEHICLE STALLED WITHOUT WARNING. HE WAS ABLE TO MANEUVER THE VEHICLE OFF THE ROADWAY AND AFTER WAITING 15-20 MINUTES, HE AS ABLE TO RESTART THE VEHICLE. THE VEHICLE WAS NOT TAKEN FOR DIAGNOSIS OR REPAIRS. THE FAILURE OCCURRED INTERMITTENTLY FOR ONE YEAR. IN ADDITION, THE CONTACT STATED THERE WAS AN ABNORMAL GASOLINE ODOR EMITTING FROM THE VEHICLE. HE WAS ABLE TO LOCATE A RECALL FOR THE FAILURE UNDER NHTSA CAMPAIGN ID NUMBER: 07E021000 (FUEL SYSTEM, OTHER: STORAGE: TANK ASSEMBLY: PRESSURE RELIEF DEVICES) BUT DID NOT CONFIRM IF HIS VEHICLE WAS INCLUDED IN THE RECALL. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 123,000 AND THE CURRENT MILEAGE WAS 133,000.
Incident Sep 5, 2009
SteeringFiled Sep 2, 2010
TL*THE CONTACT OWNS A 2001 CHEVROLET CORVETTE. THE CONTACT STATED THAT HE TOOK THE VEHICLE IN FOR RECALL NHTSA CAMPAIGN ID NUMBER: 04V060000 COMPONENT: STEERING:COLUMN LOCKING:ANTI-THEFT DEVICE. THE VEHICLE WAS SERVICED FOR THIS RECALL IN 2008 AND NOW THE FAILURE HAS RECURRED. THE CONTACT STATED THAT THIS IS A SAFETY ISSUE DUE TO THE FACT THAT THE REMEDY FOR A SAFETY ISSUE FAILED CREATING THE SAME SAFETY CONDITION. THE FAILURE AND CURRENT MILEAGES WERE 27,000. UPDATED 12/22/10. *LJ
Incident Aug 18, 2010
Vehicle speed controlFiled Jul 22, 2010
TL*THE CONTACT OWNS A 2001 CHEVROLET CAVALIER. WHILE DRIVING 30 MPH, THE RPMS BEGAN TO INCREASE AND SUDDENLY, THE VEHICLE ACCELERATED ON ITS OWN. THE CONTACT APPLIED EXTREME FORCE TO THE BRAKES AND SHIFTED INTO NEUTRAL GEAR IN ORDER TO SLOW DOWN. THE VEHICLE CONTINUED TO LUNGE FORWARD EVERY TIME THE VEHICLE CAME TO A STOP. THE FAILURE OCCURRED THREE TIMES. THE DEALER WAS NOT NOTIFIED. THE FAILURE WAS NOT DIAGNOSES OR REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 209,000.
Incident Jul 21, 2010
Air bags, seat beltsCrashFiled Jun 9, 2010
CAR WAS INVOLVED IN A ACCIDENT WITH A 18 WHEELER IT HIT THE SIDE THE WENT AROUND TO THE FRONT THERE WERE THREE PEOPLE IN THE CAR TWO KIDS AND ONE ADULT DRIVER THE SEAT BELTS POPPED ALOOSED AND THE AIR BAGS DID NOT DEPLOY THERE WERE PICTURES TAKEN AT THE SCENE AND THERE IS A POLICE REPORT THIS IS A VERY BAD PROBLEM MY KIDS ARE ONLY TWO AND FIVE AND THERE SEAT BELTS DID NOT HOLD!!!!!!!!!!!!!!!!!! *TR
Incident Jun 3, 2010
Steering, electrical systemFiled Apr 17, 2010
WHENEVER THE STEERING WHEEL IS TURNED A "CLUNK" CAN BE HEARD AND FELT. THIS HAPPENED BACK IN ABOUT 2003 AND STILL CONTINUES TO THIS DAY. ON SECOND COMPLAINT, ODOMETER NUMBERS NO LONGER SHOW UP PROPERLY. ONLY WHEN PRESSURE IS APPLIED TO THE ODOMETER AREA DO THE NUMBERS LIGHT UP. *TR
