1995 Ford Aerostar

1995 Ford Aerostar

Overall

Not Rated

Front Crash

Not Rated

Side Crash

Not Rated

Rollover

Not Rated

SERVICE BRAKES, HYDRAULIC

CERTAIN AFTERMARKET BRAKE HYDRAULIC MASTER CYLINDERS SOLD AS REPLACEMENT BRAKE CYLINDERS FOR CERTAIN FORD, DAIMLERCHRYSLER, AND JEEP PASSENGER VEHICLES. THESE BRAKE CYLINDERS WERE SOLD UNDER THE BRAND NAMES OF NAPA, RAYBESTOS, AIMCO, AC DELCO, CARQUEST, BENDIX, AND WAGNER. ONLY PRODUCTS THAT WERE MANUFACTURED FROM JULY 27, 2005 THROUGH JANUARY 17, 2006 (DATE CODES 0529 THROUGH 0602) ARE SUBJECT TO THIS RECALL. WHEN SUBJECT TO VERY COLD TEMPERATURES, AN INTERNAL SEAL IN THE MASTER CYLINDER COULD LOSE FLEXIBILITY AND MAY CAUSE BRAKE FLUID TO LEAK.

Campaign: 06E022000

EQUIPMENT:OTHER:LABELS

THE CERTIFICATION LABEL ON THESE VEHICLES HAVE INCORRECT REAR TIRE SIZES LISTED. P215/70R14SL SHOULD BE P215/75R14SL. THIS DOES NOT COMPLY WITH FMVSS NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS."

Campaign: 95V037000

ELECTRICAL SYSTEM:IGNITION:SWITCH

VEHICLE DESCRIPTION: MINI VANS. THESE VEHICLES WERE PRODUCED WITH A HIGHER THAN SPECIFIED ELECTRICAL LOAD THROUGH THE ACCESSORY POWER FEED CIRCUIT. THE POTENTIAL FOR CONTACT BETWEEN THE B2 (BATTERY), A2 (ACCESSORY), AND P1 (PROOF) CIRCUITS CAN OCCUR, CREATING A SHORT CIRCUIT, ALLOWING CURRENT TO FLOW THROUGH THE GROUND WIRE.

Campaign: 99V029000

ELECTRICAL SYSTEM:WIRING:FRONT UNDERHOOD

VEHICLE DESCRIPTION: MINI VANS. HEAT GENERATION IN THE WIRING HARNESS TO THE FUEL PUMP/SENDER ASSEMBLY CAN CAUSE AN ELECTRICAL SHORT. THE VEHICLE COULD EXPERIENCE A LOSS OF POWER AND BECOME IMMOBILIZED AND THE FUEL GAUGE MAY BE ERRATIC.

Campaign: 99V028000

POWER TRAIN:TRANSFER CASE (4-WHEEL DRIVE)

VEHICLE DESCRIPTION: ALL WHEEL DRIVE PASSENGER MINIVANS. THESE VEHICLES CAN DEVELOP POWERTRAIN BENDING RESONANCE OR TRANSFER CASE OUTPUT SHAFT BUSHING DISPLACEMENT. THE POWERTRAIN BENDING RESONANCE OR THE OUTPUT SHAFT BUSHING DISPLACEMENT CAN RESULT IN STRUCTURAL FAILURE OF THE TRANSMISSION AND/OR TRANSFER CASE. FLUID EXPLUSION, DRIVESHAFT SEPARATION OR LOSS OF VEHICLE DRIVE CAN RESULT.

Campaign: 97V204000

EQUIPMENT:MECHANICAL:CARRIER/RACK

THE SPARE TIRE SUPPLIED WITH THE VEHICLE CAN CONTACT THE BRAKE LINES ON THE REAR AXLE IF IT IS MOUNTED IN THE UNDERBODY SPARE TIRE CARRIER. SUCH CONTACT COULD RESULT IN FRACTURE OF A REAR BRAKE LINE.

Campaign: 94V239000

SERVICE BRAKES, AIR:DISC:ROTOR

EQUIPMENT DESCRIPTION: AFTERMARKET BRAKE ROTORS FOR USE ON CERTAIN FORD AND MAZDA TRUCKS. CRACKED CASTINGS CAUSED CRACKS TO APPEAR ON THE OUTER DIAMETER OF THE ROTOR HAT OR AROUND THE STUD HOLE.

Campaign: 98E010000

FUEL/PROPULSION SYSTEM

TL* THE CONTACT OWNS A 1995 FORD AEROSTAR. AFTER REFUELING THE VEHICLE, THE CONTACT DETECTED A STRONG FUEL ODOR AROUND THE VEHICLE. THE CONTACT DISCOVERED THAT THE FUEL TANK WAS LEAKING FUEL. IN ADDITION, THE FUEL STRAP AND THE FUEL INLET WERE CRACKED. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHERE IT WAS DIAGNOSED THAT THE FUEL TANK NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 165,000.

