2004 Chevrolet Suburban

THE TRUCK FAILS TO RESTART AFTER DRIVING IT AN AT FIRST IT WOULD RESTART AFTER 15 - 20 MINUTES AFTER IT SITS AN NOW IT DOES NOT START AT ALL SO FAR I KNOW IT IS HAPPENING TO MORE THAN 20 VEHICLES INCLUDING THE STATE PATROL 2016 SUBURBANS AND SEVERAL OF THE PICKUPS

Incident Dec 10, 2016

TAKATA RECALL. THE GAUGE CLUSTER STOPPED WORKING. NOW THE IGNITION AND AC WILL NOT WORK. OIL PRESSURE SENSOR READING WRONG. TOOK IT TO GET CODE READ AND 35 CODES CAME UP. HAD TO PUT ON A TOGGLE SWITCH JUST TO START IT. CANT SEE SPEED AND THAT MAKES IT VERY DANGEROUS TO DRIVE AT THIS POINT. THINK ALL OF THIS IS DUE TO WATER LEAK ON DRIVERS SIDE. STEERING CONTROLS STOPPED WORKING TODAY. THIS REALLY NEED TO BE A SAFETY CONCERN TO THE MANUFACTURER AS IT COULD REALLY GET SOMEONE HURT OR KILLED.

Incident Nov 30, 2018

RUSTED BREAKE LINES, PARKED IN DRIVEWAY COULD NOT USE BRAKES AFTER STARTING THE CAR

Incident Jul 31, 2018

CRACKED DASH, NEVER REMOVED, GARAGE KEPT. CRACKED RUNS THROUGH DASH FROM FRONT WINDOW TOWARDS RADIO CLUSTER. DASH HAS SHARP PIECES THAT IN ACCIDENT CAN EASILY BE BROKEN OFF.

Incident Jan 1, 2012

THIS PROBLEM CONCERNS A 2004 CHEVROLET SUBURBAN. THE SEAT HEATER SWITCH, LOCATED ABOVE THE DRIVER'S DOOR ARMREST, TURNS ITSELF ON WHEN THE CAR IS OPERATING. THE HEATED SEAT BECOMES EXTRAORDINARILY HOT RAPIDLY AND IT IS DIFFICULT TO TURN OFF - EVERY BUMP AND JAR IN THE ROAD TURNS THE LIGHT AND THE SEAT BACK ON. THE LIGHT'S LOCATION WHICH INDICATES THE OPERATION OF THE HEATED SEATS IS DIFFICULT TO SEE AS WELL - ESPECIALLY WHEN THE SUN IS STRONG & I'M WEARING SUNGLASSES. LOOKING DOWN AND AWAY FROM THE ROAD AND TRAFFIC IS FAIRLY DANGEROUS. THIS DISTRACTION COULD EASILY EVOLVE INTO AN ACCIDENT AS THE DRIVER IS CONSTANTLY TRYING TO TURN THE HEATED SEAT OFF. I HAVE HAD THIS ITEM "REPAIRED" ONCE, YET THE PROBLEM CONTINUES. THE MOST MEMORABLE MOMENT WAS TRYING TO DRIVE IN A TORRENTIAL RAINSTORM ON THE INTERSTATE. I PULLED OVER FOR SAFETY BEFORE I TRIED TO TURN OFF THE LIGHT. THE MINUTE I PULLED BACK ONTO THE INTERSTATE, THE HEATED SEAT TURNED ITSELF BACK ON AND STAYED ON FOR THE NEXT 250 MILES. I KNOW I AM NOT THE ONLY PERSON WITH A 2004 SUBURBAN THAT SUFFERS FROM THIS PROBLEM. WE HAVE TAKEN THE FUSE OUT OF THE CAR THAT CONTROLS THE HEATED SEATS, BUT THAT ALSO AFFECTS THE ABILITY TO READJUST THE SEAT POSITION FOR THE INDIVIDUAL DRIVERS. THE HEATED SEAT DISTRACTION COMBINED WITH THE LOCATION OF THE SWITCH ARE DEFINITELY A SAFETY ISSUE AND SHOULD BE REPAIRED.

