1992 Ford Crown Victoria

1992 Ford Crown Victoria 4-DR.

Overall

Not Rated

Front Crash

Not Rated

Side Crash

Not Rated

Rollover

Not Rated

VEHICLE SPEED CONTROL:CRUISE CONTROL

FORD IS RECALLING 225,000 MY 1992-2003 ECONOLINE, MY 1993-1995 TAURUS SHO, MY 1992-1998 CROWN VICTORIA, MY 1993 BRONCO, F-SERIES, MY 1995-1997 F-SERIES SUPER DUTY STRIPPED CHASSIS, MY 1992-1998 MERCURY GRAND MARQUIS, AND MY 1992-1995 LINCOLN TOWN CAR VEHICLES. THE AFFECTED VEHICLES WERE PREVIOUSLY REPAIRED USING A WIRING HARNESS THAT IS NOT COMPATIBLE WITH THE VEHICLE CIRCUIT POLARITY.

Campaign: 08V051000

VEHICLE SPEED CONTROL

ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.

Campaign: 07V336000

FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY

IN ORDER TO ENHANCE POLICE OFFICE SAFETY, MODEL YEAR 1992-2003 CROWN VICTORIA POLICE INTERCEPTOR (CVPI) VEHICLES WILL BE EQUIPPED WITH SHIELDS DESIGNED TO HELP PROTECT THE FUEL TANK IN HIGH-SPEED REAR-IMPACT CRASHES. FORD ALSO WILL BE OFFERING AN OPTIONAL TRUNK PACKAGE DESIGNED TO IMPROVE THE SAFE TRANSPORT OF SHARP-EDGED, HEAVY EQUIPMENT IN THESE VEHICLES.

Campaign: 02I003000

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS

Campaign: 96I002000

ELECTRICAL SYSTEM

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE SPEED CONTROL DEACTIVATION SWITCH CAN DEVELOP A RESISTIVE SHORT IN THE ELECTRICAL CIRCUIT THAT COULD POTENTIALLY RESULT IN AN UNDERHOOD FIRE. A FIRE IS POSSIBLE BOTH WHEN THE VEHICLE IS RUNNING AND WHEN THE VEHICLE ENGINE IS OFF. ALSO, THE SHORT COULD DISABLE THE SPEED CONTROL SYSTEM OR CAUSE THE BRAKE LIGHT FUSE TO OPEN.

Campaign: 99V124000

UNKNOWN OR OTHER

INCORRECT INSTRUMENT PANEL WIRING ASSEMBLIES IN SOME VEHICLES WILL NOT ACTUATE THE "ANTI-LOCK" BRAKE WARNING LIGHTS.

Campaign: 92V023000

SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT

VEHICLE DESCRIPTION: CERTAIN 1996-1999 FORD CROWN VICTORIA POLICE, FLEET, NATURAL GAS, AND 1996-1999 LINCOLN TOWN CAR LIMOUSINE VEHICLES THAT WERE PRODUCED WITH A LOWER CONTROL ARM BALL JOINT CONTAINING A ONE PIECE BEARING; AND 1990-1996 FORD CROWN VICTORIA POLICE, FLEET, AND NGV VEHICLES AND 1990-1996 LINCOLN TOWN CAR LIMOUSINE VEHICLES THAT HAVE BEEN SERVICED WITH EITHER A BALL JOINT CONTAINING THE ONE-PIECE BEARING OR A FRONT LOWER CONTROL ARM CONTAINING A BALL JOINT WITH A ONE-PIECE BEARING. THE ONE-PIECE BEARING WITHIN THE LOWER CONTROL ARM BALL JOINT CAN WEAKEN SLOWLY DURING USE AND EVENTUALLY CRACK. THIS COULD RESULT IN SEPARATION OF THE BALL AND CAP OF THE JOINT, ALLOWING THE CONTROL ARM TO DROP TO THE GROUND.

Campaign: 98V322000

SEATS:FRONT ASSEMBLY:POWER ADJUST

AN UNUSED POWER SEAT HARNESS CONNECTOR IS POSITIONED ON THE RUBBER FLOOR MAT UNDER THE SEAT. IF THE VEHICLE IS OPERATED IN COLD WEATHER IN AREAS THAT HAVE LARGE AMOUNTS OF SALT USED FOR SNOW AND ICE CONTROL, A PUDDLE OF SALTWATER CAN ACCUMULATE ON THE RUBBER FLOOR MATS, REPEATEDLY WETTING THE CONNECTOR. THIS WILL RESULT IN CORROSION OF THE CONNECTOR, CAUSING A CURRENT TO FLOW BETWEEN THE TERMINALS WITHOUT TRIPPING THE CIRCUIT BREAKER.