ELECTRICAL SYSTEM

TL*THE CONTACT OWNS A 1995 FORD AEROSTAR. WHILE DRIVING 20 MPH, THE VEHICLE SHUT OFF WITHOUT WARNING. THE CONTACT OPENED THE HOOD AND NOTICED THAT THE FUEL LINES WERE EXTREMELY HOT BEFORE THEY BURST INTO FLAMES. THE CONTACT SUSTAINED A BURNED RIGHT HAND. THE FIRE DEPARTMENT STATED THAT THE FUEL PUMP CAUSED THE FIRE. A POLICE REPORT WAS FILED. THE MANUFACTURER STATED THAT HIS VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 99V028000 (ELECTRICAL SYSTEM: WIRING: FRONT UNDER HOOD). THE CURRENT AND FAILURE MILEAGES WERE 150,000.

SEAT BELTS

WENT TO INSTALL CAR SEAT IN THREE ROW, PASSENGER SIDE AND THE SEAT BELT CAME UNLATCHED. IT WILL NOT STAY BUCKLED AT ALL. WENT TO A DEALERSHIP AND THEY WANT TO CHARGE US OVER $100 FOR BUCKLE AND AN HOURS WORTH OF LABOR. WE ARE DUE IN 2 WEEKS WITH THIRD CHILD AND THAT IS THE ONLY SPOT LEFT IN THE VAN THAT THE CAR SEAT FITS IN. *NM

TIRES

AT APPROXIMATELY 12:00 AM 6/23/06, I WAS DRIVING FROM ALBANY, TX TO DALLAS, TX ON HIGHWAY 180... AND THE TREAD ON MY RIGHT REAR TIRE SEPARATED FROM THE REST OF THE TIRE. THE TIRE IS A BRIDGESTONE TURANZA. I WAS DOING BETWEEN 70 AND 75 AT THE TIME AND THE VEHICLE WAS TOTALLY OUT OF CONTROL UNTIL I WAS ABLE TO REDUCE SPEED TO ABOUT 25. INTERESTINGLY, THE REMAINING TIRE DID NOT GO FLAT. IT WAS STILL INFLATED WHEN I CAME TO A HALT. THE TREAD TORE OFF PART OF MY REAR BUMPER AND MARKED UP THE REAR SIDE PANEL OF MY VEHICLE. I HAVE TAKEN MANY PICTURES OF THE TIRE AND OF THE DAMAGE TO MY VEHICLE. THIS IS THE THIRD TIRE OF A 4 TIRE SET THAT HAS GIVEN ME PROBLEMS. THE FIRST TWO DEVELOPED RIDGES IN THE TREAD. I REPLACED THEM LAST AUGUST. THE REAR TIRES AT THE TIME SEEMED FINE. NOW, TEN MONTHS LATER... HERE I AM ON THE HIGHWAY AND THE TREAD SEPARATES. I COULD HAVE EASILY DIED OR BEEN SERIOUSLY INJURED. IF THERE HAD BEEN TRAFFIC AT THE TIME... THERE WOULD HAVE BEEN AN ACCIDENT AS MY VEHICLE WAS ALL OVER THE HIGHWAY UNTIL THE SPEED WAS REDUCED AND CONTROL COULD BE REGAINED. *JB

ELECTRICAL SYSTEM

DT: THE CALLER SAID IGNITION FAILED. SHE SAID A YEAR AGO THAT THE VEHICLE STARTED BY ITSELF WITHOUT A KEY. SHE STATED THAT CURRENTLY SHE HAD INTERMITTENT TROUBLE STARTING THE VEHICLE. THE LIGHTS ON THE DASHBOARD WILL COME ON BUT THE VEHICLE WILL NOT START. DEALER SAID VEHICLE WAS NOT RECALLED. THEY WILL NOT HELP HER FOR FREE. MANUFACTURER HAS NOT BEEN CONTACTED YET. *AK *NM

ENGINE AND ENGINE COOLING

THE VEHICLE WAS PARKED IN THE OFFICE PARKING LOT. SUDDENLY A CUSTOMER NOTIFIED THE CONSUMER THAT THERE WAS A VEHICLE FIRE. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. THE MANUFACTURE WILL MAKE CONTACT WITH THE CONSUMER FOR INSPECTION. *NM *NM

ELECTRICAL SYSTEM

THE INTERIOR OF THE DASH BOARD CAUGHT FIRE ON ITS OWN, WHILE THE VEHICLE WAS PARKED. MANUFACTURER WILL BE CONTACTED BY CONSUMER. *NM

ELECTRICAL SYSTEM

CONSUMER ATTEMPTED TO GET THE VEHICLE RECALL 99V029000 REPAIRED. HOWEVER, THE DEALER KEPT GIVING THE CONSUMER EXCUSES WHY THEY COULD NOT FIX THE IGNITION SWITCH. *AK *SC *JB

EXTERIOR LIGHTING

HEADLIGHTS GO OFF AND ON. USE TO ONLY HAPPEN WHILE ON HIGH BEAM. BUT IS NOW DOING IT ON LOW BEAM. THIS IS THE SECOND FORD I HAVE OWNED TO DO THIS.*AK

WHEELS

REAR PASSENGER WHEEL CAME OFF OF 1995 FORD AEROSTAR EXT VAN. THE WHEEL INCLUDED THE REAR BRAKE DRUM AND BROKE THE AXLE, RESULTING IN A CRASH INTO THE HIGHWAY MEDIAN AT 60MPH.