2000 Ford Crown Victoria

2000 Ford Crown Victoria 4-DR.

Overall

Not Rated

Front Crash

Not Rated

Side Crash

Not Rated

Rollover

Not Rated

STEERING

Dorman Products, Inc. (Dorman) is recalling certain model Dorman Steering Shafts, part number 425-359, Solutions Steering Shafts, part number 7-0359, and OE Solutions Steering Shafts, part number 425-359, manufactured April 17, 2014, to September 28, 2015. These aftermarket replacement steering shafts are sold for use in 1995-2002 Ford Crown Victoria, Mercury Grand Marquis, and Lincoln Town Car vehicles. These steering shafts may separate during operation if the integral fastener is loose or missing and if the interfacing vehicle shaft is compressed in length.

Campaign: 15E082000

FUEL SYSTEM, GASOLINE

CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.

Campaign: 06E056000

SEAT BELTS:FRONT:RETRACTOR

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THESE VEHICLES MAY HAVE BEEN BUILT WITH THE LEFT REAR SEAT BELT RETRACTOR ATTACHING BOLTS INCORRECTLY TIGHTENED.

Campaign: 00V083000

EQUIPMENT:MECHANICAL:INTEGRATED JACK/LEVELER/STABILIZER

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THESE VEHICLES HAVE JACKING INSTRUCTIONS WHICH, IF FOLLOWED, COULD CAUSE THE VEHICLE OPERATOR TO PLACE THE JACK ON A FRAME WELD WHEN ATTEMPTING TO RAISE A REAR WHEEL. IF THE VEHICLE IS JACKED UP WITH THE JACK PLACED ON THE FRAME WELD AND IF THE VEHICLE IS FREE TO ROLL (WHEELS NOT BLOCKED OR CHOCKED), THE JACK COULD YIELD AND THE VEHICLE MAY DROP SUDDENLY.

Campaign: 00V200000

SEAT BELTS:FRONT:ANCHORAGE

VEHICLE DESCRIPTION: PASSENGER VEHICLES USING AFTERMARKET FRONT PASSENGER SIDE SEAT BELT ASSEMBLIES THAT WERE SOLD BY FORD PARTS DEPARTMENTS FROM JANUARY 1, THROUGH JUNE 13, 2000. THESE SEAT BELT ASSEMBLIES FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 209, "SEAT BELT ASSEMBLIES." THE EQUIPMENT INVOLVED IS SERVICE STOCK SEAT BELT ASSEMBLIES, MODEL NOS. H 9977, H 9979, T 9063, AND T 9217, BUILT BY TRW VEHICLE SAFETY SYSTEMS, INC. (TRW) MANUFACTURED FROM JUNE 1, 1998 THROUGH MAY 21, 2000. SOME OF THESE SEAT BELT ASSEMBLIES MAY HAVE BEEN INSTALLED AS SERVICE REPLACEMENT EQUIPMENT ON THE VEHICLES INVOLVED IN THE RECALL.

Campaign: 00V157002

VISIBILITY:WINDSHIELD WIPER/WASHER

VEHICLE DESCRIPTION: A WINDSHIELD WIPER CONTROL MODULE MAY NOT BE CAPABLE OF CARRYING THE CURRENT REQUIRED DURING HIGH LOAD CONDITIONS ON THE WIPERS (I.E., ICE, SNOW, OR OTHER DEBRIS).

Campaign: 00V138000

FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY

IN ORDER TO ENHANCE POLICE OFFICE SAFETY, MODEL YEAR 1992-2003 CROWN VICTORIA POLICE INTERCEPTOR (CVPI) VEHICLES WILL BE EQUIPPED WITH SHIELDS DESIGNED TO HELP PROTECT THE FUEL TANK IN HIGH-SPEED REAR-IMPACT CRASHES. FORD ALSO WILL BE OFFERING AN OPTIONAL TRUNK PACKAGE DESIGNED TO IMPROVE THE SAFE TRANSPORT OF SHARP-EDGED, HEAVY EQUIPMENT IN THESE VEHICLES.

Campaign: 02I003000

FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY

ON CERTAIN NATURAL GAS VEHICLES, IF A FLAME FROM A VEHICLE INTERIOR FIRE BECOMES LOCALLY DIRECTED AT THE NATURAL GAS FUEL TANK LOCATED IMMEDIATELY BEHIND THE REAR SEAT, THE FLAME COULD DAMAGE THE FIBERGLASS WRAP ON THE TANK WEAKENING THE TANK.