Incident Jun 15, 2008

THE BRAKE FLUID LINES RUSTED AT THE AREA UNDER THE DRIVER SIDE WHEEL, CAUSING THE FLUID TO LEAK UNEXPECTEDLY, THUS RENDERING NO BRAKES. THE LEAK HAPPENED ON MY VEHICLE AND ANOTHER IN THIS SAME AREA. THE MECHANIC SAID THERE COULD BE IS A PROBLEM IN THE MANUFACTURING OF THE LINES DUE TO THE CONSTRUCTION AND BECAUSE ITS TOO CLOSE TO THE WHEEL SALT AND ROAD CONDITIONS CAUSES THIS AREA TO RUST MORE EASILY. HE'S HAD A NUMBER OF CHEVY SUB. WITH THIS SAME PROBLEM IN FOR REPAIR/REPLACEMENT.

Incident Oct 15, 2017

VEHICLE GAS GAUGE AND ODOMETER GAUGES CLUSTERS ARE NOT WORKING THIS PUTS US IN DANGER I DID NOT KNOW HOW MUCH GAS I NEED AND HOW FAST I WAS GOING THIS SHOULD BE FIXED BY THE MANUFACTURER BECAUSE IT WAS A CLUSTER DEFECT

Incident Jul 5, 2016

BRAKE MODULATING SYSTEM SPONTANEOUSLY CAUGHT ON FIRE WHILE PARKED IN MY DRIVEWAY. ONCE THE FIRE WAS PUT OUT, THE CAR WOULD NO LONGER START.

Incident Apr 25, 2017

THE EXHAUST MANIFOLD BOLTS HAVE SNAPPED OFF, 4 OF THEM TO BE EXACT. EXHAUST FUMES CAN NOW LEAK INTO TO THE CAB AND POISON OCCUPANTS.

Incident Mar 18, 2017

INSTRUMENT CLUSTER SHORTS OUT AND GEAR INDICATOR GOES BLANK. NO MESSAGE CENTER INFORMATION WARNINGS ARE DISPLAYED. PART IS DEFECTIVE AND CAR MAKERS SHOULD REPLACE IT. NOT KNOWING WHAT GEAR VEHICLE IS IN CAN LEAD TO DEATH IF VEHICLE LEFT IN NEUTRAL AND ROLLS AWAY. GM NEEDS TO FIX THIS EXPENSIVE PROBLEM. ALSO 4L60E TRANSMISSION ON THESE VEHICLES FAILS AND STARTS SLIPPING BECAUSE OF DEFECTIVE SUN SHELL AND REAL PISTON SEAL. GM SHOULD RECALL ALL THESE BAD TRANSMISSIONS. WARRANTY SHOULD HAVE BEEN FOR LIFE. WHY SHOULD SUCH AN EXPENSIVE PART TO REPAIR FAIL UNDER NORMAL USE? RECALL ! BOTH THESE PARTS FAIL WHEN DRIVING. ALL WARNING OF VEHICLE CONDITIONS ARE SENT TO FAILED CLUSTER. VEHICLE WAS MADE IN MEXICO FOR RE-IMPORTATION AND SALE IN USA AND MAYBE PARTS SUPPLIERS IN MEXICO PROVIDED DEFECTIVE PARTS. MANY PEOPLE HAVE SUFFERED FINANCIAL LOSS TRYING TO FIX THESE PROBLEMS, LASTLY, THE EMISSION SOLENOID NEAR THE TANK ALSO FAILS. VEHICLE MAY NOT PASS EMISSION. *TR

Incident Jan 8, 2016

WHILE AVOIDING ANOTHER VEHICLE I APPLIED MY BRAKES SUDDENLY. THE BAKE LIKE CONNECTING THE ABS UNIT AND THE REAR BRAKES FAILED DUE TO CORROSION/RUST THAT WAS NOT OBSERVABLE DUE TO THE LINE BEING RAN BETWEEN THE VEHICLES FRAME AND BODY AND GAS TANK. ALTHOUGH THIS LOCATION MIGHT HAVE MADE FOR EASY MANUFACTURING IT HAS LED TO THE LINE BEING IN A LOCATION THAT CANNOT BE VISUALLY INSPECTED TO PREVENT DANGEROUS CONDITIONS FROM BUILDING UP FROM LACK OF AWARENESS. .

