2004 Chevrolet Corvette

I have owned this vehicle the last 6 years. When the amount of fuel is over one-half tank, there is an abnormal odor of fuel. When pulling into the garage, there's fuel leaking if over one-half tank. Once the engine is cut off the fuel leak ceases. To control the issue, I keep the fuel level at less than one-half tank. A certified local mechanic determined the fuel tank and crossover tube cross connector needed to be replaced. The vehicle has not been repaired. The mechanic stated the failure was related to NHTSA Action Number: PE10015 (Fuel System, Gasoline). The approximate failure mileage was 26,500, when i bought the car. The mechanic stated that GM did issue a service bulletin around 2010 stating that GM would make repairs if the failure occurred within 10 years/100,000 miles. The local GM dealer will not repair my vehicle since it is out of time frame window. It's not fair to those who bought the car after the 10-year cutoff point. or do not drive these vehicles very much.

Incident Sep 10, 2017

The contact owns a 2004 Chevrolet Corvette. The contact stated while driving at slow speeds and approaching a stop, an abnormal odor of fuel was detected. The contact noticed there was fuel leaking in the garage. The vehicle was taken to the local dealer where it was diagnosed that the fuel tank and crossover tube cross connector needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure but no additional assistance was provided. The contact stated the failure was related to NHTSA Action Number: PE10015 (Fuel System, Gasoline). The approximate failure mileage was 41,000. The contact stated that the vehicle was repaired and is seeking reimbursement from the manufacturer for the cost.

Incident Aug 20, 2022

The contact's friend owns a 2004 Chevrolet Corvette. The contact stated that while his friend was starting the vehicle, the steering wheel seized. The dealer was made aware of the failure but informed the contact that they were unable to assist due to the age of the vehicle. The vehicle was not diagnosed nor repaired. The manufacturer was not made aware of the failure. The contact related the failure to NHTSA Campaign Number: 04V060000 (Steering) however, the VIN was not included in the recall. The failure mileage was approximately 75,000.

Incident Jul 31, 2022

Left side fuel tank developed a leak- this is a problem known to GM- they offered warranty repairs for ten years-I purchased the vehicle after this additional warranty had expired- my complaint is this is a known defective part which I would replace at my expense however GM has discontinued this part- I feel that while GM will no longer cover the cost of parts and labor the replacement parts should be available

Incident Jun 1, 2019

The vehicle has a fuel leak. I just purchased this vehicle a few weeks ago, it's 16 years old and has only 36,000 miles on it. It smelled terribly of fuel when I purchased it. I had the vehicle looked at and it has a fuel leak where the quick connectors connect to the fuel tanks. Anyhow, there's a special coverage adjustment which extended the warranty to 10 yrs/100,000 miles. I'm obviously outside of those parameters, but I feel that since the manufacturer admitted fault and stated that my particular VIN is affected, they should be held accountable for fixing a safety issue with my vehicle. How they got away with issuing a special coverage adjustment for such an issue rather than a simple recall is beyond me.

Incident Jul 28, 2021

leaking left fuel tank

Incident Jul 2, 2021

Have been in contact with 2 employees from GM, called and left voicemails and sent emails. No reply after it was requested that I take the Corvette to my local dealership for diagnosis. The ECL motor is not working property, causing the steering wheel to lock up and fuel supply to shut off. Sent attachment with diagnosis; however, no reply. GM indicated that this was previously fixed, but it obviously was not. My assertion is that there should not be a expiration date on safety recalls, and the ECL motor is not working properly creating a very dangerous situation. This happens every time that I drive the car. There have been several instances of me starting the car, pulling into traffic, and then the car shuts down. It has been very scary as I pull the key and wait 10 seconds to restart the car. Sometimes I have to do it twice. It is my contention that GM should be responsible for fixing this problem that was previously identified by GM as an issue/concern.

