2016 Chevrolet Cruze Limited

On [XXX], the right front passenger side control arm/ball joint broke as my daughters were driving home. The car was in motion on a major street in Kansas City, KS when the control arm/ball joint broke. My daughter was in the right-hand lane when it broke as the car was in motion. The front of the car forcefully propelled in the air, landed, and jerked my daughter into the side walk. Afterwards, she fought the car over to the left-hand turn lane to stop in a somewhat safer spot on a major street. My oldest daughter driving suffered neck injuries from the seatbelt and my youngest daughter bumped her head. Both were hurt. An independent mechanic diagnosed the issue as well as Hendrick Chevrolet in Shawnee Mission Kansas. The parts are available for inspection. Hendrick Chevrolet failed to properly diagnose this issue when my car was in their care and service department on 06/14/24. I paid for an inspection but Hendrick Chevrolet's technician failed to record play in the broken wheel and if the car was in need of an alignment. This is unacceptable behavior considering the technician had both front tires off to inspect the brakes and was paid to perform a complete inspection on my car as described in Chevy's inspection literature provided by the dealership. He also provided an incorrect brake pad measurement. Through several Chevrolet/Chevy Cruze online forums, Cruze owners have asked several questions and recorded several comments regarding having a broken control arm and having to replace the ball joint bolt. Also, recalls were previously issued with other GM vehicles having a right-front passenger side defective control arm, which potentially could be a GM fabrication issue with control arms. No warning lamps, noises, or messages alerted to this issue. This would have been a fatal incident involving my daughters and other drivers if it occurred on the highway at a higher rate of speed. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Incident Jun 22, 2024

Water leak in trunk. Took car in 3 time to have it fixed after them doing the recall( 84279073 f-lamp kit). Every time it went in they found a leak in a different spot. 15Feb17 they found water leaking from right side of the spoiler retainer holes. Dealer removed spoiler applied double back tape and sealer. Reinstalled spoiler 02Mar17 found pin hole leak in weather strip. Dealer replaced weather strip. 01jan24 start having electrical issues. Hard starting/ running weird and finally dead battery. Had les swabs install battery and remove water in trunk. Car starts but shuts off when driving. 05mar24 Dealer finds leak coming from right side spoiler and now 1 licence plat bolt. Charged me 600.00 . to reseal. Here we go again They could never stop/find the leak before and will not warranty previous work. Isn't this a fire/safty issue? That started the recall in the 1st place. And why wasn't drain plugs required for this yr.car. I believe it was in the newer one. I would like to know how many people had to take their car in multiple times to never have the problem truly fixed. Is this a tactic used to make consumers go away and say they fixed the recall, but never really did.

Incident Jun 4, 2024

Power train system (po299) A turbocharger harnesses the flow of exhaust gases that spins an internal turbine. This turbine then forces or packs air into the engine faster than normal .This action increases the horsepower of the engine. When it doesn’t work!!!!A failed turbo charger will cause a decrease in engine performance which isn’t for family . (Manufacturer recall number:A212338300 recall date 11/05/21

Incident Oct 16, 2021

The contact owns a 2016 Chevrolet Cruze. The contact stated while driving at various speeds, the vehicle inadvertently shut off without warning. The contact stated that soon after the failure, the vehicle independently restarted, and the vehicle resumed normal vehicle operation. The vehicle was taken to a dealer where a diagnostic test was performed and recommended that the fuel system be cleaned. The manufacturer was not notified of the failure. The vehicle was not repaired. The failure mileage was approximately 33,000.

Incident Oct 27, 2023

Hit a buck on highway. When airbags went off I felt sudden sharp pain in my left arm. I was later advised that it most likely was shrapnel from the airbag. It was obvious from the injury something hit my arm with a lot of force. The car was a total loss and in possession of insurance company. Concerned that it could have been my eye.

Incident Oct 27, 2023

I was driving down the road when my son said he smelled something and made pull over. There were what I thought were small flames on the floor so i dumped my water on them, then i realized the seat itself was melting and dripping stuff on the floor. then the seat went up. Very shortly after that the car was completely engulfed and is now a total loss.

