2004 Chevrolet Malibu

SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

SOME OF THESE PASSENGER VEHICLES HAVE AN ELECTRONIC CONTROL UNIT (ECU) THAT MAY CALCULATE A HIGHER THAN ACTUAL VEHICLE SPEED BECAUSE OF AN ERRATIC REAR-WHEEL SPEED SENSOR SIGNAL, AND CAUSE ABS ACTIVATION WHERE IT IS NOT NEEDED OR NEEDED ABS ACTIVATION TO BE EXTENDED DURING BRAKING AS THE VEHICLE SPEED DROPS TO ABOUT 3 MPH.

ON CERTAIN PASSENGER VEHICLES, ANALYSIS OF AN A SIDE IMPACT CRASH TEST CONDUCTED BY THE NHTSA;S NEW CAR ASSESSMENT PROGRAM (NCAP) INDICATED THAT THE OUTBOARD ANCHORAGE OF THE DRIVER'S SEAT BELT COULD DISCONNECT BECAUSE OF CONTACT BETWEEN THE SEAT TRIM AND THE ANCHORAGE CONNECTOR WHEN THE SEAT WAS ADJUSTED TO ITS LOWEST POSITION.

CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD (FMVSS) NO. 208, "OCCUPANT CRASH PROTECTION." SOME OF THESE VEHICLES THAT WERE NOT EQUIPPED WITH AN ADVANCED OCCUPANT RESTRAINT SYSTEM (AORS) HAVE DRIVER AND PASSENGER SIDE SUN VISORS WITH AORS LABELS. THE AORS LABELS DO NOT INCLUDE STATEMENTS AND THE ILLUSTRATION REQUIRED BY FMVSS NO. 208 FOR VEHICLES WITHOUT AORS.

In March of 2015 recall for steering shift was done. The car is loosing power again when you are turning a corner it has happened several times. A powere steering code was on. A local shop looked at it and cleared it.

Incident Apr 15, 2022

The contact owns a 2004 Chevrolet Malibu. The contact stated while reversing the power steering failed without warning. The vehicle was taken to the dealer and they stated the steering shaft needed to be replaced. The vehicle was not repaired. The manufacturer was contacted and they stated that the vehicle was not under warranty. The failure mileage 139,000.

Incident Jun 21, 2022

Driving along the power steering goes out. You have to pull over, turn engine off and on and ok until the next time. This was a recall that was fixed in 2014. It’s happening again. Happens everywhere. Slowly out to parking lot to highway speeds and everywhere in between. Exactly same when it happened in 2014. Recall 14116

Incident Jun 9, 2022

The contact owns a 2004 Chevrolet Malibu Maxx. The contact stated while driving approximately 30 MPH, the vehicle lost power steering functionality. The power steering warning light was illuminated. The vehicle was taken to an independent mechanic and diagnosed with power steering failure. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 117,000.

Incident May 1, 2022

The 2004 Chevy Malibu Maxx equipped with Electric Power Steering experienced a sudden loss of power steering assist. The power steering loss made it extremely difficult to control the direction of the car and can cause crash. The problem has been confirmed by the dealer after a $185 inspection to just read a code. The problem has been covered by recall Bulletin No. 14116. However, the recall DID NOT fix the problem and the exact problem showed up. Mike Maroone Chevrolet North and GM stated "when the recall is done it's done", although the problem was still there. A message was displayed on the Driver Information Center and a chime sounds to inform the driver. The Bulletin is https://static.nhtsa.gov/odi/rcl/2014/RCRIT-14V153-6084.pdf. There is also news on GM's website. https://media.gm.com/media/us/en/gm/home.detail.html/content/Pages/news/us/en/2014/mar/0331-power-steering.html

Incident Mar 15, 2022

EPS went out, warning message for steering on message board. Cannot steer very easily. Have not taken to dealer due to not wanting to operate unnecessarily

