2001 Chevrolet Suburban

CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE AND ROAD SALT.

VEHICLE DESCRIPTION: PICKUP AND UTILITY TRUCKS. SOME OF THESE VEHICLES HAVE AN INTERNAL COMPONENT IN THE OUTBOARD SEAT BELT RETRACTORS FOR THE 2ND AND 3RD ROW OF SEATS THAT COULD BE CRACKED. WITH REPEATED ACTUATION OF THE LOCKING MECHANISM, THE CRACK COULD SPREAD TO THE POINT SUCH THAT THE SEAT BELT WOULD NO LONGER LOCK.

VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND SPORT UTILITY VEHICLES. SOME OF THESE VEHICLES HAVE LOOSE OR MISSING REAR WHEELHOUSE PLUGS. UNDER CERTAIN VEHICLE OPERATING CONDITIONS, EXHAUST GASES CAN FLOW FORWARD AND ACCUMULATE IN THE REAR WHEELHOUSE.

THE PASSENGER SIDE REAR DOOR WINDOW BREAKS WHEN THE WINDOW IS DOWN FOR NO REASON. I HAVE HAD TO REPLACE IT 4 TIMES IN THE LAST 60 DAYS. THERE APPEARS TO BE NO DAMMAGE TO ANY OF THE INSIDE OF WINDOW OR THE WINDOW REGULATOR. THE VEHICLE WAS STATIONARY AND MY DAUGHTER OPENED THE DOOR AND THE WINDOW BROKE.

Incident Sep 6, 2017

EXHAUST AND MANIFOLD COVER BOLTS ARE TOO WEAK AND THE HEADS BREAK OFF. I HAD TO REPLACE ALL OF THEM WITH RACING BOLTS. MUCH BETTER NOW.

Incident Aug 20, 2014

ON MARCH 16, 2017, I WAS TRAVELLING ON A MOUNTAIN HIGHWAY IN NORTHERN CALIFORNIA IN MY 2001 SUBURBAN WITH THE DRIVER'S SEAT HEATER ON. I WAS SITTING ON A THIN SEAT CUSHION. TWENTY MINUTES INTO THE 40 MINUTE TRIP, I TURNED MY SEAT HEATER OFF. TEN OR SO MINUTES LATER, I SMELLED A HORRIBLE RUBBER/PLASTIC BURNING SMELL. WHEN I REACHED MY DESTINATION, I LIFTED MY CUSHION AND SAW THAT THE SEAT HAD A BURNED HOLE THROUGH THE LEATHER AND INTO MY SEAT CUSHION. IT WAS WARM, BUT I DID NOT SEE A FLAME. WHEN I GOT HOME IN THE BAY AREA, I CONTACTED GM, AND THEY OPENED A CASE NUMBER AND TOLD ME TO TAKE MY VEHICLE TO A DEALER, AND THEY WOULD INVESTIGATE. I RECEIVED A CALL YESTERDAY FROM THE CUSTOMER SERVICE REP., AND SHE TOLD ME THAT THEY WOULD NOT BE COVERING THIS AS MY CAR WAS OUT OF WARRANTY, IN SO MANY WORDS. I ASKED WHAT THE DEALER HAD FOUND, AND SHE COULDN'T TELL ME. I REITERATED TO HER THAT THIS IS A SAFETY CONCERN FOR ME. MY PASSENGER SIDE SEAT HEATER IS NOW GETTING VERY HOT, AND I AM CONCERNED NOW ABOUT THAT. PLEASE NOTE, THE DRIVER'S SEAT HEATER IS STILL WORKING IF YOU ACCIDENTALLY HIT THE BUTTON ON THE DOOR. TODAY, I FOUND OUT FROM THE DEALER THAT THEY WERE NOT INSTRUCTED BY GM TO LOOK INTO THE SEAT TO SEE WHAT CAUSED THIS, ONLY TO TAKE PICTURES, ETC. NOBODY KNOWS WHY IT HAPPENED. HOW CAN THEY DENY ANYTHING WITHOUT DETERMINING THE CAUSE IS MY THOUGHT. AREN'T THEY CONCERNED THEIR SEATS OVERHEAT? SHOULD THEY BE WARNING THE PUBLIC? MY SEATS ARE IN VERY GOOD CONDITION, EVEN THOUGH IT IS AN OLDER VEHICLE. INTERESTING TO NOTE WHEN WE PICKED THE CAR UP FROM THE DEALERSHIP THAT THE SERVICE WRITER SAID I SHOULDN'T WORRY SINCE IT IS NOT WORKING NOW BECAUSE A WIRED PROBABLY BROKE (EVERYTHING IS PROBABLY OR MAYBE). I CORRECTED HIM AND SHOWED HIM THAT IT DOES. HE WAS VERY SURPRISED TO SEE THAT IT STILL DID. SO, THE QUESTION IS WHY DID IT OVERHEAT. PLEASE ADVISE.

