2009 Chevrolet Silverado 3500

2009 SILVERADO CRACKED PASSENGER SIDE DASH BOARD HAD IT REPLACED BY GMC DEALER AND IT CRACKED AGAIN SAME PLACE AS THE FIRST CRACK. TRUCK HAS LESS THEN 77 THOUSAND MILES.

Incident Apr 1, 2013

THE DASH PANELS ON THE TOP OF THE DASH BOARD HAVE COMPLETELY BROKEN I FEEL THAT IF THE PASSENGER AIRBAG WERE TO DEPLOY IT WOULD BE A SAFETY ISSUE. PIECES OF THE DASH COULD POSSIBLY BECOME A HAZARD AND INJURE MYSELF OR MY PASSENGERS THIS NEEDS TO BE ADDRESSED THIS IS A VERY COMMON ISSUE AMONG MANY CHEVROLET VEHICLES

Incident Mar 26, 2016

#09184 AIRBAG LIGHT STAYS ON AND MESSAGE SERVICE AIRBAGS IS ON.

Incident Jan 12, 2016

CRACKING IDENTIFIED NEAR THE PASSENGER SIDE AIRBAG ON THE DASH OF THE TRUCK. DISCOVERED WHEN REPLACING TRUCK WINDSHIELD. CRACKING ALSO SEEN ON OPPOSITE SIDE OF DASH.

Incident Jan 20, 2016

SEVERAL CRACKS IN MY DASH (4-5). ONE IS AT THE CORNER OF THE PASSENGER AIRBAG. THE DASH IS SO BRITTLE IT CRACKS FROM JUST CLOSING THE DOOR. I'M AFRAID WHAT MIGHT HAPPEN IF I'M IN AN ACCIDENT AND BROKEN DASH PIECES GO FLYING THROUGHOUT THE CAB. THIS IS NO DOUBT A SAFETY CONCERN! NOT TO MENTION AN EYE SORE AND RESALE KILLER. THIS STARTED A FEW YEARS AGO AND CONTINUES TO GET WORSE.

Incident Mar 16, 2012

TL* THE CONTACT OWNS A 2009 CHEVROLET SILVERADO. THE CONTACT STATED THAT WHILE DRIVING AT 65 MPH, THE DOOR AJAR WARNING CHIMED BEFORE THE POWER DOORS LOCKED AND UNLOCKED INDEPENDENTLY, THE GAUGES FLUCTUATED AND THE INSTRUMENT PANEL ILLUMINATED. IN ADDITION, THE VEHICLE FAILED TO ACCELERATE WHEN THE ACCELERATOR PEDAL WAS DEPRESSED. THE FAILURE RECURRED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED BUT THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 70,000.

Incident Oct 6, 2014

PURCHASED USED VEHICLE FROM DEALER (DANIELS CHEVROLET, BUICK, GMC TRUCKS, INC. SWAINSBORO, GA) AND AFTER SALE DISCOVERED EMISSION SYSTEM WAS DISABLED AND DPF (DIESEL PARTICULATE FILTER) HAD BEEN PHYSICALLY REMOVED; PROBABLY BY PREVIOUS OWNER.

Incident Oct 7, 2015

FUEL LEAKING/SPRAYING OUT OF THE REAR AUXILIARY FUEL TANK. I NOTICED A STRONG SMELL OF RAW GASOLINE COMING FROM THE REAR OF THE VEHICLE. UPON FURTHER INSPECTION I OBSERVED THE RAW FUEL WAS COMING OUT OF THE FUEL MODULE CONNECTING FUEL LINE. THE METAL FUEL LINE SITS IN A WELL OF THE REAR TANK AND WAS COMPLETELY COVERED WITH DIRT/MOISTURE/RAW FUEL. THE TANK WAS REMOVED AND WE IMMEDIATELY NOTICED THAT THE METAL PORTION OF THE FUEL MODULE METAL PIPING WAS RUSTED THRU AND THAT WAS WHERE THE RAW FUEL WAS BEING SPRAYED/POOLING IN THE WELL AREA. THE DESIGN OF THE FUEL TANK & MODULE CREATES A PERFECT LOCATION FOR DIRT/MOISTURE TO ACCUMULATE. ANY TYPE OF IGNITION SOURCE COULD HAVE CAUSED A CATASTROPHIC FIRE AND POSSIBLE EXPLOSION. THE REMOVED ORIGINAL FUEL MODULE WAS IN PERFECT WORKING CONDITION EXCEPT FOR THE ROTTED METAL PORTION OF THE MODULE. I REPLACED THE ROTTED FUEL MODULE WITH A NEW GM OEM FUEL MODULE. THIS NEW MODULE HAS THE SAME EXACT CONSTRUCTION AS THE ORIGINAL PART. SINCE THERE IS NO POSSIBLE WAY TO CLEAN OR KEEP CLEAN THE WELL AREA OF THE TANK, I CAN ONLY ASSUME THE NEW OEM PART WILL DETERIORATE IN THE SAME MANNER. THE VEHICLE HAD ABOUT 34000 MILES ON IT WHEN THE CONDITION OCCURRED. SINCE IT IS OUT OF WARRANTY THE NEW MODULE COSTS FOR LABOR AND PARTS WAS IN EXCESS OF $1000.00. IN CONCLUSION I THINK THIS MATTER SHOULD BE INVESTIGATED FURTHER BECAUSE IT IS OBVIOUSLY A SAFETY HAZARD INVOLVING RAW FUEL BEING EJECTED FROM THE FUEL TANK UNDER PRESSURE WHILE THE PUMP IS RUNNING.