Incident Jan 1, 2003
Engine and engine coolingFiled Apr 13, 2010
3 TIMING CHAINS AND TENSIONERS IN 4 YEARS ON A 2001 CAVALIER 2,2 SEEM TO BE A PROBLEM IN DESIGN. *TR
Incident Jul 15, 2004
Seat beltsCrash2 injuredFiled Apr 7, 2010
2001 CHEVROLET CAVALIER. LETTER FROM REGARDING CHEVROLET SEAT BELT MALFUNCTION. *TGW THE CONSUMER STATED THE PASSENGER SIDE SEAT BELT DID NOT RESTRAIN HIS WIFE DURING AN ACCIDENT, BUT INSTEAD IT EXTENDED ITS FULL LENGTH. CONSEQUENTLY, THE CONSUMERS WIFE WAS TOSSED AROUND IN THE VEHICLE AND HIT HER HEAD ON THE WINDOW WHICH CAUSED INJURIES TO HER FACE, NOSE AND EYES. HER ANKLE AND FINGERS WERE BROKEN AND RIGHT WRIST WAS FRACTURED. HIS WIFE ALSO SUSTAINED A STRESS FRACTURE ON HER LOWER SPINE. THE CONSUMER SUFFERED A MINOR INJURY TO HIS THUMB. *JB UPDATED 04/29/10.*JB UPDATED 03/11/11*JB
Incident Mar 2, 2007
Fuel system, gasolineFiled Oct 11, 2009
FUEL GAUGE NOT WORKING JUST LAST MONTH I HAD TO BE TOWED BECAUSE MY GAUGE SHOWED FULL ALSO GOT FUEL SEND THROUGH ROAD SIDE SERVICE ON 2 OCASSIONS I TRIED TO KEEP TRACK OF BY WRITING DOWN MY MILEAGE BUT THEN THE FUEL GAUGE APPEARS TO BE WORKING FOR A WHILE. *TR
Incident Aug 24, 2009
Service brakes, hydraulicCrashFiled Sep 12, 2009
THE REAR BRAKES ON THE CHEVROLET CAVALIER CAN BECOME UNADJUSTED AND WHEN YOU HAVE TO BRAKE QUICKLY, THE BRAKES CAN LOCKUP AND SEND YOU INTO A SKID. THIS HAPPENED TO ME AND CAUSED ME TO HAVE AN ACCIDENT, BUT I WAS NOT AWARE OF THE TYPE BRAKING SYSTEM THE CAR IS EQUIPPED WITH SO I DIDN'T UNDERSTAND WHY THE CAR WENT INTO A SKID UNTIL MUCH LATER, AFTER I ALMOST REAR ENDED SOMEONE. PERSONNEL AT THE REPAIR SHOP EXPLAINED THE BRAKING SYSTEM TO ME. *TR
Incident Aug 16, 2008
Engine and engine cooling, electrical systemFiled May 27, 2009
TL*THE CONTACT OWNS A 2001 CHEVROLET CAVALIER. WHILE DRIVING 25-35 MPH, THE TRACTION LIGHT FLASHED AND THE ENGINE BEGAN TO MAKE KNOCKING AND RATTLING NOISES. THE CONTACT PULLED THE VEHICLE OVER TO CHECK THE ENGINE AND THE NOISE STOPPED. WHEN HE BEGAN DRIVING AGAIN, EVERY LIGHT ON THE INSTRUMENT PANEL ILLUMINATED. THE CONTACT PULLED OVER AGAIN AND TURNED OFF THE VEHICLE. WHEN HE RESTARTED THE VEHICLE, THE KNOCKING STOPPED AND THE LIGHTS STOPPED FLASHING. THE FAILURE HAS OCCURRED ON THREE OCCASIONS. A MECHANIC DIAGNOSED THE VEHICLE, BUT COULD NOT REMEDY THE ISSUE. THE CONTACT IS AFRAID TO DRIVE THE VEHICLE. THE CURRENT MILEAGE WAS 67,358 AND FAILURE MILEAGE WAS 67,000.