Campaign: 93V193000

LATCHES/LOCKS/LINKAGES:HOOD:LATCH

VEHICLE DESCRIPTION: POLICE AND TAXI VEHICLES. THE HOOD LATCH STRIKER CAN WEAR OR BECOME DETACHED FROM THE HOOD.

Campaign: 97V024000

FUEL SYSTEM, GASOLINE,VEHICLE SPEED CONTROL

CAR KEPT ACCELERATING AFTER I LET OFF. I HAD TO STAND ON THE BRAKES TO MAKE IT STOP. THE FRONT WHEELS LOCKED UP BUT THE CAR KEPT MOVING. USING 250-280 POUNDS OF PRESSURE ON THE BRAKE PEDAL I FINALLY STOPPED WITHOUT INCIDENT. THE INCIDENT CAN BE VIEWED AT YOUTUBE. IT IS TITLED RAM CAM EPISODE 5. IT IS THE LAST PART OF THE VIDEO. *TR

VEHICLE SPEED CONTROL

TL* THE CONTACT OWNS A 1992 FORD CROWN VICTORIA. THE CONTACT STATED THAT THE CRUISE CONTROL WOULD NOT DEACTIVATE WHEN THE BRAKES WERE DEPRESSED AND WOULD ACCELERATE INSTEAD. THE DEALER WAS CONTACTED AND THEY INFORMED HIM THAT THEY WOULD RETURN HIS CALL WITHIN A FEW DAYS. THE MANUFACTURER WAS CONTACTED BUT WOULD NOT ASSIST DUE TO THE AGE OF THE VEHICLE. NO FURTHER ASSISTANCE WAS OFFERED. THE FAILURE MILEAGE WAS 103,500. UPDATED 08/10/11*LJ THE CONSUMER STATED WHEN THE CRUISE CONTROL WAS ACTIVATED, THE VEHICLE WOULD ACCELERATE INSTEAD OF DECELERATE WHEN THE BRAKE WAS APPLIED. UPDATED 08/12/11*JB

ELECTRICAL SYSTEM,EXTERIOR LIGHTING

1.RIDING ONE NIGHT HEADLIGHTS JUST GO OFF ON THE HIGHWAY,SMELLED PLASTIC BURNING/ 2.HEADLIGHT SWITCH OVERHEATING MELTING PLUG CONNECTED TO WIRING/ HAPPENS ALL THE TIME/ FIRE OR EVEN CAUSE A WRECK OR GET A TRAFFIC VIOLATION. 3.CHANGED SWITCH CHANGED PLUG SAME THING HAPPENED AGAIN &AGAIN,LOOKED AT PARTS ON OTHER CARS SAME MODEL SAME YEAR DIFFERENT MODEL DIFFERENT YEAR SAME PROBLEM IN THE SAME SPOT!! [ THE FORD 1992 CROWN VICTORIA]. *TR

FUEL SYSTEM, GASOLINE,VEHICLE SPEED CONTROL,UNKNOWN OR OTHER

TL*THE CONTACT OWNS A 1992 FORD CROWN VICTORIA. THE CONTACT RECEIVED A RECALL NOTICE FOR THE VEHICLE SPEED CONTROL: CRUISE CONTROL. WHILE AT A LOCAL REPAIR SHOP, THE MECHANIC IDENTIFIED ANOTHER FAILURE IN THE FUEL LINE. THE DEALER INFORMED THE CONTACT THAT THEY HAD THE PARTS AVAILABLE AND ADVISED HER TO BRING THE VEHICLE IN FOR REPAIR. AT THE TIME, SHE COULD NOT DRIVE TO THE DEALER DUE TO THE FUEL LINE FAILURE. THE PURCHASE DATE AND RECALL NUMBER WERE UNKNOWN. THE FAILURE AND CURRENT MILEAGES WERE 91,000. UPDATED 07/07/08. *LJ WATER LEAKED INSIDE THE VEHICLE. UPDATED*JB

STEERING,POWER TRAIN

TL*THE CONTACT OWNS A 1992 CROWN VICTORIA. WHILE DRIVING SPEEDS RANGING FROM 20 TO 40 MPH, THE VEHICLE BEGAN IDLING AND ATTEMPTED TO SHUT OFF. THE VEHICLE WAS SHUT OFF AND RESTARTED. THE CONTACT NOTICED WATER LEAKING FROM THE BOTTOM OF THE TRANSMISSION AND THE CHECK ENGINE LIGHT ILLUMINATED. THE STEERING COLUMN WAS INSTALLED BACKWARDS, WHICH CAUSED THE FEATURES OF THE STEERING COLUMN NOT TO OPERATE NORMALLY. THE CURRENT MILEAGE WAS 232,871 AND THE APPROXIMATE FAILURE MILEAGE WAS 200,000. UPDATED 03/23/09. *LJ UPDATED 03/24/09*JB