Incident Nov 16, 2016

TOTAL BRAKE FAILURE (VEHICLE HAS 95,387) MILES) AT 40 MPH IN MOTION. STABIL-TRAC LIGHT INDICATED AT THE TIME OF FAILURE, SERVICE BRAKE INDICATOR ON DISPLAY INFORMATION CONSOLE. . DEPLOYED 4WD LOW, DROPPED TO LOWER GEAR AND HIT EMERGENCY BRAKE TO STOP THE VEHICLE ON SHOULDER OF ROAD. GOT OUT OF VEHICLE SAW BRAKE FLUID ALL OVER THE SKIDS AND FRAME. CAUSE: TOWED TO LOCAL SHOP INDICATED THAT BRAKE LINES ON DRIVER SIDE AND LINES GOING TO FRONT WHEEL WERE COMPLETELY RUSTY AND "LIKE PAPER". THIS WAS UNSETTLING I DON'T LIVE NEAR SALTWATER BUT DRIVE THE VEHICLE A LOT IN WINTER. HAD I BEEN IN A DENSELY POPULATED AREA, THERE CERTAINLY WOULD HAVE BEEN LOSS OF LIFE. THIS VEHICLE WEIGHS OVER 6000 LBS AND NO BRAKES IS LIKE TO TRYING TO STOP A TRAIN. PLEASE INVESTIGATE SIMILAR FAILURES AS THIS FAILURE IN SIMILAR VEHICLES/ANY VEHICLE COULD CAUSE LOSS OF LIFE.

Incident Oct 6, 2016

STEEL BRAKE LINES: DIRECTLY UNDER DRIVERS FEET BENEATH VEHICLE IS CLUSTER OF FOUR BRAKE LINES HELD IN PLACE BY A PLASTIC BRACKET.THESE BRAKE LINES ARE HIDDEN BY A LARGE CORRUGATED BLACK WIRING HARNESS. ALL FOUR LINES ARE EXTREMELY CORRODED AT BRACKET AND AT LEAST ONE OF THEM FAILED COMPLETELY AND INSTANTANEOUSLY. UNLIKE GM REPORTS THAT IT'S A DUAL BRAKE SYSTEM AND VEHICLE WILL RETAIN BRAKING CAPABILITIES IN OUR CASE THIS IS FALSE . WORD NEEDS TO GO OUT ABOUT THESE VEHICLES BUT PREFERABLY A RECALL. MY 15 YEAR OLD NEWLY ISSUED PERMIT HOLDER WAS AT THE WHEEL AND WE WERE ONE LEFT TURN FROM DESCENDING A 200 FOOT TALL 6% GRADE HILL WITH A BUSY INTERSECTION AND STOP LIGHT AT THE BOTTOM. ALSO LIVING IN MINNESOTA KNOWING CLASSIC CAR OWNERS WITH ORIGINAL STEEL BRAKE LINES WITH NO ISSUES I'M LED TO BELIEVE DESIGN IS A CONTRIBUTING FACTOR IN THESE BRAKE FAILURE ISSUES. THANK YOU FOR YOUR TIME. *TR

