2011 Ford E-150 Van

2011 Ford E-150 Passenger VAN RWD

Overall

Not Rated

Front Crash

Not Rated

Side Crash

Not Rated

Rollover

★★★☆☆

FUEL SYSTEM, OTHER:STORAGE

Landi Renzo USA is recalling certain model year 2011-2014 Ford E-150, E-250, and E-350 vehicles modified January 2, 2011, through February 24, 2014 to operate on compressed natural gas (CNG). In the affected vehicles, the left and right rear brackets that support the rear CNG cylinder may fail, allowing the cylinder to dislodge from the vehicle.

Campaign: 14V097000

EQUIPMENT ADAPTIVE/MOBILITY

National Van Builders, Inc. (National Van) is recalling certain 2007-2014 Ford E-150 and E-250 vehicles manufactured February 26, 2007, to August 19, 2014, and equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts manufactured by Ricon Corporation. The platform side plate of the affected wheelchair lifts may crack.

Campaign: 14V584000

EQUIPMENT ADAPTIVE/MOBILITY

MobilityWorks (WMK Inc.) is recalling certain model year 2006-2014 Ford E-150, E-250, and E-350 vans modified by MobilityWorks to be equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts manufactured by Ricon Corporation. The affected lifts are equipped with folding link arms that may have pivot holes that are too big, allowing the bearings to move out of position.

Campaign: 15V729000

VISIBILITY:WINDSHIELD

Ford Motor Company (Ford) is recalling certain model year 2011 Ford E-150, E-250, E-350, and E-450 vehicles built from May 12, 2011, through May 26, 2011. Due to improper manufacturing conditions, some of the windshields may form bubbles after an extended time in hot temperatures. As such, these vehicles fail to conform to the requirements of Federal Motor Vehicle Safety Standard No. 205, "Glazing Materials."

Campaign: 11V445000

FUEL SYSTEM, OTHER:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS

Roush Performance Products, Inc. (Roush) is recalling certain model year 2010-2012 Ford E-150 Wagons and Cargo Vans, E-250 Cargo Vans and Extended Cargo Vans, E-350 Wagons, Extended Wagons, Cargo Vans, and Extended Vans, and E-450 Cutaway models. These models were modified by Roush to be equipped with certain propane fuel system conversion kits manufactured January 2011 to August 2012 with an aluminum fuel line fitting. Due to a reaction between the different metals, the affected kits may develop a propane leak where the aluminum fuel line fitting contacts the brass supply valve housing.

Campaign: 14V426000

FUEL SYSTEM, OTHER:FUEL INJECTION SYSTEM

ROUSH IS RECALLING CERTAIN MODEL YEAR 2009-2011 FORD E-150, E-250, AND E-350 5.4L ENGIN VANS/WAGONS/CUTAWAYS, AND MODEL YEAR 2010-2011 FORD E-450 6.8L ENGINE CUTAWAY VEHICLES ALTERED BY ROUCH TO OPERATE USING THE ROUSH BRANDED CLEANTECH PROPANE AUTOGAS FUEL SYSTEM. THE FUEL RAILS INCLUDED IN THE KITS CONTAIN IMPROPERLY SEATED INJECTOR RETENTION CLIPS. THIS COULD RESULT IN LEAKAGE OF PROPANE AUTOGAS.

Campaign: 11V450000

FUEL SYSTEM, OTHER:FUEL INJECTION SYSTEM

ROUSH IS RECALLING CERTAIN AFTERMARKET ROUSH CLEAN TECH LIQUID PROPANE AUTOGAS FUEL SYSTEM KITS USED FOR INSTALLATION ON THE FOLLOWING VEHICLES: MODEL YEAR 2007 AND 2008 FORD E-350 (DUEL REAR WHEEL), MY 2009-2011 FORD E- 150, E-250, AND E-350, AND MY 2009-2011 FORD E-450 CUTAWAYS. THE FUEL RAILS INCLUDED IN THE KITS CONTAIN IMPROPERLY SEATED INJECTOR RETENTION CLIPS. THIS COULD RESULT IN LEAKAGE OF PROPANE AUTOGAS. THE PART NUMBERS OF THE AFFECTED KITS ARE: P07C2-176KIT-AB, P10C2-RCOMMKIT-AB, P10C2-R150KIT-AA, P10C2-R150KIT-AC, P10C2-R350KIT-AC, P11C2-R150KIT-AA, P11C2-R150KIT-AB, P11C2-R350KIT-AA, P11C2-R350KIT-AB, P10-SO-RKIT-BA, PBC2-RKIT158-AB, PBC2-RKIT176-AB, AND PBC2-RKITMB-AC.

Campaign: 11E033000

EQUIPMENT ADAPTIVE/MOBILITY

Cummings Mobility Conversion & Supply (Cummings) is recalling certain model year 2006-2014 Ford E-150, E-250, E-350, Chevrolet Express, 2006-2008 Dodge Sprinter, and 2009-2014 Mercedes-Benz Sprinter, and 2013 Ford Transit Connect vehicles manufactured January 1, 2006, to October 8, 2014, equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts manufactured by Ricon Corporation after January 1, 2006. The platform side plate of the affected wheelchair lifts may crack.

