2004 Chevrolet Trailblazer EXT

MOST OF THE GAUGES ARE VERY ERRATIC WHEN IN MOTION OR STOPPED. TACHOMETER JUMPS AROUND, OIL PRESSURE READS ALL OVER, SPEEDOMETER GOES TO ZERO OR FULL SCALE, AMP METER DROPS BELOW 14 AND LIGHTS DIM WHEN THIS HAPPENS, (HAVE HAD THE ALTERNATOR REPLACED 3 TIMES, THIS IS QUITE A SAFETY CONCERN FOR ME AS I HAVE NO IDEA WHAT TO BELIEVE ON ANY OF THE GAUGES. NO REPAIR SHOP HAS BEEN ABLE TO SOLVE THE PROBLEM.

Incident Jan 2, 2017

TL* THE CONTACT'S SON OWNS A 2004 CHEVROLET TRAILBLAZER. THE CONTACT STATED THAT THE DRIVER'S SIDE WINDOW LOOKED ABNORMAL. WHEN THE DOOR WAS OPENED, THE CONTACT NOTICED THAT THE DRIVER'S SEAT HAD CAUGHT FIRE AND EXTINGUISHED ITSELF OUT. FIRE AND POLICE REPORTS WERE NOT FILED. THERE WERE NO INJURIES. THE VEHICLE WAS NOT TAKEN TO A DEALER OR INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING OR REPAIRS. THE MANUFACTURER INFORMED THE CONTACT THAT THERE WAS NO RECALL TO PROVE THAT THE MALFUNCTION WAS A MANUFACTURER DEFAULT. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS APPROXIMATELY 190,000. *LN PHOTOS ATTACHED. *JB

Incident Oct 1, 2019

WELL I HIT A TREE AN THE AIRBAGS DIDN'T DEPLOYED BUT THE AIRBAG LIGHT IS ON

Incident Sep 29, 2019

1 OWNER VEHICLE - BOUGHT IN 2004 & HAD 8 MILES ON IT. HAS BEEN VERY WELL KEPT & CURRENTLY HAS ONLY 65,000 MILES ON IT AS OF 9/16/19. AS OTHERS, THE ELECTRICAL CLUSTER HAS MALFUNCTIONED. SPEEDOMETER QUIT WORKING OVER A YEAR AGO & NOW THE FUEL GAUGE HAS FAILED. PROBLEM IS WITH THE CLUSTER AS "ESTIMATED MILEAGE" STILL WORKS. HAVE NOTICED THAT OTHER GAUGES ACT ERRATIC AT TIMES. THIS HAS BEEN AN ONGOING ISSUE THAT CHEVY IS WELL AWARE OF YET FAIL TO ACT. TO TB TO DEALER FOR REPAIRS THEY STATED THERE IS NO RECALL. COST OUT OF MY POCKET FOR REPAIR WILL BE OVER $800.00. SPEEDOMETER ORIGINALLY FAILED WHILE DRIVING ON HWY. IT STARTED TO WORK AGAIN BUT FAILED AGAIN WHILE DRIVING ON THE HWY A FEW WEEKS LATER. FUEL GUAGE SIMPLY STOPPED WORKING AFTER STARTING VEHICLE.

Incident Oct 1, 2018

TL* THE CONTACT OWNS A 2004 CHEVROLET TRAILBLAZER. WHILE DRIVING APPROXIMATELY 45 MPH, THE LOW BEAM HEADLIGHTS WENT OUT WITHOUT WARNING. THE FAILURE RECURRED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO WAS UNABLE TO DUPLICATE THE FAILURE; HOWEVER, THEY REPLACED THE FRONT PANEL SWITCH AND CONNECTOR. THE FAILURE RECURRED. THE DEALER AND MANUFACTURER WERE NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 146,577.