SERVICE BRAKES, HYDRAULIC

TL*THE CONTACT OWNS A 1992 FORD CROWN VICTORIA. WHEN THE CONTACT PLACES HER VEHICLE IN DRIVE AND DEPRESSES THE ACCELERATOR PEDAL, THE VEHICLE SUDDENLY ACCELERATES TO 40 MPH AND THE ENGINE RPMS INCREASE. SHE MUST APPLY THE BRAKES WITH BOTH FEET IN ORDER FOR THE VEHICLE TO COME TO A COMPLETE STOP. AFTERWARDS, SHE SMELLS THE SCENT OF BURNING PLASTIC. THE MECHANIC STATED THAT THE FAILURE COULD BE CAUSED BY THE BRAKE PRESSURE SWITCH. HE INFORMED THE CONTACT THAT BRAKE FLUID MAY BE FLOWING TO THE SWITCH AND CAUSING THE HEAT TO ACTIVATE. THIS CAUSES THE VEHICLE TO ACCELERATE AND COULD RESULT IN A FIRE. THE CONTACT ALSO STATED THAT HE LOSES BRAKE POWER OCCASIONALLY, EVEN THOUGH BRAKE FLUID IS PRESENT. HE ALSO NOTICED SMOKE COMING FROM THE REAR OF THE VEHICLE, WHICH IS CAUSING THE TRANSMISSION TO FAIL. THE POWERTRAIN WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 33,000.

VEHICLE SPEED CONTROL

I PARKED MY 1992 FORD CROWN VICTORIA ON THE STREET WHILE I WAS AT MY HOME FOR 45 MINUTES. I DECIDED TO LEAVE TO GO SOMEWHERE ELSE. WHEN I GOT TO MY CAR, I SMELLED BURNING AND SAW WISPS OF SMOKE COMING FROM UNDERNEATH MY ENGINE AREA. I QUICKLY OPENED MY DRIVER'S SIDE DOOR AND SMELLED SMOKE AND POPPED THE HOOD. INSIDE, THERE WAS A SMALL FIRE (GRAPEFRUIT SIZE) IN FRONT OF THE STEERING COLUMN. I RAN INTO THE HOUSE AND GOT SOME WATER AND DOUSED THE FLAMES. I WAS VERY LUCKY, BECAUSE I SEEM TO HAVE CAUGHT THE FIRE WITHIN A FEW MINUTES OF WHEN IT STARTED. I TOOK THE CAR INTO MY LOCAL FORD DEALERSHIP, AND THE PROBLEM WAS THE CRUISE CONTROL DEACTIVATION SWITCH. THEY REPLACED THE CRUISE CONTROL SWITCH AND A WIRING HARNESS THAT HAD BURNED (AT MY EXPENSE). THEY INFORMED ME THAT THE PROBLEM WAS FIXED. I CALLED FORD TO DISCUSS THIS ISSUE, AND THEY INFORMED ME THAT MY CAR WAS UNDER RECALL BACK IN 1999, AND THE PROBLEM WAS FIXED ON 7/7/1999 WHEN MY DAD OWNED THE CAR. THIS WAS ACTUALLY EVEN MORE CONCERNING TO ME, BECAUSE THE REPLACEMENT SWITCH, WHICH SUPPOSEDLY FIXED THE ORIGINAL SPONTANEOUS COMBUSTION PROBLEM, SEEMS TO BE DEFECTIVE AS WELL!! SO MY CAR IS NOW ON ITS SECOND "FIXED" CRUISE CONTROL SWITCH. I AM ALSO CONCERNED FROM MY DISCUSSION WITH THE NHTSA REPRESENTATIVE. HE SAID THAT NO RECALLS CAN BE ISSUED FOR VEHICLES THAT ARE OVER 10 YEARS OLD. HE THEN TOLD ME THAT MY COMPLAINT WOULD NOT DO ANYTHING SINCE MY CAR WAS OVER 10 YEARS OLD. I DON'T EXPECT TO BE REIMBURSED FROM MY EXPERIENCE WITH THE FIRE, HOWEVER, THIS IS DISTURBING TO ME KNOWING THAT MY COMPLAINT COULD BE DISMISSED OUT OF HAND. I WANT TO MAKE SURE THAT OTHERS DON'T HAVE THIS SAME PROBLEM. ESPECIALLY WHEN DEALING WITH A CAR SETTING ITSELF ON FIRE WHEN IT IS NOT RUNNING. THIS COMPLAINT SHOULD BE THOROUGHLY EVALUATED BEFORE DISMISSING IT. IF THE CAR HAD BEEN PARKED IN MY GARAGE WHILE I SLEPT, IT COULD HAVE EASILY BURNED DOWN THE HOUSE, OR KILLED SOMEONE. *NM