Incident Oct 8, 2023

My vehicle gives the message "shift to park" even when it placed in park, making it impossible to lock and possibly causing the battery to run down. Continuing to restart the vehicle and placing in park until the message goes away has been my only resolution. The issue has been reproduced by an independent service center. They were unable to ascertain what was causing the issue. I am aware a recall was issued for this problem in earlier model Chevy Cruzes. It seems my vehicle should have also been included in this recall. It is evident this has been a huge problems in GM vehicles and when it continues to affect later vehicles it should be addressed and corrected by the company.

Incident Aug 10, 2023

At first, and only on cold/rainy/snowy weather, while driving the radio would randomly turn off and turn itself back on (i have videos of this). Sometimes it would last a few seconds, sometimes a few minutes. While this was happening, the blinker sounds wouldn't work. I brought it to Chevy in Geneva, NY for diagnostics. No check engine codes ever. They told me that the radio computer needed to be updated. I had them fix it, only to find out that the problem would still happen. Over a few months, it developed more symptoms. It started to not shut off when I pushed the button, and it also started stalling when it went into auto off, but would turn back on if I put it in park and re started. At first it would stall in auto off at random times. This caused an accident in the summer of 2019. I was at a stop sign, waiting to make a right hand turn, took my foot off the brake and car stalled. The car behind me thought I was going and rear ended me. I had to drive around in the summer with the heat on, as it was the only way to prevent the car from going into auto off. I had the car looked at a few more times after that (paying $100 diagnostic fees every time). Brought it back to chevy and the told me it was because of the damage to my trunk allowing water to get to the battery (it wasn't). Issues then turned into stalling at auto off, but not turning back on once in park. I brought it to the dealership I bought it from and they looked at the alternator and had them clean all battery terminals and replace the battery. This worked for 2 weeks before continuing. It got to the point that I had to jump start my car everytime I wanted to drive it or it stalled. Finally it just wouldnt start, So i had it towed to chevy again in 2021. They determined the issue was the starter and replaced. It worked but as of now (9/13/23) my car has began stalling at auto off. It is very dangerous, car gives no warning!! There is too much to say with limited space

Incident Jul 19, 2019

The contact owns a 2016 Chevrolet Cruze. The contact stated while driving 25 MPH, the front air bag warning light illuminated, and the message "Service Air Bags" was displayed. The vehicle was taken to the dealer that stated that the front passenger side air bags needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 137,000.

Incident Aug 7, 2023

Stability Track came on randomly all of sudden car was stalling, running poorly and smell Gas , sure enough leaking Gas Everywhere, very dangerous. Lucky car did not catch on fire. I am still paying for this car. Just thankful no one got injured. THERE IS NO RECALLS FOR THIS VIN ABSOLUTELY SHOULD BE.

Incident Aug 31, 2023

I have a 2016 cheavy cruise. It keeps overheating I have replaced the thermostat and thermostat housing and still have had issues with it overheating. I have done research and several cruises with this year have had the same issues.

Incident Sep 2, 2023

There is currently a recall for Chevrolet Cruzes because of overheating, that is caused by the cooling system and the antifreeze leaking out at the thermostat housing. This is exactly what happened to my 2016 Cruze as we drove down the highway and warning lights and sounds started going off that required it to be put in the shop (Local Chevy Dealer) and have these parts replaced. If you read the safety recall for this issue on the Chevy Cruze and look at my receipt it is almost the same wording. However, the dealer told me that my Chevy Cruze was NOT covered by the recall. I believe the recall should be expanded to include all Cruzes.

Incident Aug 5, 2023

I have been taking a burning smell emanating from the vehicle. When I took vehicle in for servicing last week, I was told that the smell was as a result of an engine leak. I was informed that my vehicle was not the first of the same make and model that the service center has seen in recent weeks. Worried that this could be an issue can lead to a fire. Planning on having repairs done, but would like to know whether this is something that can be investigated to determine whether it is a manufacturer defect.

Incident Aug 5, 2023

System failure…airbag light continues to come on and go off. It says service airbag. If John Elway Chevrolet repairs the airbag system will it impact the integrity of the airbags. The airbag light doesn’t say which airbag is defective. I want to make sure that my family and I are safe when we are in the car.