Incident Sep 15, 2015

WHILE DRIVING MY 2009 SILVERADO AT 33,000 MILES I NOTICED THE CHECK ENGINE LIGHT WENT ON AND IT WAS RUNNING ROUGH. AFTER TAKING TO THE DEALERSHIP IT WAS DETERMINED THE #7 CYLINDER WAS NOT WORKING. ACCORDING TO THE MECHANIC THE AFM FOR THE 5.3 LITER ENGINES HAS AN OIL CONSUMPTION ISSUE. HALF OF THE ENGINE WAS REBUILT DUE TO THE AMOUNT OF CARBON BUILT UP INSIDE THE ENGINE. AGAIN AT 78,000 MILES THE CHECK ENGINE LIGHT WENT ON AGAIN. THIS TIME THE DEALERSHIP HAD THE VEHICLE FOR 2 WEEKS TO AND DETERMINED THE ENGINE HAD EXCESSIVE CARBON BUILD UP AND A ENGINE SOAK WAS PERFORMED ALONG WITH SPLASH GUARDS ADDED TO THE VALVE COVERS TO KEEP THE ENGINE OIL FROM ESCAPING AS THE AFM WAS OPEARTIONAL. AT 98,000 MILES THE OIL PRESSURE SENSOR AND THE VALVE COVER GASKET HAD TO BE REPLACED. NOW, AT 140,000 MILES THE WATER PUMP, CRANK SHAFT AND BEARINGS HAD TO BE REPLACED. THE DEALERSHIP SAID I NEEDED A NEW ENGINE BECAUSE THEY WOULD NOT REBUILD THE ENGINE DUE TO THE MILEAGE. I HAVE CHANGED THE OIL EVERY 3,000 MILES AND STARTED USING FULL SYNTHETIC MOTOR OIL SINCE MY ENGINE ISSUES AT 33,000 MILES. GM IS AWARE OF THIS ISSUE WITH THE AFM AND CONTINUES TO DO NOTHING. I CONTACT GM CUSTOMER CARE AND THEY STATED THAT MY TRUCK HASN'T BEEN SEEN AT A DEALERSHIP IN OVER A YEAR, THEY WILL NOT ASSIST IN THE COST OF REPLACING THE ENGINE. BUT, THEY WILL GIVE ME A $1,000 CREDIT TOWARDS A NEW VEHILCE. INSTEAD OF FIXING THE PROBLEM, GM JUST TURNS THERE HEADS ON THE ENGINE PROBLEMS AND EXPECTS YOU TO PAY FOR A NEW GM VEHICLE. GM STAND BEHIND YOUR PRODUCT!!!!

Incident Oct 26, 2015

CRACK DEVELOPED IN DASH AT APP 50K MILES NEXT TO PASSENGER AIRBAG. CRACK HAS CONTINUED TO EXPAND SINCE.

Incident Sep 17, 2014

MAJOR OIL CONSUMPTION BURNED 4QTS BETWEEN OIL CHANGES TRUCK HAS THE 5.3L V8 NOT TO IMPRESSED DUE TO THE FACT IT ONLY HAS 75000 MILES ON IT

Incident Oct 27, 2015

TL* THE CONTACT OWNS A 2009 CHEVROLET SILVERADO. THE CONTACT STATED THAT THE DASHBOARD ABOVE THE PASSENGER SIDE AIR BAG WAS CRACKED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE DASHBOARD NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 90,000.

