1997 Ford Aerostar

1997 Ford Aerostar

Overall

Not Rated

Front Crash

Not Rated

Side Crash

Not Rated

Rollover

Not Rated

SERVICE BRAKES, HYDRAULIC

CERTAIN AFTERMARKET BRAKE HYDRAULIC MASTER CYLINDERS SOLD AS REPLACEMENT BRAKE CYLINDERS FOR CERTAIN FORD, DAIMLERCHRYSLER, AND JEEP PASSENGER VEHICLES. THESE BRAKE CYLINDERS WERE SOLD UNDER THE BRAND NAMES OF NAPA, RAYBESTOS, AIMCO, AC DELCO, CARQUEST, BENDIX, AND WAGNER. ONLY PRODUCTS THAT WERE MANUFACTURED FROM JULY 27, 2005 THROUGH JANUARY 17, 2006 (DATE CODES 0529 THROUGH 0602) ARE SUBJECT TO THIS RECALL. WHEN SUBJECT TO VERY COLD TEMPERATURES, AN INTERNAL SEAL IN THE MASTER CYLINDER COULD LOSE FLEXIBILITY AND MAY CAUSE BRAKE FLUID TO LEAK.

Campaign: 06E022000

VEHICLE SPEED CONTROL:CABLES

VEHICLE DESCRIPTION: MINIVANS EQUIPPED WITH 3.0L ENGINES. AN ACCELERATOR CABLE WAS KINKED DURING INSTALLATION, CAUSING THE CORE WIRES TO EVENTUALLY FRAY.

Campaign: 00V425000

ELECTRICAL SYSTEM:IGNITION:SWITCH

VEHICLE DESCRIPTION: MINI VANS. THESE VEHICLES WERE PRODUCED WITH A HIGHER THAN SPECIFIED ELECTRICAL LOAD THROUGH THE ACCESSORY POWER FEED CIRCUIT. THE POTENTIAL FOR CONTACT BETWEEN THE B2 (BATTERY), A2 (ACCESSORY), AND P1 (PROOF) CIRCUITS CAN OCCUR, CREATING A SHORT CIRCUIT, ALLOWING CURRENT TO FLOW THROUGH THE GROUND WIRE.

Campaign: 99V029000

POWER TRAIN:TRANSFER CASE (4-WHEEL DRIVE)

VEHICLE DESCRIPTION: ALL WHEEL DRIVE PASSENGER MINIVANS. THESE VEHICLES CAN DEVELOP POWERTRAIN BENDING RESONANCE OR TRANSFER CASE OUTPUT SHAFT BUSHING DISPLACEMENT. THE POWERTRAIN BENDING RESONANCE OR THE OUTPUT SHAFT BUSHING DISPLACEMENT CAN RESULT IN STRUCTURAL FAILURE OF THE TRANSMISSION AND/OR TRANSFER CASE. FLUID EXPLUSION, DRIVESHAFT SEPARATION OR LOSS OF VEHICLE DRIVE CAN RESULT.

Campaign: 97V204000

SERVICE BRAKES, AIR:DISC:ROTOR

EQUIPMENT DESCRIPTION: AFTERMARKET BRAKE ROTORS FOR USE ON CERTAIN FORD AND MAZDA TRUCKS. CRACKED CASTINGS CAUSED CRACKS TO APPEAR ON THE OUTER DIAMETER OF THE ROTOR HAT OR AROUND THE STUD HOLE.

Campaign: 98E010000

ELECTRICAL SYSTEM

I FOUND TWO INCOMPLETE RECALLS. I CALLED THE DEALER 9/28/2020 AT [XXX] AND SPOKE TO [XXX]. SHE PUT THE VIN IN HER SYSTEM, SAW THE TWO RECALLS AND SAID THE PARTS WOULD BE ORDERED. NO RESPONSE. I CALL [XXX] 10/5/2020 AT THE SAME NUMBER AND SHE SAID ABOUT THE SAME THING. THEN I CALLED 10/8/2020 AND ANOTHER SERVICE ADVISOR PRINTED OUT THE ISSUE WITH MY PHONE NUMBER [XXX] AND SAID [XXX] WOULD CALL ME AFTER LUNCH. NO RESPONSE. I TRIED CALLING THE FORD CUSTOMER SERVICE 800 392-3673 AND AFTER PRESSING '#' FOR TWO COMMERCIALS, THE RECORDER HUNG UP. THE VEHICLE HAS BEEN RUNNING FINE, BUT THESE ARE TWO RECALLS THAT ARE CONCERNS. (00S56 & 99S02). THANK YOU VERY MUCH. [XXX]AUGUSTA, GA INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