Incident Sep 24, 2018

WHEN DRIVING OUR VEHICLE FROM MYRTLE BEACH THIS WEEK WE NOTICED A SMELL ABOUT HALF WAY HOME THAT REEKED OF ROTTEN EGGS. THE SMELL WAS SO BAD THAT I BECAUSE NAUSEOUS AND DEVELOOED A SEVERE HEADACHE. AFTER WE REACHED OUR HOUSE AND SHUT OFF THE VEHICLE THE NEXT DAY I TRIED TO CRANK THE VEHICLE AND IT WOULD NOT CRANK SO AFTER RESEARCHING THE SMELL AND POSSIBLE CAUSES WE BOUGHT A NEW BATTERY FOR THE VEHICLE AND CHANGED THE BATTERY OURSELVES WHICH CAUSED MY HUSBAND TO DEVELOP A SEVERE COUGH AND UPPER RESPITORY PROBLEMS DUE TO THE BOILING THAT WAS OCCURING INSIDE THE BATTERY. HENCE THE SMELL OF ROTTEN EGGS.

Incident Jul 25, 2019

ACCELERATING ON IT'S OWN AND IDLING

Incident Jul 4, 2019

SMELL OF GAS WHEN DRIVING VERY STRONG MUST DRIVE WITH WINDOW OPEN

Incident Jul 22, 2019

TAKATA RECALL/ I WAS IN A ACCIDENT AND MY AIR BAGS NEVER WENT OFF WHY IS THAT I THOUGHT IT WAS A SAFTEY FEATURE?

Incident Jun 27, 2019

TL* THE CONTACT OWNS A 2004 CHEVROLET TRAILBLAZER. THE CONTACT STATED THAT WHILE THE BRAKES WERE BEING SERVICED BY AN INDEPENDENT MECHANIC, THE TECHNICIAN NOTICED THAT THE ENTIRE FRONT END FRAME WAS RUSTED. THE DEALER AND THE MANUFACTURER WERE NOT CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 150,542.

Incident Jun 14, 2019

BRAKE LIGHTS FLICKER OFF AND ON. WHEN THE VEHICLE IS IN MOTION AND BRAKES ARE PRESSED, THE BRAKE LIGHTS DO NOT LIGHT UP. THIS CONTINUES TO HAPPEN WITH A NEW LIGHT BULB PLACED IN.

Incident May 17, 2019

WHEN IN MOTION, THE FUEL GAUGE AND SPEEDOMETER STOPPED WORKING. THE SPEEDOMETER PROBLEM BEGAN WHEN I WAS ON THE HIGHWAY AND 100 MILES AWAY FROM HOME. WHEN THE PROBLEM BEGAN, THE GAUGES WOULD SPORADICALLY MOVE UP AND DOWN. NOW THEY DO NOT MOVE UP.

Incident Oct 20, 2010

I OWN A 2004 CHEVROLET TRAILBLAZER EXT AND JUST LIKE THE THOUSANDS OF OTHERS MINE HAS A DEFECTIVE GAS TANK FILLER ON THE TOP OF THE TANK. IT'S A KNOWN BAD PART FEOM THE FACTORY. MINE HAS HAD A HOLE FOR A WHILE NOW. IT CAN LITERALLY LEAK OVER 10 GALLONS OF GAS A DAY IF YOU FILL THE TANK TO FULL. EVEN IF YOU DON'T THE SMELL OF GAS IN AND AROUND THE VEHICLE IS TERRIBLE. MY CHECK ENGINE LIGHT IS ON BECAUSE OF IT. IT RUNS LIKE CRAP BECAUSE OF IT. WHAT'S MORE DANGEROUS THAN SPILLING GAS EVERYWHERE YOU GO!? SOME PEOPLE HAVE HAD CHEVY PAY FOR THE REPAIRS ON THERE 2004 TRAILBLAZER. LOOK IT SHOULDN'T MATTER WHAT YOUR VIN# IS OR HOW MANY MILES AT THIS POINT (I JUST HIT 150,000) THE GAS TANKS ON THESE VEHICLES ARE FAULTY, THEY'RE DANGEROUS, THEY'RE EXSPENSIVE. I SURELY DONT HAVE $800-$1500 LAYING AROUND TO FIX A PART THAT IS KNOWN AND PROVEN TO BE BAD. WE ALL KNOW TBEY ARE BAD, CHEVROLET KNOWS IT, THE NHTSA KNOWS IT. THE KICKER IS YOU CANT EVEN FIND USED GAS TANKS FOR THESE THINGS TO SAVE MONEY. EVERY SINGLE ONE IS JUNK OR ALREADY REPLACED ONE THAT WAS JUNK. IT IS COMPLETELY CRAZY THAT THE OWNERS OF THESE VEHICLES WHERE NEVER PROBABLY TAKEN CARE OF IN REGARDS TO THIS ISSUE WITH THE GAS TANKS