Incident Mar 16, 2017

I WAS DRIVING ON THE HIGHWAY 95 COMING BACK FROM DAYTONA WHEN A DRIVER LET ME KNOW THAT MY TIRES WHERE LOW SO I WHEN TO A GAS STATION TO PUT SOME AIR IN AND THATS WHEN I NOTICE THAT MY TIRES HAD A LOT OF NAILS LTHE 4 TIRES. THIS IS RIDICULOUS. MY TIRES ARE LNOT EVEN 2 YEARS OLD AND I HAVE THE RECEIPT TO PROVE IT. SOMEONE HAS TO DO SOMETHING. BECAUSE I HAVE A NEW BORN BABY WITH ME AND DRIVING WITH FLAT TIRES IS NOT AN OPTION. PLEASE TAKE MY COMPLAINT IN CONSIDERARATION. THANK YOU

Incident Feb 9, 2017

TL* THE CONTACT OWNED A 2001 CHEVROLET SUBURBAN. WHILE DRIVING AT AN UNKNOWN SPEED, SMOKE EMITTED FROM THE ENGINE COMPARTMENT OF THE VEHICLE. THE CONTACT PULLED OVER AND DISCOVERED THAT THE FRONT END AND FRONT WHEELS WERE ON FIRE. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. FIRE AND POLICE REPORTS WERE FILED. THERE WERE NO INJURIES. THE VEHICLE WAS TOWED TO A SALVAGE YARD AND DEEMED DESTROYED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 204,654.

Incident Oct 2, 2016

TL* THE CONTACT OWNED A 2001 CHEVROLET SUBURBAN. WHILE DRIVING THE VEHICLE, SMOKE EMITTED UNDER THE HOOD OF THE VEHICLE. THE CONTACT COASTED THE VEHICLE TO THE SIDE OF THE ROAD AND EXITED THE VEHICLE. THE VEHICLE CAUGHT ON FIRE, WHICH WAS EXTINGUISHED BY THE FIRE DEPARTMENT. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED AND DESTROYED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 200,000. THE VIN WAS NOT AVAILABLE.