WHEELS,ENGINE

I WAS GIVEN THIS VAN WITH A HANDICAPPED LIFT AS A PRESENT FROM SOME PEOPLE AT OUR CHURCH. EVER SINCE I GOT IT THE ENGINE LIGHT HAS BEEN ON. I'VE HAD IT CHECKED SEVERAL TIMES BUT NO ONE SEEMS TO KNOW HOW TO FIX IT. ANOTHER PROBLEM I'VE BEEN HAVING IS THAT THE LEFT FRONT TIRE WEARS OUT MORE QUICKLY THAN THE OTHER THREE. WE'VE HAD IT BALANCED SEVERAL TIMES BUT WE STILL HAVE THAT PROBLEM EVEN WITH NEW TIRES. SINCE I AM HANDICAPPED AND USE AN ELECTRIC WHEELCHAIR IF A TIRE BLOWS OUT I MAY NOT BE ABLE TO GET OUT USING THE RAMP LIFT THAT WAS INSTALLED AND THE SAME APPLIES TO THE ENGINE. HOW DO I KNOW IF THE ENGINE HAS SOMETHING WRONG WITH IT IF THE LIGHT IS ON ALL THE TIME? *TR

FUEL SYSTEM, GASOLINE,VEHICLE SPEED CONTROL

NOTE: I WISH I HAD FOUND THIS SITE YEARS AGO. I COULD NOT GET PAST FORDS "BRICK WALL" TO SPEAK TO AN ENGINEER! 1. 1997 AEROSTAR - ACCELERATOR PEDAL WAS PRESSED DOWN QUICKLY TO PASS (2 LANE HIGHWAY). 2. NOW IN THE LEFT LANE, NOT FAR AHEAD OF PASSED THE CAR - I EXPERRIENCED A COMPLETE LOSS OF POWER - HARD RIGHT OVER TO SOFT SHOULDER - AVOIDED AN ONCOMING HEAD ON COLLISION - L JUST MISSED THE CAR BEING PASSED BY INCHES AND STOPPED. THE CRIMPED END OF CABLE TO THE CARBURATOR HAD RELEASED FROM THE ACCELERATOR PEDAL. 3. I CLAMPED THE CABLE BACK ONTO THE PEDAL WITH VICE GRIPS. (DROVE TO DEALER). FORD REPLACED THE CABLE. THAT PROBLEM HAS NOT HAPPENED AGAIN. (I DO NOT PRESS DOWN HARD EITHER!) *TR

WHEELS

OBSERVED FULL CRACK ON ALUMINUM WHEEL RIM SPOKE. THIS IS STANDARD ALUMINUM WHEEL FROM MANUFACTURER. SERIOUS SAFETY ISSUE. THIS PROBLEM SAME AS HTTP://WWW.MOTORBEAT.COM/COMPLAINT/438440/. *TR THIS IS THE SECOND RIM THAT THIS PROBLEM HAS OCCURRED. ANOTHER RIM FAILED IN THE SAME MANNER ONE YEAR AGO. REPLACED.

