1993 Ford Aerostar

1993 Ford Aerostar

Overall

Not Rated

Front Crash

Not Rated

Side Crash

Not Rated

Rollover

Not Rated

SERVICE BRAKES, HYDRAULIC

CERTAIN AFTERMARKET BRAKE HYDRAULIC MASTER CYLINDERS SOLD AS REPLACEMENT BRAKE CYLINDERS FOR CERTAIN FORD, DAIMLERCHRYSLER, AND JEEP PASSENGER VEHICLES. THESE BRAKE CYLINDERS WERE SOLD UNDER THE BRAND NAMES OF NAPA, RAYBESTOS, AIMCO, AC DELCO, CARQUEST, BENDIX, AND WAGNER. ONLY PRODUCTS THAT WERE MANUFACTURED FROM JULY 27, 2005 THROUGH JANUARY 17, 2006 (DATE CODES 0529 THROUGH 0602) ARE SUBJECT TO THIS RECALL. WHEN SUBJECT TO VERY COLD TEMPERATURES, AN INTERNAL SEAL IN THE MASTER CYLINDER COULD LOSE FLEXIBILITY AND MAY CAUSE BRAKE FLUID TO LEAK.

Campaign: 06E022000

SERVICE BRAKES, AIR:DISC:ROTOR

EQUIPMENT DESCRIPTION: AFTERMARKET BRAKE ROTORS FOR USE ON CERTAIN FORD AND MAZDA TRUCKS. CRACKED CASTINGS CAUSED CRACKS TO APPEAR ON THE OUTER DIAMETER OF THE ROTOR HAT OR AROUND THE STUD HOLE.

Campaign: 98E010000

ELECTRICAL SYSTEM:IGNITION:SWITCH

VEHICLE DESCRIPTION: MINI VANS. THESE VEHICLES WERE PRODUCED WITH A HIGHER THAN SPECIFIED ELECTRICAL LOAD THROUGH THE ACCESSORY POWER FEED CIRCUIT. THE POTENTIAL FOR CONTACT BETWEEN THE B2 (BATTERY), A2 (ACCESSORY), AND P1 (PROOF) CIRCUITS CAN OCCUR, CREATING A SHORT CIRCUIT, ALLOWING CURRENT TO FLOW THROUGH THE GROUND WIRE.

Campaign: 99V029000

POWER TRAIN:TRANSFER CASE (4-WHEEL DRIVE)

VEHICLE DESCRIPTION: ALL WHEEL DRIVE PASSENGER MINIVANS. THESE VEHICLES CAN DEVELOP POWERTRAIN BENDING RESONANCE OR TRANSFER CASE OUTPUT SHAFT BUSHING DISPLACEMENT. THE POWERTRAIN BENDING RESONANCE OR THE OUTPUT SHAFT BUSHING DISPLACEMENT CAN RESULT IN STRUCTURAL FAILURE OF THE TRANSMISSION AND/OR TRANSFER CASE. FLUID EXPLUSION, DRIVESHAFT SEPARATION OR LOSS OF VEHICLE DRIVE CAN RESULT.

Campaign: 97V204000

POWER TRAIN

TL* THE CONTACT OWNS A 1993 FORD AEROSTAR. WHILE DRIVING AT APPROXIMATELY 80 MPH, THERE WAS A VIBRATION COMING FROM THE DRIVER SIDE AND THERE WAS FLUID LEAKING FROM THE VEHICLE. THE CONTACT NOTICED THAT THE TRANSMISSION TRANSFER CASE WAS FRACTURED AND FLUID WAS LEAKING. THE VEHICLE WAS TOWED TO THE CONTACTS RESIDENCE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS NOT AVAILABLE.

ELECTRICAL SYSTEM

TL* THE CONTACT OWNS A 1993 FORD AEROSTAR. THE CONTACT STATED THAT THE KEY BECAME LODGED IN THE IGNITION. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR A DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 169,000.

STRUCTURE

BACKED INTO PINE TREE IN DRIVEWAY. SHATTERED PLASTIC BUMPER COVER. CAN NOT REPLACE BUMPER COVER BECAUSE FORD SAYS OBSOLETE. ALSO NO AFTER MARKET BUMPER CAN BE FOUND FOR THIS MODEL. THIS BUMPER PROTECTS NO ONE. *JS FORD WON'T EVEN GIVE ME THE FORD PART NUMBER. ITS A CARGO VAN. OTHER MODEL COVERS CAN BE BOUGHT FROM AFTER MARKET SELLERS BUT NOT THE CARGO VAN. ONLY PLACE TO GET ONE IS JUNK YARDS IF YOU ARE GET LUCKY. MOST OF THEIR COVERS ARE BUSTED ALSO. A CAR IS A HAZARD WITHOUT A BUMPER. *JS

ELECTRICAL SYSTEM

TL*THE CONTACT OWNS A 1993 FORD AEROSTAR. THE CONTACT STATED THAT HE NOTICED ELECTRICAL PROBLEMS. THERE WAS A CLICKING SOUND AND HE COULD FEEL A PULSATION IN THE DASHBOARD; THERE WERE ALSO ELECTRICAL SHORTAGES. HE CALLED THE DEALERSHIP ABOUT RECALL 99V029000 AND WAS TOLD THAT HIS VEHICLE WAS NOT INCLUDED IN THE RECALL. HE ALSO CONSULTED THE MANUFACTURER AND IT WAS CONFIRMED THAT THE VEHICLE WAS NOT INCLUDED. THE VEHICLE HAD NOT BEEN REPAIRED TO-DATE. THE CURRENT MILEAGE WAS 144,705. THE FAILURE MILEAGE WAS APPROXIMATELY 144,670. UPDATED 02/22/11