Campaign: 03V472000

SEAT BELTS:FRONT:ANCHORAGE

VEHICLE DESCRIPTION: PASSENGER VEHICLES USING AFTERMARKET DRIVER'S SEAT BELT ASSEMBLIES THAT WERE SOLD BY FORD PARTS DEPARTMENTS FROM JANUARY 1, THROUGH JUNE 13, 2000. THESE SEAT BELT ASSEMBLIES FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 209, "SEAT BELT ASSEMBLIES." THE EQUIPMENT INVOLVED IS SERVICE STOCK SEAT BELT ASSEMBLIES, MODEL NOS. H 9977, H 9979, T 9063, AND T 9217, BUILT BY TRW VEHICLE SAFETY SYSTEMS, INC. (TRW) MANUFACTURED FROM JUNE 1, 1998 THROUGH MAY 21, 2000. SOME OF THESE SEAT BELT ASSEMBLIES MAY HAVE BEEN INSTALLED AS SERVICE REPLACEMENT EQUIPMENT ON THE VEHICLES INVOLVED IN THE RECALL.

Campaign: 00V157001

AIR BAGS:FRONTAL

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THESE VEHICLES MAY HAVE BEEN BUILT WITH LOWER THAN THE INTENDED LEVEL OF TORQUE ON THE BOLTS THAT ATTACH THE AIR BAG ELECTRONIC CRASH SENSOR MODULE TO THE VEHICLE.

Campaign: 00V050000

TIRES

Purchased 2 Cooper Endeavor tires July 2022 from a highly popular national retailer, 225/60-R16. The tires were installed professionally by a Ford Dealership. The first of the 2 tires developed a hazardous outer sidewall "egg" within a few weeks of installation (under 1k mi). Having no visible or known damage it was reluctantly replaced by the tire retailer under their provided Road Hazard warranty. Rolling forward to present, following documented tire rotation schedule and documented monthly tire pressure checks, the 2nd Cooper Endeavor "60k mi marketed tire" developed a hazardous outer sidewall egg 29 mo later with only 21.6k mi. driven. The new tire tread depth was 10.5/32 in. and remaining tread depth is 7/32 in. at it's greatest wear area. This 2nd sidewall egg tire was removed by a reputable tire dealership and inspected showing no visible damage to the inner or outer sidewall, tire tread or the rim bead.

EXTERIOR LIGHTING,STRUCTURE,SERVICE BRAKES

I WAS DRIVING ND I DIDN'T SEE A POT HOLE SO AFTER I DROVE ACROSS IT LIKE A MILE OR MORE MY HEAD LIGHT STARTED FLICKING ND AFTER WEN I DROVE FOR LIKE 30MIN THEY TURNED OF ND IT ALSO CAUSED ALL THE LIGHT TO TURN OFF INSIDE ND OUT THE CAR

VISIBILITY

TL* THE CONTACT OWNS A 2000 FORD CROWN VICTORIA. THE CONTACT STATED THAT THE ORIGINAL WINDSHIELD HAD SOME CRACKS AND CHIPS, SO HE DECIDED TO HAVE THE WINDSHIELD REPLACED. THE CONTACT STATED THAT THE REPLACEMENT WINDSHIELD IMPAIRED HIS VISION WHILE DRIVING BECAUSE HE COULD NOT SEE THE ROAD CLEARLY. THE CONTACT STATED THAT THE WINDSHIELD HAD A FOGGY, HAZY SMOKE SCREEN AND WAS NOT CLEAR. THE CONTACT TOOK THE VEHICLE BACK TO THE INDEPENDENT MECHANIC WHERE THE WINDSHIELD WAS PURCHASED; HOWEVER, NO DEFECT WAS NOTICED. THE MECHANIC OFFERED TO REPLACE THE WINDSHIELD, BUT STATED THAT IT WOULD BE NO DIFFERENT THAN THE ONE THAT WAS ORIGINALLY SOLD TO HIM. THE CONTACT TOOK THE VEHICLE TO ANOTHER INDEPENDENT MECHANIC WHO STATED THAT THEY WERE FAMILIAR WITH THESE PARTICULAR FUYAO WINDSHIELDS (PRODUCT NUMBER: AS1M848 DOT-459 SOLAR TINT DW1506). THE CONTACT DROVE TO THE DISTRIBUTION WAREHOUSE AND WAS INFORMED THAT THE WINDSHIELDS WERE NOT FACTORY REPLACEMENT WINDSHIELDS, BUT WERE AFTERMARKET WINDSHIELDS. THE FORD MANUFACTURER WAS NOTIFIED AND INFORMED THAT THE CONTACT'S WINDSHIELD WAS NOT A FACTORY AUTHORIZED WINDSHIELD REPLACEMENT. THE CONTACT HAD THE REPLACEMENT WINDSHIELD FOR THREE WEEKS AND HAD VISIBILITY ISSUES EACH TIME WHILE DRIVING. THE FAILURE MILEAGE WAS UNKNOWN.