Incident Aug 9, 2015

WAS TOLD BY DEALER THAT IMPACT SENSOR WAS BAD. VEHICLE HAS NEVER BEEN IN ACCIDENT. HERE THAT THIS IS A COMMON PROBLEM. SOUNDS LIKE GM IS USING A DEFECTIVE PART. VEHICLE HAS LESS THAN 20,000 MILES. COSTING ME $330 FOR REPAIR. CAN YOU CHECK INTO THIS ?

Incident Jun 5, 2015

I GOT THIS TRUCK USED AT 94K MILES ON IT. IT WAS STILL IN STANDARD WARRANTY. I GOT THE OIL CHANGED STARTED GETTING THAT CLICKING/KNOCKING NOISE. I TOOK IT BACK TO THE SHOP THAT DID THE OIL CHANGED. THEY LOOKED INTO AND TOLD ME IT WAS A COMMON PROBLEM WITH CHEVY ENGINES IS THE VALVE LIFTERS BREAK AND NEEDS REPLACED ALONG WITH THE CAMS. IF I DRIVE TOO MUCH A POSSIBILITY TO ADD SHAVINGS INTO THE MOTOR AND TEAR IT UP. QUOTES FROM 3 DIFFERENT FRIEND RECOMMEND AUTO SHOPS FROM ALL OF THEM TO GET A NEW ENGINE OR GET RID OF THE TRUCK. I AM STILL MAKING PAYMENTS ON IT. SO CAN'T DO THAT. I DID TAKE IT TO THE DEALERSHIP AND THEY REFUSED TO HELP ME AT ALL. I WAS OUT OF THE WARRANTY PERIOD AND GOOD LUCK. THAT SUCKS! I DID MAKE A SCENE TO THEM IN FRONT OF CUSTOMERS. SINCE THEN I HAVE DONE SOME RESEARCH FINDING OUT THIS IS VERY MUCH A PROBLEM IN ALL CHEVY ENGINES DATING BACK TO 06. THE AFM, EXCESSIVE OIL CONSUMPTION. AT ONE POINT CHEVY DID DO A RECALL FOR A YEAR IN 07-08. FOR THIS PROBLEM. BUT NOT FOR ANY OTHER YEARS I CAN FIND. IF THEY KNEW/KNOW OF THIS PROBLEM WHY NOT SOLVE IT? I HAVE TO FIX THIS TRUCK ITS MY DAILY DRIVER AND WORK VEHICLE. TOTAL HATING CHEVY RIGHT NOW AND HAS ALWAYS BEEN MY LOVE! I AM A SINGLE MOM AND I KNOW HAVE TO COME UP WITH A NEW ENGINE ABOUT 3,500 THEN ADD LABOR AND SUPPLIES ABOUT 6K TOTAL. NOT HAVE AND VERY STRESSED OUT.

Incident May 15, 2015

I HAVE A 2009 CHEVY PICKUP AND EVERY TIME YOU PUT THE BRAKES ON THE TAILLIGHTS COME ON BUT THEY WONT GO OFF WHEN YOU TAKE YOUR FOOT OFF THE PEDEL.NOW I'V CHANGED OUT THE SWITCH UNDER THE DASH 3 TIMES STILL THEY DO THE SAME THING SO I WENT BACK TO THE OLD SWITCH. WHY IS THIS HAPPENING TELL ME PLEASE I NOTICE I WAS NOT THE ONLY ONE THAT HAS THIS PROMBLEM???????????

Incident Feb 18, 2015

2009 CHEVROLET SILVERADO. CONSUMER WRITES IN REGARDS TO CHASSIS ELECTRONIC MODULE CONTAINING INTERNAL CONTAMINATION RECALL NOTICE ISSUES. *SMD THE CONSUMER IS SEEKING REIMBURSEMENT, AS HE EXPERIENCED A FAILURE PRIOR TO THE RECALL. THE FUEL PUMP MODULE SHORTED OUT AND DAMAGED THE WIRING.*JB

Incident May 14, 2014

2009 CHEVROLET SILVERADO. CONSUMER WRITES IN REGARDS TO THROTTLE POSITION SENSOR REPLACEMENT. *SMD THE CONSUMER STATED WHEN THE THROTTLE POSITION SENSOR FAILED, IF CAUSED A SIGNIFICANT REDUCTION IN ENGINE POWER AND DISABLED THE TRACTION CONTROL AND STABILITRAK FUNCTION. THE CONSUMER STATED THE THROTTLE POSITION SENSOR FAILED A YEAR AFTER HE PURCHASED THE VEHICLE. *JB