Incident Jul 20, 2021

THE CONTACT OWNS A 2004 CHEVROLET CORVETTE. THE CONTACT STATED WHILE DRIVING 35 MPH, THE CONTACT SMELLED AN ABNORMAL FUEL ODOR COMING FROM THE ENGINE COMPARTMENT. THERE WAS NO WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TOWED TO THE LOCAL DEALER TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE FUEL TANK CROSSOVER PIPE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT YET REPAIRED. THE CONTACT RELATED THE ISSUE TO AN UNKNOWN MANUFACTURER’S RECALL. THE MANUFACTURER WAS INFORMED OF THE FAILURE BUT OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 36,000.

Incident Jul 13, 2020

GAS SMELL COMING FROM REAR OF CAR AFTER DRIVING. NO VISIBLE LEAKS, BUT LEAKING FUEL VAPOR.

Incident Apr 18, 2021

WHILE TRAVELING DOWN THE FREEWAY AT AROUND 80 MPH ON A STRAIGHT FLAT SURFACE, THE CORVETTE SHARPLY VEERED TO THE SIDE AS I HEARD A LOUD SCREECH FROM ONE OF THE BRAKES IT LASTED FOR ABOUT A SECOND. THE TURN WAS SO ABRUPT I THOUGHT I WAS GOING TO ROLL BUT AFTER FISHTAILING WAS ABLE TO GET THINGS GOING STRAIGHT. IMMEDIATELY A SERVICE ACTIVE HANDLING SYSTEM MESSAGE POPPED UP. HAPPENED ABOUT A WEEK LATER GOING ABOUT 60 MPH NOT QUITE AS ABRUPT. THIS CONDITION COULD HAVE LEAD TO A FATALITY.

Incident Mar 16, 2021

GASOLINE LEAK FROM A CROSSOVER PIPE CONNECTION CONNECTING THE TWO GAS TANKS. DRIPPIG RAW FWEL ONTO A HOT EXHAUST SYSTEM AND TRANSMISSION. COMMOM PROBLEM ON TNIS YEAR AND MODEL. REPAIR WAS COVERED FOR FIRST 10 YEARS AND 100,000 MILES BY MANUFACTURER. STILL AND ISSUE WITH CARS NOT REPAIRED.

Incident Nov 15, 2020

WHEN USING TELESCOPING STEERING WHEEL THE ACTIVE HANDLING LIGHT A CAME ON AND THE CAR PULLED HARD TO THE LEFT INTO ONCOMING TRAFFIC LANE WHILE DRIVING . I HAD NEVER USED THE TELESCOPING STERLING WHEEL FEATURE PRIOR TO THIS .*DT*JB

Incident Jun 15, 2018

AFTER TELESCOPING STEERING WHEEL, ACTIVE HANDLING SYSTEM WARNING LIGHT CAME ON AND WHILE DRIVING CAR PULLED LEFT INTO ONCOMING TRAFFIC LANE

Incident Aug 1, 2018

THE EBCM DOES NOT WORK I'VE TRIED TO HAVE IT REPAIRED 3 TIMES NOW TOLD UNREPAIRABLE GM NO LONGER MAKES THE PART WITH SO MANY VETTE OWNERS HAVING THIS PROBLEM YOU WOULD WONDER WHY THERE ISN'T SOMETHING BEING DONE CAUSE NOW WE ARE DRIVING VEHICLE NOT THE WAY IT WAS INTENDED SPOKE TO GM MANY TIMES PRETTY TOLD DISCONTINUED SORRY TOO BAD YOUR ON YOUR OWN

Incident Oct 1, 2019

TL* THE CONTACT OWNS A 2004 CHEVROLET CORVETTE. WHILE DRIVING, THE SERVICE COLUMN LOCK INDICATOR ILLUMINATED. THE CONTACT TOOK THE VEHICLE TO CASEY CHEVROLET (11700 JEFFERSON AVE, NEWPORT NEWS, VA 23606, (757) 320-1476), BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 68,000.

