1993 Ford Bronco

1993 Ford Bronco 2-DR. 4x4

Overall

Not Rated

Front Crash

Not Rated

Side Crash

Not Rated

Rollover

Not Rated

VEHICLE SPEED CONTROL:CRUISE CONTROL

FORD IS RECALLING 225,000 MY 1992-2003 ECONOLINE, MY 1993-1995 TAURUS SHO, MY 1992-1998 CROWN VICTORIA, MY 1993 BRONCO, F-SERIES, MY 1995-1997 F-SERIES SUPER DUTY STRIPPED CHASSIS, MY 1992-1998 MERCURY GRAND MARQUIS, AND MY 1992-1995 LINCOLN TOWN CAR VEHICLES. THE AFFECTED VEHICLES WERE PREVIOUSLY REPAIRED USING A WIRING HARNESS THAT IS NOT COMPATIBLE WITH THE VEHICLE CIRCUIT POLARITY.

Campaign: 08V051000

EXTERIOR LIGHTING

CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Campaign: 06E026000

VEHICLE SPEED CONTROL

ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.

Campaign: 07V336000

TIRES:TREAD/BELT

THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. EQUIPMENT DESCRIPTION: FORD IS REPLACING ALL FIRESTONE WILDERNESS AT 15, 16, AND 17 INCH TIRES MOUNTED ON FORD TRUCKS AND SUVS. FORD REPORTS TREAD SEPARATION CAN OCCUR DUE TO A COMBINATION OF THE SENSITIVITY OF THE TIRE DESIGN TO STRESS, AGING, AND MANUFACTURING DIFFERENCES BETWEEN PLANTS. FORD IS REPLACING THESE TIRES TO PREVENT POSSIBLE PREMATURE TIRE FAILURE. VEHICLE DESCRIPTION: THE VEHICLES LISTED BELOW MAY HAVE BEEN ORIGINALLY EQUIPPED WITH FIRESTONE WILDERNESS AT TIRES OR MAY HAVE HAD WILDERNESS AT TIRES INSTALLED DURING THE FIRESTONE RECALL LAUNCHED IN AUGUST 2000. CERTAIN 1991 THROUGHT 2002 FORD EXPLORER CERTAIN 2001 THROUGHT 2002 EXPLORER SPORT, AND SPORT TRAC CERTAIN 1997 THROUGH 2002 MERCURY MOUNTAINEER CERTAIN 1991 THROUGH 2001 RANGER CERTAIN 1999 THROUGH 2001 EXPEDITION CERTAIN 1991 THROUGH 1994, AND 1997 MODEL YEAR F-SERIES CERTAIN 1991 THROUGH 1994 BRONCO NOTE: BOTH ORIGINAL EQUIPMENT AND REPLACEMENT TIRES ARE AFFECTED.

Campaign: 01X001000

STRUCTURE:BODY:BUMPERS

THE U-CLIP STYLE NUTS THAT RETAIN THE FRONT BUMPERS TO THE FRONT BUMPER INNER ARMS CAN FRACTURE.

Campaign: 94V018000

PARKING BRAKE:CONVENTIONAL

THE PARKING BRAKE CONTROL SELF-ADJUST PAWL DOES NOT LINE UP PROPERLY WITH THE SELF-ADJUST RACHET CAUSING THE PAWL TO SLIP OVER ONE OR MORE TEETH IN THE RACHET.

Campaign: 94V169001

POWER TRAIN:TRANSFER CASE (4-WHEEL DRIVE)

THE TRANSFER CASES HAVE BEEN BUILT WITH THE WRONG ELECTRIC SHIFT MOTOR. THE TRANSFER CASES CAN SLIP OUT OF THE 4 X 4 HIGH GEAR POSITION DURING COASTING IN FORWARD GEARS OR WITH POWER APPLIED IN REVERSE GEAR.

Campaign: 93V089000

POWER TRAIN

MY 1993 FORD BRONCO HAS AN ESOF (ELECTRONIC SHIFT ON THE FLY) TRANSFER CASE. WITH FOUR WHEEL DRIVE ENGAGED, ON ROAD AND OFF, WHENEVER THE VEHICLE IS COASTING THE TRUCK WILL SUDDENLY ACT LIKE IT IS NO LONGER IN GEAR. SHIFTING INTO PARK AND AND BACK WILL NOT CHANGE ANYTHING. THE TRUCK MUST BE TAKEN OUT OF FOUR WHEEL DRIVE IN ORDER TO START DRIVING AGAIN. I BELIEVE THIS TO BE DANGEROUS AS IT COULD ALLOW ME TO NOT REACT IN THE CASE OF AN EMERGENCY. IT THINK THAT IT IS A SIMILAR PROBLEM TO THE RECALL 93V089000.

ELECTRICAL SYSTEM

TL* THE CONTACT OWNS A 1993 FORD BRONCO. WHILE DRIVING AT APPROXIMATELY 10 MPH, THE VEHICLE STALLED AND CAUSED ANOTHER VEHICLE TO CRASH INTO THE CONTACT'S VEHICLE. A POLICE REPORT WAS FILED AND THERE WERE UNKNOWN INJURIES SUSTAINED THAT REQUIRED MEDICAL ATTENTION. IT WAS DIAGNOSED THAT THE IGNITION SWITCH NEEDED TO BE REPLACED. THE CONTACT DID NOT DISCLOSE WHERE THE VEHICLE WAS TAKEN FOR DIAGNOSTIC TESTING. THE VEHICLE WAS NOT REPAIRED. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 05V017000 (ELECTRICAL SYSTEM). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.