Incident Oct 2, 2016

WHILE THANKFULLY DRIVING AT A LOW SPEED, MY BRAKES COMPLETELY FAILED WITH NO WARNING..PEDDLE WENT TO THE FLOOR, I WAS ABLE TO STOP BY SHIFTING THE TRANS DOWN TO 2ND THEN 1ST. MECHANIC SAID KNEW EXACTLY WHAT THE PROBLEM WAS WHEN I EXPLAINED WHAT HAPPENED AFTER I STOPPED, PUMPED THE BRAKES AND BRAKE FLUID FLOWED FROM UNDER THE TRUCK GENERALLY UNDER WHERE THE DRIVER SITS. MECHANIC EXPLAINED THAT THE BRAKE LINE BROKE AND IS VERY COMMON, AND THAT IT JUST STARTED SHOWING UP A FEW YEARS AGO WHEN THESE "C" BODY TRUCKS AGED. I SPOKE TO ANOTHER MECHANIC AT A CHEVY DEALERSHIP NEAR MY HOME AND HE SAID THE SAME THING THAT IT'S VERY COMMON AND THAT GM NOW SELLS A KIT FOR A COMPETE BRAKE-LINE SYSTEM REPLACEMENT BECAUSE IT HAS BECOME SO COMMON. A FEW DAYS BEFORE I HAD BEEN DRIVING AT HIGH SPEEDS THROUGH THE MOUNTAINS ON I-81 WITH A CARLOAD FULL OF PEOPLE, HAD THIS HAPPENED AT THAT TIME IT COULD HAVE BEEN CATASTROPHIC. REVIEWING CONSUMER COMPLAINTS ON YOUR SITE I SEE THIS IS A REOCCURRING COMPLIANT AND I CAN'T BELIEVE THERE HAS NOT BEEN A RECALL ON THIS, AS THERE IS NO MORE IMPORTANT SAFETY SYSTEM ON A AUTOMOBILE THAN BRAKES....CHEVY HAD A RECALL ON MY 98' BUICK FOR A VALVE COVER GASKET LEAKING THAT DIDN'T COME CLOSE TO THIS POTENTIAL DANGER.

Incident Aug 17, 2016

TL* THE CONTACT OWNS A 2001 CHEVROLET SUBURBAN. WHILE DRIVING APPROXIMATELY 5 MPH, THE ANTI-LOCK BRAKES ACTIVATED WITHOUT WARNING, WHICH MADE THE VEHICLE HARD TO STOP. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 05V379000 (SERVICE BRAKES, HYDRAULIC). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS NOT PROVIDED. THE APPROXIMATE FAILURE MILEAGE WAS 190,000.

Incident Jul 1, 2016

TL* THE CONTACT OWNS A 2001 CHEVROLET SUBURBAN 1500 EQUIPPED WITH FIRESTONE WILDERNESS LETIRES, TIRES SIZE: 265/70R16. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY AT 55 MPH, THE VEHICLE BEGAN TO VIOLENTLY SHAKE AND VIBRATE BEFORE A LOUD BOOMING SOUND WAS HEARD. AFTER STOPPING THE VEHICLE, IT WAS DISCOVERED THAT THE REAR PASSENGER SIDE TIRE HAD EXPERIENCED A BLOWOUT. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE FAILURE MILEAGE WAS 150,000 AND THE TIRE FAILURE MILEAGE WAS 10,000. THE VIN WAS NOT AVAILABLE.

Incident Jul 24, 2016

THREE TIMES I HAD COMPLETE BRAKE FAILURE. DRIVING TWO TIMES AND HAD JUST ARRIVED AT MY DESTINATION THIRD TIME, WHICH WAS TODAY -- SURPRISE!!!! HAD TO SLOWLY DRIVE HOME, YET AGAIN, WITH NO BRAKES!!!!!

Incident Mar 31, 2016

BRAKE LINES FAILED TWICE DUE TO RUST AND CORROSION BECAUSE CHEVY USED A INFERIOR STEEL PRODUCT ON ALL TRUCKS FROM 1998 TO 2005. THE DEALER REPAIRED MY 2002 AVALANCHE FOR $600.00 TO REPLACE ALL THE BRAKE LINES. HOWEVER THEY WILL NOT REPAIR MY 2001 SUBURBAN WHICH HAS THE SAME PROBLEMS. GM NEEDS TO RE-CALL ANY VEHICLE OR AT LEAST MAKE A REPAIR KIT AND INSTALLATION AT A REDUCED RATE BECAUSE THIS VEHICLE IS UNSAFE TO DRIVE. THIS IS NOT DUE TO OWNER ERROR OF WASHING THE FRAME DURING WINTER OR WINTER MAINTENANCE. THERE IS NEW LINES THAT ARE COATED TO RESIST COROSION AND WERE USED TO REPAIR MY AVALANCHE. MY 2001 SUBURBAN BRAKE LINES FAILED IN MOTION WHILE IN TRAFFIC APPLYING THE BRAKE PETAL TO STOP.

