2021 Chevrolet Silverado 1500

General Motors, LLC (GM) is recalling certain 2020 Chevrolet Bolt EV and 2021 GMC Canyon and Sierra 1500, 2500 and 3500, Yukon, Yukon XL, Cadillac Escalade and Escalade ESV and Chevrolet Blazer, Camaro, Colorado, Equinox, Silverado 1500, 2500 and 3500, Suburban and Tahoe vehicles. Incorrect bolts may have been used at one or more fastening locations to secure the seat belts to the vehicle. If an incorrect bolt was used, the seat belt may not be properly attached to the vehicle.

General Motors, LLC (GM) is recalling certain 2019-2021 Chevrolet Silverado 1500 and GMC Sierra 1500, 2021 Chevrolet Suburban and Tahoe and GMC Yukon XL and 2020-2021 Chevrolet Silverado 2500 and 3500 and GMC Sierra 2500 and 3500 vehicles. The seat belt brackets may not be secured to the seat frame in the front-row center seating position.

General Motors LLC (GM) is recalling certain 2020 Buick Enclave, Cadillac XT5, GMC Acadia and Chevrolet Traverse vehicles and 2020-2021 Chevrolet Silverado 1500, GMC Sierra 1500 vehicles. The vehicles may have been manufactured with Continental tires that were overcured.

The contact owns a 2021 Chevrolet Silverado 1500. The contact stated that the vehicle experienced excessive oil consumption at 2,600 miles. The vehicle was taken to the dealer, where it was diagnosed with a blown engine. The engine was replaced; however, the contact stated that the replacement engine continued to consume a significant amount of engine oil. The vehicle was taken back to the dealer, where the replacement engine was diagnosed with premature engine failure at 37,100 miles. The contact stated that during the engine failure, there was an abnormal sound coming from the engine and transmission. The manufacturer was notified of the failure. The contact stated that the vehicle had been taken to the dealer every 1,000 miles for oil to be added due to the excessive oil consumption. The dealer confirmed the initial engine failure and the premature failure with the replacement engine. The failure mileage was 37,100.

Incident Jul 1, 2021

My truck is the 2021 with the 6.2l L87 motor. My truck is not in the scope of the recall but i had the same failure and received a remanufactured engine without any warranty coverage.

Incident Sep 3, 2026

The contact owns a 2021 Chevrolet Silverado 1500. The contact stated that the vehicle previously had a bell housing installed to catch internal metal shavings; however, the housing assembly failed again and needed to be replaced. The vehicle was taken to a dealer for a diagnostic test. The contact associated the failure with the torque converter. The torque converter was previously replaced once. The contact stated that while driving, the vehicle felt like it was driving over rumble strips or speed bumps, which the contact felt and heard. The manufacturer was notified of the failure. The dealer was unable to duplicate the failure. The failure mileage was 60,000.

Incident Sep 16, 2026

This vehicle's engine failed on a high-volume roadway in [XXX] which resulted in a significant safety issue. The vehicle was taken to a certified Chevrolet dealership in Scottsdale (Van Chevrolet) whereby the engine in this 5.3L V8 was replaced due to catastrophic engine failure with the lifters being the suspected cause of the failure. Aside from the $10,400 cost of the remanufactured engine replacement, I have had considerable discussions (live and written) with GM Arizona and Corporate representatives outlining the issue(s) and filing formal complaints. These have gone relatively unheeded... Unfortunately, this is the second 5.3L V8 engine failure in one of our GM vehicles as I will be filing yet another formal complaint under separate cover for a 2021 Tahoe 5.3L V8 which had an engine failure requiring new lifters. I am not done yet as I have an appointment tomorrow for what appears to be, a third Chevrolet vehicle with a 5.3L V8 engine lifter failure. Depending on the outcome of this service appointment, I may be filing a third safety complaint regarding the GM 5.3L V8 engine. In my opinion, the NHTSA should absolutely open an investigation into this engine in the same manner that you have a formal investigation/recall in effect for the 6.2L GM engine as based on two personal experiences, the safety of the driver and passengers in these vehicles is compromised due to what appears to be significant engineering and/or manufacturing issues on the part of General Motors. Thank you for your consideration and I am free to discuss in further detail at [XXX] or [XXX]. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Incident Jun 21, 2026