Incident Dec 28, 2010

THE FIRST INCIDENT OCCURRED WHILE DRIVING THE VEHICLE ON THE HIGHWAY. THE ENGINE LIGHT CAME ON AND THE DASH READOUT GAVE A LOW OIL PRESSURE WARNING. THE TRUCK WAS TOWED TO THE DEALER. THEY SAID IT WAS A BAD OIL PRESSURE SENSOR AND REPLACED IT AT A COST OF APPROXIMATELY $450.00. FIVE MONTHS LATER THE SAME PROBLEM HAPPENED AGAIN WHILE DRIVING ON THE FREEWAY TOWING A HORSE TRAILER. I AGAIN HAD THE VEHICLE TOWED INTO THE DEALER. THEY SAID THE OIL WAS LOW AND DID AN OIL CHANGE. THE WARNING LIGHT WAS OFF WHEN WE GOT THE TRUCK BACK. THE LATEST INCIDENT HAPPENED ON 4/18/2015. THE ENGINE LIGHT CAME ON AGAIN. I BROUGHT THE TRUCK TO AN AUTO PARTS STORE WHERE THEY READ THE FAULT CODE. THE CODE IS P0521 - OIL PRESSURE SENSOR OR OIL LOW. I CHECKED THE OIL IT WAS NEARLY FULL BUT I ADDED A LITTLE ANYWAY. THE LIGHT STAYED ON. I MADE AN APPOINTMENT AT THE DEALER. THE LIGHT WENT OFF THE DAY BEFORE OUR APPOINTMENT. I BROUGHT THE VEHICLE TO THE DEALER AND NOW THEY ARE TELLING ME THAT THE TRUCK PROBABLY NEEDS AN OIL PUMP AND A VALVE COVER AND IT WILL COST APPROXIMATELY $1075.00 TO FIX. I HAVE DONE EXTENSIVE RESEARCH ON THIS PROBLEM ON THE INTERNET. THERE ARE HUNDREDS OF OWNER COMPLAINTS ON VARIOUS WEBSITES DOCUMENTING THE SAME PROBLEM I AM HAVING. THERE APPEARS TO BE A DEFECT IN THE DESIGN OF THE OIL SYSTEM IN THESE VEHICLES. MY TRUCK JUST WENT OUT OF WARRANTY IN DECEMBER 2014. THEY WANT ME TO PAY FOR THIS REPAIR EVEN THOUGH I HAVE ALREADY PAID FOR REPAIRS FOR THE SAME PROBLEM WHILE IT WAS UNDER WARRANTY. THIS APPEARS TO BE A SERIOUS PRODUCT DEFECT AND GM SHOULD ISSUE A RECALL. *TR

Incident Feb 14, 2014

WIFE DROVE TRUCK TO THE STORE IT WAS RAINING HARD THIS DAY. CAME OUT AND TRUCK WAS DEAD. JUMPED THE TRUCK AND TOOK IT HOME.LOOKED AT THE BATTERY. STILL HAD FACTORY BATTERY. REPLACED THE BATTERY. NEXT MORNING THE TRUCK WAS DEAD. JUMPED THE NEW BATTERY TRUCK STARTED . TURNED TRUCK OFF /COULD HEAR SOMETHING RUNNING IN THE FUEL TANK. FOUND OUT THAT THERE WERE PROBLEMS WITH THE FUEL MODULE ABOVE THE SPARE TIRE. CALLED THE DEALERSHIP FOR THE THIRD TIME. CREG SMITH AUTO GROUP. GALION OHIO 44833. COULD NOT GET THE SERVICE MANAGER ON THE PHONE. LEFT HIM A VOICE MAIL. NEVER RETURNED MY CALL. NEXT DAY CALLED FOR SERVICE MANAGER. THEY COULD NOT FIND HIM IN THE BUILDING. TOLD A MAN ON THE OTHER END OF THE PHONE EVERYTHING THAT WAS GOING ON. SOMETHING WAS DRAINING MY BATTERY AND SOMETHING WAS RUNNING.24/7. MAN TOLD ME HE WOULD CALL ME BACK. NEVER DID. LEFT FOR DEALERSHIP WITH THE TRUCK. TRUCK STOPPED ON ME IN MIDDLE OF THE ROAD HAD IT TOWED HOME. NEVER MADE IT TO THE DEALERSHIP. I AM VERY UPSET WITH EVERYTHING NOW. I TURNED THE KEY AND THE TRUCK STUCK ON WAS STILL TRYING TO START AFTER I TURNED KEY OFF. . WAS AFRAID OF THE FUEL SYSTEM AND ELECTRICAL SYSTEM TOGETHER. .ONE SPARK COULD BLOW ME UP. NOW TRUCK WILL NOT START AT ALL. PLEASE HELP ME. I WAS TOLD BY DEALER THAT I HAD TO COME TO A DEALER .ALL PARTS HAD TO BE REPROGRAMMED FOR THE TRUCK. I HAVE NO MONEY ! ONLY OWE 2,400 AND TRUCK IS PAID OFF PLEASE HELP ME. *TR

