1998 Ford Crown Victoria

1998 Ford Crown Victoria 4-DR.

Overall

Not Rated

Front Crash

Not Rated

Side Crash

Not Rated

Rollover

Not Rated

STEERING

Dorman Products, Inc. (Dorman) is recalling certain model Dorman Steering Shafts, part number 425-359, Solutions Steering Shafts, part number 7-0359, and OE Solutions Steering Shafts, part number 425-359, manufactured April 17, 2014, to September 28, 2015. These aftermarket replacement steering shafts are sold for use in 1995-2002 Ford Crown Victoria, Mercury Grand Marquis, and Lincoln Town Car vehicles. These steering shafts may separate during operation if the integral fastener is loose or missing and if the interfacing vehicle shaft is compressed in length.

Campaign: 15E082000

FUEL SYSTEM, GASOLINE

CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.

Campaign: 06E056000

VEHICLE SPEED CONTROL:CRUISE CONTROL

FORD IS RECALLING 225,000 MY 1992-2003 ECONOLINE, MY 1993-1995 TAURUS SHO, MY 1992-1998 CROWN VICTORIA, MY 1993 BRONCO, F-SERIES, MY 1995-1997 F-SERIES SUPER DUTY STRIPPED CHASSIS, MY 1992-1998 MERCURY GRAND MARQUIS, AND MY 1992-1995 LINCOLN TOWN CAR VEHICLES. THE AFFECTED VEHICLES WERE PREVIOUSLY REPAIRED USING A WIRING HARNESS THAT IS NOT COMPATIBLE WITH THE VEHICLE CIRCUIT POLARITY.

Campaign: 08V051000

EQUIPMENT:MECHANICAL:INTEGRATED JACK/LEVELER/STABILIZER

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THESE VEHICLES HAVE JACKING INSTRUCTIONS WHICH, IF FOLLOWED, COULD CAUSE THE VEHICLE OPERATOR TO PLACE THE JACK ON A FRAME WELD WHEN ATTEMPTING TO RAISE A REAR WHEEL. IF THE VEHICLE IS JACKED UP WITH THE JACK PLACED ON THE FRAME WELD AND IF THE VEHICLE IS FREE TO ROLL (WHEELS NOT BLOCKED OR CHOCKED), THE JACK COULD YIELD AND THE VEHICLE MAY DROP SUDDENLY.

Campaign: 00V200000

SEAT BELTS:FRONT:ANCHORAGE

VEHICLE DESCRIPTION: PASSENGER VEHICLES USING AFTERMARKET FRONT PASSENGER SIDE SEAT BELT ASSEMBLIES THAT WERE SOLD BY FORD PARTS DEPARTMENTS FROM JANUARY 1, THROUGH JUNE 13, 2000. THESE SEAT BELT ASSEMBLIES FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 209, "SEAT BELT ASSEMBLIES." THE EQUIPMENT INVOLVED IS SERVICE STOCK SEAT BELT ASSEMBLIES, MODEL NOS. H 9977, H 9979, T 9063, AND T 9217, BUILT BY TRW VEHICLE SAFETY SYSTEMS, INC. (TRW) MANUFACTURED FROM JUNE 1, 1998 THROUGH MAY 21, 2000. SOME OF THESE SEAT BELT ASSEMBLIES MAY HAVE BEEN INSTALLED AS SERVICE REPLACEMENT EQUIPMENT ON THE VEHICLES INVOLVED IN THE RECALL.

Campaign: 00V157002

VEHICLE SPEED CONTROL

ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.

Campaign: 07V336000

FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY

IN ORDER TO ENHANCE POLICE OFFICE SAFETY, MODEL YEAR 1992-2003 CROWN VICTORIA POLICE INTERCEPTOR (CVPI) VEHICLES WILL BE EQUIPPED WITH SHIELDS DESIGNED TO HELP PROTECT THE FUEL TANK IN HIGH-SPEED REAR-IMPACT CRASHES. FORD ALSO WILL BE OFFERING AN OPTIONAL TRUNK PACKAGE DESIGNED TO IMPROVE THE SAFE TRANSPORT OF SHARP-EDGED, HEAVY EQUIPMENT IN THESE VEHICLES.