ELECTRICAL SYSTEM

TL*THE CONTACT OWNS A 1993 FORD AEROSTAR. THE CONTACT STATED THAT HIS VEHICLE WAS PRODUCED WITH A HIGHER THAN SPECIFIED ELECTRICAL LOAD THROUGH THE ACCESSORY POWER FEED CIRCUIT. THE POTENTIAL FOR CONTACT BETWEEN THE B2 (BATTERY), A2 (ACCESSORY), AND P1 (PROOF) CIRCUITS CAN OCCUR; THEREFORE, CREATING A SHORT CIRCUIT AND ALLOWING CURRENT TO FLOW THROUGH THE GROUND WIRE. ON NUMEROUS OCCASIONS, HE NOTICED THAT THE SWITCH MODULE MELTED AND THE INSTRUMENT CONTROL PANEL LIGHTING WAS INOPERATIVE. AS A RESULT, THE RISK OF A SEVERE FIRE INCREASED. THE MANUFACTURER STATED THAT THE VIN WAS EXCLUDED FROM NHTSA CAMPAIGN ID NUMBER 99V029000 (ELECTRICAL SYSTEM:IGNITION:SWITCH); THEREFORE, THEY WOULD NOT ASSUME FINANCIAL RESPONSIBILITY FOR THE REPAIR. THE VEHICLE HAS NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS 168,000 AND CURRENT MILEAGE WAS 180,000.

TIRES

BOUGHT FOUR TIRES: SIGMA SHADOW. 55,000 MILES WARRANTY. 215/75R14, 6K60, AT TIRE KINGDOM LOCATED AT: 8790 SW 24TH ST. MIAMI, FL. 33165. TELEPHONE 305 227 4110. *TR ON OCT. 22, 2007 THE REAR RIGHT TIRE BLEWOUT. THE TIRE HAD 7,194 MILES. TIRE KINGDOM GAVE ME TWO TIRES WHICH THEY INSTALLED IN THE FRONT. ON NOV. 19, 2007 ANOTHER TIRE BLEWOUT. THIS TIRE HAD 10,550 MILES. THIS LAST INCIDENT HAPPENED IN HOUSTON. I WENT TO NTB (PART OF THE SAME COMPANY) LOCATED AT: 7115 FM 1960 ROAD WEST. TELEPHONE 281- 580-1689. I TALKED TO THE MGR. MR. FRED JOHNSON. I SHOWED HIM THE BLOWNOUT TIRE, ALL THE PAPERS ETC..AND ASKED HIM TO REPLACE THE BLOWNOUT TIRE PLUS THE OTHER ORIGINAL TIRE. HE SAID THAT HE WOULD ONLY REPLACE THE BLOWNOUT TIRE, HE DID NOT HAVE THE TIRE IN STOCK SO I HAD TO RETURN. SINCE HE DID NOT WANT TO REPLACE THE TWO ORIGINAL TIRES, I ASKED HIM FOR THE NAME AND TELEPHONE OF THE DISTRICT MGR. HE TOLD ME THAT HIS NAME WAS ARTHAY BENTON AND HIS TELEPHONE 1-865-951-4622. I CALLED MR. BENTON AND EXPLAINED THE PROBLEM TO HIM. HE SAID HE WOULD CALL ME BACK. THE PERSON THAT CALLED ME BACK WAS MR. FRED JOHNSON AND TOLD ME THAT THEY WOULD NOT GIVE ME ANY TIRES NOT EVEN REPLACE THE BLOWNOUT TIRE. I TOOK THE BLOWNOUT TIRE TO ANOTHER NTB STORE AND THEY REPLACED IT. I AM VERY CONCERNED ABOUT THE SAFETY OF THESE TIRES PARTICULARLY THE ORIGINAL TIRE. THE FIRST INCIDENT HAPPENED ON I-10 IN FLORIDA, THE SECOND INCIDENT ON 610 IN HOUSTON. IN BOTH INCIDENTS, WHEN THE TIRES FAILED, I LOST CONTROL OF THE CAR AND MIRACULOUSLY I DID NOT HAVE AN ACCIDENT. IF YOU NEED ADDITIONAL INFORMATION, LET ME KNOW. SINCERELY ANTONIO DURANCE *TR

ELECTRICAL SYSTEM

JUST GOT HOME AND WAS PARKED IN FRONT OF THE HOUSE. ABOUT 30 MIN LATER SOMEONE WAS KNOCKING ON ARE DOOR TELLING US THE VAN WAS ON FIRE. THERE WAS NO KEYS LEFT IN THE VAN. THE FIRE BURN THE DASH AND THE RIGHT SIDE OF THE INSIDE OF THE ENGINE AND THE HOOD. THE VAN IS NOW TOTAL. *NM

ENGINE AND ENGINE COOLING

DT*: THE CONTACT STATED UPON CHANGING BOTH THE FUEL FILTER AND THE OIL FILTER, THE VEHICLE MADE A KNOCKING NOISE WHILE DRIVING 20 MPH. THE VEHICLE WAS TAKEN TO A PRIVATE REPAIR SHOP WHO WAS UNABLE TO DETERMINE THE CAUSE OF THE PROBLEM.

UNKNOWN OR OTHER

CONSUMER REQUESTING INFORMATION ON RECALLS FOR 1993 FORD AEROSTAR. *TS *JB

ELECTRICAL SYSTEM,VISIBILITY,UNKNOWN OR OTHER

TOGGLE SWITCH ON SUNROOF HAS ALREADY BEEN REPLACED ONCE AND NOW IT HAS GONE OUT AGAIN. DOES NOT STOP ON ITS OWN FOR OPEN AND CLOSE. I DON'T FEEL I SHOULD HAVE TO PAY FOR SOMETHING THAT CONTINUES TO BREAK.