Campaign: 14V706000

SEATS:FRONT ASSEMBLY:POWER ADJUST

FORD IS RECALLING CERTAIN MODEL YEAR 2011 E-150, E-250, E-350 AND E-450 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 207, "SEATING SYSTEMS." IT MAY BE POSSIBLE THAT UNDER UNUSUALLY HIGH LOADS, SUCH AS DURING A CRASH, THE DRIVER POWER SEAT TRACK WORM GEAR MAY FRACTURE.

Campaign: 11V246000

FUEL SYSTEM, OTHER:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS

ROUSH PERFORMANCE PRODUCTS IS RECALLING CERTAIN 2011 FORD E-SERIES VANS EQUIPPED WITH 5.4 OR 6.8 LITER ENGINES THAT HAVE BEEN ALTERED BY ROUSH TO OPERATE USING THE ROUSH LIQUID PROPANE AUTOGAS FUEL SYSTEM. A VALVE IN THE SYSTEM MAY HAVE BEEN MISMACHINED ALLOWING A PROPANE LEAK.

Campaign: 11V307000

EQUIPMENT

Mobility Works is recalling certain model year 2006-2012 Ford E-150, E-250 and E-350 vehicles manufactured August 2006 through August 2012. The vehicles are equipped with certain Ricon S series and K Series wheelchair lifts with an optional armored pendant cable. The armored cable may be positioned such that it does not clear the wheelchair lift.

Campaign: 13V261000

FUEL SYSTEM, OTHER:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS

ROUSH IS RECALLING CERTAIN AFTERMARKET ROUSH CLEAN TECH LIQUID PROPANE AUTOGAS FUEL SYSTEM KITS PRODUCED BETWEEN DECEMBER 17, 2010, AND MAY 6, 2011, USED FOR INSTALLATION ON FLEET VEHICLES MODEL YEAR 2009 THROUGH 2011 FORD E-SERIES VANS/WAGONS/SHUTTLES/CUTAWAY (150, 250 AND 350) WITH 5.4L ENGINES ("E-SERIES"), AND MY 2011 FORD E-450 CUTAWAYS. THE VALVES INSTALLED IN THE SERVICE PORT OF THE FUEL RAILS OF THE KIT WERE UNDER MINIMUM SPECIFICATION FOR THE DIAMETER. THIS LED TO INSUFFICIENT COMPRESSION OF THE O-RING, ALLOWING LEAKAGE OF PROPANE AUTOGAS. THE PART NUMBERS OF THE AFFECTED KITS ARE: P10C2-R150KIT-AA, P10C2-R150KIT-AC, P10C2-R350KIT-AC, P11C2-R150KIT-AA, P11C2-R150KIT-AB, P11C2-R350KIT-AA, P11C2-R350KIT-AB, P-10-SO-RKIT-BA, PBC2-RKIT158-AB, PBC2-RKIT176-AB, AND PBC2-RKITMB-AC.

Campaign: 11E019000

SUSPENSION

PREMATURE LOWER BALLJOINT FAILURE. DRIVER AND PASSENGER SIDES. WHILE DRIVING FORWARD OR REVERSE AND TURNING RIGHT OR LEFT OR WHEN BRAKING YOU WOULD HEAR POPPING AND TIRE RUBBING SOMETHING UNDERNEATH. VEHICLE HAD ONLY 55,000 MILES DISPLAYED ON THE ODOMETER. THIS OCCURRED AT WHEN VAN WAS IN MOTION.

ENGINE

WHEN ENGINE IS STARTED IN THE MORNINGS YOU CAN HEAR A KNOCKING SOUND WHICH SEEMS TO SUBSIDE AS THE ENGINE IS WARMING. I'VE BEEN WATCHING THE VIDEO ON YOUTUBE ABOUT THE CATASTROPHIC CONSEQUENCES THIS WILL EVENTUALLY OCCUR IF THE CAUSE IS NOT DISCOVERED AND REPAIRED. PLEASE REFER TO YOUTUBE VIDEOS FORDTECHMAKEULOCO SEE THE 2004-2015 TITLED FORD F-150/E-150 LOWER BALLJOINT REPLACEMENT AND HOW A FAILED $4.00 PART TURNED INTO A $7,000 MOTOR REPAIR. OIL PUMPS ALSO. HAPPENS IN THE DRIVEWAY IDLING . FORD DEALER WANTED $125. TO DIAGNOSE THIS MORNING THURSDAY 12/10/2020.