Vehicle has a bad valve body which was confirmed by the dealer. Driving down the street and the engine went from 3 to 4 gear and the rear wheels locked up. Also when coming to a stop the truck jerks so bad it snaps your neck. GM has major problems with these trucks and knows the problems and keeps issuing bulletins however they have a massive backlog of orders for parts to fix these trucks which leaves people's trucks sitting at service centers for months waiting for backordered parts

Incident Sep 11, 2026

Truck stalled out while driving as if it had run out of fuel. Had to be towed to my house

Incident Sep 26, 2026

the engine seized. I tore into the motor to inspect what caused it and it spun a connecting rod bearing on cylinder 1. I have been paying 600 a month on it without being able to drive it since this happened in november of 2024.

Incident Nov 15, 2024

According to 2 mechanics- including a body shop - the frame has prematurely rusted due to: TSB 19-NA-255 - Wax Coating on Frame Peeling, Metal Shows Corrosion/Rusting There's so much damage to a 2021 truck, that it may not survive this winter. The frame welds are breaking due to the lack of frame protection. I asked my dealership, Lamoille Valley Chevrolet 868 VT RT 15E HYDE PARK, VT 05655, on two separate occasions to check for damage. One time they made no report, the second time they told me it was normal wear and tear. I've been told trucks 20 years older than mine, are in better condition. There was no protection for this frame.

Incident Sep 23, 2026

The contact owns a 2021 Chevrolet Silverado 1500. The contact stated that after activating the 4WD feature, the rear wheels locked up with the check engine warning light illuminated. The vehicle was taken to the dealer on several occasions to be diagnosed. Several unknown parts were replaced; however, the failure persisted. The vehicle was not repaired. The contact referenced Safety Recall : N242454440; as a possible cause for the failure. The manufacturer was not notified of the failure. The failure mileage was 102,490.

Incident May 14, 2025

Around 60k miles my truck started shifting rough and at odd times. Then it went into “limp” mode. I took it to the dealership and they replaced my battery and a solenoid. I asked about the transmission and they told me it was because it was in “limp mode”. I’ve continued to have issues with it then a couple of months ago while driving to work at around 60mph the truck harshly downshifted into a low gear causing the rear tires to break loose on the wet roads and sending me into an extended spin. I had the truck towed home and then to the local dealership. After researching, I have found that this is very common with the same vehicles in this year and that there are multiple recalls to address the issues. Unfortunately my VIN is not included. I believe the needed repairs and the associated costs should be GM’s responsibility under special coverages: N242454441 and N242454440-03

Incident Jul 21, 2026

The water pump went bad at 31,000 miles. If I continued driving and the pulley fell off the engine would overheat. I took it to the dealer and they confirmed the pump failure and want me to pay over $1,400 for repair that should be covered under warranty. There was no warning lamps lit, the pump just started making a grinding sound.

Incident Sep 17, 2026

My truck started skipping and over time the check engine light came on. I took it in and they are saying it is the lifters, which is costly. I know this truck was built during COVID and I know a lot of the manufacturers were dealing with skeleton crews. I heard this was an issue with the 2021 Silverado trucks, and a recall. Can you please advise?

Incident Sep 1, 2026

Engine failed and truck caught on fire from the engine failure

Incident Jan 24, 2026

2021 silverado engine failure. Yes it was inspected by a dealership and my extended warranty company and serviced by the dealership. Back on August 5th I experienced a misfire cylinder 3 and felt loss of power. On August 7th the dealership diagnosed both camshafts, 1 lifter, 1 valve, and 1 fuel injector was damaged and never received at warning lights or messages on the dashboard. I was without the vehicle for 39 days and within 10 hrs after picking up the truck i got an engine light on and several new codes on it and can not be driven and being towed. I feel these engines need a recall as it is well documented that these engines go between 60 and 80,000 miles and some a lot less than that, mine has 70,800 and went and now being towed with in less than 24 hrs after engine repair. I will be in contact with a lawyer to follow up on this matter.