Incident Apr 14, 2015

TL* THE CONTACT OWNS A 2009 CHEVROLET SILVERADO. WHILE DRIVING AT 35 MPH, THE VEHICLE LOST POWER. IN ADDITION, THE CONTACT STATED THAT REDUCED ENGINE POWER WAS DISPLAYED ACROSS THE MESSAGE BOARD. THE VEHICLE WAS TAKEN TO A DEALER. THE TECHNICIAN DIAGNOSED THAT THE THROTTLE BODY NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 59,000. UPDATED 5/29/15*CN UPDATED 9/29/2017*CN

Incident Mar 15, 2015

LOCKS STARTED LOCKING/UNLOCKING. GEAR INDICATOR WAS GOING FROM DRIVE TO PARK. HEAT CAME ON BY ITSELF AND FAN WENT FROM HIGH TO LOW. SPEEDOMETER WENT FROM 70MPH TO 55 MPH WITH LOSS OF ENGINE POWER. HEADLIGHTS WERE FLASHING ON AND OFF. AFTER PULLING OFF I-75 AND GETTING TO A SAFE STOPPING AREA THE TRUCK WOULD NOT START AFTER TURNING THE ENGINE OFF. THE ENGINE COMPARTMENT FELT EXTREMELY HOT: ESPECIALLY THE BATTERY. AFTER 10 MINUTES, THE TRUCK WAS ABLE TO START AND CONTINUE THE REST OF THE TRIP. AFTER DOING SOME INTERNET RESEARCH, THIS PROBLEM IS WELL DOCUMENTED ON VARIOUS CHEVY FORUMS AND CAR MESSAGE BOARDS. REPLACING THE MEGA FUSE AND BATTERY CABLES APPEARS TO SOLVE THE MAJORITY OF THE ISSUES AS IT DID IN MY CASE. THE DEFECTIVE MEGA FUSE AND BATTERY CABLES CAUSED THE EXCESSIVE VOLTAGE THROUGH THE CABLES, CAUSING EXTREME HEAT WHICH RESULTED IN SCORCH MARKS ON THE TERMINAL ENDS OF THE BATTERY CABLES AND THE INSULATION OF THE CABLES CHANGING COLOR AS WELL AS THE ABOVE ISSUES. I AM VERY GRATEFUL THAT AN ELECTRICAL FIRE DIDN'T HAPPEN WHICH I BELIEVE COULD HAVE EASILY BEEN THE CASE. *TR

Incident Jan 18, 2015

TL* THE CONTACT OWNS A 2009 CHEVROLET SILVERADO. THE CONTACT STATED THAT THE PASSENGER SIDE DASHBOARD CRACKED WHERE THE AIR BAG WAS LOCATED. THE VEHICLE WAS TAKEN TO A DEALER. THE TECHNICIAN DIAGNOSED THAT THE DASHBOARD NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 19,000. THE VIN WAS UNAVAILABLE. UPDATED 4/13/15*CN

Incident Jul 15, 2014

THE BRAKE SYSTEM WENT OUT. THE DEALER REFUSED TO REPAIR UNDER WARRANTY, BECAUSE IT IS OUT OF WARRANTY. THIS IS THE SECOND 2009 WITH BRAKE PROBLEMS. ....UPDATED 04/02/15 *BF

Incident Feb 1, 2015

TL*THE CONTACT OWNS A 2009 CHEVROLET SILVERADO. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE ENGINE STALLED WITHOUT WARNING. THE FAILURE RECURRED NUMEROUS TIMES. THE CONTACT DIAGNOSED THAT THE FUEL SYSTEM CONTROL MODULE NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 56,000.