Incident May 21, 2009
Fuel system, gasoline, electrical systemFiled Mar 11, 2009
IN DECEMBER, 2006 I HAD A NEW ALTERNATOR AND A NEW FUEL PUMP PUT IN (895.00). 1/10/07 MY IGNITION MODULE AND THE FUEL PRESSURE REGULATOR WENT OUT (695.45). 5/14/07 MY IGNITION COIL NEEDED REPLACING (252.18). NOVEMBER 8, 2007 I NEEDED TO REPLACE THE IGNITION SWITCH AND VALVE COVER GASKET ($500) I'M AM TIRED OF REPAIRING. IT'S GOT AN ELECTRICAL PROBLEM THAT'S CAUSING MY IGNITION STUFF TO BURN OUT. *TR
Incident Jan 10, 2007
Engine and engine cooling, fuel system, gasoline, electrical system, equipmentFiled Dec 27, 2008
IN DECEMBER, 2006 I HAD A NEW ALTERNATOR AND A NEW FUEL PUMP PUT IN (895.00). 1/10/07 MY IGNITION MODULE AND THE FUEL PRESSURE REGULATOR WENT OUT (695.45). 5/14/07 MY IGNITION COIL NEEDED REPLACING (252.18). NOVEMBER 8, 2007 I NEEDED TO REPLACE THE IGNITION SWITCH AND VALVE COVER GASKET ($500) I'M AM TIRED OF REPAIRING. IT'S GOT AN ELECTRICAL PROBLEM THAT'S CAUSING MY IGNITION STUFF TO BURN OUT. *TR
Incident Dec 28, 2006
Fuel system, gasolineFiled Nov 29, 2008
FUEL PUMP FAILURE ON A 2001 CHEVY CAVALIER WITH ONLY 67000 MILES. ESTIMATES FOR PARTS AND LABOR RUN APPROX. 400 - 500 DOLLARS . *TR
Incident Nov 18, 2008
Engine and engine cooling, electrical systemFiled Sep 16, 2008
TL*THE CONTACT OWNS A 2001 CHEVROLET CAVALIER. ONE DAY AFTER PURCHASING THE VEHICLE, IT WOULD NO LONGER START. THE VEHICLE WAS TOWED TO A MECHANIC AND AN INJECTOR, PUSH ROD, AND SPARK PLUG WERE INSTALLED. APPROXIMATELY TWO DAYS AFTER RETRIEVING THE VEHICLE, IT WOULD NOT START AGAIN. THE CURRENT AND FAILURE MILEAGES WERE 91,000. UPDATED 10/16/08. *LJ UPDATED 10/17/08. *JB
Incident Sep 4, 2008
Electrical systemFiled Aug 18, 2008
AIR BAGS WILL NOT WORK, RUNNING LAMPS OR HEADLIGHTS WILL NOT WORK WINDOW WASHERS WILL NOT WORK, WIPERS ERRATIC, ETC.*TR
Incident Jan 11, 2007
Fuel system, gasolineFiled Aug 13, 2008
VEHICLE'S ENGINE TURNED OFF WHILE TRAVELING 65 MPH. PULLED OVER SAFELY. CRANKED BUT WOULD NOT START. TOWED TO GM DEALERSHIP. VEHICLE CHECKED BY DEALERSHIP DETERMINE FUEL PUMP NEEDS REPLACING. FUEL PUMP REPLACED AT A COSTS OF $ 640.00 CAR HAS ONLY 29000 MILES ON IT. OWN A 2001 OLDS ALERO. FUEL PUMP HAS BEEN REPLACED TWICE. ONLY 76000 MILES ON VEHICLE. *TR
Incident Aug 13, 2008
Fuel system, gasolineFiled Aug 1, 2008
THE CAR WAS BOUGHT AND THE RECALL HAS CAUSED OTHER PROBLEMS. SO NOW THE CAR CAN NO LONGER BE USED. PLEASE HELP ME IN THIS THANK YOU. *TR
Incident Dec 7, 2007
TiresFiled Jun 29, 2008
I HAVE HAD SEVERAL FLAT TIRES ON THE SET OF BF GOODRICH TIRES ON MY 2001 CAVALIER. THE TIRES HAVE NOT SUFFERED ANY ROAD DAMAGE, BUT HAVE INSTEAD JUST DRY ROTTED TO THE POINT WHERE THEY GO FLAT AS I AM DRIVING. THIS HAS HAPPENED TO ME AT LEAST 4 TIMES AND AT ONE POINT I WAS GIVE FOUR BRAND NEW BF GOODRICH TIRES TO COMPENSATE FOR THE PROBLEMS THAT I HAVE. THE PROBLEMS DID NOT STOP THERE AND I HAVE SINCE HAD SEVERAL FLATS THAT TOOK PLACE AS I WAS DRIVING, WHICH AS ANYONE KNOWS IS A HORRIBLE TIME TO HAVE A FLAT TIRE. THE TIRES ARE UNSAFE AND MAY EVENTUALLY LEAD TO A HORRIBLE ACCIDENT. *TR
Incident Jun 28, 2008
Exterior lightingFiled May 5, 2008
DAYTIME RUNNING LIGHTS HAVE MALFUNCTIONED, HIGH BEAMS WILL NOT WORK. AN ELECTRICAL WIRING CONNECTOR TO THE HEADLIGHTS IS LOCATED UNDER THE BATTERY TRAY AND IS CORRODED AND CRACKING. *TR
Incident May 2, 2008
Power trainFiled Apr 22, 2008
TL*THE CONTACT OWNS A 2001 CHEVROLET CAVALIER. WHILE DRIVING APPROXIMATELY 45 MPH, THE CONTACT HEARD A POPPING SOUND AND FELT SOMETHING DROP FROM THE VEHICLE. THE VEHICLE STOPPED AND WOULD NOT MOVE; THEREFORE, IT HAD TO BE TOWED. THE CURRENT MILEAGE WAS 47,675 AND FAILURE MILEAGE WAS 47,525.