Incident Mar 9, 2022

I was driving to work with my son and sister in the car when the steering wheel suddenly got very tight and started jerking when I attempted to make a left or right turn. I then stopped at a gas station and as soon as I came to a complete stop the vehicle shut off before I could turn it off manually. I then attempted to turn the key on and start the vehicle but it would not turn over, it would only make a clicking sound. I called a friend that was close by to come and assist me so when they arrived I asked them to jump my vehicle off via jumper cables which did get my vehicle's engine to finally start. The car sounded very weak as if it was going to shut off again once we disconnected the jumper cables but it didn't shut off. Nothing was working inside the car or outside meaning I had no radio, no interior lights and nothing on my dash was working. The speedometer wasn't working, the rims Guage wasn't working, the temp Guage wasn't working nor was anything else working on my dash. The turn signals were not working for either side and none of my headlights or taillights were working either. And I still did not safely have control of the steering. The only warning lamp, which didn't appear until my friend jumped my car off, was what looked like a symbol of a vehicle with a symbol of a locked lock in front of it. This failure just happened so I have not taken the car to a certified mechanic to inspect it but the car is available for inspection at any time. I can not afford to put my car in the shop, I work part time at a restaurant in my town and I'm also disabled and I also care for my 8 year old son who is severely autistic so I have no extra money to fix these problems. Please I need help.

Incident Oct 15, 2021

The contact owns a 2004 Chevrolet Malibu Classic. The contact stated that while stopped at a red light, the vehicle lost motive power and abnormal noises were heard coming from the dashboard. The contact attempted to restart the vehicle when the door locks began to lock and unlock inadvertently. The contact was able to restart the vehicle and drove the vehicle to a locksmith. The locksmith informed the contact that there was no failure with the ignition switch. The dealer was made aware of the failure but informed the contact that they could not repair the vehicle. The vehicle was not diagnosed nor repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 91,000.

Incident Sep 15, 2021

The contact owns a 2004 Chevrolet Malibu. The contact stated while the vehicle was parked and the engine running the contact noticed that their front driver and passenger headlight were very low in both low beam and high beam and that the light eventually burned out. The contact inspected the vehicle and saw that the light bulb sockets for both the front driver side and passenger had melted. The contact stated the cause of the failure is the wiring behind the headlight assembly that is causing the headlight socket to melt. The contact replaced the headlight bulb sockets themselves with aftermarket parts to repair the failure, however, the failure persisted and reoccurred. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was unknown.

Incident Jan 2, 2019

The power steering went out while driving. The car was being backed out of the driveway. The car had lights go off when it happened. Once the car was restarted power steering worked again. This problem has only occurred once as far as known. The steering was incredibly hard to move when the issue occurred. It is foreseeable that if issue happens at the wrong time on the freeway it could lead to injury or death of driver, passenger, or others outside the vehicle. If it happens at high speeds during a turn any number of serous damage or injuries could occur. The vehicle was taken to a mechanic who said a dealership would have the equipment properly diagnose the problem. If the mechanic did it himself he would have to replace several parts one a time and it might not be fixed. I will have my son take it to a dealership to look at it. Lights went off during the problem, but it is UNKNOWN which ones lit up. The lights went off, but since significant force had to be used to pull the wheel even slightly the exact lights that went off are unknown.

Incident Aug 8, 2021

I have Chevy Malibu Maxx and none of the recall issues have been taken care of. I would like to get these recalls taken care of before I have accident.

Incident Aug 1, 2021

Eps goes out. At first only happened when I first started my car but if I restarted it then the issue went away. Problem increased over time & power steering went out while driving. Now it just won’t come back on. Wheel “twitches” or “seizes” on its own. If I put cruise control on the speed increases slightly on its own overtime on its own. It is available for inspection upon request. My safety surely felt at risk & I felt my dogs safety was at risk too. Also any of my passengers safety or anyone else on the road at that time for that matter , had I not been paying 110% attention & noticed the check engine light some on / power steering go out, I could have crashed or someone else could’ve hit me, etc.. Power steering went out while driving quite a few times & I’ve seen numerous complaints for these issues with this same year & model so it has to be a defect not just a personal issue. Have seen comments/reviews all over the internet about these issue , mostly the electric power steering , and even some that say they had replaced their steering column on 3 separate occasions out of pocket with no help resolving this issue from gm or Chevrolet. They first appeared as soon as the power steering went out. No lights prier & no power steering warning on the radio dash thing. (It says when I’m low on washer fluid, or when the power steering goes out, etc.. across my radio)