Incident Nov 22, 2019

PREPURCHASE RECALL SEARCH.

Incident Nov 4, 2019

TL* THE CONTACT OWNS A 2004 CHEVROLET CORVETTE. WHILE THE VEHICLE WAS PARKED OUTSIDE THE GARAGE AND THE IGNITION WAS STARTED, THE CLUTCH WAS RELEASED AND THE VEHICLE SEIZED. ALSO, THE STEERING COLUMN LOCK WARNING MESSAGE ILLUMINATED ON THE INSTRUMENT PANEL. THE CONTACT ASSOCIATED THE FAILURE WITH NHTSA CAMPAIGN NUMBER: 04V060000 (STEERING). THE VEHICLE WAS NOT ABLE TO BE DRIVEN. THE CONTACT CALLED MAGUIRE CHEVROLET CADILLAC OF ITHACA (LOCATED AT 35 CINEMA DR, ITHACA, NY 14850, (607) 272-9292) AND NOTIFIED THEM OF THE FAILURE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE DEALER AND MANUFACTURER WERE NOT NOTIFIED. THE FAILURE MILEAGE WAS 6,890. *TR

Incident Oct 6, 2019

TL* THE CONTACT OWNS A 2004 CHEVROLET CORVETTE. THE CONTACT STATED THAT THE STEERING COLUMN WAS MALFUNCTIONING. THE LOCKING PIN FOR THE ANTI-THEFT DEVICE FOR THE STEERING COLUMN WAS NOT WORKING AND STOPPED THE VEHICLE FROM MOVING. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS CONTACTED AND STATED THAT THERE WERE NO RECALLS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 33,200.

Incident Jul 18, 2019

THE FUEL TANK LEAKS WHEN THE ENGINE IS RUNNING. IN 2010, THIS CONDITION RESULTED IN AN ADDITIONAL WARRANTY FOR THE ISSUE THAT EXPIRED IN 2014, BUT I HAVE A LOWER MILEAGE CAR (LESS THAN 18,000 MILES) SO THE ISSUE DID NOT OCCUR UNTIL NOW. THE PROBLEM EMERGED SUDDENLY AFTER FULLY REFILLING THE FUEL TANK RECENTLY.

Incident Jul 14, 2019

TL* THE CONTACT CALLED ON BEHALF OF AN OWNER OF A 2004 CHEVROLET CORVETTE. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC DUE TO A FUEL LEAK. THE MECHANIC DETERMINED THAT THE PLASTIC OPENING OF THE FUEL TANK, WHICH CONNECTED A PRIMARY TANK TO THE SECONDARY TANK HOSE, WAS FRACTURED AND FUEL WAS LEAKING. THE VEHICLE NEEDED A NEW FUEL TANK AND CROSSOVER COMPONENTS. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 39,000.

Incident Jun 19, 2019

I BOUGHT A 2004 CORVETTE USED WITH 67K MILES ON IT. THE DEALERSHIP HAD ONLY FILLED THE TANK TO LESS THAN HALF FULL.,AFTER MY FIRST FILL UP GAS POURED OUT FROM UNDERNEATH, BEHIND DRIVERS SIDE TIRE. I PAID $ 16,500 FOR THE CAR , SO I TOOK IT BACK TO DEALER AND THEY SAID THEY WOULD REPAIR. AFTER ABOUT 10 DAYS I WENT TO DEALER AND NOTICED THE CAR HAD NOT EVEN MOVED. HE SAID THEY DID NOT KNOW HOW TO FIX IT AND THEY HAD ANOTHER DEALERSHIP IN ANOTHER STATE THAT THEY WOULD NEED TO TAKE IT TO. I LEFT WITH THE CAR UNREPAIRED.IS THERE ANYTHING I CAN DO ? I BELIEVE IT IS A RECALL ON THE CROSSOVER TUBE AND THE RECALL HAS EXPIRED. CLOSE TO A $1500 TO $1800 REPAIR

Incident Jan 15, 2019

THERE IS A KNOWN LEAK IN THE LEFT FUEL TANK. MY VEHICLE HAS SYMPTOMS BUT WAS NEVER FIXED. VEHICLE IS 15 YEARS OLD BUT ONLY 76,000 MILES.

