1996 Ford Bronco

1996 Ford Bronco 2-DR. 4x4

Overall

Not Rated

Front Crash

Not Rated

Side Crash

Not Rated

Rollover

Not Rated

VEHICLE SPEED CONTROL

ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH SPEED CONTROL, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT, SMOKE, OR BURN.

Campaign: 05V388000

EXTERIOR LIGHTING

CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Campaign: 06E026000

POWER TRAIN

TRANSMISSION JUMPS OUT OF OVERDRIVE, AFTERWARDS HARD SHIFTS IN ALL GEARS AFTER HIGH RPMS. THE FIX IS TO STOP, CUT THE ENGINE OFF AND THE TRANSMISSION RESETS FOR LACK ON A BETTER TERM. WHEN THE BRONCO IS IN OD AND IS JUST CRUSING, NOT IN A PULL, IS WHEN THE OD JUMPS OUT. LIKE ANY OTHER THING IT DOES NOT HAPPEN ALL THE TIME.

EXTERIOR LIGHTING

HEAD LIGHT DIMMER SWITCH/TURN SIGNAL SWITCH. AFTER HEAD LIGHTS HAVE BEEN RUNNING FOR A FEW MINUTES, THE HEAD LIGHTS WILL BEGIN TO FLASH ON/OFF IN EITHER HIGH BEAMS OR LOW BEAMS. I HAVE FOUND THE ISSUE TO BE IN THE HIGH BEAM SWITCH ITSELF. IF THIS HAD HAPPENED ON A BUSY STREET OR IN A LOCATION WHERE PEOPLE WERE CROSSING THE ROAD IT COULD HAVE BEEN VERY BAD. RESEARCH SHOWED THIS TO BE A VERY COMMON ISSUE AND SHOULD BE CHANGED. THERE IS EVEN A HARNESS FOR SALE THAT ROUTES POWER AROUND THIS SWITCH AND THROUGH A RELAY SETUP TO CORRECT THIS ISSUE. I'M SURE FORD SHOULD BE FIXING THIS ISSUE BEFORE SOMEONE GETS HURT, DUE TO INABILITY TO SEE... *TR

VEHICLE SPEED CONTROL

TL* THE CONTACT OWNS A 1996 FORD BRONCO. WHILE PARKED, THE CONTACT NOTICED SMOKE COMING FROM UNDER THE HOOD. THE CONTACT ATTEMPTED TO EXTINGUISH THE FIRE WITH A FIRE EXTINGUISHER BUT WAS UNABLE TO CONTROL THE FIRE. THE FIRE DEPARTMENT REPORTED TO THE SCENE AND A REPORT WAS FILED. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER: 05V388000 (VEHICLE SPEED CONTROL) BUT WAS ADVISED BY THE MANUFACTURER THAT THE VIN WAS NOT INCLUDED IN THE RECALL. THE VEHICLE WAS DESTROYED. THE APPROXIMATE FAILURE WAS 180,000.

TIRES

TL*THE CONTACT OWNS A 1996 FORD BRONCO WITH INDICO THORNBIRD 385* 14 * 16 TIRES(NA) DOT NUMBER KPBC80507. THE TIRES WERE VIBRATING; THEREFORE, THE CONTACT HAD THEM ROTATED. DURING THE ROTATION THE CONTACT WAS TOLD THAT THE LINING INSIDE OF ALL FOUR TIRES CURLED UP. THE MANUFACTURER INSISTED THAT THIS WAS NOT A PREVIOUS CONCERN ON INDICO TIRES. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE ON THE TIRES WAS 4000.

VEHICLE SPEED CONTROL

1996 FORD BRONCO CAUGHT FIRE OVER WEEKEND WHILE MY FAMILY AND I WERE DRIVING HOME. MONDAY FORD HAD IT TOWED INTO THE LOCAL DEALERSHIP TO REPAIR AND NOW, THREE DAYS LATER THEY ARE TELLING ME THAT THEY WILL NOT REPAIR IT SINCE I KNEW ABOUT THE PROBLEM. I ARGUED THAT I HAD NO IDEA AND THEY SAY THAT THEY MAILED ME A CARD AT THE END OF 2007. THE VEHICLE IS AT THE DEALERSHIP AND THEY WANT ME TO COME PAY CASH FOR THE REAPAIRS. PLEASE HELP.