Incident Apr 25, 2021

TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU. THE CONTACT STATED WHILE DRIVING AT 60 MPH, THE STEERING WHEEL SEIZED NOT ALLOWING THE CONTACT TO HAVE CONTROL OF THE VEHICLE. AS A RESULT, THE VEHICLE RAN INTO A SIDE BEARING. THE AIR BAGS FAILED TO DEPLOY. A POLICE REPORT WAS NOT FILED. THE CONTACT SUSTAINED SOME BACK SORENESS. THE VEHICLE WAS ABLE TO START BACK UP AND THE CONTACT DROVE THE VEHICLE BACK HOME. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. A DEALER WAS NOT CONTACTED. THE MANUFACTURER HAD NOT BEEN INFORMED OF FAILURE. THE FAILURE MILEAGE WAS 255,450.

Incident Apr 27, 2021

THE SENSOR AND OR POWER STEERING ASSIST IS MALFUNCTIONING AND SENDING WARNING AND SHUTS DOWN THE ELECTRIC STEERING ASSIST. MUST TURN VEHICLE OFF AND THEN RESTART SEVERAL TO GET STEERING TO RELEASE. THERE WAS NO NOTICE GIVEN TO [XXX] WHEN THE RECALL(S) WERE ISSUED FOR 2004 CHVY MALIBU. STATIONARY THUS FAR. PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

Incident Sep 15, 2020

POWER STEERING UPON IGNITION LIGHTS UP AND LOCKS POWER STEERING. TURN OFF AND RESTART SEVERAL TIMES BEFORE OPERATIONAL. ABS LIGHT INTERMITTENTLY COMES ON WHILE DRIVING. ELECTRIC ASSIST POWER STEERING. BOTH IN STATIONARY AND WHILE DRIVING IN CITY AND HIGHWAY.

Incident Apr 12, 2019

I WAS DRIVING MY 2004 MALIBU CLASSIC , WHEN ALL THE VEHICLE , TURNED OFF ,CAUSING ME TO HIT THE VEHICLE IN FRONT OF ME AND THAT VEHICLE HITTING ANOTHER CAR , THERE WHERE 3 VEHICLE INVOLVED WITH INJURY'S, MY VEHICLE WAS TOLLED AND WAS SENT TO A TOW YARD , AT THE TIME OF THE INCIDENT I WAS WORKING AS A MAINTENANCE WORKER AND WOULD CARRY MY WORK KEYS WITH MY VEHICLE KEYS , NEVER WOULD HAVE THOUGHT IT WOULD HAVE TURNED THE IGNITION

Incident Jan 14, 2012

RECALL # 14E044000, VIN# [XXX]. THE VEHICLE EXHIBITS STEERING ISSUES AS DESCRIBED IN 14E044000 AND DIAGNOSED BY A MECHANIC. BROUGHT VEHICLE TO THE CHEVROLET DEALER AND THEY STATE THERE ARE NO RECALLS BASED ON VIN. HOW TO DETERMINE SPECIFIC VINS THAT ARE IMPACTED? WAS DRVING ON 3/1/21 AND STEERING BECAME ERRATIC. TOOK VEHICLE TO MECHANIC IMMEDIATELY WHERE IT WAS DIAGNOSED. MECHANIC STATED THERE WAS A RECALL AND TO CONTACT CHEVROLET. PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

Incident Mar 1, 2021

STEERING MECHANISM IS OUT CAN'T CONTROL CAR HAVE TO TURN IT OFF AND ON AND CONTINUES TO GO OUT WHILE DRIVING THE VEHICLE

Incident Feb 19, 2021

WELL MY IGNITION SWITCH WENT OUT I REPLACE THAT.NOW IT'S SHORTAGES IN WIRING AND LIGHTS HEAT ON AN OFF SOMETIMES SHOCKS

Incident Jan 19, 2021

DRIVING ON CITY STREETS AT APPROXIMATELY 35 MPH WHEN SUDDENLY THE POWER (ASSIST) STEERING GOES OUT...THE CHECK ENGINE LIGHT IS ILLUMINATING...THE RADIO SCREEN STATES 'POWER STEERING' AS AN AUDIBLE CHIME WAS HEARD.

