2025 Ford Bronco 4dr

2025 Ford Bronco 4dr SUV 4WD

Overall

Not Rated

Front Crash

★★★★☆

Side Crash

Not Rated

Rollover

★★★☆☆

SUSPENSION:FRONT:CONTROL ARM:UPPER BALL JOINT

Ford Motor Company (Ford) is recalling certain 2024 Ranger, and 2024-2025 Bronco vehicles. The front upper control arm ball joint nut may not have been installed or tightened properly, allowing the front upper control arm to detach from the knuckle assembly.

Campaign: 24V770000

POWER TRAIN:AUTOMATIC TRANSMISSION:FLUID/LUBRICANT:VALVES/VALVE BODY

Ford Motor Company (Ford) is recalling certain 2024-2025 F-150, Bronco, 2024 Ranger, 2025 Mustang, Explorer, and Aviator vehicles. The transmission valve body may have been machined incorrectly, which can cause reverse gear failure, or unexpected forward movement in reverse or neutral gear.

Campaign: 25V164000

SUSPENSION:FRONT:CONTROL ARM:UPPER BALL JOINT

Ford Motor Company (Ford) is recalling certain 2025 Bronco vehicles. The front upper control arm ball joint nut may be missing or tightened improperly, allowing the front upper control arm to detach from the knuckle assembly.

Campaign: 25V260000

SUSPENSION:FRONT:CONTROL ARM:LOWER ARM

Ford Motor Company (Ford) is recalling certain 2024-2025 Bronco vehicles. The front lower control arm fasteners may not have been tightened properly, allowing the control arm to detach from the frame.

Campaign: 25V308000

SEATS:CRITICAL FASTENERS

Ford Motor Company (Ford) is recalling certain 2025 Ranger and Bronco vehicles. The bolts that secure the driver's seat frame to the body may be loose or missing. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 207, "Seating Systems."

Campaign: 25V311000

SUSPENSION:FRONT:CONTROL ARM:UPPER BALL JOINT

Ford Motor Company (Ford) is recalling certain 2024-2025 Bronco and Ranger vehicles. The front upper control arm ball joint fastener may be missing or tightened improperly, allowing the front upper control arm to detach from the knuckle assembly.

Campaign: 25V310000

LATCHES/LOCKS/LINKAGES:DOORS:LOCK

Ford Motor Company (Ford) is recalling certain 2025 Bronco four-door vehicles. The left-hand rear door may be able to be opened from inside the vehicle when the child safety lock is in the "ON" position.

Campaign: 25V397000

AIR BAGS:FRONTAL

Ford Motor Company (Ford) is recalling certain 2025 Bronco vehicles. The active vent flap on the passenger side may prevent the air bag from deploying as intended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."

Campaign: 25V396000

SERVICE BRAKES, HYDRAULIC:POWER ASSIST:ELECTRIC:CONTROL MODULE:SOFTWARE

Ford Motor Company (Ford) is recalling certain 2025 Lincoln Navigator, F-150, Expedition, Bronco, and Ranger vehicles. The Electronic Brake Booster (EBB) module may malfunction while driving or when the driver is utilizing an Advanced Driver Assistance System (ADAS) feature, resulting in a loss of power brake assist.

Campaign: 25V488000

VISIBILITY:WINDSHIELD

Ford Motor Company (Ford) is recalling certain 2025 Bronco and Ranger vehicles. During manufacturing, the windshield may not have been properly bonded to the vehicle, allowing it to detach in a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 212, "Windshield Mounting."

Campaign: 25V683000

ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL

Ford Motor Company (Ford) is recalling certain 2025-2026 Bronco and Bronco Sport vehicles. The Instrument Panel Cluster (IPC) may fail at startup.

Campaign: 25V788000

SERVICE BRAKES, HYDRAULIC:POWER ASSIST:ELECTRIC:CONTROL MODULE

Ford Motor Company (Ford) is recalling certain 2025 Lincoln Navigator, F-150, Expedition, Bronco, and Ranger vehicles. The Electronic Brake Booster (EBB) module may malfunction while driving or when the driver is utilizing an Advanced Driver Assistance System (ADAS) feature, resulting in a loss of power brake assist.

Campaign: 25V823000

BACK OVER PREVENTION:SOFTWARE

Ford Motor Company (Ford) is recalling certain 2021-2026 Ford Bronco and 2021-2024 Ford Edge vehicles. The Accessory Protocol Interface Module (APIM) may overheat and shutdown, which can prevent the rearview camera image from displaying as intended.

Campaign: 26V124000

ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE)

Ford Motor Company (Ford) is recalling certain 2025 Ranger, Lincoln Nautilus, Mustang, Maverick, Explorer, Escape, Lincoln Corsair, Bronco Sport, and Bronco vehicles. The exhaust gas recirculation (EGR) valve may fail, resulting in an unexpected loss of drive power.

Campaign: 26V122000

POWER TRAIN:AUTOMATIC TRANSMISSION

Ford Motor Company (Ford) is recalling certain 2021-2025 Bronco vehicles. The transmission to transfer case joint may be misaligned due to an incorrectly performed previous repair, which could lead to wear of the transmission output shaft splines and transfer case input splines.