Incident Jan 29, 2016

WHEN VEHICLE IS IDLING WHILE NOT MOVING EXTREME AMOUNTS OF EXHAUST FUMES ARE ENTERING THE CABIN AREA THROUGH THE VENTILATION SYSTEM. THIS IS DUE TO DEFECTIVE EXHAUST MANIFOLD BOLTS WHICH ARE BREAKING ALLOWING THE EXHAUST MANIFOLD TO OPEN AND ALLOW FUMES TO ENTER THE ENGINE COMPARTMENT WHICH RESULTS IN THE EXHAUST FUMES ENTERING THE PASSENGER CABIN AREA THROUGH THE VENTILATION SYSTEM. THIS IS A HEALTH ISSUE FOR PASSENGERS INSIDE THE CABIN BREATHING THE TOXIC EXHAUST FUMES. THIS SHOULD BE A SAFETY RECALL ON GM TO FIX THE PROBLEM DUE TO POOR ENGINEERING DESIGN AND FOR USING POOR QUALITY COMPONENTS WHICH FAIL FOR NO REASON. ALSO THIS IS AN EXTREMELY DANGEROUS SITUATION FOR PASSENGERS INSIDE THE VEHICLE, WHICH HAVE TO BREATH THE DANGEROUS EXHAUST FUMES. GM SHOULD BE MADE TO REPAIR ALL VEHICLES AFFECTED BY THIS PROBLEM WHICH WERE DESIGNED AND ENGINEERED WITH INFERIOR PARTS WHICH ARE CAUSING THIS DANGEROUS SITUATION FOR MILLIONS OF PEOPLE ACROSS THIS COUNTRY.

Incident Dec 28, 2015

EXHAUST BOLTS BROKEN AND CAUSING A LEAK MAKING THE VEHICLE UNABLE TO PASS EMISSIONS ALSO. STEERING STABILIZERS BROKEN.

Incident Nov 25, 2015

PREMATURE REAR SECTION OF BRAKE LINE RUST OUT 2001 CHEVY SUBURBAN.

Incident Dec 2, 2015

TL* THE CONTACT OWNS A 2001 CHEVROLET SUBURBAN. THE CONTACT STATED THAT THE ENGINE STALLED WITHOUT WARNING. THE ENGINE WARNING LIGHT ILLUMINATED PRIOR TO THE FAILURE. THE CONTACT WAS ABLE TO DRIVE THE VEHICLE TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING, WHICH LOCATED A FAILURE CODE AT THE CRANKSHAFT POSITION SENSOR. THE MANUFACTURER STATED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 07V521000 (ENGINE AND ENGINE COOLING). THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 101,000.

Incident Oct 20, 2015

WHILE TRAVELLING ON THE HIGHWAY AT APPROXIMATELY 50 MPH, VEHICLE STRUCK AN ADULT DEER - FRONT END SQUARE HIT OFFSET TO PASSENGER SIDE. FRONT PASSENGER LIGHTS, GRILL, RADIATOR SUPPORTS, BUMPER, SIDE FENDER, AND HOOD ALL SEVERELY DAMAGED. AIRBAGS DID NOT DEPLOY. DAMAGE TO THE VEHICLE ENDED UP AT $4,386.

Incident Sep 5, 2015

COMPLETE BREAK FAILURE. BREAK PEDAL WENT TO FLOOR AND ALMOST KILLED MY FAMILY. NOTICED LEAKING BREAK FLUID COMING OUT OF RUSTED BREAK LINE UNDER VEHICLE.