Incident Jan 29, 2021

FIRST, THE CAR ROUTINELY BURNS OUT TURN SIGNALS, AND OVERHEATS THE TURN SIGNAL TO THE POINT THAT IT MELTS THE HOUSING THTA THE LIGHT BULB SNAPS INTO. I HAVE HAD TO REPLACE THE HEADLIGHT HOUSING/LAMP WIRINGS HARNESS MULTIPLE TIMES ALONG WITH MANY LIGHT BULBS. SECOND, THERE IS A RECALL FOR THE ELECTRONIC POWER STEERING. MY PARTICULAR VIN WAS RECALLED FOR AN ELECTRONIC POWER STEERING SENSOR. THE POWER STEERING HAS GONE OUT ON ME WHILE DRIVING TWICE, SO I BROUGHT IT TO THE DEALER. THEY INDICATED THE ELECTRONIC POWER STEERING MOTOR NEEDS TO BE REPLACED,AND IS NOT COVERED UNDER AND RECALLS. THERE APPEARS TOBE NUMEROUS RECALLS ON GM VEHICLES RELATED TO THE ELECTRONIC POWER STEERING, AND REPLACING MOTORS FOR THAT MATTER, BUT THE DEALER HAS INDICATED THERE IS NO SUCH RECALL RELATED TO MY PARTICULAR VEHICLE/VIN. THIS SEEMS RATHER SUSPECT WITH THE NUMBER OF RECALLS RELATED TO THESE VEHICLES, AND FOR ME TO HAVE THE STEERING GO OUT, BUT MY PARTICULAR VEHICLE DOES NOT QUALIFY. I WAS DRIVING ON A CITY STREET WHEN IT WENT OUT ONCE. I MADE IT HOME SAFELY, ALBEIT VERY HARD TO TURN THE WHEEL, AND THEN THE POWER STEERING WORKED AFTER TURNING OFF THE VEHICLE AND BACK ON AGAIN. IT WENT OUT AGAIN IN THE PARKING LOT OF THE CAR DEALER WHEN DROPPING IT OFF THE BE LOOKED AT.

Incident Jan 16, 2021

AFTER STARTING ENGINE, ENGINE WILL TURN OFF AND RADIO DISPLAY SCREEN WILL READ 'ENGINE POWER REDUCED.' ENGINE WILL NOT START FOR SEVERAL MINUTES, BUT THE LIGHTS, RADIO, DASH LIGHTS AND EVERYTHING WILL STILL WORK. THIS HAS HAPPENED IN MY DRIVEWAY. THE FIRST TIME THIS EVER HAPPENED I WAS ON A BUSY MAIN ROAD AT A STOP LIGHT IN THE LEFT TURN LANE. THE CAR SHUDDERED AND THE ENGINE LOST POWER. AGAIN, THE DISPLAY SCREEN DISPLAYED THE SAME MESSAGE. THE CAR WAS ROLLING BACKWARDS AND WOULD NOT ACCELERATE. AFTER SEVERAL ATTEMPTS THE ENGINE DID START AGAIN. THANKFULLY IT WAS 6:00 AM AND I WAS ON MY WAY TO WORK SO THERE WAS VERY LIGHT TRAFFIC.

Incident Dec 15, 2020

TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU. THE CONTACT STATED WHILE DRIVING AT LOW SPEEDS, THE STEERING WHEEL WAS LOOSE. THE CHECK ENGINE AND POWER STEERING WARNING LIGHTS WERE ILLUMINATED. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V153000 (STEERING). THE VEHICLE WAS TAKEN TO SERRA CHEVROLET 7850 US-64, MEMPHIS, TN 38133, (901) 328-9262) WHERE THE CONTACT WAS INFORMED THAT THE VEHICLE WAS IN BAD CONDITION. THE DEALER DECLINED TO COMPLETE THE RECALL REPAIR. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 225,000.