Incident Sep 17, 2016

2004 CHEVY SUBURBAN - SUDDEN & COMPLETE LOSS OF BRAKE PRESSURE AT HIGHWAY SPEED. VEHICLE BRAKES WERE INSPECTED IN JULY THROUGH THE VA STATE INSPECTION PROGRAM - NO ISSUES FOUND - TODAY ON 8/30/16 WHILE EXITING A FREEWAY RAMP AT 60MPH TRAFFIC CAME TO SUDDEN STOP. WHEN THE SERVICE BRAKE WAS APPLIED IN WHAT WOULD BE CONSIDERED A STAB/EMERGENCY BRAKING MANEUVER THERE WAS A COMPLETE AND SUDDEN LOSS OF BRAKE PRESSURE - PEDAL WENT TO FLOOR WITHOUT WARNING, BRAKE WOULD NOT PUMP UP ADEQUATE ENOUGH TO SLOW VEHICLE. I HAD TO USE A COMBINATION OF PARKING BRAKE APPLICATION AND UTILIZING THE SOFT SHOULDER AND DITCH TO STOP THE VEHICLE. THE BRAKE WARNING INDICATOR (RED) AND SERVICE INDICATOR DID NOT ILLUMINATE UNTIL AFTER THE THIRD OR FOURTH APPLICATION OF THE BRAKE PEDAL. SUBURBAN WAS TOWED. CAUSATIVE FACTORS = RUPTURED BRAKE LINE.

Incident Aug 30, 2016

BRAKE LINE (HARD LINE) CATASTROPHIC FAILURE. UNABLE TO STOP ON COMING TO HIGHWAY INTERSECTION USING HYDRAULIC BRAKES. HAD TO RESORT TO APPLYING PARKING BRAKE TO STOP VEHICLE. ON INSPECTION MAIN BRAKE HYDRAULIC LINE RUPTURED- FLUID SPEWED ON ROADWAY AND APPROXIMATELY 1/2 OF FLUID FROM MASTER CYLINDER. LIMITED RESIDUAL PRESSURE FROM SECONDARY WAS UNABLE TO STOP VEHICLE WITHOUT MECHANICAL ASSIST FROM PARKING BRAKE.

Incident Aug 20, 2016

BRAKE LINES BETWEEN THE AREA OF THE BRAKE FLUID RESERVOIR AND ABS MODULATOR HEAVILY CORRODED. ONE OR MORE LINES FAILED ON 7/10/2016 REQUIRING VEHICLE TOW. VEHICLE WAS OPERATIONAL ASIDE FROM THE FAILURE OF BRAKING SYSTEM. WHEN DEPRESSED, VEHICLE BRAKE PEDDLE HAD LITTLE RESISTANCE AND TRAVELED COMPLETELY TO FLOOR PANEL UNDER NORMAL PRESSURE FROM FOOT. THE INCIDENT/FAILURE OCCURRED DURING NORMAL TRAVEL AND DURING AN ATTEMPTED STOP AT RED LIGHT. BRAKE SYSTEM FAILURE PREVENTED A SAFE STOP AND THE VEHICLE CONTINUED THROUGH THE INTERSECTION RUNNING A RED LIGHT. FORTUNATELY, THE INTERSECTION WAS CLEAR AND NO ACCIDENT OCCURRED. THE VEHICLE WAS PARKED IMMEDIATELY AFTERWARDS AND A TOW VEHICLE CALLED. THE VEHICLE IS CURRENTLY PARKED UNTIL REPAIRS CAN BE APPLIED. TOWING EXPENSE- 125.00 PARTS EXPENSE- 85.00 (REPLACING ALL AFFECTED LINES, FRONT BRAKING SYSTEM.) LABOR- 100.00 APPROX.

Incident Jul 10, 2016

TL* THE CONTACT OWNS A 2004 CHEVROLET SUBURBAN. WHILE THE VEHICLE WAS IN THE PARK POSITION, THE GEAR SHIFTED INTO THE NEUTRAL POSITION UNEXPECTEDLY WITHOUT WARNING. THE FAILURE OCCURRED ONCE. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 148,000.