Incident Aug 6, 2015

I WAS APPLYING THE BRAKES ON MY 2001 CHEVROLET SUBURBAN, MODEL 2500, AS I TURNED INTO MY DRIVEWAY. THE BRAKES FAILED TO ENGAGE. THIS RESULTED IN THE VEHICLE RUNNING INTO THE FRONT OF THE GARAGE. THE BRAKES NOW APPEAR TO BE WORKING FINE. THE BRAKES HAVE FAILED ON PREVIOUS OCCASIONS, BUT NEVER TO THE POINT OF ALLOWING THE VEHICLE TO HIT ANYTHING. ACCORDING TO THE GM DEALER, THEY CAN'T FIX THE PROBLEM WITHOUT A FAILURE CODE IN THE COMPUTER. AN INDEPENDENT SERVICE GARAGE SAID THE SAME.

Incident Aug 20, 2015

TL* THE CONTACT OWNS A 2001 CHEVROLET SUBURBAN EQUIPPED WITH HERCULES ALL TRAC A/T TIRES, SIZE: 265/70R16 (NA). WHILE DRIVING APPROXIMATELY 70 MPH, THE REAR DRIVER SIDE TIRE BLEW OUT. THE TIRE WAS REPLACED WITH A SPARE TIRE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT TIRE TECHNICIAN WHO REPLACED THE TIRE. THE VIN WAS UNAVAILABLE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE TIRE FAILURE MILEAGE WAS 5,000 AND THE APPROXIMATE VEHICLE FAILURE MILEAGE WAS 205,000.

Incident Aug 15, 2014

DRIVING ON HIGHWAY AT 75MPH BATTERY, SECURITY AND LOW FUEL POPPED ON INTO MESSAGE CENTER. GAS GAUGE, VOLT METER, AND TEMPERATURE GAUGE QUIT WORKING, HAD TO PULL OFF THE SIDE OF THE HIGHWAY BECAUSE OF IT ALMOST GOT HIT. I KNOW NUMEROUS PEOPLE WITH SAME ISSUE.

Incident Jun 19, 2015

THE ABS ACTIVATE WITHOUT REASON WHEN I SLOW TO A STOP. THE PROBLEM BEGAN INFREQUENTLY AND I ATTRIBUTED IT TO POSSIBLE SLIPPERY SURFACE CONDITIONS. OVER THE PAST YEAR THE PROBLEM HAS GOTTEN MUCH WORSE AND HAPPENS FREQUENTLY NOW. RESEARCH INDICATES THAT THIS IS A KNOWN PROBLEM AND THE SUBJECT OF A RECALL FOR "SNOW" STATES - LIKE DC AND MARYLAND WHICH ARE JUST ACROSS THE POTOMAC RIVER FROM WHERE I LIVE AND USE MY SUBURBAN. THIS IS THE SECOND SERIOUS BRAKE ISSUE WITH THIS VEHICLE. ALL THREE BRAKE LINES HAVE BEEN REPLACED OVER AN APPROXIMATE 18 MONTH PERIOD TWO YEARS AGO AS A RESULT OF SUDDEN BRAKE FAILURE CAUSED BY CORRODED BRAKE LINES. THIS IS ALSO A WELL KNOWN PROBLEM (THOUGH NOT ONE I WAS AWARE OF WHEN MY BRAKES FAILED AND WERE REPAIRED). MY RESEARCH INDICATES THAT MANY OWNERS HAVE SUFFERED FROM THESE PROBLEMS. THE NHTSA SHOULD FURTHER INVESTIGATE THESE PROBLEMS AND EXPAND/INITIATE RECALLS FOR THESE PROBLEMS.