Campaign: 26V236000

SEATS:CRITICAL FASTENERS

Ford Motor Company (Ford) is recalling certain 2024-2026 Ranger and Bronco vehicles. The front seats may have a loose or dislodged seat frame height-adjust pivot bolt.

Campaign: 26V268000

ENGINE AND ENGINE COOLING:ENGINE:HARD PARTS INTERNAL/MECHANICAL

Ford Motor Company (Ford) is recalling certain 2025-2026 Explorer, Ranger, and Bronco vehicles. The engine may fail, which can result in a loss of drive power.

Campaign: 26V343000

STRUCTURE:BODY

Ford Motor Company (Ford) is recalling certain 2022-2026 Bronco vehicles. The fender flares may not be properly secured and detach from the vehicle.

Campaign: 26V403000

ENGINE

Ford Motor Company (Ford) is recalling certain 2021-2026 Bronco and Bronco Raptor vehicles. The engine compartment wiring harness may become damaged and short circuit.

Campaign: 26V468000

ELECTRICAL SYSTEM,SERVICE BRAKES,FORWARD COLLISION AVOIDANCE

I purchased a 2025 Ford Bronco Outer Banks to flat tow behind my motorhome. Ford dealership in [XXX] said the Bronco can be flat towed and I reviewed the owners [XXX] , regarding flat towing, with the dealership prior to purchase. I went to a reputable hitch installer to add a demco/Air Force one braking system. We went on a 3 month trip out west and followed the directions in the Ford owners [XXX] to flat towing. Unfortunately while being towed the car came out of neutral tow 3 times while and there is no warning system to alert us when this happens. It cannot be felt or detected in our 44 ft coach. Luckily kind strangers saw our rear tires dragging and smoking and signaled to us. The last time we were on I55 near [XXX]. This was quite frightening as this could have easily turned into an accident for us and others on the road. I was able to drive a nearby Ford dealership who assessed the damage. We were lucky that only the rear tires were badly damaged and Ford replaced them for free. It was only at this time that we learned Ford sends out bulletins to dealerships re: updates. Per the dealership a bulletin was sent out in March 2026 stating that fuses 28 and 29 needed to be pulled. I asked why owners do not receive these updates and the dealer did not know. So thereafter we pulled the two fuses and waited 5 min for the Bronco to go in sleep mode. Even after all this, the Bronco would come out of sleep mode at times (2x) while being towed. For our safety and others on the road, we stopped flat towing the Bronco and my husband drove the coach and I drove the Bronco back to our home in [XXX]. Ford does not have a consistent fix for this issue and it scares me that there will be a horrific accident at some point. We tried to tell Ford of this issue and looked into a buy back or lemon law;however, Ford denied any problems( but they did replace our rear tires for free). INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

SUSPENSION,AIR BAGS,SEAT BELTS

Possible suspension on front driver side caused loss of control of vehicle and separation of front tire from body. Failure of front airbags to deploy despite impact, Recall of front seat or seatbelt entire malfunction caused ejection and death of driver.

ELECTRICAL SYSTEM,ENGINE

The contact owns a 2025 Ford Bronco. The contact received notification of NHTSA Campaign Number: 26V468000 (Engine, Electrical System); however, the part to do the recall repair was not available. The dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was notified of the issue. The contact had not experienced a failure.

FORWARD COLLISION AVOIDANCE

The contact owns a 2025 Ford Bronco. The contact stated that while driving at an undisclosed speed, the vehicle lost motive power, and the Forward Collision Avoidance Automatic Emergency Braking and several unknown warning lights illuminated. The vehicle was taken to the dealer several times; however, no cause for the failure was found. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 14,000.

ELECTRICAL SYSTEM,SERVICE BRAKES,FORWARD COLLISION AVOIDANCE

Flat towing a 2025 Bronco behind a 2025 Newmar Dutchstar using a Blue Ox tow bar with Demco AirForce Braking System. Ford has a setting called neutral towing. It allows you to tow behind a motorhome with brake lights, braking, etc. When the Ford is in neutral tow, and in neutral gear, all 4 wheel roll freely and you can tow safely. What's happening is the Ford is waking up out of neutral tow when the 12V battery gets low. This isn't supposed to happen as there is a 7 Pin electrical connector from the motorhome to the 6 pin electrical connected to the Bronco. Once the 12v battery gets low, the Ford computer wakes up, see's it moving the back tow tires, so the system is applying the emergency brake locking up the 2 back tires. This has now happened three times as we have traveled from [XXX] to [XXX] (had it looked at Crossroads of Ford of Apex where I bought it). I took it in to Schmop Ford in Denver and after almost a deadly accident on XXX near [XXX], to XXX. They found the back two tires destroyed. Ford replaced the tires at no charge, but the issue remains. THIS SUV SHOULD NOT BE APPROVED FOR FLAT TOWING. It is dangerous and could be deadly. You have no way of knowing unless someone else tells you. Thanks to the stranger on XXX on XXX. They told us of our issue so we pulled over. If we were to continue driving the motorhome, the tires would've been totally destroyed, a fire, or cause us to flip over. There are so many complaints on the internet about this issue. You must make Ford fix this issue with a software fix immediately. Don't make my complaint for another unlucky traveler like myself. I have enclosed the back tire picture. You can see one tire with the tread completely gone, the other tire tread missing is not shown. You can also see how the tires are mis-shaped from rubbing across the highway cement. I AM TRYING TO UPLOAD PICTURES BUT YOUR SYSTEM IS GIVING ME AN ERROR FOR A JPEG LESS THAN 10MB INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