SUSPENSION,ELECTRICAL SYSTEM,EXTERIOR LIGHTING

WHILE DRIVING AT VARIOUS TIMES ELECTRICAL PROBLEMS OCCUR, HEADLIGHTS WILL GO OUT ALONG WITH INSTRUMENT PANEL. SOMETIMES THE FAN ON WILL COME ON AND WILL CUT OFF EVEN WHEN IT IS OFF. WHEN TEMP IS COLD HEATER BLOWS COLD AIR. HOT OUTSIDE HEATS WORKS. AC WORKS FINE IN BOTH CLIMATES. DRIVERS SIDE WINDOW WILL NOT COME DOWN IN CERTAIN TEMPERATURES. HEADS HAVE LOW VISIBILITY AND LENS COVER GETS MOISTURE INSIDE. YOU HAVE TO DRIVE AT NIGHT WITH HIGH BEAMS TO TRY AND SEE AT ALL. SUSPENSION IS DEFINITELY A PROBLEM ON STEERING CAR HAS A SWAYING MOTION AT TIMES ESPECIALLY IN WARM WEATHER POPPING, SQUEAKY NOTICES CAN ALSO BE HEARD. VEHICLE HAS 92,000 ACTUAL MILES BUT IS BECOMING A HAZARD TO DRIVE. VEHICLE HAS BEEN INSPECTED BY A REPUTABLE REPAIR SERVICE WHO STATES SUSPENSION LOOKS GOOD, PARTS HAVE GREASE IN JOINTS, ETC AND HEATER PROBLEM EVERYTHING WAS IN SPECS. LARGE FORD DEALERSHIP 35 MILES AWAY WOULD NOT SCHEDULE AN APPOINTMENT DUE TO CAR BEING AN OLDER MODEL. IF PROBLEMS ARE NOT FOUND, AN ACCIDENT IS WAITING TO HAPPEN! NOTE : ELECTRICAL PROBLEMS HAVE BEEN ONGOING AND HAVE INCREASINGLY BECOME WORSE.

EXTERIOR LIGHTING

BROUGHT USED JULY 26,2017 FIRST TIME DRIVING AT NIGHT HEADLIGHTS FLASH OFF AND ON THEN GO OUT COMPLETELY WHILE DRIVING ON A MAIN HIGHWAY.FORD HAS PROBLEM WITH LIGHT MODULE TRIED GETTING VKP-31F32-Z01 RELAYS BUT MY RESEARCH FOUND DISCONTINUED 2009 I'M SCREWED BY FORD & RELAY MANUFACTURE.MAY NOT BE IN YOUR DATA BASE BUT IT'S STILL A SAFETY HAZARD & PREVIOUS OWNER SHOULD HAD THIS RESOLVED.

STEERING,SEAT BELTS,FUEL/PROPULSION SYSTEM

SEAT BELTS DON'T HAVE ELASTICITY. STEERING COLUMN STEERING FEELS LOOSE, GEAR SHIFTER FEELS SLOPPY. HAPPENS WHEN THE CAR IS STATIONARY OR IN MOTION.

EXTERIOR LIGHTING

WHEN DRIVING FOR ABOUT 30-45 MINUTES, ALL LIGHTS GO OFF FOR 1-2 MINUTES, FUSE GETS VERY HOT UNDER DASH.

ENGINE

I WAS DRIVING ACROSS THE CAUSEWAY WHEN MY CAR STARTED SHAKING. I TURNED DOWN THE RADIO AND IT SOUNDED LIKE IT BACK FIRING. I PULLED OVER AND CALLED MY MECHANIC TO MEET ME WHERE I BROKED DOWN. H IMMEDIATELY SAW THE PROBLEM BUT HE COULD NOT FIX IT. I HAD TO BRING IT TO ANOTHER SHOP TO GET IT REPAIRED. LUCKILY WHEN THIS HAPPENED I WAS GETTING OFF THE CAUSEWAY BECAUSE THAT BRIDGE IS 24 MILES LONG.

EXTERIOR LIGHTING,ELECTRICAL SYSTEM

TL* THE CONTACT OWNS A 2000 FORD CROWN VICTORIA. WHILE DRIVING VARIOUS SPEEDS, THE HEADLIGHTS AND INSTRUMENT PANEL LIGHTING FLICKERED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 150,000.

ENGINE

DEFECTIVE PLASTIC INTAKE MANIFOLD PRONE TO CRACKING AND LEAKING COOLANT. THIS ITEM WAS PREVIOUSLY REPORTED TO NHTSA AND FORD WAS REQUIRED TO PAY FOR REPAIRS ALREADY DONE AND TO EXTEND WARRANTY. I'M TOLD THAT WARRANTY EXPIRED FOR SOMETHING THAT A RECALL SHOULD HAVE TAKEN CARE OF. I'M TOLD THAT COST TO REPAIR IS IN EXCESS OF $1400. CONTACTED DEALER AND FORD ASKING FOR REPLACEMENT OF PART AND I WILL PAY LABOR BUT BOTH DECLINED. *TR