Incident Aug 5, 2026

Engine noise, unable to pass or fail pico test due to to much noise in truck. Engine failure.

Incident Sep 11, 2026

LM2 engine coolant control valve failure. My vehicle VIN is not listed for the repair i dont know how it is not but they want me to pay outa pocket

Incident Jul 8, 2026

Statement for NHTSA Subject: Safety Complaint – 2021 Chevrolet Silverado Unexpected Jerking/Harsh Transmission Engagement I am submitting this complaint regarding my 2021 Chevrolet Silverado 1500 2.7L Turbo with approximately 128,000 miles. My vehicle has developed a recurring problem involving harsh/jerking transmission engagement, hesitation, shuddering and abnormal shifting. The truck can jerk when engaging or changing gears and has also experienced a hard engagement when shifting from Reverse into Drive. During normal driving, the vehicle can hesitate or feel as though it is repeatedly fluttering/shifting instead of providing smooth and predictable acceleration. The vehicle has produced diagnostic trouble codes including P0700, U0100 and P0420. I am concerned that this condition could create a safety hazard, particularly if the vehicle unexpectedly jerks, hesitates or fails to respond normally when accelerating or changing gears in traffic. I am requesting that NHTSA document this complaint and review whether there is a pattern or potential safety-related defect involving transmission engagement, shifting or drivetrain control on 2021 Chevrolet Silverado vehicles. GM has published service information concerning delayed and harsh transmission engagement on certain Silverado applications, including 2019–2021 models, which makes me concerned that my vehicle may be experiencing a related issue. I am retaining my repair records, diagnostic information, receipts, videos and mileage/date information documenting when the problem occurs. I am willing to provide this information if requested. Please help me get my truck corrected, I love my Chevy Truck. Thanks Sincerely [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Incident Sep 1, 2026

Following recall review by the dealership, experienced sudden, catastrophic engine failure nearly stranding me on the road with my son. Awaiting final diagnostics from the dealership, but every indication, errors, and symptoms align with all the other complaints that I have reviewed on line for the make/model of my vehicle. Recall assessment and corrective actions ineffective resolving engine failure.

Incident Sep 6, 2026

My 2021 Chevrolet Silverado 1500 RST with the 6.2L engine experienced an engine seizure. The engine was replaced by a Chevrolet dealership under a GM safety recall. Immediately after picking up the vehicle following the recall engine replacement, the truck stalled while still in the Chevrolet dealership parking lot. There was no warning before this first stall. We continued our trip because we did not realize at the time that the stall could indicate a problem following the engine replacement. During the drive from [XXX] to [XXX], the problem continued. In [XXX], the check engine light illuminated and the truck began malfunctioning. The vehicle subsequently stalled again. The problem continued after returning to [XXX]. A Chevrolet dealership in [XXX] inspected the vehicle and reproduced/confirmed a problem involving the camshaft position sensor wiring/connector. The dealership demonstrated the problem by manipulating the connector/wiring and recorded a video of the diagnostic procedure. The vehicle is currently at the Chevrolet dealership and is available for inspection. The affected component should also be available for inspection because it has not yet been repaired. The [XXX] dealership has characterized the wiring/connector condition as normal wear. However, the first stall occurred immediately after the GM recall engine replacement, while the vehicle was still on the repairing Chevrolet dealership's property. Unexpected engine stalling creates a serious safety risk because the vehicle can lose propulsion without warning while driving, including at highway speeds or in traffic. I am concerned that the camshaft position circuit/wiring/connector problem may be associated with the recall engine replacement procedure or replacement engine. I am requesting that NHTSA investigate whether other vehicles receiving this GM 6.2L engine recall remedy have experienced similar camshaft position circuit failures or unexpected stalling after engine repair. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Incident Sep 4, 2026

The contact owns a 2021 Chevrolet Silverado 1500. The contact stated that while driving 40 MPH, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. The contact stated that the transmission was slipping while shifting gears and the transmission was shuddering. The dealer was contacted by phone and made aware of the failure. The vehicle was taken to the dealer, where it was diagnosed with transmission failure. The contact was informed that the transmission needed to be replaced. The vehicle was not repaired. The contact was informed that the parts were ordered. The manufacturer was contacted by phone and made aware of the failure, and a case was filed. The contact was informed that the warranty had expired five months prior. The failure mileage was approximately 53,020.