Campaign: 02I003000

FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY

ON CERTAIN NATURAL GAS VEHICLES, IF A FLAME FROM A VEHICLE INTERIOR FIRE BECOMES LOCALLY DIRECTED AT THE NATURAL GAS FUEL TANK LOCATED IMMEDIATELY BEHIND THE REAR SEAT, THE FLAME COULD DAMAGE THE FIBERGLASS WRAP ON THE TANK WEAKENING THE TANK.

Campaign: 03V472000

SEAT BELTS:FRONT:ANCHORAGE

VEHICLE DESCRIPTION: PASSENGER VEHICLES USING AFTERMARKET DRIVER'S SEAT BELT ASSEMBLIES THAT WERE SOLD BY FORD PARTS DEPARTMENTS FROM JANUARY 1, THROUGH JUNE 13, 2000. THESE SEAT BELT ASSEMBLIES FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 209, "SEAT BELT ASSEMBLIES." THE EQUIPMENT INVOLVED IS SERVICE STOCK SEAT BELT ASSEMBLIES, MODEL NOS. H 9977, H 9979, T 9063, AND T 9217, BUILT BY TRW VEHICLE SAFETY SYSTEMS, INC. (TRW) MANUFACTURED FROM JUNE 1, 1998 THROUGH MAY 21, 2000. SOME OF THESE SEAT BELT ASSEMBLIES MAY HAVE BEEN INSTALLED AS SERVICE REPLACEMENT EQUIPMENT ON THE VEHICLES INVOLVED IN THE RECALL.

Campaign: 00V157001

SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT

VEHICLE DESCRIPTION: CERTAIN 1996-1999 FORD CROWN VICTORIA POLICE, FLEET, NATURAL GAS, AND 1996-1999 LINCOLN TOWN CAR LIMOUSINE VEHICLES THAT WERE PRODUCED WITH A LOWER CONTROL ARM BALL JOINT CONTAINING A ONE PIECE BEARING; AND 1990-1996 FORD CROWN VICTORIA POLICE, FLEET, AND NGV VEHICLES AND 1990-1996 LINCOLN TOWN CAR LIMOUSINE VEHICLES THAT HAVE BEEN SERVICED WITH EITHER A BALL JOINT CONTAINING THE ONE-PIECE BEARING OR A FRONT LOWER CONTROL ARM CONTAINING A BALL JOINT WITH A ONE-PIECE BEARING. THE ONE-PIECE BEARING WITHIN THE LOWER CONTROL ARM BALL JOINT CAN WEAKEN SLOWLY DURING USE AND EVENTUALLY CRACK. THIS COULD RESULT IN SEPARATION OF THE BALL AND CAP OF THE JOINT, ALLOWING THE CONTROL ARM TO DROP TO THE GROUND.

Campaign: 98V322000

ELECTRICAL SYSTEM

TL* THE CONTACT OWNS A 1998 FORD CROWN VICTORIA. THE CONTACT STATED THAT WHILE ATTEMPTING TO START THE VEHICLE, SMOKE EMITTED FROM THE VEHICLE. THE CONTACT STATED THAT THE FUSE WHICH CONTROLS THE IGNITION COILS AND THE POWERTRAIN CONTROL MODULE UNDER THE DASHBOARD BLEW. THE VEHICLE WAS DIAGNOSED BY AN INDEPENDENT MECHANIC WHO STATED THAT THERE WAS AN ELECTRICAL SHORT TO THE GROUND WIRE FOR THE ELECTRICAL SYSTEM THE VEHICLE WAS NOT REPAIRED. BILL BROWN FORD LOCATED AT (32222 PLYMOUTH RD, LIVONIA, MI 48150 (734) 399-4244) WAS CONTACTED HOWEVER, AN APPOINTMENT WAS NOT AVAILABLE TO HAVE THE VEHICLE DIAGNOSED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE BUT OFFERED NO ASSISTANCE. THE APPROXIMATE FAILURE MILEAGE WAS 237,000.