Incident Jul 1, 2014

MY SON WAS DRIVING AND REAR ENDED A MAN GOING APPROXIMATELY 50 MPH. THE FRONT END SUSTAINED A GREAT DEAL OF DAMAGE, INCLUDING, BUT NOT LIMITED TO, THE ENGINE BEING PUSHED BACK SEVERAL INCHES. THE AIR BAGS DID NOT DEPLOY. MY SON SUSTAINED MINOR WHIPLASH TYPE INJURIES TO HIS NECK AND BACK.

Incident Jun 15, 2015

TL* THE CONTACT OWNED A 2001 CHEVROLET SUBURBAN. WHILE DRIVING AT 55 MPH UPHILL, THE CONTACT DEPRESSED THE BRAKE PEDAL AND THE VEHICLE HYDROPLANED. AS A RESULT, THE CONTACT CRASHED INTO THE REAR OF A PICK-UP TRUCK. THE AIR BAGS FAILED TO DEPLOY. A POLICE REPORT WAS FILED. THERE WAS ONE INJURY THAT REQUIRED MEDICAL ATTENTION. THE VEHICLE WAS DESTROYED AND TOWED TO AN INDEPENDENT MECHANIC. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 270,000.

Incident Jun 18, 2015

TL* THE CONTACT OWNS A 2001 CHEVROLET SUBURBAN 1500. WHILE DRIVING AT 65 MPH, THE ENGINE STALLED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 180,000. UPDATED 7/28/15*CN UPDATED 10/18/2017*CN

Incident May 31, 2015

I WAS DRIVING ON THE NJ TURNPIKE NEAR EXIT 10, TRAVELLING TO BOSTON. AHEAD, ALL TRAFFIC WAS STOPPED IN BOTH THE INNER AND OUTER SET OF LANES. AS I DECELERATED, I HEARD A NOISE AND THE TRUCK JERKED SLIGHTLY. WHEN I TRIED TO PULL OFF THE ROAD INTO THE SERVICE LANE, I HAD NO TRANSMISSION AND HAD TO DRIFT TO THE SHOULDER. I WAS TOLD THERE WAS A CATASTROPHIC FAILURE OF THE TRANSMISSION AND IT HAD TO BE COMPLETELY REBUILT (UNDER WARRANTY). WHEN THE VEHICLE HAD AROUND 70,000 MILES (ABOUT 2 YEARS AGO, 2013), THE TRANSMISSION FAILED AGAIN AND HAD TO BE COMPLETELY REBUILT AGAIN. PATHETIC. THE VEHICLE CURRENTLY HAS 83,000 MI ON IT.

Incident May 6, 2004

DRIVING AT 65 MPH DOWN THE INTERSTATE, SUDDENLY THE SUNROOF GLASS SEPARATED FROM THE FRAME AND FLEW AWAY INTO THE ROAD BEHIND US. THE INSIDE SUN SHADE WAS ALSO SUCKED OUT. THE SUNROOF WAS CLOSED AT THE TIME. THE FRAME AND MOTOR ARE INTACT AND STILL OPERATE NORMALLY. SUNROOF WAS MADE BY VERMEULEN-HOLLANDIA, MODEL: TVS S/N 461569. THERE IS A RECALL ON 2002-UP MODELS FROM THEM BUT NOT FOR THIS SERIAL NUMBER. COMPANY NAME IS NOW WEBASTO. *TR

Incident Apr 26, 2015

TL* THE CONTACT OWNS A 2001 CHEVROLET SUBURBAN 1500. THE CONTACT STATED THAT THE VEHICLE FAILED TO START. AFTER INSPECTING THE VEHICLE, THE CONTACT NOTICED THAT THE FUEL PUMP WAS DISABLED AND THE ODOR OF FUEL WAS PRESENT. ALSO, THE CONTACT INDICATED THAT THE FUEL GAUGE DISPLAYED INACCURATE FUEL LEVELS WHILE OPERATING THE VEHICLE AND THE SERVICE ENGINE SENSOR LIGHT HAD ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND THE CONTACT WAS INFORMED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 05V155000 (FUEL SYSTEM, GASOLINE). THE CONTACT STATED THAT THE VEHICLE EXPERIENCED THE SAME FAILURE LISTED IN THE RECALL. THE FAILURE MILEAGE WAS 260,000.