Incident Nov 1, 2019

ELECTRICAL WIRES/COMPONENTS ISSUES, INSTRUMENT CLUSTER LIGHTS NOT TURNING ON, VEHICLE WITH A WRENCH INDICATOR LIGHT COMES ON & OFF, TRACTION CONTROL WITH A SLASH ON TC INDICATOR LIGHT COMES ON & OFF (TC/), WHEN MY CAR IS RUNNING AN IDLING OR PARKED OR IDLING AT A STOP LIGHT OR DRIVING IN A CERTAIN SPEED LIMIT THE STEERING WHEEL SHACKS/SHUDDERS REPEATEDLY MOVING ON ITS OWN ONCE IN A AWHILE BUT NOW IT CONSTANTLY GETTING WORSE LASTING LONGER, ENGINE LIGHT STAYS ON EVEN AFTER I REPLACED THE PARTS OBDLL SCANNER SAY WHAT TO FIX & REPLACE, OWNED THE CAR OVER A 1 YEAR AN BUILD KNOWLEDGE ABOUT THE CAR AND GOOGLE RECALLS AFTER OWNING IT. I BELIEVE IT'S (POWER STEERING WHEEL COMPONENTS OR POWER STEERING WHEEL ASSIST MOTOR) I WAS DRIVING IN THE FREEWAY WITH MY BABIES GOING 65 SPEED LIMIT & I LITERALLY SEEN LIFE FLASHED BEFORE MY EYES WHEN THE STEERING WHEEL WON'T TURN/LOCKS UP IN A BUSY FREEWAY. IT WAS BEYOND THE WORSE EXPERIENCE OF MY LIFE BECAUSE MY BABIES IS IN THE CAR WHEN IT HAPPENED, I DON'T EVER WANT IT TO HAPPEN AGAIN EVER OR TO ANYONE ELSE. PLEASE & THANK YOU IF YOU CAN FIX IT, IT'S OUR ONLY TRANSPORTATION FOR MY SPOUSE & BABIES. AN ONE MORE OTHER THING IS "I DON'T KNOW IF IT'S A PART OF IT THE THROTTLE BODY MALFUNCTION". I HOPE THAT'S ENOUGH & ACCURATE INFORMATION ABOUT IT

Incident Oct 21, 2020

ON 01/14/2012 I WAS DRIVING A 2004 MALIBU CLASSIC IN WHICH I ENDED UP IN A CRASH INVOLVING 3 VEHICLES, I WAS DRIVING ON A STREET ABOUT 30 MILES PER HOUR WHEN MY MALIBU HAD SUDDENLY TURNED OFF WITHOUT POWER STEERING AND BREAKS I HIT THE CAR IN FRONT OF ME, THEN THAT CAR HIT THE CAR IN FRONT OF HIM, MY 2004 MALIBU WAS TOTALED, THE INSURANCE COMPANY, WAS A TOTAL LOSS, AT THE TIME I WAS TICKETED FOR FOLLOWING TOO CLOSELY, HOWEVER I KNEW THAT THIS MALIBU HAD LOSS POWER CAUSING THE ACCIDENT

Incident Jan 14, 2012

IT FEELS AS THOUGH THE STEERING IS LOOSENING. ALIGNMENT IS OFF AS WELL. BOTH ISSUES BEGAN ABOUT THE SAME TIME. A DULL CLUNKING SOUND CAN BE HEARD WHEN TURNING RIGHT. THIS CAR APPEARS TO HAVE ALREADY HAD THE STEERING REPLACED FROM THE 2014 RECALL BUT I BELIEVE THE REPLACEMENT PARTS ARE ALSO DEFUNCT AND SHOULD AND WILL BE RECALLED AGAIN. IT IS NOT SEEMINGLY DEPENDENT ON SET RPM OR MPH TO MAKE THE NOISE OR FEEL LOOSE IN MY HANDS. IT IS INTERMITTENT AND UNPREDICTABLE. CRUISE CONTROL STILL WORKING, EPS LIGHT NOT LIT. STRUTS ARE GOING SO MAY BE THE ISSUE. JUST IN CASE IT IS THE POWER STEERING HAVING NOT PROPERLY BEEN REPAIRED AFTER THE RECALL, OR REPAIRED WITH SHODDY PARTS, I THOUGHT IT BEST TO REPORT THE ISSUE. LIVES WERE LOST TO THE IGNITION SWITCH FAILURES FROM CHEVY, LUCKILY I PULLED INTO A SHOP IMMEDIATELY AFTER MY CAR SHUT OFF THE FIRST TIME AND GOT IT REPAIRED. MONTHS LATER PEOPLE WERE DYING. FRIENDS OF MINE. NOT ME. I TRUSTED MY GUT. I KNEW THAT WAS DANGEROUS AND I HAVE THE SAME INCLINATION NOW WITH THIS ISSUE.