Incident Jan 9, 2015

WELL MAINTAINED VEHICLE WITH LESS THAT 78K MILES AND TRANSMISSION FAILING. GM SHOULD BE FORCED TO STEP UP AND PAY FOR THE REPAIRS. VEHICLE IS A LEMON. HAVE REPLACED AND FIXED MULTIPLE OTHER ISSUES. 3 DOOR LOCK ACTUATORS GONE OUT...2 TIMES FIXED FUEL SYSTEM VAPOR CANISTER...PASSENGER WINDOW SWITCH FAILED...CRUISE NOT WORKING... *TR

Incident Jan 17, 2015

I WAS DRIVING IN HEAVY TRAFFIC AND USED MY LEFT TURN SIGNAL ALL OF THE LIGHTS IS THE TRUCK STARTED FLASHING AND THE DOORS UNLOCKED AND LOCKED THEM SELVES. THEN TWO MILES LATER STILL IN HEAVY TRAFFIC I FLASHED MY LIGHTS AT A TRUCK TO LET HIM KNOW HE COULD SAFELY ENTER MY LANE AT WHICH POINT THE TRUCK CUT COMPLETELY OFF GOING 35 MPH IN HEAVY TRAFFIC. THIS IS VERY UNSAFE AND I AM LUCKY THAT NO ONE WAS FOLLOWING TO CLOSE. *TR

Incident Jan 16, 2015

ACCELERATOR STUCK DRIVING ON AN INTERSTATE GOING 65M/H. SLAMMED ON MY BRAKES TOOK A GOOD 30 SECONDS BEFORE I COULD GET IT TO SLOW DOWN AND STOP ON THE SIDE OF THE ROAD. HAS NOT HAPPENED SINCE. *TR

Incident Nov 28, 2014

WENT OUT TO TRUCK TO MOVE IT AND NOTICED WIPERS UP ON WINDSHIELD, TRIED TO START IT AND ONLY CHECK ENGINE LIGHT CAME ON , LOOKED UNDER HOOD TO FIND AN ELECTRICAL BURNING SMELL COMING FROM FUSE BOX. DISASSEMBLED FUSE BOX TO FIND IT WAS MELTED AND FOUND EVIDENCE OF COMBUSTION, WIRING HARNESS CONNECTOR X2 PIN N5 WAS MELTED AND CONNECTOR X5 PINS G1 H1,2,3,4 K 4,5,6 AND J 2,3,4 HAD MELTED THIS IS ALL THE DAMAGE THAT I FOUND. *TR

Incident Oct 13, 2014

THE DASH ON MY 2009 CHEVROLET SILVERADO HAS CRACKED AROUND THE PASSENGER SIDE AIR BAG. THIS CONCERNS ME AS IF THE AIR BAG DEPLOYS THIS WILL CAUSE PIECES OF THE DASH TO INJURE THE PERSON IT IS SUPPOSED TO PROTECT. THERE IS NUMEROUS INFORMATION ON THE INTERNET WITH PEOPLE WITH THE SAME PROBLEM. I TOOK THIS TO THE CHEVROLET DEALER I BOUGHT THE VEHICLE FROM IN FOLEY AL AND THEY REFUSE TO DO ANYTHING ABOUT IT. *TR

Incident Oct 12, 2014

TL* THE CONTACT OWNS A 2009 CHEVROLET SILVERADO. THE CONTACT STATED THAT WHILE HAVING THE ANNUAL SERVICE PERFORMED, THE TECHNICIAN NOTIFIED THAT CONTACT THAT THE FRONT BUMPER WAS EXPOSED TO WATER CAUSING A SHORTAGE IN THE SENSOR. THE FAILURE CAUSED THE AIR BAG LIGHT TO ILLUMINATE AND IT WOULD PREVENT THE AIR BAG FROM DEPLOYING DURING A CRASH. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE APPROXIMATE FAILURE MILEAGE WAS 76,600. UPDATED 12/9/14*CN THE CONSUMER STATED THE LEFT FRONT CRASH SENSOR HAD WATER DAMAGE. THE VEHICLE WAS REPAIRED. UPDATED 6/1/2015 *JS

Incident Oct 13, 2014

TL* THE CONTACT OWNS A 2009 CHEVROLET SILVERADO. WHILE DRIVING APPROXIMATELY 55 MPH, THE CHECK ENGINE WARNING INDICATOR ILLUMINATED AND THE AIR CONDITIONER TURNED OFF WARNING INDICATOR FLASHED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE TECHNICIAN STATED THAT THE THERMOSTAT NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 54,000.