POWER TRAIN

TL* THE CONTACT OWNS A 1993 FORD BRONCO. THE CONTACT WAS DRIVING APPROXIMATELY 40 MPH WHILE COASTING HE ATTEMPTED TO ACCELERATE AND THE VEHICLE WOULD NOT RESPOND. THE CONTACT STATED THAT THE DEFECT WAS ONLY OCCURRED AFTER THE VEHICLE WAS COASTING. THE VEHICLE WAS DIAGNOSED BY AN INDEPENDENT MECHANIC WHO DETERMINED THAT THE TRANSFER CASES SLIPPED OUT OF THE 4X4 GEAR DURING THE INCIDENT. THE CONTACT INDICATED THAT HE EXPERIENCED THE SAME DEFECT LISTED IN THE NHTSA CAMPAIGN NUMBER 93V089000 (POWER TRAIN) BUT THE MANUFACTURER DID NOT INCLUDE THE VEHICLE IN THE RECALL. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND NO SOLUTION WAS OFFERED. THE FAILURE MILEAGE WAS 37,000. UPDATE 4/7/14 VA THE CONSUMER REQUESTED ASSISTANCE WITH HAVING FORD REIMBURSE THE $1,500 FOR REPAIR OF THE VEHICLE. THE CONSUMER BELIEVES THE VEHICLE SHOULD HAVE BEEN INCLUDED IN THE RECALL. *JS

PARKING BRAKE

TL* THE CONTACT OWNS A 1993 FORD BRONCO. THE CONTACT STATED THAT WHILE PARKED, THE EMERGENCY BRAKE WAS ENGAGED AND FAILED TO RESPOND. THERE WAS A RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 94V169001 (PARKING BRAKE). THE MANUFACTURER WAS NOTIFIED AND STATED THAT THE VIN WAS NOT INCLUDED IN THE EXPIRED RECALL. THE VEHICLE WAS NEITHER DIAGNOSED NOR REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 135,000.

SERVICE BRAKES

TL* THE CONTACT OWNS A 1993 FORD BRONCO. THE CONTACT STATED THAT WHILE PARKED HE ATTEMPTED TO APPLY THE PARKING BRAKE BUT IT DROPPED TO THE FLOOR BOARD. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STATED THAT THE BRAKES WOULD HAVE TO BE REPLACED. AFTER THE REPAIRS THE FAILURE RECURRED. THERE WAS A RECALL UNDER NHTSA CAMPAIGN ID NUMBER: 94V169001 (PARKING BRAKE:CONVENTIONAL) THAT MAY BE RELATED TO THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THE VEHICLE WAS NOT INCLUDED IN THE RECALL. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 109,000.

VEHICLE SPEED CONTROL

TL*THE CONTACT OWNS A 1993 FORD BRONCO. THE CONTACT RECEIVED A RECALL NOTICE FOR THE VEHICLE SPEED CONTROL (NHTSA CAMPAIGN ID NUMBER 07V336000). THE DEALER STATED THAT THE PARTS WOULD NOT BE AVAILABLE UNTIL DECEMBER OF 2007. THE CONTACT FELT THAT THE WAIT TIME FOR THE RECALL REPAIR WAS EXCESSIVE. THERE HAD BEEN NO FAILURE TO DATE. THE CURRENT MILEAGE WAS 126,000. UPDATED 10/26/07. *JB

TIRES

1993 EDDIE BAUER BRONCO RIGHT FRONT TIRE BLEW OUT. *TS WHEN THE TIRE BLEWOUT THE CONSUMER LOST CONTROL O THE VEHICLE AND ENDED UP IN A SHALLOW DITCH. THE CONSUMER WAS ABLE TO GET THE VEHICLE BACK ON THE ROAD AND PUT THE SPARE TIRE ON. THE REMAINING TIRES WERE DRIVEN ANOTHER 10000 MILES THEN REMOVED DUE TO BULGES IN THE SIDEWALL. THE TIRES WERE T HEN STORED IN THE CONSUMER'S SHED. THE CONSUMER RECEIVED A RECALL ON THE TIRE AND CONTACTED THE MANUFACTURER. THE CONSUMER WAS TOLD TO TAKE THE TIRE TO THE TIRE DEALER AND HAVE THE TIRE SENT TO THEM. THE CONSUMER RECEIVED A LETTER FROM THE MANUFACTURER STATING THAT THE TIRES WERE NO LONGER UNDER WARRANTY BECAUSE THEY WEREN'T ON THE TRUCK. *NM

ELECTRICAL SYSTEM,VISIBILITY,UNKNOWN OR OTHER

TOGGLE SWITCH ON SUNROOF HAS ALREADY BEEN REPLACED ONCE AND NOW IT HAS GONE OUT AGAIN. DOES NOT STOP ON ITS OWN FOR OPEN AND CLOSE. I DON'T FEEL I SHOULD HAVE TO PAY FOR SOMETHING THAT CONTINUES TO BREAK.

STRUCTURE

RIGHT SIDE DASH BOARD LOOSE. NEED TO REPLACE THE BRACKET I THINK THERE WAS A RECALL ON IT.*AK

TIRES

ON TWO SEPERATE OCCASIONS, TIRE TREAD SEPARATED FROM THE TIRES WHEN TRAVELING 60-65 MPH. THE TIRES ARE FIRESTONE FIREHAWK ATX 33X12.50R15LT MOUNTED ON A 1993 FORD BRONCO. ON THE SECOND OCCASION, THE TREAD SEPARATION RESULTED IN LOSS OF CONTROL OF THE VEHICLE AND A SINGLE CAR ACCIDENT INTO A GAURD RAIL. THE SECOND FAILED TIRE IS STILL AVAILABLE. ALL FIRESTONE TIRES HAVE SINCE BEEN REPLACED ON THE VEHICLE.