Incident Aug 4, 2023

The contact owns a 2016 Chevrolet Cruze. The contact stated while driving 25 MPH and depressing the brake pedal, the check engine warning light illuminated, and the message "Service Brake System" was displayed simultaneously. The vehicle failed to respond. The contact stated that he applied more pressure to the brake pedal and the vehicle responded. The contact was able to continue driving; however, the failure recurred while driving to the residence. The vehicle was taken to an independent mechanic, where it was diagnosed that the vacuum pump had seized, which fractured the camshaft. The mechanic diagnosed that the vacuum pump and the camshaft needed to be replaced. The vehicle was not repaired. The dealer and the manufacturer were not notified of the failure. The failure mileage was approximately 108,000. The contact wanted to include the number of the brake pump part of their vehicle - 12662789. The contact also stated that other SUV models of various model years have the same defective part.

Incident Jul 28, 2023

Power steering warning keeps coming and going, replaced battery didn't fix saw a lot of complaints about negative battery cable so replaced that and it fixed the issue. cruze's up to 2015 recalled this the 2016 obviously needs it too.

Incident Jul 25, 2023

When I start my car it will sputter then die, also cuts off while driving. It cuts off but will crank up and die again after so many tries it will drive a while and do it again. The check engine was on and I have fixed the O2 sensor, the mass air flow sensor, Ive replaced the turbo hose it had a big chunk ripped out of it which we have no clue how that happened, I just changed the PCV valves a few weeks ago and the car started but would not go in drive nor reverse put it back in shop and cleaned the throttle body and it ran good the whole day today I started cutting off again.

Incident May 26, 2023

The contact owns a 2016 Chevrolet Cruze. The contact stated that on several occasions while driving at various speeds, the brake pedal was depressed, and the vehicle stalled. The vehicle was restarted after two attempts. The check engine warning light was illuminated during the failure. The vehicle was taken to a dealer where it was diagnosed that the catalytic converter and Oxygen sensor needed to be replaced. The vehicle was not repaired. The contact manufacturer was notified of the failure. The failure mileage was 97,800.

Incident Jul 18, 2023

The contact owns a 2016 Chevrolet Cruze equipped with Continental Tires, Tire Line: Conti Pro Contact, Tire Size: 195/65/R15, DOT Number: P5AEWBNU1018. The contact stated while driving 45 MPH, there was an abnormally loud sound coming from the front and rear passenger’s side tires. Upon visual inspection, that contact found no issues with the tires. The contact stated that the tires were original tires. The cause of the failure was not yet determined. The manufacturer was not notified of the failure. The failure mileage was 89,000.

Incident May 15, 2023

It suddenly come up with ac off to keep engine feom overheating on message .I have had 4 theromstat housings put on in the last month and it is still leaking around housing and leaking coolant out onto ground and thit has only 73000 miles .Yes it will be available to inspect if in local area afraid to drive to far and i still owe a year on this car.

Incident May 5, 2023

My 21 yr old daughter was in serious accident May 3. 2022 on the way to her college. The accident was horrific. Her left hand middle finger was impaled by a piece of metal L shaped. The hospital said it was an airbag pin. She was covered in cuts and injuries but her finger/ hand were the worst by far. She has had a surgery and will need additional surgeries. I would like it looked into please. I was very grateful it wasn’t her eye or neck.

Incident May 3, 2022

My daughter was driving the car and she said that he check engine light came on and she pulled over and turned it off. She immediately called her dad and while on the phone with him the car started shaking and it over heated and all the fluids were underneath the car. I arrived about 15 mins later and saw all the over spill on the side of the road. Called a tow truck and had it towed to a dealership, which told us that GM is aware of the problem with the Chevy Cruze engine doing this. They said that there is no way for you to tell that the part is going bad til it happens and once it does the car gets so hot it crack the head gasket. It is a 3500.00 fix and it is all because of the thermostat at the bottom of the engine. We had it fixed at 93.000 miles and it now has 110,000 and we are now having the turbo replaced and the dealership said it is a known problem but GM isnt willing to do a recall because it cost so much to fix but they are aware of the problem with then engines in the 2014 to 2016 cruze and since they arent made to fix it they pass the cost on to the customer.