SEATS

They have yet to repair this recall even though a remedy has been available. I have asked multiple times at my dealer and they always have a reason they can’t do it. They text me one time and never set the appointment. I have called and called and even went in. I asked at my oil change and at first they said yes but then they said they couldn’t check because “it would take all day and they did not have the time”. I went in at 8:15 or 9:15am. I even called after I made my oil change appointment and verified on the phone they can check for the recall that day and they said yes. But changed it when I showed up. I haven’t heard back since then. Here is the recall information; Manufacturer Recall Number26S30 NHTSA Recall Number26V268 They also have yet to notify me of the second recall on the vehicle causing engine fires. I only found out because I have a news app and saw an article. I have the Ford app and it “alerts me to recalls” but I’ve found out about every recall from the news not Ford until months after. Why aren’t they notifying customers promptly?

UNKNOWN OR OTHER

2025 Ford Bronco Raptor right passenger fender flew off at highway speed on JUN 10, 2026 - took it to Ford for repair, repaired, and it has happened again today JUL 23, 2026; was able to reattach fender with clasps still in place; have also notified local Ford Dealership on issue again.

STRUCTURE

Bronco hard top is beginning to warp really bad and delaminate. Classic problem happening with there and ford still refuses to come up with a real solution. Every day the warping gets worse and I’m just waiting for it to get bad enough so I can take it in and ford actually do something about it. The warping and delaminating also impacts the seals of the hardtop panels on the car. The top also rattles really bad. Absolutely crazy for an expensive car. It’s very obvious that climate and humidity have the largest impact on this issue and STILL they do nothing about it.

ELECTRICAL SYSTEM

On June 22, 2026, my 2025 Ford Bronco caught fire while parked outside a store. The vehicle had been parked for approximately five minutes when the fire began. There were no warning lights, alerts, unusual odors, or other indications of a problem before the incident. The fire and heavy smoke appeared to originate from the center console area near the gear shifter. The flames quickly spread throughout the driver’s side, center console, front passenger area, and the rest of the vehicle’s interior. The entire interior sustained severe fire and heat damage and was substantially melted. The responding fire department advised that temperatures inside the vehicle were well over 300 degrees. Firefighters disconnected the vehicle’s battery, after which the vehicle began to cool. Based on their initial observations, they indicated that the fire appeared to be electrical in nature. The vehicle had recently been filled with gasoline, which made the situation even more dangerous. Fortunately, no one was inside the Bronco, no other vehicles were parked nearby, and the fire department responded quickly. The vehicle has been transported to a repair facility but has not yet been inspected to determine the precise cause of the fire. I am extremely concerned that a nearly new vehicle could suddenly catch fire while turned off and parked, without any warning. This could have occurred while I was driving, with passengers inside, or while the Bronco was parked in my garage. Under those circumstances, the fire could have caused serious injury or death, destroyed my home, or endangered other people and property. I am submitting this complaint because I believe this incident presents a serious public-safety concern. I respectfully request that NHTSA investigate whether other 2025 Ford Bronco owners have experienced similar electrical fires and whether a defect exists that could place drivers, passengers, families, first responders, and the public at risk.

UNKNOWN OR OTHER

When the vehicle is in "Eco" mode, and an attempt is made to rapidly accelerate in an emergency situation, pressing the accelerator pedal to the floor results in a significant delay before *any* engine response is detected, far beyond what is reasonable for a normal gasoline powered vehicle. In several situations, I was in heavy traffic; traffic in the lane in which I was travelling was relatively slow. I attempted to change lanes into an adjacent lane in which traffic was moving much faster. When traffic allowed, I merged into the faster lane, and pressed the accelerator pedal to the floor. Prior to pressing the accelerator pedal, the vehicle was moving approximately 20 mph. Nothing happened for several seconds, and then the vehicle suddenly accelerated. During the period of non-response, traffic in the faster lane caught up to my vehicle. I am able to reproduce the issue 100%. The dealer's response is that "it's normal" (typical service response) and there was no attempt to investigate. I have driven several identical make/model vehicles belonging to friends, and one dealer vehicle (test drive) and they all exhibit the same issue. There are no warning lamps, errors, codes, or any indication that any system is faulty. The high latency in the throttle control system is clearly an ECU programming issue, and it increases the risk of collision. I have only observed this issue in models of this vehicle with an automatic transmission. I do own an identical model of this vehicle with a manual transmission, and this issue is not present.