Incident Oct 14, 2015

THE CABIN SMELLS VERY STRONGLY OF GAS AND AS IS LEAKING FROM UNDER THE VEHICLE WHEN DRIVEN.

Incident May 20, 2019

"TAKATA RECALL" I WAS RECENTLY IN A CAR ACCIDENT THAT WAS LISTED IN THE POLICE REPORT AS A HEAD ON COLLISION AND NOT ONE AIRBAG DEPLOYED. THE IMPACT AS I WAS TOLD WAS HARD ENOUGH THAT THE AIRBAGS SHOULD HAVE DEPLOYED.

Incident Apr 14, 2019

STRONG SMELL OF RAW GAS

Incident Feb 22, 2018

ALL LIGHTS STOPPED WORKING, EXCEPT WHEN SWITCHING TO HIGH BEAMS. FRONT LIGHTS AND BRAKE LIGHTS DO NOT WORK. WHEN USING THE HIGH BEAMS, THE FRONT LIGHTS OPERATE ON HIGH ONLY. THE CAR CANNOT BE SAFELY DRIVEN AT NIGHT.

Incident Mar 25, 2019

RUSTED FUEL LINES- GARAGE CHECKED STRONG FUEL SMELL AND DISCOVERED RUSTED FUEL FILLER AND LINES

Incident Feb 8, 2019

I'VE BEEN GETTING A RAW SMELL OF GAS WHILE DRIVING.

Incident Jan 1, 2017

2004 CHEVY TRAILBLAZER KEEPS GETTING CAM POSITION SENSOR FAULT. CAUSING CHECK ENGINE LIGHT TO COME ON. SEEMS TO BE A COMMON PROBLEM WITH THIS MODEL. WE HAVE REPLACED THIS PART THREE TO FOUR TIMES ON OUR TRUCK. TRUCK BEGAN TO RUN ROUGH ENGINE KNOCKED AND HAD REDUCED POWER.

Incident Jan 15, 2019

PART # 19120564 RUBS ON TAILGATE WHEN OPENING . DOES SECURE PROPERLY. EVENTUALLY, FLEW OFF WHILE DRIVING.

Incident Jun 22, 2010

THE SAME THING RUNNING OFF THE FUSE TO THE CPU GROUNDS OUT ON THE BODY BLOWING THE FUSE MAKING IT SEEM LIKE THE CPU IS BAD. I WENT AND STARTED IT AND PUT IN DRIVE, FUSE BLEW, AND THE ENGINE SHUT DOWN

Incident Nov 2, 2018

TRANSMISSION OIL COOLER LINES ARE CORRODED TO THE POINT WHERE THEY ARE LEAKING FLUID AND THE VEHICLE ONLY HAS 130000 MILES ON IT.

Incident Jun 5, 2018

AFTER STARTING MY 2004 CHEVY TRAILBLAZER THE GAUGES ON THE INSTRUMENT PANEL DID NOT WORK. BUT THE ABS, SEAT BELT, BREAK AND CHECK ENGINE LIGHTS ARE ON. THE INDICATOR FOR GEARS IS OUT. THE SPEEDOMETER JUMPS SO NOT ALWAYS SURE HOW FAST I'M GOING. I HAVE ONLY OWNED THIS VEHICLE FOR A SHORT TIME. BUT AFTER SOME RESEARCH I HAVE DISCOVERED THAT THIS IS A VERY COMMON PROBLEM WITH THIS VEHICLE.