Incident May 1, 2019

ONE DAY I NOTICED THAT MY GARAGE HAD A STRONG GAS SMELL. OVER TIME, I REALIZED THAT IF MY GAS TANK WAS APPROX. BELOW 1/3 FULL IT DID NOT SMELL. CHEVROLET INFORMED ME IT WAS COVERED FOR 100,000 MILES/10 YEARS WHICHEVER COMES FIRST. HOWEVER, I NEVER KNEW A RECALL COULD HAVE A TIME LIMIT BECAUSE OBVIOUSLY THIS IS A SAFETY ISSUE. I WROTE CHEVROLET A CERTIFIED LETTER DESCRIBING MY PROBLEM WITH NO RESPONSE. THIS IS A COMMON PROBLEM WHICH IS CONFIRMED BY LOOKING AT YOUR SITE.

Incident Jun 1, 2018

GASOLINE VAPORS ARE LEAKING FROM FUEL VENT AND TRANSFER LINES, CREATING AN EXPLOSION HAZARD. THE PROBLEM IS MORE OF AN ISSUE WHEN PARKED ALLOWING A SPARK TO IGNITE THE FUEL VAPORS.

Incident Oct 3, 2017

STRONG FUEL SMELL AFTER FILLING THE GAS TANK. GOES AWAY ONCE TANK IS LESS THAN 1/2 FULL AS READ BY THE GAUGE.

Incident Jul 15, 2018

AFTER FILLING THE GAS TANK STRONG GAS SMELL COMING FROM FILL AREA BUT NO VISIBLE FUEL LEAK THE GAS SMELL DOES NOT GO AWAY AFTER DAYS AND MANY MILES DRIVEN.

Incident Jul 15, 2018

TAKATA RECALL VISIBLE GASOLINE LEAKAGE AFTER VEHICLE HASN'T BEEN PARKED OVER A PERIOD OF MONTHS. THEN I BEGAN TO TAKE NOTES OF WHAT , WHEN , WHERE THIS LEAK WAS OCCURRING, I WOULD FILL THE TANK, PARK THE AUTO IN THE GARAGE . THE NEXT TIME I USED THE VEHICLE, A NOTICEABLE GAS ODOR, SPOT ON THE GARAGE FLOOR WAS NOTED. I STARTED TO PLACE A CARDBOARD UNDER THE FRONT END TO MORE READILY BE ABLE TO OBSERVE THE SUBSTANCE LEAKING. THE ODOR WAS UNMISTAKABLE. SEVERAL OCCURRENCES N SPOTTING IS EVIDENT AFTER HAVING PARKED IN MY GARAGE . THE AUTO WAS PARKED OVERNIGHT IN MY GARAGE. I AM LISTING THE LATEST CALENDAR DATE AND PHOTO. I HAVE OTHER DATES IN MY NOTEPAD. 2) MY SEATBELT OCCASIONALLY WILL NOT LOCK. I HEAR THE CLICK OF A SEATBELT LOCK THEN UPON DRIVING AWAY FROM MY HOME ~ ,25 MILES ~ MY SEATBELT UNLOCKED THROUGH NO FAULT OF MY OWN. 3) AIRBAG CANNOT BE CHECKED FOR EFFECTIVENESS .