Incident Oct 4, 2014

DASH BOARD CRACKED AT PASSENGER SIDE AIRBAG, CONCERNED ABOUT SAFETY OF PASSENGER IF BAG DEPLOYS IMPROPERLY DUE TO THIS COMPROMISED DASH. *TR

Incident Jul 15, 2014

MY CHEVY TRUCK IS A C1500.I ALSO HAVE A CRACK IN THE DASH ABOVE MY PASSENGER SIDE AIR BAG ON THE DASH.I NOTICED IT WHEN MY TRUCK ONLY HAD 10,000 MILES ON IT. IT'S NOT FROM THE SUN BECAUSE MY TRUCK STAYS IN THE GARAGE.IT SEEMS THERE ARE MANY OF US THAT HAS THIS ISSUE. *TR

Incident Apr 7, 2010

KEY COMES OUT OF THE IGNITION WHILE TRUCK IS RUNNING. *TR

Incident Aug 15, 2012

REAR PASSENGER DOOR LOCK DOES NOT LOCK OR UNLOCK ON 2009 CHEVY SILVERADO. WHILE DRIVEING THE GRAND KIDS TO SCHOOL THE REAR DRIVER SIDE DOOR OPENED WHILE GOING AROUND A CORNER. THE GRANDSON DID ADMIT THAT HE HAD HIS HAND ON DOOR HANDLE. COME TO FIND OUT THAT THE DOOR LOCK HAS FAILED ON THIS DOOR. WE ARE LUCKY THAT WE INFORNCE THE SEATBELT RULES OR THIS WOULD HAVE BEEN A REAL ACCIDENT. I CONTACTED GM AND HAD THE VECHILE LOOKED AT. THE DOOR LOCK MOTOR HAS FAILED AND THE DELAER TOLD ME THAT IT IS A KNOWN PROBLEM AND THEY HAVE CHANGED 100'S OF THEM. I CONTACTED GM AND OPENED A CASE BUT GM SAID THAT THEY WILL NOT ADDRESS THE PROBLEM. ANOTHER LOCK HAS FAILED AND AGAIN GM WILL NOT ADMIT THAT THERE IS A PROBLEM WITH THE DOOR LOCKS. I SEE THAT THERE ARE 1000'S OF POSTS ON THE WEB ABOUT FAILED DOOR LOCKS ON THIS YEAR VECHICLE.

Incident Aug 12, 2012

WHILE DRIVING DOWN THE HIGHWAY, HEARD A NOISE AND THEN NOTICED THE DASH ABOVE THE AIRBAG HAD DEVELOPED AN OBVIOUS CRACK THAT IS APPROXIMATELY 1 INCH LONG. UPON CLOSER INSPECTION OF THE DASH, NOTICED THAT THERE IS ALSO A HAIRLINE CRACK IN THE DASH ABOVE THE AIRBAG APPROXIMATELY 4 INCHES TO THE RIGHT OF THE FIRST NOTICED CRACK. *TR

Incident Aug 1, 2014

ON THREE SEPARATE OCCASIONS THE FUEL GAUGE ON MY 2009 SILVERADO READ FULL, WHEN IT WAS ACTUALLY NEAR EMPTY. THE FIRST TIME WAS DRIVING THROUGH THE DESERT ON HWY 395 IN CALIFORNIA. THE OUTSIDE TEMPERATURE WAS OVER 100 DEGREES. I KNEW I HAD DRIVEN TOO FAR FOR THE GAUGE THE BE CORRECT. THERE ARE VERY FEW GAS STATIONS ON THAT ROAD. THE SECOND TIME IT HAPPENED WAS ON THE SAME ROAD A YEAR LATER DRIVING THROUGH THE DESERT. I FINALLY REALIZED THE PROBLEM WAS THE HEAT, WHEN IT HAPPENED AT MY HOME TOWN IN JAMUL, CA WHEN IT WAS OVER 100 DEGREES. THE LOW FUEL WARNING NEVER CAME ON AND THE GAUGE SAID FULL. I TURNED THE TRUCK ON AND OFF AND IT STILL SAID FULL. THE GAUGE CORRECTED AFTER I ADDED FUEL. I INQUIRED AT THE DEALER IF THERE WERE ANY RECALLS AND THEY SAID THERE WAS NOT. *TR