POWER TRAIN,ELECTRICAL SYSTEM,EQUIPMENT

NEED TO KNOW WERE TO START TO GET ALL THE PROBLEMS ON MY VAN TAKEN CARE OF ALL THE RECALLS, OF POWER TRAIN THE ELECTRICAL AND WHATEVER ELSE WAS REPORTED TO ME ON MY REPORT OF THE RECALLS ON THIS 1997 AREOSTAR VAN THANK YOU MARYJEAN. *TR

LATCHES/LOCKS/LINKAGES

1997 AEROSTAR REAR HATCH: 1 OF 2 ANCHOR STUDS WHICH SUPPORT THE TAIL HATCH PNEUMATIC SPRING (VEHICLE BODY END) BROKE, ALLOWING THE HATCH TO IMMEDIATELY FALL ON TO OPERATOR. ALTHOUGH THERE ARE 2 PNEUMATIC SUPPORTS, 1 IS INSUFFCIENT TO SUPPORT THE WEIGHT OF THE HATCH. SIMILAR EXPERIENCE WITH 1994 MODEL.

FUEL SYSTEM, GASOLINE,ELECTRICAL SYSTEM

MY 1997 FORD AERO STAR VAN PRODUCED A PUFF OF SMOKE FROM THE STEERING COLUMN NEAR THE IGNITION SWITCH. I TOOK IT TO MY MECHANIC WHOM CHECKED THE RECALL NOTICES AND FOUND ONE RESULTING IN AN ELECTRICAL OVERLOAD SHORT CIRCUIT AND OVERHEATING IN THE STEERING COLUMN ELECTRICAL COMPONENTS. WHEN THE KEY WAS TURNED OFF IT SUBSIDES. SINCE THIS OCCURRENCE THE INSTRUMENT PANEL HAS NOT WORKED AND BLEW ALL FUSES, THE FUEL PUMP DOES NOT TURN ON WITH THE KEY AFTER MULTIPLE ATTEMPTS IT ENGAGES SOME TIMES. THE FORD DEALER DID THE RECALL WORK BUT DID NOT FIX OR EXAMINE THE STEERING COLUMN OR THE COMPONENTS THAT BURNED OR OVER HEATED AS A RESULT OF THE OVERLOAD. [XXX] UPDATED 07/19/2012 *JS INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

WHEELS

CONSUMER'S HUSBAND DISCOVERED THAT ONE OF THE RIMS HAD CRACKED IN THREE PLACES. *LA ANOTHER RIM WAS FOUND WITH CRACKS IN THREE PLACES AS WELL. *SC *JB

WHEELS

CONSUMER TOOK VEHICLE TO THE DEALERSHIP FOR INSPECTION, AND MECHANIC DETERMINED THAT TWO FRONT RIMS CRACKED. *AK CONSUMER CALLED FORD MOTOR COMPANY AND SAID THAT THEY WON'T ADDRESS THE PROBLEM BECAUSE IT'S NOT ON WARRANTY OR RECALL. HOWEVER, CONSUMER REPLACED BOTH RIMS. *LA

POWER TRAIN,UNKNOWN OR OTHER

MY TRANSMISSION DEVELOPED A BAD LEAK IN THE FRONT SEAL. I PAID TO HAVE THE TRANSAXLE REMOVED AND THE SEAL REPLACED. THE FLUID WAS CHANGED AS WELL AS THE FILTER AND THEN SHORTLY AFTERWARDS THE CARS OVERDRIVE STOPPED WORKING. IT WILL SHIFT INTO OVERDRIVE BUT IT WILL SHIFT RIGHT BACK OUT WHEN I STEP ON THE GAS EVEN THE LEAST LITTLE BIT. I COULD NOT AFFORD TO HAVE IT FIXED SO I PUT IT IN DRIVE AND DROVE IT FOR ABOUT 3 WEEKS AND YESTERDAY I WAS DOING ABOUT 60 AND THE CAR SHIFTED INTO SECOND GEAR FOR NO REASON AND THEN RIGHT BACK INTO THRID. THEN ABOUT A HALF MILE LATER IT BEGAN SHIFTING FROM THIRD TO SECOND AND BACK OVER AND OVER. TALK ABOUT GETTING JERKED AROUND! IT WAS LIKE SOMEONE STEPPING ON THE BRAKES! NOW I AM ON FOOT AND I AM ON FOOT AND DUE TO OUR GREAT ECONOMY I AM OUT OF WORK FOR THE TIME BEING. THEY SHOULD OFFER A MANUAL TRANSMISSION ON ALL THEIR CARS.