Incident Mar 5, 2018

TL* THE CONTACT OWNS A 2004 CHEVROLET CORVETTE. WHILE DRIVING 35 MPH, THE STEERING WHEEL SEIZED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO GALLES CHEVROLET (2801 UNIVERSITY BLVD NE, ALBUQUERQUE, MN 87107) WHERE IT WAS DIAGNOSED THAT THE STEERING COLUMN NEEDED REPLACEMENT. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER INFORMED THE CONTACT THAT THERE WERE NO RECALLS AND THE VEHICLE WAS NOT UNDER WARRANTY. THE FAILURE MILEAGE WAS APPROXIMATELY 89,000. THE VIN WAS NOT AVAILABLE.

Incident Jun 6, 2018

AFTER FILLING UP MY VEHICLE, DROVE HOME SAT IN DRIVEWAY FOR A FEW MINUTES, ADJUSTED RADIO STATIONS, I SMELLED A STRONG ODOR OF GAS, TURN VEHICLE OFF STILL SMELLING GAS, LOOKED UNDER DRIVER'S SIDE OF VEHICLE AND SEEN A PUDDLE OF FLUID, PUT MY FINGER IN IT AND IT WAS GAS!, I'M THINKING NOW THAT'S WHY THE USED CAR DEALERSHIP ONLY PUT A HALF A TANK OF GAS IN IT! PURCHASED THIS 2004 CORVETTE BACK IN MARCH 2018 HAVE ONLY PUT 60 MILES ON IT, IT NOW ONLY HAS 14,936 MILES ON IT! WHAT COULD HAVE HAPPENED IF I PARKED THE CAR IN SHOPPING CENTER PARKING LOT, WITH A CIGARETTE THAT JUST BEEN THROWN DOWN?

Incident Apr 8, 2018

PUT 15 GALLONS OF GAS INTO TANK, IMMEDIATELY NOTICED GAS SMELL INSIDE CAR AND OUTSIDE, DROVE APPROXIMATELY 10 MILES AND SMELL INCREASED. STOPPED CAR AND IMMEDIATELY SAW GAS DRIPPING IN FRONT OF LEFT REAR TIRE AND FORMING A PUDDLE, STOPPED DRIPPING AFTER 5 MINUTES OR SO. DROVE TO HOME AND LET SIT UNTIL MORNING, HAD CAR TOWED TO CHEVROLET DEALER THAT MORNING. TOLD BY DEALER THAT GAS TANK IS CRACKED AND CROSSOVER PIPE IS DEFECTIVE. REPAIRS TO BE NEAR $3000.

Incident Dec 18, 2017

FUEL LEAKING FROM FUEL TANK WHEN I FUEL

Incident Oct 2, 2017

FUEL TANK CROSSOVER TUBE HAS A CRACK. I FOUND A SPECIAL COVERAGE #10150 THE NHTSA ISSUE IN AUGUST 2010, BUT HAS EXPIRED. I CONTACTED GM AND ASKED FOR ASSISTANCE, TO WHICH THEY REFUSED. MY CAR HAS 20K MILES ON IT. I HAVE PERFORMED ALL MAINTENANCE, KEEP IT METICULOUSLY CLEAN AND NOT DRIVE IT RECKLESSLY. IF I FILL UP THE CAR THERE IS A NOTICEABLE FUEL LEAK TO THE POINT THERE IS A PUDDLE UNDER THE CAR. AT THIS POINT I CANNOT DRIVE THE CAR FOR FEAR OF FIRE AND THE CAR WILL NOT PASS AN EMISSION TEST. I PURCHASED THE CAR IN ALASKA IN 2009 WITH 9K MILES ON IT. I NEVER RECEIVED ANY INFO REGARDING THE NHTSA #10150 SPECIAL COVERAGE. THE ESTIMATED COSTS OF REPAIR IS BETWEEN $3000 TO $4500. IS THERE ANY ASSISTANCE THE NHTSA CAN PROVIDE?