VEHICLE SPEED CONTROL

TL*THE CONTACT OWNS 1996 FORD BRONCO. THE CONTACT STATED THAT WHEN THE CRUISE CONTROL SWITCH WAS ENGAGED, THE VEHICLE BEGIN TO ACCELERATE BEYOND ITS SET SPEED. THE CONTACT WAS DRIVING 55 MPH. THE CONTACT DID NOT CALL THE MANUFACTURER. THE DEALER INFORMED THE CONTACT THAT THE CRUISE CONTROL SWITCH NEEDED TO BE REPLACED. THE CONTACT REPLACED THE CRUISE CONTROL WITH A USED CRUISE CONTROL SWITCH AND THAT HAS REMEDIED THE FAILURE. THE CONTACT STATED THAT THE FAULTY CRUISE CONTROL COULD HAVE CAUSED A CRASH. THE FAILURE MILEAGE WAS 203,000.

ELECTRICAL SYSTEM,VEHICLE SPEED CONTROL

TL*THE CONTACT OWNS A 1996 FORD BRONCO. SPARKS WERE DRIPPING BELOW THE DRIVER'S SIDE OF THE VEHICLE. THE CONTACT'S NEIGHBOR ATTEMPTED TO EXTINGUISH THE FIRE WITH THE GARDEN HOSE, BUT WAS UNSUCCESSFUL. EVENTUALLY, SEVERAL NEIGHBORS WERE ABLE TO EXTINGUISH THE FLAMES WITH GARDEN HOSES AND FIRE EXTINGUISHERS. THE FLAMES APPEARED FROM THE DRIVER'S SIDE WHEEL AND INSIDE THE PASSENGER COMPARTMENT. THE POLICE AND FIRE DEPARTMENTS WERE CALLED TO THE SCENE AND A REPORT WAS FILED. THE FIRE DEPARTMENT CONTINUED TO EXTINGUISH THE FIRE INSIDE THE VEHICLE. THEY ALSO DISCONNECTED THE BATTERY IN FEAR THAT IT MAY CAUSE AN ELECTRICAL FIRE. THE VEHICLE WAS DEEMED AS DESTROYED BY THE INSURANCE COMPANY. THE CAUSE OF THE FAILURE WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE LESS THAN 130,000. UPDATED 4/28/09 *CN UPDATED 04/30/09.*JB UPDATED 12/08/09. *LJ UPDATED 12/10/09.*JB

VEHICLE SPEED CONTROL

TL*THE CONTACT OWNS A 1996 FORD BRONCO. WHILE THE VEHICLE WAS PARKED IN A LOT, IT SUDDENLY CAUGHT FIRE. FLAMES AND SMOKE APPEARED FROM THE HOOD OF THE VEHICLE. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE AND A REPORT WAS FILED. THE VEHICLE HAS NOT YET BEEN REPAIRED. THROUGH NUMEROUS RESEARCH, THE CONTACT DISCOVERED NHTSA CAMPAIGN ID NUMBER 05V388000 (VEHICLE SPEED CONTROL). HE CALLED THE MANUFACTURER AND THEY ACKNOWLEDGED THE DEFECT AND STATED THAT THEY WOULD INVESTIGATE TO DETERMINE IF THE FIRE WAS LINKED TO THE RECALL. THE CONTACT BELIEVES THAT HE SHOULD HAVE RECEIVED A RECALL NOTICE. THE CURRENT AND FAILURE MILEAGES WERE 136,000.

VEHICLE SPEED CONTROL

MY VEHICLE WAS PARKED IN THE YARD FOR SEVERAL HOURS, AND I WAS WORKING IN MY SHOP ABOUT 30 FEET AWAY. I STARTED SMELLING BURNING PLASTIC, AND I THOUGHT THAT THE NEIGHBORS WERE BURNING TRASH. WHEN THE ODOR BECAME STRONGER, I LOOKED OUT THE DOOR OF MY SHOP. THERE WAS SMOKE POURING OUT FROM UNDER THE HOOD, AND FROM THE FRONT OF THE GRILLE. I RAN AND GOT THE GARDEN HOUSE, AND STUCK IT IN THE WHEELWELL, IN A HOLE THAT HAD BURNED THROUGH THE INNER FENDER. ONCE THE FIRE SEEMED NEARLY OUT, I OPENED THE HOOD TO FINISH QUENCHING THE FLAMES. *TR

ELECTRICAL SYSTEM,VEHICLE SPEED CONTROL

DROVE 1996 FORD BRONCO 3 BLOCKS AND PARKED IT IN CLOSED UP GARAGE. CAME BACK A FEW DAYS LATER AND FOUND IT BURNT UP. FIRE BURNT UNDER HOOD AND DASH. IT SCORCHED THE VEHICLE PARKED NEXT TO IT AND DAMAGED INSIDE OF GARAGE. *TR