Incident Apr 20, 2016

FUEL RUNNING OUT TOP OF GAS TANK AFTER FUELING

Incident May 15, 2016

THE GM INSTRUMENT CLUSTER STEPPER MOTORS AND LIGHTS HAVE FAILED. THIS RESULTS IN A SAFETY HAZARD BECAUSE IT IS IMPORTANT TO KNOW THE SPEED OF THE VEHICLE AND THE FUEL LEVEL AS WELL AS OTHER IMPORTANT ENGINE INFORMATION.

Incident Mar 1, 2016

THE GEAR SHIFT INDICATOR LIGHTS IN THE GM INSTRUMENT CLUSTER ARE NO LONGER WORKING. THIS CREATES A SAFETY ISSUE BECAUSE THE DRIVER CAN SHIFT INTO THE INCORRECT GEAR ACCIDENTALLY CAUSING AN ACCIDENT. THERE IS NO OTHER ALTERNATE GEAR SHIFT INDICATOR IN THE VEHICLE.

Incident Mar 1, 2016

DRIVING AS NORMAL ATTEMPT TO STOP AND PEDAL WENT TO THE FLOOR. NO BRAKES. COASTED TO STOP LUCKILY NOT TRAVELING AT HIGH SPEED. INSPECTION REVEALED RUSTED THROUGH BRAKE LINES. AND ALL FLUID GONE FROM MASTER CYLINDER.

Incident Jan 5, 2016

TL* THE CONTACT OWNS A 2004 CHEVROLET SUBURBAN 1500. THE CONTACT STATED THAT THE REAR HATCH WOULD NOT OPEN. THE DEALER STATED THAT THE ACTUATOR NEEDED TO BE REPLACED. THE CONTACT NOTIFIED THE MANUFACTURER. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 200,000. UPDATED 04/20/16*LJ *TR

Incident Dec 27, 2015

TL* THE CONTACT OWNS A 2004 CHEVROLET SUBURBAN. WHILE DRIVING 25 MPH, THE BRAKE PEDAL WAS DEPRESSED AND THE BRAKES SEIZED. THE SERVICE BRAKES WARNING INDICATOR ILLUMINATED AFTER THE BRAKE FAILURE. THE CONTACT STATED THAT THE EMERGENCY BRAKE WAS ENGAGED IN ORDER TO STOP THE VEHICLE. THE CONTACT ALSO STATED THAT BRAKE FLUID WAS LEAKING UNDER THE VEHICLE. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE BRAKE LINES FAILED DUE TO CORROSION AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 114,000.

Incident Nov 13, 2015

BRAKE LINE FAILED WHILE TOWING BOAT ON CITY STREET NORMAL BRAKING LOST 3/4 BRAKING POWER, PEDAL WENT ALMOST TO THE FLOOR, JUST STOPPED IN TIME BEFORE REAR ENDED SOMEONE.

Incident Oct 27, 2015

BRAKES FAILED UNDER HARD STOP (HIGHWAY, IN MOTION). INTERMEDIATE STEEL BRAKE LINE FAILED TO REAR BRAKES IN A MODE OF RUPTURE DUE TO CORROSION. ALL OTHER STEEL LINES WERE CORRODED AND CONTACTED GM. 2 OTHER SILVERADO LINE VEHICLES OWNED ALSO FAILED THIS YEAR DUE TO CORROSION. GM RESPONSE WAS THAT NO RECALL EXISTED. REPLACED ALL STEEL BRAKE LINES IN VEHICLE WITH STAINLESS AFTERMARKET LINES. AFTER MULTIPLE CONTACTS WITH GM CUSTOMER SERVICE, I WAS TOLD TO SAVE MY RECEIPTS FOR REPAIRS. THIS IS AN INCORRECT MATERIAL SPECIFICATION, LATENT DEFECT AND GM NEEDS TO BE HELD ACCOUNTABLE. SAVED BRAKE LINES FROM THIS VEHICLE FOR ANY POTENTIAL USE. 3 VEHICLES THAT I OWN WITH THE SAME REPAIR IN 8 MONTHS. INEXCUSABLE!