Incident Jan 17, 2022

Keep having the engine light on. First time it was my Catalyst and now my engine light is on again with code P0420 and keeps leaving from the coolant

Incident Dec 19, 2022

Paid thousands of dollars into getting a thermostat housing and thermostat leaking antifreeze a couple months ago started leaking antifreeze again just now

Incident Dec 15, 2022

My car was recalled for problems with fuel system or something of that nature, I took it to get repaired not once but about 3 times and problem is still ongoing. When I press the gas, the car shoots all the way to the 3rd gear and gets stuck at about 27 miles which is very dangerous, especially when I’m on the freeway. It will also cut off in the middle of the road making me have to put my car in park and recrank the car, multiple people have almost ran dead into the back of my car. They basically told me it is no way to fix my car. Now, it has caused more problems. My car is now saying “engine power reduced” and “service brake assist” when I try to press the brakes, it’s literally almost impossible. I have to almost stand on the brake and it still does not stop all the way. My brakes are new btw, so it shouldn’t still have this error message. I’m basically driving a lemon. This car is not reliable at ALL. I have put so much money into this car and with it being a 2016, you would think it wouldn’t have all of these problems… the car just jerks when I’m driving and nobody can seem to fix it! Oh, and let me not forget about the fuse that blew in my USB ports causing me not to be able to use all the features of my vehicle. This car is a nightmare. Also, I believe that when there are recalls for safety issues like this, we should be notified but of course that’s asking for too much. I have only had this car since 2019. It was serviced on 4/28/21, 5/26/21, 6/6/21 and after that I literally gave up and just hope I don’t wreck out and die.

Incident Apr 28, 2021

My car, started to get a messaged saying reduced engine power, after that it started to make a noise I took it to re pair and the car, sometimes makes that noise and I’m driving and out of nowhere the car turns off

Incident Aug 1, 2022

The contact owns a 2016 Chevrolet Cruze D2. The contact stated that while driving 20-25 MPH, the contact crashed into another vehicle. The air bags failed to deploy. As a result, the contact had whiplash to the neck and the front seat passenger head hit the windshield and whiplash to the neck. Medical attention was required. A police report was filed. The vehicle was towed to a tow lot. The vehicle was not diagnosed or repaired. The dealer nor the manufacturer were not notified of the failure. The failure mileage was approximately 58,000.

Incident Nov 18, 2022

The contact owns a 2016 Chevrolet Cruze. The contact stated that he noticed that the coolant level was low and added coolant to the reservoir. The contact stated that when he returned, he noticed the coolant had leaked onto the ground. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was 55,070.

Incident Nov 11, 2022

The contact owns a 2016 Chevrolet Cruze. The contact stated while inspecting the vehicle, she noticed that the vehicle was low on antifreeze, and added antifreeze. The next day when she returned home from work, she became aware that the antifreeze level was again low. The vehicle was not taken to the dealer to be diagnosed or repaired. The manufacturer was contacted, and a message was left. The failure mileage was 69,000.

Incident Oct 29, 2022

Catalytic Converter , it is a 2016 , it absolutely should not be faulty/defective AT ALL . I checked with Dick Wolstrom Chevy Dealer , if this would be included in the Powertrain Warranty and they said it expired in December . I checked with the other Yearly Recalls for this problem, and it did show this exact same recall for the all the previous years of this make and model of car . It should be fixed , I never heard of a Catalytic Converter be defective like this especially in a newer year car . Can you please help me ? Also, I am having problem with the Fuel pressure Sensor , Air flow intake sensor, Knock sensor , all (3) this is crazy . This is the 2nd time the knock sensor has been replaced . My main concern is the Catalytic Converter , please advise , it should be covered in the powertrain warranty on this car , regardless . It is very expensive to be replaced .