Incident Mar 30, 2015

I WAS TRAVELING AROUND 40MPH ON A LOCAL ROAD ON MY WAY FROM DROPPING THE KIDS OFF AT SCHOOL. I TRIED TO SLOW DOWN TO TURN ONTO MY STREET, AND THE SUBURBAN BRAKES DID NOT RESPOND AT ALL. THANKFULLY, THERE WAS NOBODY AHEAD OF ME, AND I SLOWED THE TRUCK GRADUALLY. I THEN IDLED BACK HOME, WITHOUT ANY FUNCTIONALITY IN MY BRAKES. UPON INSPECTION, WE DISCOVERED THE BRAKE LINES HAD RUPTURED. ALL MAINTENANCE IS AND HAD BEEN UP TO DATE. *TR

Incident Feb 4, 2015

TL*THE CONTACT OWNS A 2001 CHEVROLET SUBURBAN. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE ENGINE STALLED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.

Incident Apr 1, 2014

WENT TO START MY 2001 CHEVY SUBURBAN AND IT WOULDN'T START. I LISTENED FOR THE FUEL PUMP TO ENGAGE AND IT WASN'T WORKING. I CHECKED THE RELAY AND NOTICED IT WAS MELTED ON ONE CORNER. I HAVE RESEARCHED THIS ONLINE AND FOUND SEVERAL COMPLAINTS ABOUT THE SAME PROBLEM. ALSO NOTICED THAT GM HAS DONE NOTHING TO FIX THIS ISSUE. I HAVE BEEN A GM FAN ALL MY LIFE AND WOULD LIKE TO CONTINUE BEING ONE. PLEASE RECALL THIS ON GOING PROBLEM GM. *TR

Incident Jan 29, 2015

I PULLED INTO A PARKING LOT AND PROCEEDED TO PARK MY SUBURBAN. I HIT THE BRAKE PEDAL AND THE BRAKES DID NOT WORK. THEY PULSATE AND GAVE OUT COMPLETELY. NO SERVICE LIGHTS OR WARNING LIGHT CAME ON PREVIOUS TO THE INCIDENT. WHEN THE BRAKES DIDN'T WORK I TRIED TO PUMP THEM TO GET THEM TO WORK BUT NOTHING WORKED AND MY SUBURBAN SMASHED INTO A BUSH AND OVER THE CURB. I JUST HAD MY BRAKE LINES REPLACES WHICH WAS QUOTED $1700 AT MY LOCAL CHEVROLET DEALERSHIP. I AM NO LOOKING INTO THE ISSUES WITH THE ABS SYSTEM. *TR

Incident Jan 26, 2014

CHEVROLET HAS CONTINUED TO IGNORE THE ABS BRAKE ISSUE WITHIN THE BRAKE CONTROL MODULE. THIS IS SEPARATE FROM THEIR WHEEL SENSOR ISSUE.THE BRAKE CONTROL MODULE.HAS A CIRCUIT BOARD ISSUE WHICH DEACTIVATES THE ABS SYSTEM AND SHOWS A BRAKE AND ABS LIGHT ON DASH.IN SNOW TODAY MY ABS FAILED AND I SLID THROUGH AN INTERSECTION NARROWLY MISSING A SCHOOL BUS A F$%^ING SCHOOL BUS.THERE IS SO MUCH INFO ON THIS ISSUE ON THE INTERNET BUT CHEVROLET SEEM TO BE IGNORING IT.THE PROBLEM IS CENTERED AROUND A CIRCUIT BOARD IN THE BRAKE CONTROL MODULE.