Incident Oct 4, 2015

TL* THE CONTACT OWNED A 2004 CHEVROLET SUBURBAN 1500. WHILE DRIVING 15 MPH, THE VEHICLE ACCELERATED INDEPENDENTLY AND THE CONTACT LOST CONTROL OF THE VEHICLE. THE CONTACT STATED THAT THE VEHICLE LEFT THE ROADWAY, RAN INTO A DITCH, WENT AIRBORNE AND FLIPPED ONTO THE PASSENGER SIDE. THE CONTACT STATED THAT THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER TECHNICAL SERVICE BULLETINS: PIT3598 (SEAT) FOR ADJUSTMENT TO THE BRAKE AND ACCELERATOR PEDALS. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC. A POLICE REPORT WAS NOT FILED. THE CONTACT SUSTAINED INJURIES THAT DID NOT REQUIRE MEDICAL ATTENTION. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS DESTROYED. THE APPROXIMATE FAILURE MILEAGE WAS 129,000.

Incident Apr 20, 2015

TL* THE CONTACT OWNS A 2004 CHEVROLET SUBURBAN. WHILE DRIVING AT APPROXIMATELY 55 MPH, THE BRAKES DID NOT ENGAGE WHEN THE BRAKE PEDAL WAS DEPRESSED. THE CONTACT WAS ABLE TO PULL OVER TO THE ROAD SIDE. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT FRONT BRAKE LINES WERE CORRODED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 170,000. THE VIN WAS NOT AVAILABLE.

Incident Oct 1, 2015

BACKING OUT OF A PARKING SPACE WENT TO STOP AND BRAKE PEDAL SUNK TO THE FLOOR ABS AND BRAKE LIGHT CAME ON I PUT THE TRUCK IN PARK OPENED THE HOOD THE MASTER CYLINDER HAD FLUID THEN LOOKED UNDER THE TRUCK AND UNDER THE DRIVERS SIDE DOOR BRAKE FLUID WAS LEAKING FROM 1 OF THE 2 STEEL RUSTED LINES HAD THE TRUCK TOWED TO A REPAIR SHOP THE SHOP SAID THE 2 LINES FROM THE MASTER CYLINDER TO THE ABS BLOCK HAD SEVERE CORROSION AND THE REST OF THE BRAKE LINES AREN'T MUCH BETTER IM SORRY GUYS BUT THIS IS A SERIOUS PROBLEM TO ME I COULD HAVE BEEN KILLED OR KILLED SOMEONE ELSE IM ONE OF THE LUCKY ONES I GUESS SO NOW THE TRUCK IS IN THE SHOP HAVING ALL THE BRAKE LINES CHANGED FOR A COST OF $ 600.00 AND GUESS WHAT WE ALSO OWN A 2003 TAHOE WITH 90000 MILES ON IT I GUESS THEY WILL HAVE TO BE CHANGED ALSO SAME CONDITION ALL BRAKE LINES RUSTED BADLY HOW MANY PEOPLE MUST BE SERIOUSLY INJURED OR KILLED BEFORE SOMETHING IS DONE ABOUT THIS PROBLEM ITS WIDE SPREAD LOOK ON LINE HOW MANY PEOPLE HAVE GONE THROUGH THIS ITS A SHAME MAKE G.M DO THE RIGHT THING HERE

Incident Sep 13, 2015

BRAKE LINES RUSTED THROUGH AND LEAKED FLUID FROM SYSTEM.