STEERING

THIS PROBLEM CONCERNS THE STEERING COLUMN OF A 1992 FORD CROWN VICTORIA RUBBING AGAINST A METAL GAS LINE UNTIL LARGE AMOUNTS OF GAS SPILL ONTO THE HOT ENGINE AND CAUSE A SAFETY OF LIFE PROBLEM... AS LONG AS THE ENGINE REMAINS ON THE ELECTRIC FUEL PUMP WILL CONTINUE TO PUMP GAS ONTO THE FIRE CAUSED BY THE FAULT. PLEASE NOTICE THAT I AM AN ENGINEER AND THIS IS NOT A SMALL MATTER - IT INVOLVES MANY THOUSANDS OF VEHICLES AND AN IDENTICAL VEHICLE HAS HAD A RECALL - YET FORD HAS NOT HAD A RECALL ON THIS MODEL ALTHOUGH I TOOK THIS ISSUE TO THE TOP OF FORD MOTOR COMPANY. THE ISSUE DEALS WITH A GASOLINE LEAK CAUSED BY THE STEERING COLUMN RUBBING ON A METAL GAS LINE - CAUSING GASOLINE TO LEAK FROM THE WORN GAS LINE IN LARGE AMOUNTS. I FIRST NOTICED THE LEAK FROM THE SMELL OF GAS - THEN I NOTICED LARGE POOLS OF GAS LEAKING FROM UNDER MY CAR. AFTER INVESTIGATING THE CAUSE, WHICH WAS THE ROTATING STEERING COLUMN RUBBING ON THE GAS LINE, I CONTACTED THE FORD DEALER AND I CONTACTED FORD MOTOR COMPANY WHO PUT ME OFF TO AN AREA PERSON WHO REBUFFED MY COMPLAINT. THE DEALER SHOWED ME A RECALL FOR THE LINCOLN CONTINENTAL WITH THE SAME EXACT PROBLEM.... THE LINCOLN CONTINENTAL AND THE FORD CROWN VICTORIA ARE IDENTICAL IN THIS RESPECT.... THE RECALL SHOWED THE EXACT GAS LINE AND THE PROBLEM.... CHECK FOR YOURSELF.... THE LINCOLN CONTINENTAL AND THE FORD CROWN VICTORIA ARE EXACTLY THE SAME UNDER THE HOOD. THE RECALL SHOWED THE SAME GAS LINE AND THE SAME PROBLEM. HOWEVER, IF YOU ARE A CREDIBLE ORGANIZATION, YOU WILL RESEARCH THIS BY SIMPLY LOOKING AT THE RECALL FOR THE LINCOLN CONTINENTAL AND WONDER WHY THE RECALL NEVER HAPPENED FOR THE FORD CROWN VICTORIA.... KEEP IN MIND THAT WE ARE TALKING ABOUT A SAFETY OF LIFE SITUATION..... THE GAS LEAK IS CONSIDERABLE..... IT WAS A RECALL ON THE LINCOLN CONTINENTAL AND YET, NEVER SHOWED UP FOR THE FORD CROWN VICTORIA. E-MAIL ME BACK I CAN'T FIGURE OUT YOUR SERIAL NUMBER THANK YOU, *NM

ELECTRICAL SYSTEM

MY FATHER BOUGHT A USED 1992 FORD CROWN VICTORIA LS. WHEN YOU TURN ON THE PARK OR DRIVING LIGHTS, THE ENTIRE DASHBOARD IS SO DIM YOU CAN HARDLY READ THE SPEEDOMETER. I HAVE BEEN DRIVING THE CAR FOR MY FATHER AND IT IS AN ACCIDENT WAITING TO HAPPEN. IN THE EVENING, THE PROBLEM RESOLVES ITSELF, IT IS DURING THE DAY.*AK

ELECTRICAL SYSTEM

WHILE DRIVING 60 MPH THE BRAKE SENSOR LIGHT CAME ON AND THE VEHICLE BEGAN SMOKING WITHOUT WARNING. WHEN THE CONSUMER PULLED OFF THE ROAD HE NOTICED THAT FLAMES WERE COMING FROM THE FRONT END. AS A RESULT THE VEHICLE WAS CONSIDERED A TOTAL LOSS. *NM THE FIRE DEPARTMENT INDICATED IT WAS A ELECTRICAL FIRE. *BF