Incident Jan 6, 2015

ON JANUARY 29, 2014, MY HUSBAND WAS DRIVING MY SUBURBAN TRAVELING ON A SNOW AND ICY ROAD WHEN THE SUBURBAN BEGIN TO SPIN AND WENT DOWN AN EMBANKMENT. HE WAS TRAPPED IN THE VEHICLE BETWEEN THE STEERING WHEEL AND WINDSHIELD. HE WAS WEARING THE SHOULDER AND LAP BELT.THE AIR BAGS DID NOT DEPLOY. TWO OTHER PASSENGERS IN THE VEHICLE HAD ONLY MINOR INJURIES. THE TENNESSEE TRAFFIC REPORT I RECEIVED STATED: AIRBAG AVAILABLE-NO DEPLOYMENT. *TR

Incident Jan 29, 2014

TL* THE CONTACT OWNS A 2001 CHEVROLET SUBURBAN 1500. THE CONTACT STATED THAT THE VEHICLE WAS SHIFTED INTO DRIVE AND THE VEHICLE FAILED TO MOVE FORWARD. THE CONTACT ALSO STATED THAT THE BRAKE WARNING LIGHT ILLUMINATED. ON ANOTHER OCCASION WHILE DRIVING AT APPROXIMATELY 5 MPH, THE ENGINE STALLED WITHOUT WARNING. THE FAILURE RECURRED MULTIPLE TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO DIAGNOSED THAT THE FUEL PUMP NEEDED TO BE REPLACED. THE MECHANIC ALSO STATED THAT THE ANTI LOCK BRAKE SYSTEM FAILED AND UNKNOWN PARTS NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED FOR THE ANTI LOCK BRAKE SYSTEM FAILURE BUT THE FUEL PUMP WAS NOT REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND INFORMED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBERS: 05V379000 (SERVICE BRAKES, HYDRAULIC) AND 05V155000 (FUEL SYSTEM, GASOLINE). THE APPROXIMATE FAILURE MILEAGE WAS 100,000.

Incident Jan 1, 2014

WHILE DRIVING IN TRAFFIC LOSS OF BRAKING DUE TO RUPTURED BRAKE LINE. UPON INSPECTION ALL LINE HAD SEVERE CORROSION RESULTING IN REPLACEMENT OF ALL BRAKE LINES. *TR

Incident Dec 6, 2013

BRAKE LINE RUPTURED CAUSING LOSS OF BRAKING ABILITY RESULTING IN CAR PASSING THROUGH RED LIGHT. *TR

Incident Nov 3, 2014

BRAKE LINES SEVERELY CORRODED AND BLEW OUT. SEVERE CORROSION UNDER TRUCK TOO. *TR

Incident Nov 4, 2014

BRAKES FAILED WHILE DRIVING. REPAIR WAS BRAKE LINES RUSTED. COST TO REPLACE BRAKE SYSTEM WAS $2500. *TR

Incident May 1, 2012

LOST TOTAL BRAKES. SERVICE SHOP NOTED SEVERE BRAKE LINE RUSTING. REPAIRED RUPTURED BRAKE LINE. TRUCK WILL BE UNDERGOING TOTAL BRAKE LINE REPLACEMENT DUE TO RUSTING. *TR

Incident Aug 29, 2013

DRIVING APPROX 50 MPH ON 4 LANE HIGHWAY. WHEN SLOWING FOR RED LIGHT AHEAD, NOTICED BRAKE PEDAL GOING CLOSER TO FLOOR THAN NORMAL. VEHICLE WAS NOT SLOWING AS NORMAL, AND BRAKE PEDAL WAS STAYING CLOSE TO THE FLOOR. GOT STOPPED AND PULLED TO SIDE OF ROAD. CHECK OF MASTER CYLINDER REVEALED BRAKE FLUID LEVEL TO BE APPROX. HALF FULL. UPON CHECKING UNDER VEHICLE, I SAW BRAKE FLUID POURING OUT FROM THE GAS TANK SHIELD. *TR

Incident Aug 23, 2014