Incident Sep 7, 2026

Loss of power , catastrophic engine failure

Incident Sep 8, 2026

The contact owns a 2021 Chevrolet Silverado 1500. The contact stated that while attempting to start the vehicle, there was an abnormal sound coming from the front driver's side of the vehicle. The contact inspected the vehicle and became aware that the exhaust manifold bolts had detached. The dealer was made aware of the failure. The contact was informed that the warranty mileage limitation had been exceeded. The manufacturer was contacted by phone, and a case was filed. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 62,248.

Incident Aug 8, 2026

My engine has been replaced twice already for total failure first time was in November 2023 and the second time was May 2026.

Incident Nov 22, 2023

The automatic power-unlatching tailgate assembly failed. The tailgate unlatches, opens, and cycles closed completely on its own while the vehicle is in motion and driving on public roads and when the gear shifts from drive to park and park to drive. The vehicle and the tailgate assembly are fully available for inspection upon request. The tailgate opening unpredictably while driving at road speeds creates an extreme safety hazard. It risks cargo flying out into traffic, which could cause a severe multi-vehicle accident or injure pedestrians. Additionally, it creates a massive driver distraction while trying to monitor the opening and closing tailgate in the rearview mirror while maintaining control of the vehicle. Sometimes there isn’t a warning light and sometimes it shows a warning light “tailgate open” I have taken it to the dealership and was told it isn’t part of the active recall for similar makes and models and my vehicles year/make/model needs to be added to the current recall for these concerns. It opened on its own while in park and turned off when the mechanic was replacing the license plate light.

Incident Sep 17, 2025

While coming to a stop, a snap ring came off the brake master cylinder. Vehicle top speed was 40mph, with the parking brake automatically engaged. ***Note from mechanic: Vehicle has several brake faults, C05CC and C05CF master cylinder piston position sensor performance, C2A17 hydraulic brake sponginess, and C0277 brake pedal position sensor fault. Tech recommends Hydraulic Brake Unit replacement***

Incident Aug 25, 2025

While driving on the road, the transmission in my truck completly neutralized all the gears (meaning it just started revving and slowing down rapidly in the middle of the road with cars in front of and behind me). And almost got me hit by several cars. I got the vehicle towed to the Chevy dealership it was bought from. The mechanics then confirmed the code was for a failed valve body in the trucks transmission. Which they had recalled in all the diesels but not gas engines.

Incident Aug 22, 2026

Vehicle went into reduced power mode and was taken to the dealership. They had to tear down the motor to diagnose the problem and determined it was the crankshaft and the motor needed to be replaced. It was out of factory warranty however it has an extended warranty and the warranty covered 80% of the repair. We still had to pay over 3k out of pocket. Vehicle is now making engine noises again and will be getting taken back to the dealership to be looked at. Currently not part of the recall however truck was built at the Mexico plant in question. We believe it may have the faulty components as well.

Incident Jun 1, 2026

Rear tailgate does not open and sometimes will show a warning on the dash that the tailgate is open when it is not. The tailgate for the heavy duty 2500/3500 trucks were recalled for the same reason but not the 1500 trucks. This is a common issue on the truck forums and is an unsafe condition.

Incident Jul 6, 2026

Number 2 cylinder lifter failure. Metal found in oil. Need to replace the engine

Incident Aug 24, 2026

Catastrophic internal engine failure Metal shavings throughout oil

Incident Mar 12, 2026

Took it to the dealer for the L87 recall back at the end of April 2026. GM stated that my truck passed the inspection and “upgraded” my oil to the new 0w-40 oil. Now 8-27-2026, 6500miles after the inspection. Driving to work in the morning, and my engine failed. What I believe happened was a lifter got stuck and the engine shook and all lights on the dash were flashing. Vehicle is currently at the dealership and they are saying the “special” warranty does not cover this failure. Which to me is completely unacceptable. Because for 72,900 miles I never had an issue with the truck. But 6500 miles after they changed the oil to the thicker oil now I have an engine failure.