Incident Jul 23, 2013

THE PROBLEM; SERVICE AIR BAG ILLUMINATES AND SHOWS UP IN THE MESSAGE CENTER. WENT TO CHEVROLET DEALER AND THEY TRIED TO CLEAR THE CODE WITH THE READER AND NO LUCK. THEY DON'T KNOW WHERE TO START, IT COULD BE ANYTHING THEY SAID. I DON'T WANT TO DUMP THOUSANDS OF DOLLARS TO RESEARCH A PROBLEM THEY DON'T KNOW IF THEY CAN CURE. HAS ANYONE ELSE EXPERIENCED THIS ISSUE? 2009 CHEVROLET 2500HD DIESEL. *TR

Incident Jan 3, 2014

EXTREME CHATTERING OF THE REAR BRAKES UPON APPLICATION WAS OBSERVED BY THE OWNER/DRIVER, INCLUDING LOCK-UP OF THE REAR WHEELS (EVEN THOUGH ABS EQUIPPED). THE VEHICLE WAS TAKEN TO THE AUTONATION CHEVROLET SUPERSTITION SPRINGS DEALERSHIP (6330 E. SUPERSTITION SPRINGS BLVD, MESA, ARIZONA 85206) FOR INSPECTION AND REPAIR (SELLING DEALER). THE DEALERSHIP INFORMED THE OWNER THAT BOTH REAR BRAKE SLAVE CYLINDERS HAD FAILED AND LEAKED HYDRAULIC FLUID ONTO THE LININGS. THIS LEAKAGE HAD CAUSED THE STICKING OF THE LININGS TO THE BRAKE DRUMS AND RESULTING CHATTERING/LOCKUP OF THE BRAKES. POST REPAIR, THERE HAVE BEEN NO FURTHER ISSUES IN THE LAST 3000 MILES OF USE. THE REPAIR WAS AT THE EXPENSE OF THE CUSTOMER. AS THIS OCCURRED AT 36094 MILES AND FOUR YEARS OF SERVICE IN RESIDENTIAL USE, I CONSIDER THIS A PRODUCT FAILURE DUE TO SOME FORM OF MANUFACTURING AND/OR INSTALLATION DEFECT WITH THE BRAKE SLAVE CYLINDERS. IN 40+ YEARS OF AUTOMOBILE OWNERSHIP OF MANY BRANDS WITH MILEAGES INTO THE 140K+ RANGE, I HAVE NEVER HAD A SLAVE CYLINDER FAILURE, NOR HAVE I EVER HEARD OF A DUAL FAILURE. THIS WAS THE SAME COMMENT BY THE SERVICE TECHNICIAN AT THE DEALER. PLEASE INVESTIGATE, OR AT A MINIMUM, ADD THIS TO YOUR WATCH LIST DATABASE. I REVIEWED THE NHTSA'S WEBSITE LIST OF DEFECTS, BUT FOUND NOTHING REGARDING THIS TYPE OF INCIDENT. THE FACT THAT IT WAS A DUAL COMPONENT FAILURE AND COULD HAVE RESULTED IN AN ACCIDENT IF HARD BRAKING HAD BEEN REQUIRED BY THE OPERATOR, THE MANUFACTURER SHOULD BE MADE AWARE OF THE ISSUE. I ATTEMPTED TO DO SO PERSONALLY, BUT FOUND THE EXPERIENCE UNSATISFACTORY. *TR

Incident Oct 24, 2013

USED THE VEHICLE FOR VACATION IN 2011 AS IT WAS JUST 1 YEAR OLD. VERY LITTLE BRAKE PED LEFT GOING DOWN HILL. GOING DOWN HILL AND STEP ON THE BRAKE AND THERE WAS A BAD VIBRATION AND GROWLING NOISE FROM THE BRAKES. I HAD IT CHECKED AND THE DEALER GROUND THE BRAKE ROTORS. THIS NEVER SOLVED THE PROBLEM, SO THEY REPLACED THE ROTORS. THIS SOLVED THE PROBLEM FOR THE WARPED ROTORS FOR A WHILE. NOW THE PROBLEM STARTED AGAIN WITH 23000 MILES AND ONLY GROWLS AND VIBRATES WHEN GOING DOWN HILL WHERE YOU HAVE TO STEP DOWN A LITTLE HARDER. HAD IT CHECKED OUT AGAIN AND THEY SAY THE ROTORS ARE WARPED AGAIN. I REPLACED THE ROTORS AND PUT NEW BRAKE PADS ON AND THE PROBLEM IS STILL THERE. I DO NOT DRIVE THE VEHICLE HARD AND ONLY ABOUT 4000 MILES PER YEAR. WHATS CAUSING THE BRAKE ROTORS TO KEEP WARPING. *TR

Incident Jul 6, 2011