Incident Aug 11, 2015

THE BRAKE LINES ON MY 2004 SUBURBAN HAVE NOW FAILED THREE TIMES. THE FIRST TIME ONE OF THE LINES HAD TO BE REPLACED AT A COST OF OVER $1000, THE SECOND TIME A SEPARATE LINE WAS PATCHED, AND NOW THE THIRD TIME THE SAME SECOND LINE THAT WAS PATCHED HAS FAILED AGAIN. ALL OF THE BRAKE LINES ARE INCREDIBLY CORRODED, SO MUCH SO THAT A FRIEND OF MINE WONDERED IF IT HAD BEEN SUBMERGED DURING HURRICANE KATRINA. BUT NOW UPON READING UP ON THE SUBJECT IT APPEARS THAT IS IS ALL GMS OF THAT TIME FRAME THAT LIVE IN SALTIER AIR. WHILE GM APPEARS TO THINK THAT THESE ARE COMPONENTS THAT SHOULD WEAR DOWN OVER TIME, THIS IS ONLY THE SECOND TIME IN THE 30 YEARS THAT I HAVE OWNED CARS TO FIND THIS PROBLEM.

Incident Jun 20, 2012

I WAS DRIVING DOWN A TWO LANE HIGHWAY AT 50 MILES PER HOUR A DOG RAN OUT IN FRONT OF MY SUV, I HIT THE BRAKES HARD AND NOTICED THE PEDAL WENT TO THE GROUND. DROVE THE CAR HOME CAREFULLY. WHEN I GOT IT IN THE GARAGE FOUND RUSTED THROUGH BRAKE LINES GOING TO THE REAR OF THE CAR LEAKING. THERE IS EXCESSIVE RUST ON THE LINES AND AN ELECTRICAL HARNESS THAT GOES TO THE GAS TANK HAS RUBBED A HOLE IN THE LINE.

Incident Aug 14, 2015

TL* THE CONTACT OWNS A 2004 CHEVROLET SUBURBAN. AFTER TURNING THE IGNITION KEY TO START THE ENGINE, BOTH THE DRIVER AND PASSENGER SIDE AIR BAGS ERRONEOUSLY DEPLOYED. DURING THE INCIDENT, THE DRIVER SUSTAINED CHEST AND FACIAL BRUISES AND LACERATIONS. THE FRONT PASSENGER SUSTAINED BRUISES AND LACERATIONS TO BOTH ARMS AND HANDS. MEDICAL ATTENTION WAS NOT RECEIVED. THE CAUSE OF THE FAILURE WAS NOT DIAGNOSED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 160,000.

Incident Jun 14, 2015

TL* THE CONTACT OWNS A 2004 CHEVROLET SUBURBAN. THE CONTACT STATED THAT THE VEHICLE WOULD INTERMITTENTLY BLOW HOT AIR DUE TO A FAILURE WITH THE AIR CONDITIONER BLOWER MOTOR. THE CONTACT STATED THAT THE BLOWER RESISTOR MODULE AND THE WIRING HARNESS WERE REPLACED; HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 174,000. UPDATED 12/03/15*LJ UPDATED 11/17/2017*CN

Incident Sep 25, 2013

THE BRAKE LINE FROM THE FRONT TO REAR RUSTED AND RUPTURED RESULTING IN VIRTUALLY NO BRAKING. UPON FURTHER INSPECTION THE BRAKE LINES ARE ALL BADLY RUSTED AND IN NEED OF REPLACEMENT. VERY UNFORTUNATE GM CHOSE TO USE SUCH AN INFERIOR MATERIAL FOR SUCH AN IMPORTANT COMPONENT. VERY DANGEROUS SITUATION GM SHOULD BE MAKING OWNERS AWARE OF.