SUSPENSION,ELECTRICAL SYSTEM,ELECTRONIC STABILITY CONTROL (ESC)

HAD MY CAR SINCE 2014 I WORKED HARD TO BUY IT. IT DROVE PRETTY DECIDE UNTILL ELECTRIC PROBLEMS STARTED TO OCCUR. THEN MY PASSANGER SIDE WHEEL FOLDED IN WHILE OPERATING WITH MY KIDS LIFE OR DEATH SITUATION IM JUST A HARD WORKING FATHER TRYING TO PROVIDE A SAFE TRANSPORTATION FOR MY FAMILY

ENGINE

TL* THE CONTACT OWNS A 1998 FORD CROWN VICTORIA. WHILE DRIVING APPROXIMATELY 45 MPH, THE CONTACT NOTICED SMOKE UNDER THE HOOD OF THE VEHICLE. THE CONTACT COASTED THE VEHICLE TO THE SIDE OF THE ROAD AND NOTICE FLAMES UNDERNEATH THE VEHICLE. THE FIRE WAS EXTINGUISHED BY THE FIRE DEPARTMENT. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TOWED TO A TOWING LOT. THE VEHICLE WAS NOT TAKEN TO A DEALER OR INDEPENDENT MECHANIC TO DETERMINE THE CAUSE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE APPROXIMATE FAILURE MILEAGE WAS 160,000.

TIRES

BOUGHT A SET OF TIRES FROM EBAY / SIMPLETIRE. THEY WERE LISTED AS NEW WITHOUT ANY DISCLAIMER. ORDERED THEM JAN. 11TH 2018, AND RECEIVED THEM JAN. 16TH, 2018 VIA FEDEX. CHECKED THE DOT DATE CODE AND SAW THAT ALL FOUR TIRES ARE OVER SIX YEARS OLD. ATTEMPTED TO CONTACT SIMPLE TIRE THROUGH EBAY MESSAGING AND THEY HAVE NOT REPLIED. HERE IS THE TIRE INFORMATION YOU ARE REQUESTING: HANKOOK I*CEPT EVO W310 235/55R17 103V XL THIS IS A MATCHED SET OF FOUR. THE FOUR DOT ARE AS FOLLOWS: DOT 5M3F EU H 3511, DOT 5M3F EU H 3811, DOT 5M3F EU H 3811, DOT 5M3F EU H 3911 AFTER READING ALL YOUR HELPFUL INFORMATION ON YOU WEBSITE I FELT THEY SOLD ME EXPIRED TIRES. HAVE NO CHOICE BUT TO USE THEM AS THE TIRES ON MY WIFE'S CAR ARE IN POOR CONDITION, AND WE JUST DON'T HAVE THE EXTRA MONEY TO BUY MORE. ANOTHER CONCERN OF MINE IS HOW MANY UNSUSPECTING CONSUMERS ARE DRIVING AROUND ON EXPIRED TIRES THEY IN GOOD FAITH BOUGHT FROM SIMPLETIRE @ EBAY?

ELECTRICAL SYSTEM

TL* THE CONTACT OWNS A 1998 FORD CROWN VICTORIA. THE CONTACT STATED THAT THE VEHICLE FAILED TO START. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 160,000.

ENGINE AND ENGINE COOLING

TL* THE CONTACT OWNS A 1998 FORD CROWN VICTORIA. WHILE DRIVING APPROXIMATELY 30 MPH, THE VEHICLE OVERHEATED WITHOUT WARNING. THE FAILURE RECURRED TWICE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE INTAKE MANIFOLD NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN AND FAILURE MILEAGE WERE UNKNOWN. UPDATED 04/05/17*LJ THE CONSUMER STATED CAR OVERHEATING DUE TO INTAKE MANIFOLD, HAD TO REPLACE INTAKE MANIFOLD. VIN FAILURE UPDATED 7/3/18*JB *TR

ELECTRICAL SYSTEM,ELECTRONIC STABILITY CONTROL (ESC)