Incident Sep 5, 2020

WHILE DRIVING CAR STEERING WHEEL STARTED TO MAKE A CLICKING SOUND BOTH LEFT AND RIGHT THEN WHEN I STOPED CAR BATTERY NEEDED TO BE JUMPED STARTED BECOME HARD TO CONTROL CAR AND IT SEEMED AS IF CAR WANTED TO LOSE POWER I WAS ON WATERMAN AND BASELINE. ON THE STREET WHEN IT BEGAN..07/15/2020 I HAD RECALL N140226 14116 WITH A CHEVY MANUFACTURER MALIBU DEALERSHIP

Incident Sep 4, 2020

TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU. THE CONTACT STATED WHILE DRIVING AT VARIOUS SPEEDS, THE BRAKE PEDAL WAS DEPRESSED HOWEVER, THE BRAKE LIGHTS FAILED TO ILLUMINATE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC TO BE DIAGNOSED. THE MECHANIC DETERMINED THAT THE BRAKE MODULE NEEDED TO BE REPLACED. PORTER CHEVROLET (414 E CLEVELAND AVE, NEWARK, DE 19711) WAS CONTACTED AND INFORMED THAT THE FAILURE NEEDED TO BE REPAIRED OUT OF POCKET. THE VEHICLE WAS NOT REPAIRED. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 14V252000 (SERVICE BRAKES, HYDRAULIC, ELECTRICAL SYSTEM, EXTERIOR LIGHTING, VEHICLE SPEED CONTROL, ELECTRONIC STABILITY CONTROL) AS A POSSIBLE SOLUTION TO THE FAILURE HOWEVER, THE VIN WAS NOT INCLUDED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND INFORMED THE CONTACT THAT THE VEHICLE WAS NOT SUBJECTED TO ANY RECALLS. THE FAILURE MILEAGE WAS APPROXIMATELY 169,000.

Incident Aug 5, 2020

THERE HAS ALREADY BEEN A RECALL THAT THEY SAY WAS FIXED. HOWEVER IT IS DOING THE EXACT SAME THING NOW.I HAVE PAID TO FIX IT AND IT HAD A RECALL. WHAT HAPPENS IS YOU R JUST DRIVING AND ALL OF A SUDDEN THE POWER STEERING GOES OUT. YOU CAN BARELY STEER THE CAR TO GET IT OFF THE ROAD. I DO NOT HAVE THE MONEY TO KEEP FIXING THE SAME PROBLEM OVER AND OVER. IT IS DOING IT NOW.. THIS WILL HAPPEN ANYWHERE CITY, HIGHWAY. LITERALLY ANYWHERE YOU MIGHT BE. IT HAS HAPPENED NUMEROUS TIMES BUT I PUT THE LAST DATE IT HAPPENED. I HAVE PRETTY MUCH HAD TO STOP DRIVING THE CAR.