Incident Sep 28, 2018

TL* THE CONTACT OWNS A 2004 CHEVROLET TRAILBLAZER. THE CONTACT STATED THAT THE UNDERCARRIAGE OF THE VEHICLE WAS SEVERELY RUSTED. THE CONTACT BECAME AWARE OF THE CORROSION BY VISIBLY INSPECTING THE VEHICLE. THE CONTACT STATED THAT THE REAR STABILIZER BAR WAS TOTALLY RUSTED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC TO BE INSPECTED. THE CONTACT WAS INFORMED THAT THE SUBFRAME THAT SUPPORTED THE REAR SUSPENSION NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. A DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOTIFIED AND PROVIDED CASE NUMBER: 8-4669457241. THE APPROXIMATE FAILURE MILEAGE WAS 160,000.

Incident Jun 1, 2018

DRIVING CONDITIONS DARK, 11PM, UNLIT, STARS VISIBLE PAVED COUNTRY ROAD WITH HILLS, CURVES AND 2-5 FOOT DITCHES. WEATHER WET BUT DRYING. VISIBILITY GOOD. VEHICLE IN MOTION NEAR LEGAL SPEED LIMIT 80 KM/HR. OCCASIONAL ONCOMING TRAFFIC, SO OCCASIONALLY SWITCHING BETWEEN LOW AND HIGH BEAMS. NOTICED LOW BEAM HEADLIGHTS FLICKERED OCCASIONALLY. EFFECT WAS ONLY VISIBLE AFTER ONCOMING TRAFFIC HAD PASSED, BEFORE SWITCHING BACK TO HIGH BEAM HEADLIGHTS. I HAD ATTRIBUTED THE EFFECT TO MY EYES ADJUSTING AFTER THE ONCOMING HEADLIGHTS. ON ONE OCCASION, AFTER THE ONCOMING VEHICLE HAD PASSED, I SWITCHED BACK TO LOW BEAM SETTING, BUT THE LOW BEAM HEADLIGHTS WERE NOT ILLUMINATING THE ROAD AT ALL. ALL I COULD SEE WAS A SMALL AMOUNT OF YELLOWISH LIGHT OFF TO THE SIDES OF THE VEHICLE FROM THE OTHER RUNNING LIGHTS, INCLUDING YELLOW LIGHTS ON THE SIDE-VIEW MIRRORS. THERE WAS INSUFFICIENT LIGHT TO SEE ANY DISTANCE DOWN THE ROAD, SO I CEASED TO DEPRESS THE ACCELERATOR PEDAL, AND COVERED THE BRAKE APPLYING GENTLE BRAKING. I STILL HAD MY FINGERS ON THE LEVER AND WAS ABLE TO SWITCH BACK TO HIGH BEAMS AFTER SEVERAL SECONDS. FORTUNATELY THE HIGH BEAMS STILL WORKED. I BROUGHT THE VEHICLE TO A STOP AT THE NEXT AVAILABLE SAFE OPPORTUNITY, TO ASSESS WHAT HAD HAPPENED. ALL OTHER LIGHTS, INCLUDING THE FOG LIGHTS WERE WORKING. I DROVE AT REDUCED SPEED ALTERNATELY USING THE FOG LIGHTS AND HIGH BEAMS. THE LOW BEAMS OCCASIONALLY STARTED WORKING AGAIN. BY THE TIME I WAS HOME, THEY HAD CEASED TO WORK. I REPLACED THE GM HDM MODULE, AND THE LOW BEAMS WORKED FOR A YEAR OR SO UNTIL THAT MODULE FAILED. THERE IS A RECALL TO REPLACE GM HDM 15016745 WITH GM HDM 13506836 BUT THE RECALL APPARENTLY DOES NOT APPLY TO MY 2004 MODEL YEAR. NHTSA RECALL NO. : 15V-519 MANUFACTURER RECALL NO. : 14291 I CONSIDER THIS TO HAVE BEEN A SEVERE LIFE THREATENING EVENT.