TAKATA RECALL MY 98 FORD CROWN VIC HEAD LIGHTS TURN ON AND OFF WHEN I DRIVE. IT MAINLY TURN ON AND OFF IS WHEN I HAVE MY HIGH BEAMS WHEN IN MOTION. I DONT KNOW WAT CAUSES IT IT RECENTLY STARTED HAPPINGING

ENGINE AND ENGINE COOLING

MY INTAKE MANIFOLD FOR MY THERMOSTAT IS COMPLETELY BROKEN WHEN I LOOKED UP ONLINE TO SEE HOW MUCH THE PART WOULD COST ME TO HAVE FIXED IT SAID THERE WAS A RECALL ON THE PART BECAUSE IN BETWEEN THE YEARS 1997-2006 FORD USED GENERIC PLASTIC TO MAKE THE PART I JUST PURCHASED THE CAR OFF A GUY LIKE 6 MONTHS AGO SO IF THERE WERE ANY RECALLS ON THE VEHICLE I HAD NO IDEA TILL IT BROKE ON ME AND I LOOKED IT UP I CALLED A FEW FORD DEALERSHIPS AND ALSO THE MAIN FORD HEADQUARTERS IN DETROIT AND EVERYONE'S GIVING ME THE RUN AROUND AND TELLING ME THERE WERE NEVER ANY RECALLS ON MY CAR AND THAT I HAVE TO PAY TO HAVE IT FIXED MEANWHILE ITS THERE FAULT FOR PUTTING THE WRONG PART IN THE CAR IN THE FIRST PLACE I NEED YOUR HELP GETTING THESE PEOPLE TO FIX MY CAR PLEASE CONTACT ME AT [XXX] OR IF I CAN'T BE REACHED ON THAT NUMBER [XXX] THANK YOU. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

STEERING,SUSPENSION,WHEELS

I WAS A PROFESSIONAL MECHANIC AND WENT TO SCHOOL FOR IT ALSO WITH OVER TEN YEARS EXPERIENCE IN THE FIELD ! THIS IS THE STORY I DECIDED TO REPLACE UPPER AND LOWER BALL JOINTS AND OUTER TIE ROD ENDS WITH UPPER CONTROL ARM BUSHINGS AND WHEEL BEARING HUB ASSEMBLY'S ALL AT THE SAME TIME TO AVOID A VEHICLE BREAKDOWN LIKE WHAT JUST HAPPENED ! THE CAR HAD ABOUT 54000 MILES ON IT WHEN I DID THIS WITH ME KNOWING THESE PARTS WERE ABOUT TO GO OUT DUE TO WEAR BEFORE 75000 MILES AT THE LATEST FROM EXPERIENCE ON AVERAGE ! BUT THIS IS THE COMPLAINT AND CONCERN ! MY LOWER PASSENGER FRONT BALL JOINT SEPARATED AT ABOUT 84000 MILES ON THE CAR WHICH IS ONLY THIRTY THOUSAND MILES OF LIFE ON THIS BALL JOINT ! NOT REASSURING AT THE LEAST ! EVEN UNDER EXTREME DRIVING I HAVE FOUND BALL JOINTS TO LAST AT LEAST 50000 MILES BEFORE GOING BAD ! THE BALL JOINT IS A DRIVE WORKS BRAND PART #DW-K8685 ADVANCE AUTO PARTS BRAND BUT HERE IS THE STRANGE PART THEY DO NOT KNOW WHO MAKES THEIR PARTS EVEN WHEN YOU CALL THEIR 1-800 # ARE THESE PARTS TESTED OR BUILT TO FEDERAL SAFETY STANDARDS THESE BALL JOINTS IF THEY SEPARATE ON THE FREEWAY CAN KILL PEOPLE THIS IS A SERIOUS SUBJECT ! I WAS BLESSED THIS BALL JOINT SEPARATED AT ABOUT 20 MILES AN HOUR ! CAN THEY BE TESTED OR RECALLED ! *TR

VEHICLE SPEED CONTROL

1998 FORD CROWN VICTORIA. CONSUMER WRITES IN REGARDS TO VEHICLE CRUISE CONTROL FAILURE. *SMD THE CONSUMER STATED FOR THE SECOND TIME, THE CRUISE CONTROL FAILED. *JB