Incident Aug 27, 2026

Lifter and cam shaft failure rendering vehicle unable to run on the side of the road 5 hours from home.

Incident Aug 22, 2026

The truck had been driving fine, no dash lights or warning messages appeared. It is available for inspection upon request. My family was at risk if this had happened on the freeway as we had been out just hours earlier. We attempted to start the engine like normal and there was a loud pop or bang and a sound like something dropped and it made loud revving sound never started up again. The initial confirmation by a certified mechanic is to be engine failure. They did not do an in depth diagnosis yet to determine if "the top valves dropped or bottom of the engine connecting rods to the crankshaft". THIS ISSUE ALL ALIGNS WITH THE CURRENT RECALL OF ENGINE FAILURE AS WELL AS THE MAKE. MODEL AND YEAR OF OUR TRUCK. But the dealership Bruce Lowrie Chevrolet says our VIN number does not qualify. Again the issue, make/model and year are all associated with the recall. We are in desperate need for our VIN to be added to the recall as it is fits all the details required.

Incident Aug 28, 2026

The contact owns a 2021 Chevrolet Silverado 1500. The contact stated that upon starting the vehicle, the engine was idling rough and the vehicle vibrated violently. The contact stated that while accelerating, the vehicle hesitate while responding. There was no warning light illuminated. The vehicle was taken to a local dealer to be diagnosed; however, no cause for the failure was found. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 70,000.

Incident Mar 1, 2026

About 2 months after bringing the truck in for the engine recall, my oil cooler blew up and I required that to be replaced, along with the radiator and hoses.

Incident Jul 12, 2026

Engine failure , early on it had the dod replace. Under warranty and I’m not 100% sure but this time it failed and took out the engine. New rotating system and valves replaced Happened at just under 100k miles With all I’m seeing about these engines I figured I’d report it.

Incident Nov 1, 2025

At 12,000 miles a lifter malfunctioned. It was repaired by my local Chevrolet dealership by replacing lifters on one side of the engine. The delearship also changed the viscosity of the oil. At 64,000 miles roughly another lifter malfunctioned and needed replacing. Had I been on the highway at the time of failure it could have posed a risk for the safety of my family and others on the road. Each time the check light was flashing at the time of the incident.

Incident May 22, 2026

The check engine light came on and my engine would stall sometimes, it would stall at start up so no safety issue. I took my truck to the dealer a week later where they said a wire was corroded from rubbing on something causing the issues and that it was a common issue.

Incident Aug 7, 2026

Truck started violently shaking while driving 70 mph on highway. Check engine light, service electric parking brake warning light, TCS/ESC warning light, started flashing on tachometer. Check engine light remained on when truck was restarted later. Chevy dealer service department reproduced problem and found broken bits of metal in the oil filter. Engine is shot. Likely caused by truck's Dynamic Fuel Management system. Dealer advises only option is to replace engine. Truck was up to date on all service maintenance.

Incident Aug 25, 2026

My husband was driving his 2021 Chevy Trailboss when it went into limp mode. It had to be towed to the dealership and it was uncovered that his truck was throwing out codes P0700 P2732 which is a known issue with this truck, resulting in internal valve body hydraulic failure. Since his vehicle is at 70k miles, and over the 60k, the dealer is pushing back and trying to say they don’t have to cover it. GM states that we should pay and then submit a reimbursement form. This is a $3800 fix. This is not our responsibility and this is unsafe. This should be a safety recall for all vehicles of this make, model, and with this transmission. Additionally, he had to have his engine replaced on this truck (we bought it brand new in 2021) with only 10k miles on it. This truck should not be built anymore and anybody facing these issues should not be held liable for them. This is a manufacturing issue and it is only one company’s fault, General Motors!

Incident Aug 17, 2026