Incident Jun 24, 2015

AIRBAG SYSTEM FAILED AND COMPONENTS NEED TO BE REPLACED...UPDATED 08/27/15 *BF

Incident Mar 2, 2015

I WAS DRIVING TO PICK MY SON UP FROM SCHOOL WHEN I LOST BRAKES. WE BARELY AVOIDED AN ACCIDENT AND HAD TO SWERVE OFF THE ROAD TO AVOID THE VEHICLE IN FRONT OF US STOPPING AT THE LIGHT. I HAD JUST REDONE MY FRONT AND REAR BRAKES/ROGERS. AFTER INSPECTING THE BRAKE LINES WE NOTICED MY LINES ARE COMPLETELY RUSTED AND WILL NOT HOLD ANY FLUID. I LIVE IN FLORIDA. NO SNOW, NO SALT ON MY ROADS. IT DISGUSTS ME THAT GM ISN'T TAKING CARE OF THIS KNOWN ISSUE. THIS IS MY 4TH SUBURBAN AND WILL BE MY LAST. I WILL NOW BE LOOKING TOWARD THE FORD, TOYOTA, OR NISSAN SUV. GM SHOULD BE MAKING THIS RIGHT. MAYBE AFTER A FEW MORE DEATHS THEY'LL SEE HOW SERIOUS THIS IS. HOW MANY DEATHS DO THEY NEED ON THEIR HANDS TO SEE IT'S A PROBLEM? ABSOLUTELY DISGUSTS ME! *TR

Incident Apr 28, 2015

WENT TO BACK OUT OF THE DRIVEWAY, BRAKE PEDAL WENT TO THE FLOOR, NO BRAKES HAD TO TAKE EXTREME STEPS TO STOP THE VEHICLE AND ALL I WAS DOING WAS BACKING OUT OF A FLAT DRIVEWAY ONTO THE STREET. TOWED VEHICLE TO AUTO SHOP - BRAKE LINES BEFORE SAFETY VALVE BROKE CAUSING THE ENTIRE BRAKING SYSTEM TO FAIL. PREVIOUSLY I HAD A BRAKE LINE BURST, HOWEVER IT WAS POST THE SAFETY VALVE WHICH ALLOWED ME TO STOP SAFELY. THE LINES BUSTING BEFORE THE SAFETY VALVE IS EXTREMELY DANGEROUS AND WOULD HAVE RESULTED IN SEVERE INJURIES HAD WE BEEN DRIVING DOWN THE ROAD AT NORMAL DRIVING SPEEDS. GM HAS AN ISSUE AND PRIOR TO THIS I WAS NOT HAPPY WITH THEM SAYING IT ISN'T AN ISSUE, NOW THAT IT BROKE IN A PLACE THAT DOES NOT HAVE ANY SAFETY MECHANISM I CONSIDER IT EXTREMELY POOR OF GM TO COVER THEIR FACE AND SAY THERE ISN'T AN ISSUE. *TR

Incident Apr 19, 2015

HEADED OUT ON A QUICK TRIP INTO TOWN. AS I TURNED OFF OF THE STREET I LIVE ON I CAME TO A STOP SIGN AND AS I WENT TO HIT THE BRAKES THEY WENT ALL THE WAY TO THE FLOOR AND I COULD NOT STOP MY VEHICLE IN TIME. I WAS LUCKY BECAUSE I WAS GOING DOWNHILL AT THE TIME BUT AS LUCK WOULD HAVE IT, NO CARS WERE AT THE STOP SIGN AND I WAS ABLE TO GO THROUGH THE STOP SIGN AND TURN LEFT ONTO AN UPHILL ROAD AND LET GRAVITY STOP MY VEHICLE. HAD THIS HAD HAPPENED ONCE I HIT THE BUSY STREET I WAS HEADED TO IT WOULD HAVE KILLED SOMEONE ELSE AS WELL AS MYSELF! I HAVE READ THAT THIS PROBLEM HAS BEEN REPORTED AND NO RECALL FROM CHEVROLET... THAT IS JUST A CRIME, IN MY OPINION! *TR

Incident Apr 3, 2015

SPEED READS 120MPH AND NOT MOVING . *TR

Incident Dec 27, 2014

WAS DRIVING DOWN INTERSTATE LOOKED AT SPEED IT WAS PEGGED OUT WAY PAST 120 I KNOW I WAS NOT GOING THAT FAST I WAS GETTING PASSED THEN WHEN I STOPPED IT ONLY COME DOWN TO ABOUT 110 SAYS U R RUNNING 100 SITTING STILL. *TR

Incident Feb 12, 2015