Incident Jul 30, 2018

TL* THE CONTACT OWNS A 2004 CHEVROLET TRAILBLAZER. WHILE OPERATING THE VEHICLE, THE LOW BEAM HEADLIGHTS AND THE BRAKE LIGHTS RANDOMLY STOPPED ILLUMINATING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO REPLACED THE LIGHT BULBS, CIRCUIT BOARDS, AND FUSES; HOWEVER, THE FAILURES CONTINUED. WHEN REPLACING THE BRAKE LIGHTS, THE BULBS MELTED INTO THE CIRCUIT BOARD. THE LOCAL DEALER WAS NOT NOTIFIED OF THE FAILURES. THE MANUFACTURER WAS NOTIFIED, BUT NO ASSISTANCE WAS OFFERED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 160,000.

Incident Feb 1, 2015

TL* THE CONTACT OWNS A 2004 CHEVROLET TRAILBLAZER. WHILE DRIVING 45 MPH, THE CONTACT DETECTED A FUEL ODOR COMING THROUGH THE VENTS. THE CONTACT MENTIONED THAT THE CHECK ENGINE INDICATOR ILLUMINATED PRIOR TO THE FAILURE. THE CONTACT ALSO STATED THAT THE INSTRUMENT PANEL DID NOT ILLUMINATE AND THE SPEEDOMETER DID NOT OPERATE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE CONTACT WAS INFORMED THAT THE FUEL PRESSURE REGULATOR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE DEALER AND MANUFACTURER WERE NOT MADE AWARE OF THE FAILURES. THE FAILURE MILEAGE WAS 153,000.

Incident Jul 16, 2018

THE LOW BEAM HEADLIGHTS BURN OUT WHILE DRIVING THE VEHICLE. THIS HAS HAPPENED 3 TIMES IN THE LAST 6 MONTHS. ALL 3 TIMES BOTH LOW BEAM BULBS BURN OUT AT THE SAME EXACT TIME WHILE TRAVELING ON A RURAL ROAD IN NH..

Incident May 4, 2018

FUEL PRESSURE REGULATOR IS LEAKING

Incident Mar 30, 2018

MY GAUGES RANDOMLY SAY LOW OIL PRESSURE BUT THERE IS NO PROBLEM AND SENSOR WAS REPLACED. NOW THE ENTIRE INSTRUMENT PANEL IS DEAD.

Incident Feb 24, 2018

WHEN DRIVING THE HEADLIGHTS ALL OF A SUDDEN JUST SHUT OFF. IT IS EXTREMELY SCARY AT NIGHT. I FOUND THAT I CAN HOWEVER USE THE BRIGHTS. THEY EVENTUALLY COME BACK ON. THIS HAS BEEN HAPPENING FOR YEARS. I KEPT HOPING FOR A RECALL AND JUST FOUND THIS SITE TO REPORT IT. THIS HAS HAPPEN ON CITY STREETS AND HIGHWAYS. IT HAS HAPPENED WHEN THERE ARE STREET LIGHTS AND VEHICLE LIGHTS AND WHEN IT IS PITCH BLACK. THE 1ST TIME IT HAPPENED, I WAS DRIVING WITH MY CHILD IN THE VEHICLE ON THE FREEWAY.

Incident Oct 5, 2007

MY FAMILY WAS DRIVING HOME ON THE FREEWAY WHEN THE COMPLETE THIRD TAILLIGHT COVER BLEW OFF. IT APPEARS THAT THE ADHESIVE THAT ATTACHES THE REAR SPOILER TO THE GLASS OF LIFT GATE HAS LOOSENED DUE TO A MANUFACTURER DEFECT.