Incident Jul 27, 2020

THE DRIVER SIDE SEAT THAT IS WELDED TO THE FRAME OF THE CAR HAS BROKE. THE RIGHT SIDE OF MY DRIVERS SIDE SEAT NOW COLLAPSES WHEN DRIVING WHICH IS EXTREMELY DANGEROUS NOT TO MENTION THE SEATBELT IS ATTACHED TO THE RIGHT SIDE OF THE SEAT AND BUCKLED INTO IT WHICH IS NOW COLLAPSED WHICH COULD CAUSE A MAJOR ISSUE IF I WAS TO EVER GET INTO AN ACCIDENT. I HAVE DONE SOME REASEARCH ONLINE AND THIS APPEARS TO BE A COMMON ISSUE AMONGSTS MOST 2004 MALIBU OWNERS. I AM THE SECOND OWNER AND I GET THE CAR IS CLOSE TO BEING 20 YEARS OLD BUT MINE ONLY HAS 60K MILES THE DRIVERS SEAT WELD SHOULD NOT JUST DETACH AND COLLAPSE WHILE DRIVING ON A PRACTICALLY BRAND NEW CAR. NOT TO MENTION I AM AN AVERAGE SIZED MAN 200 LBS 5 FOOT 7 ON TOP OF THAT I ENQUIRED TO FIX IT AT MY LOCAL CHEVROLET DEALER AND IT WILL COST WELL OVER 1000 DOLLARS BASED ON A VERBAL ESTIMATE. I CAN JERRY RIG THE SEAT TO NOT COLLAPSE BUT THAT DOESNT STOP THE FACT THAT GOD FORBID IM IN AN ACCIDENT MY DRIVERS SEAT COULD POTENTIALLY BECOME DETACHED HURLING MYSELF AND THE SEAT INTO THE WINDOW CAUSING SEVERE BODLY HARM OR WORSE DEATH. PLEASE LOOK INTO THIS AS IM SURE MANY OTHER PEOPLE HAVE THIS SAME PROBLEM IT IS A FAULTY WELD IN THE DRIVERS SEAT AND NEEDS TO BE ADRESSED BY THE MANUFACTURER CHEVROLET

Incident Jul 28, 2020

THE DASH HAS ABS, TCH AND SECURITY LIGHT COMES SHORTLY AFTER CAR HAS BEEN STARTED WITH IN SCOUND COMES A BEEPING SOUND WERE ALL THREE LIGHTS STAY ON UNTIL ENGINE IS CUT OFF. THE LIGHT BULBS HAS MELTED PLASTIC COVER ON THE FRONT TURN SIGNAL/PARK LAMP DRL. WHEN SPEED IS INCREASING ON HIGH WAY FREE WAY CAR TENDS TO PULL LEFT ON ITS OWN

Incident Jun 4, 2020

HAD TO REPLACE HEAD LIGHT BULBS HAS MELTED PLASTIC COVER DASHBOARD HAS WARNING LIGHTS THAT COME ON AND STAY ON

Incident Jun 4, 2020

TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU MAXX. THE CONTACT STATED THAT WHILE MAKING A LEFT TURN THE VEHICLE SHIFTED INTO NEUTRAL INDEPENDENTLY WITHOUT WARNING. THE CONTACT DEPRESSED THE BRAKE PEDAL TO STOP THE VEHICLE. THE CONTACT ATTEMPTED TO MANUALLY SHIFT THE VEHICLE INTO PARK HOWEVER, THE TRANSMISSION FAILED TO ENGAGE. THE CONTACT PUSHED THE VEHICLE OVER TO THE SIDE OF THE ROADWAY. THE VEHICLE WAS TOWED TO MIDWAY CHEVROLET (2323 W BELL RD, PHOENIX, AZ) WHERE IT WAS DIAGNOSED AND DETERMINED THAT THE TRANSMISSION FAILED AND NEEDED TO BE REPLACED. THE CONTACT MENTIONED NHTSA CAMPAIGN NUMBER: 14V224000 (POWER TRAIN) AS A POSSIBLE SOLUTION TO THE FAILURE, HOWEVER THE VIN WAS NOT INCLUDED. THE MANUFACTURER WAS CONTACTED HOWEVER, NO FURTHER ASSISTANCE WAS PROVIDED. THE FAILURE MILEAGE WAS APPROXIMATELY 100,000.

Incident Apr 10, 2018

THE ANTI THEFT GAS CUT OFF FEATURE HAS RENDERED MY VEHICLE UNABLE TO START. I HAVE TRIED MANY METHODS BUT THE PROBLEM PERSISTS. IT STARTS WHEN IT WANTS TOO, BUT NOT WHEN I DO. *TR

Incident Jun 3, 2020

TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE REVERSING OUT OF A PARKING LOT, THERE WAS AN ABNORMAL SOUND COMING FROM THE STEERING. THE VEHICLE WAS TAKEN TO JOHN AMATO (8301 N 76TH ST, MILWAUKEE, WI 53223) TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE STEERING SHAFT NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED HOWEVER, THE FAILURE RECURRED. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 14E044000 (STEERING) HOWEVER, THE VIN WAS NOT INCLUDED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS APPROXIMATELY 56,245. INVALID VIN.