Incident May 24, 2017

GASOLINE SMELL

Incident Oct 9, 2017

DRIVER SIDE GAS TANK HAS BEEN LEAKING FOR ABOUT A MONTH AM HAVING HEAVY FUEL SMELL WHEN CAR IS PARKED AND AFTER FUELING UP

Incident Jul 19, 2017

CRACK ON REAR WHEEL POLISHED ALUMINUM ORIGINAL EQUIPMENT WHEEL LEAKING AIR FROM CRACK ON OUTER INNER RIM TPMS ALERTED ME TO LOSS OF AIR PRESSURE NEVER HIT A CURB. WHEEL SHOWS NO OTHER DAMAGE

Incident Jul 3, 2017

CAR BEGAN GUSHING FUEL OUT OF TOP OF TANK ONCE FUEL SYSTEM PRESSURIZED. HIRED ROLLBACK TO TAKE TO MECHANIC WHO INFORMED THAT CROSSOVER LINE WAS BAD. MECHANIC ALSO STATED THAT THERE WAS A RECALL FOR THIS ISSUE. I AM SECOND OWNER OF CAR, WHICH ONLY HAS 2150 MILES ON IT, SO KNEW NOTHING ABOUT IT. I WOULD LIKE TO BE REIMBURSED FOR THIS EXPENSE!

Incident May 4, 2017

STRONG SMELL OF GAS WHEN PARKED IN GARAGE,ALWAYS USED CARPORT UNTIL NOW SO I NEVER NOTICED. BUT NOW HAVE A GARAGE, BUT I AM AFRAID OF STRONG FUEL SMELL MAY BE DANGEROUS. HAS NEW GAS CAP AND NO GAS LEAK.

Incident Dec 1, 2016

TL* THE CONTACT OWNS A 2004 CHEVROLET CORVETTE. THE CONTACT STATED THAT WHILE DRIVING AT 20 MPH, THE SERVICE ACTIVE HANDLING SYSTEM WARNING MESSAGE ILLUMINATED. IN ADDITION, THE CONTACT STATED THAT WARNING CHIME FAILED TO OPERATE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE THERMOSTAT, SERPENTINE BELT AND TENSIONER BELT NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 74,000.

Incident Jan 1, 2017

I HAD A STRONG FUEL SMELL IN MY GARAGE AND A SMALL PUDDLE OF FUEL ON MY GARAGE FLOOR. I HAD GOTTEN A RECALL NOTICE FROM GM SOME TIME AGO, TOOK MY CAR TO THE DEALER AT THE TIME AND THEY SAID THEY COULD DO NOTHING UNLESS THERE WAS A LEAK. NOW, I HAVE THE LEAK, BUT GM REFUSES TO FIX THE PROBLEM BECAUSE SOME TIME PERIOD HAS EXPIRED. THIS LEAK HAS BEEN REPAIRED BY ANOTHER SHOP, BUT I AM OUT OVER $2,000 FOR A PROBLEM GM KNEW COULD CAUSE THE CAR TO BURN UP. I SEEK FOR GM TO REIMBURSE ME FOR THIS REPAIR OF A CRITICAL SAFETY ISSUE.

Incident Oct 3, 2016

LEAVING SERVICE STATION AFTER FILLING CAR WITH FUEL GAS FUMES WERE FILLING THE CAR. PARKED IT IN GARAGE AND NEXT MORNING GARAGE STUNK OF GAS FUMES. BACKED CAR OUT OF GARAGE AND SAW NO FUEL LEAKING BUT FUMES STILL VERY BAD IN CAR. CALLED LOCAL CHEVROLET DEALER AND THEY SAID THERE WAS NOT A RECALL FOR THIS. HUSBAND TOOK CAR TO AUTO SHOP AND PUT ON HOIST, WHERE A WET SPOT WAS FOUND. MECHANIC SAID THE CONNECTOR TUBE BETWEEN THE TWO GAS TANKS WAS WET FROM THE GASOLINE. NO WAY TO TAKE A PHOTO BECAUSE THE AREA TO LOOK UP AND SEE THE CONNECTOR IS SO SMALL.

Incident Oct 12, 2016