Incident Jan 16, 2018

MY GAUGE CLUSTER WILL INTERMITTENTLY STOP WORKING BOTH WHILE DRIVING AND WHILE VEHICLE IS PARKED AND RUNNING. USUALLY AFTER A FEW MOMENTS IT WOULD GO BACK TO NORMAL BUT NOW THE ISSUE IS GETTING WORSE AND I HAVE TO TAP ON THE GAUGE CLUSTER FOR THE GAUGES TO RESUME WORKING.THIS HAS BEEN AN ONGOING PROBLEM SINCE APPROXIMATELY 2006 BUT CHEVY REFUSES TO ISSUE A RECALL ON THIS ISSUE WHICH IS IN MY OPINION A SAFETY ISSUE

Incident Jun 1, 2006

INSTRUMENTAL PANEL/ GAGE CLUSTER. ALL GAGES CONTINUE TO FAIL SPIKING ALL OVER THE PLACE PRIOR TO FAILING. AIR BAG LIGHT CONTINUES TO BLINK ON THEN OFF RANDOMLY

Incident Dec 22, 2017

CRACKED EXHAUST MANIFOLD

Incident May 9, 2017

STALLS - I HAVE TAKEN THIS TRAILBLAZER INTO THE DEALER FOR THIS STALLING PROBLEM AND I AM TOLD NO PROBLEM FOUND. VEHICLE STALLS AFTER COMING TO A STOP OR WHEN MOVING SLOWLY. THIS IS AN INTERMITTENT.

Incident Nov 1, 2005

MY DRIVING LIGHTS TURN OFF AND ON WHILE IM DRIVING I TOOK IT TO CHECK AND THEY SAID IS A FACTORY PROBLEM WITH ELECTRIC SYSTEM BUT MY LIGHTS TURN OFF WHILE IM DRIVING

Incident Nov 1, 2017

CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH 4 -WHEEL DRIVE FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 101, NO. 110, NO. 114, NO. 225, NO. 209, & NO. 208. VECHICLES WERE BUILT WITH A LEFT -FRONT BRAKE PIPE WITH A CIRCUMFERENTIAL SCORE AT A RANDOM LOCATION ALONG THE LENGHT OF THE PIPE AS THE RESULT OF THE MANUFACTURING PROCESS. IF THE BRAKE PIPE PARTIALLY OR FULLY FRACTURED,BRAKE PEDAL TRAVEL WOULD IMMEDIATELY INCREASE AND FRONT BRAKE PERFORMANCE WOULD BE REDUCED UNDER CERTAIN CIRCUMSTANCES THE FRONT LOWER CONTROL ARM BRACKETS MAY FRACTURE. MISSING WELDS ON THE REAR FLOW PLAN THE CALIBRATION OF THE TRANSFER CASE CONTROL MODULE COULD CAUSE INSUFFICIENT HIGH SPEED GEAR ENGAGEMENT. THIS FRACTURE COULD RESULT IN SEPARATION OF THE FRONT LOWER CONTROL ARM FROM THE FRAME SOME OF THESE VEHICLES WERE BUILT WITH A RANGE SHIFT COLLAR IN THE TRANSMISSION TRANSFER CASE THAT CONTAINS CRACKS.

Incident Aug 11, 2017

TL* THE CONTACT OWNS A 2004 CHEVROLET TRAILBLAZER. THE CONTACT STATED THAT THE INSTRUMENT PANEL FAILED TO FUNCTION PROPERLY. THE INSTRUMENT PANEL SHORTED OUT AND VARIOUS GAUGES FAILED TO WORK. WHILE DRIVING, THE INSTRUMENT PANEL SCREEN WENT BLANK NUMEROUS TIMES INTERMITTENTLY. THE VEHICLE HAD TO BE RESTARTED TO RESET THE COMPUTER. THE DEALER (OCEAN CREST CHEVROLET BUICK GMC CADILLAC, 855 ALTERNATE HWY 101, WARRENTON, OR 97146, (503) 836-7913) WAS NOTIFIED OF THE FAILURE. THE MANUFACTURER STATED THAT THERE WAS NOT RECALL CAMPAIGN AND ADVISED THAT THE VEHICLE BE TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING AND REPAIR. THE CONTACT WAS PROVIDED WITH A CASE NUMBER. THE FAILURE MILEAGE WAS NOT AVAILABLE.

Incident Oct 1, 2010