Incident May 8, 2013

TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE ATTEMPTING TO MAKE TURNS THERE WAS RESISTANCE IN THE STEERING WHEEL. THE CONTACT STATED THAT THE STEERING WHEEL WOULD RETURN TO THE INITIAL POSITION. PHIL LONG FORD OF MOTOR CITY LOCATED AT (1212 MOTOR CITY DR, COLORADO SPRINGS, CO 80905 (844)237-2169, STATED THAT THE VEHICLE WAS NOT SUBJECTED TO A RECALL. THE CONTACT STATED THAT THE VEHICLE WAS REPAIRED UNDER AN UNKNOWN RECALL BY THE FORMER OWNER OF THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND INFORMED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 148,000.

Incident Jan 2, 2020

TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU CLASSIC. THE CONTACT STATED THAT WHILE DRIVING AT AN UNDISCLOSED SPEED, THE STEERING WHEEL INDEPENDENTLY TURNED TO THE LEFT WITHOUT WARNING. THE VEHICLE WAS TURNED OFF AND BACK ON BUT FAILED TO FIX THE ISSUE. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE RACK AND PINION DETACHED FROM THE SUBFRAME AND NEEDED TO BE REPLACED. THE CONTACT STATED THAT ONLY THE BUSHING WAS REPLACED AND NOT THE RACK AND PINION. IN ADDITION, THE CONTACT STATED ON ANOTHER OCCASION THE VEHICLE FAILED TO SHIFT TO REVERSE OR GO INTO FORWARD GEAR WHILE IN THE MIDDLE OF THE ROAD. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC AND WAS DIAGNOSED THAT THE SHIFT CABLE WAS FRACTURED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 157,000.

Incident Apr 3, 2019

WHEN I ACCELERATE TO GET ONTO THE FREEWAY AND PUSH ON THE GAS THE CHECK LIGHT WITH THE TOOL WILL COME ON AND I AM UNABLE TO STEER MY CAR AND THE STEERING LOCKS. IT ISN'T UNTIL I EASE UP OFF THE GAS PEDAL DOES IT STOP. THIS HAS ALMOST CAUSED AN ACCIDENT AS I WAS UNABLE TO CONTROL MY CAR.

Incident Jan 11, 2020

POWER STEERING FAILS UNDER HARD ACCELERATION. WHEN THIS OCCURS THE CHECK ENGINE LIGHT COME ON AND THE STEERING HAS NO ELECTRIC ASSIST. THIS CONTINUES UNTIL THE ACCELERATION IS REDUCED. AFTER REDUCED ACCELERATION THE CHECK ENGINE LIGHT GOES OFF THE THE POWER STEERING RETURNS TO NORMAL. THIS OCCURS INTERMITTENTLY, BUT TYPICALLY ON A FREEWAY ON RAMP WHILE GETTING UP TO SPEED AND TRYING TO MERGE WITH TRAFFIC.

Incident Jan 6, 2020

MY THEFT LIGHT CAME ON A MONTH AFTER THE IGNITION WAS REPAIRED DUE TO RECALL. IT IS ALWAYS ON NOW. I HAVE REPLACED THE FUEL PUMP, SPARK PLUGS, AND TIMING CHAIN. MY CAR STILL WONT START AFTER ALL OF THAT AND THE THEFT LIGHT IS STILL ON. I HAVE BEEN WITHOUT A CAR FOR 2 MONTHS NOW DUE TO IT NOT STARTING. IT WILL ROLL OVER BUT NOTHING MORE HAPPENS.WHEN ALL OF THIS HAPPENED IT WAS STATIONARY AND IT WAS PARKED IN A PARKING LOT WHERE I WORK.

Incident Nov 10, 2019