Incident Oct 17, 2022

Around 150,000 miles I had the code p0011 the dealership did work but code kept coming back on. So I was told I needed a cylinder head. I wanted a 2nd opinion so I took it to another dealership and was told I need to replace the engine. So July of 2021 engine was replaced. Around 09/2021 cylinder head was replaced with other work done. Now code p0011 came back on again and it’s in the show getting another cylinder head around 188,000 miles. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? It was inspected by Vann York Chevrolet in High Point, NC and Modern Chevrolet in Winston Salem, NC. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes it have been. How was your safety or the safety of others put at risk? Yes, I do feel like I was at risk due to engine surge and or reduced power at times. What component or system failed or malfunctioned, and is it available for inspection upon request? Yes an inspection can be done at any time. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? Prior to this I kept my car service and I do have receipts. Check engine light came on 04/2021 with code p0011. Then on 07/2021 is when I got my car back with the remanufactured engine. So a 1st cylinder head came with the engine, the around 09/2021 2nd cylinder head, and now 3rd cylinder head of this remanufactured engine. This p0011 code cost me over $7,000 which I had to take a loan out and still paying for but still having the same problem. Which every thing now is covered under the engine warranty which is 3yrs or 100,000 miles. Not to mention 04/2021 I had just spent $1,339.55 water pump gaskets and seals. I have connected GM customer support. But I shouldn’t had to replace an engine around 150,000 miles and the cylinder head shouldn’t had to be replaced 3 times now. I have my records if you need to see them.

Incident Apr 7, 2021

2 issues. 1st is the PCV system. PCV valve will fail regularly 1-3 years. This requires a new intake manifold and valve cover possible new hose and possible sensor replacement. Can cause stability and traction control failure. 2nd is the engine's head gasket. Between 60-70k miles these vehicles get blown head gaskets. Due to this failure, you could experience a total engine failure which will completely shut down all vehicle functions. If not properly observed this vehicle will not only have a complete failure. It will need an entire new engine due to cracked block and head or warped block and head. If it becomes warped you will need to machine both the block and head and or replace the entire engine long before it reaches 100k miles. Rendering the vehicle absolutely useless. Coolant issues with these vehicles are bad as well. Even if all these issues get fixed in a timely manner you will still most likely have a blown head gasket as I did. Engine failures on a busy highway are a big safety concern.

Incident Sep 26, 2022

While at red light, stop signs, or transitioning turns, the engine shuts off and does not restart. Sometimes it shuts down when driving at extremely low speeds. This is dangerous because I have had to push the car while transitioning in multipile lane intersections. Luckily others stop and help me push the car to shoulder or convenience gas stations. The battery and spark plugs are new, and the car has plenty of fuel.

Incident Aug 15, 2022

The turbo is messed up my car would not pull when stepping on the gas. Almost got in an accident on the freeway and hood started smoking. Spoke to a mechanic and said it was due to the turbo charger

Incident Sep 14, 2022

Was at a red light and my car shut off. It started back up and I was able to get home. I am now afraid my car will just stop while driving and I will crash and die

Incident Sep 12, 2022

The contact owns a 2016 Chevrolet Cruze. The contact stated that on multiple occasions while driving over 50 MPH, the A/C unit turned off independently and the instrument panel displayed a message that the engine was overheating. Additionally, the engine power reduced message was displayed. The contact stated that after receiving message alerts on the instrument panel, the vehicle decelerated to 15-20 MPH. The vehicle was taken to an independent mechanic to be diagnosed. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The contact stated that the failure reoccurred on several occasions and the instrument panel displayed message alerts for the engine overheating and the engine power being reduced. The contact attempted to call local dealers but was not successful. The vehicle was not repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 106,000.

Incident Jun 7, 2021

The car randomly shuts off when driving. It also has problems with accelerating when the AC system is turned on.

Incident Aug 30, 2022

My 2016 Chevy Cruise heating and cooling system failed. Car engine over heats causing engine to stop in mid drive. Hoses (main) and connections to heating and cooling systems faulty. Main hose to cooling system faulty (dry rotted ).

Incident Sep 3, 2022

The contact owns a 2016 Chevrolet Cruze. The contact stated that on several occasions, a strange noise could be heard while the brake pedal was depressed. The contact stated while accelerating above 35 MPH, the Service Stabil Trak and powertrain control module (PCM) warning lights illuminated. The vehicle was towed to an independent mechanic where it was diagnosed that the powertrain control module (PCM) failed and needed to be replaced. The vehicle was not repaired. The dealer was notified of the failure. The manufacturer was not notified of the failure. The approximate failure mileage was 92,000.

Incident Jul 17, 2022

Vacume pump failure causing brakes to become very difficult to apply. Pump also brakes inside the valve cover. Causing timing issues and possible camshaft damage.

Incident Jul 27, 2022