Incident Apr 12, 2008
Electrical systemFiled Feb 8, 2008
TL*THE CONTACT OWNS A 2001 CHEVROLET CAVALIER. WHILE DRIVING AT VARIOUS SPEEDS, THE HEADLIGHTS WOULD SPORADICALLY FAIL AND CAUSE POOR VISIBILITY. SHE TOOK THE VEHICLE TO A MECHANIC AND THEY STATED THAT THE WIRING HARNESS WAS CORRODED IN THE PLASTIC SLEEVES, WHICH CAUSED THE HEADLIGHTS TO FAIL. THE VEHICLE HAS NOT BEEN REPAIRED. THE MANUFACTURER DID NOT PROVIDE ANY ASSISTANCE. THE FAILURE AND CURRENT MILEAGES WERE 131,000.
Incident Jan 19, 2008
Power trainFiled Jan 30, 2008
I WAS DRIVING AT 40 MILE PH AND ALL OF A SUDDEN THE CAR HESITATED ACTED LIKE IT COULDN'T GET INTO GEAR -THE TRACK OFF LIGHT WAS ON-I WAS DRIVING ON FLAT SURFACE NO WET CONDITIONS THIS HAPPENED MORE THEN TEN TIMES. HAD CAR LOOKED AT BY MECHANIC COULD NOT EXPLAIN IT RESETS AFTER TURNING OFF CAR AND STARTING IT UP AGAIN IT WAS CHECKED ON COMPUTER FOUND NO PROBLEM BUT ON LAST TIME THE CAR DIED AS I WAS DRIVING INTO THE REPAIR SHOP IT WAS AGAIN CHECK AND THE REPAIR MAN SHOWED ME THAT HE SHOULDN'T GET ANY INFO BECAUSE IT WASN'T SENDING INFO TO HIS COMPUTER. THIS SCARES ME I DRIVE MY TWO YOUNG CHILDREN TO SCHOOL IN THIS CAR .IT IS STILL DRIVABLE BUT FOR SHORT DISTANCES. I I HAVE CONTACTED MANUFACTURER THEY SAY THEY HAVE NO INFO ON THIS HAPPENING TO ANYONE ELSE. I WILL BE TAKING IT BACK TO DEALER TO PUT ON THEIR COMPUTER TO SEE IF THEY CAN FIND OUT WHAT'S WRONG MY REPAIR PERSON THINKS THE PCM NEEDS REPLACED. *TR
Incident Oct 28, 2007
NHTSA crash ratings
2001 Chevrolet Cavalier 2-DR.
- Front, driver
- 3 out of 5 stars
- Front, passenger
- 4 out of 5 stars
- Side, front seat
- 1 out of 5 stars
- Side, rear seat
- 2 out of 5 stars
- Rollover
- Not Rated
2001 Chevrolet Cavalier 4-DR.
- Front, driver
- 4 out of 5 stars
- Front, passenger
- 4 out of 5 stars
- Side, front seat
- 1 out of 5 stars
- Side, rear seat
- 3 out of 5 stars
- Rollover
- 4 out of 5 stars
Rated under NHTSA's pre-2011 program, which scored each seat. These stars can't be compared with ratings from 2011 on.
Decode a 2001 Chevrolet Cavalier VIN
Get the exact trim, engine, transmission, plant and safety equipment for one specific car.