SERVICE BRAKES

VACUUM PUMP MAKING NOISE WHEN BACKING UP AND TURNING. MY MECHANIC SAID THERE IS RECALL ON 2011-2012 FORD F-150 AND I CALLED DEALER FROM WHICH I PURCHASED AND WAS TOLD NO RECALL ON MY TRUCK. I FEEL THIS IS A SAFETY ISSUE WITH BRAKES AND SHOULD BE COVERED IN EXTENDED WARRANTY

ELECTRICAL SYSTEM

ODOMETER READ 136,707 ON 5-12-17 / 2-19-19 READ 136,708 DEALER WOULD NOT EXPLAIN

POWER TRAIN

TRANSMISSION SUDDENLY DOWNSHIFTS INTO 1ST AND JUMPS A LITTLE WHEN IN MOTION. USUALLY HAPPENS AT SPEEDS UNDER 20 MPH

FUEL/PROPULSION SYSTEM

I STARTED GETTING A CHECK FUEL INLET WARNING OCCASIONALLY AND THEN MY CHECK ENGINE LIGHT CAME ON SO I TOOK THE VEHICLE IN FOR SERVICE. I WAS INFORMED THAT THE CANISTER PURGE VALVE WAS FAULTY AND WAS IN NEED OF REPLACEMENT AT THE COST OF $341. AS IT WERE MY 2010 FORD FUSION HAS THE VERY SAME PART BEING REPLACE AS PART OF A SAFETY RECALL. I NOTED THIS TO BOTH MY FORD DEALER AND FORD CUSTOMER SERVICE BUT I AM STILL RESPONSIBLE FOR THE REPAIR. MY QUESTION IS WHY IT'S A SAFETY RECALL IN ONE INSTANCE BUT AN OWNERS RESPONSIBILITY IN ANOTHER.

POWER TRAIN

AT ANY SPEED IT WILL SHIFT INTO 1ST GEAR WITHOUT WARNING. SPEEDOMETER WILL FLUCTUATE BETWEEN 0-65MPH. REAR WHEELS LOCK UP, AND YOU WILL LOOSE CONTROL OF VEHICLE. A COUPLE HOURS AGO, ON THE FREEWAY IT SHIRTED TO 1ST GEAR, LOCKED UP THE REAR END, AND THE CAR BEHIND ME CRASHED INTO CENTER DIVIDER TRYING TO AVOID ME. THIS LOCK UP HAS HAPPENED 4 TIMES ON FREEWAY AND MANY TIMES ON STANDARD ROADWAY. I TOOK IT TO FORD AND THEY SAID IT NEEDED A RE-FLASH OF THE COMPUTER, AND THAT WOULD FIX THE PROBLEM. THAT WAS ON SATURDAY 2/18, AND IT JUST DID IT AGAIN MONDAY 2/20. I ENDED UP FACING THE WRONG WAY ON THE RAINY FREEWAY. IT IS NOW AT THE FORD DEALER AGAIN. THEY SAY IT COULD BE COVERED UNDER THE RECALL BUT ARE NOT SURE. THIS IS VERY DANGEROUS!!! SOMEONE WILL LOOSE THEIR LIFE!!

SERVICE BRAKES

WHEN APPLYING THE BRAKES THE FIRST BRAKING ACTION DOESN'T SEEM TO BE AS EFFECTIVE AS SAY THE SECOND APPLICATION AS FAR AS BRINGING THE VEHICLE TO A STOP, WHEN IN MOTION. IT DOESN'T SEEM TO MATTER WHETHER IT'S ON THE STREET OR HIGHWAY OR TURNING. MARCH OF 2016 I HAD TO MAKE A SUDDEN STOP AND DIDN'T THINK I WOULD AVOID THE VEHICLE IN FRONT OF ME. HOWEVER A SEMI TRACTOR WITH TRAILER REAR ENDED ME CAUSING ABOUT $5,000.00 DAMAGE TO THE LEFT REAR OF THE E-150. BEFORE TAKING THE VEHICLE ON VACATION I REPORTED THE BRAKING ISSUE WITH THE ANDY MOHR FORD IN PLAINFIELD IN., THEY SAID THE BRAKES NEEDED BLED WITH A MACHINE AND THAT IF THAT DIDN'T FIX THE ISSUE THEY WOULD BLEED THEM MANUALLY. I DIDN'T TAKE IT BACK BECAUSE THEY DIDN'T SEEM TO HAVE A CLUE AS TO WHAT THE PROBLEM MIGHT BE. I PAID FOR THE MACHINE BLEED, JUST AROUND $100.00. I KNEW FROM MY PREVIOUS EXPERIENCE AS A MECHANIC, THAT BLEEDING THE SYSTEM WOULDN'T CORRECT THE PROBLEM, AS THE BRAKE PEDAL WAS SOLID AND NOT SOFT OR MUSHY. ANYWAY, I ASKED AND RECEIVED A REFUND AND STILL THE PROBLEM PERSISTS. THEY DID REPLACE THE LEFT REAR AXLE SEAL THAT I DISCOVERED WHILE PERFORMING MAINTENANCE BEFORE TAKING A TRIP TO FLORIDA. THE LEAKING AXLE SEAL HAD NO AFFECT WITH THE VEHICLE STOPPING AS THERE WAS NO LUBRICANT DRIPPING OR SLINGING ONTO THE ROTOR OR BRAKE CALIPER. THANK YOU FOR YOUR CONCERNS. THEY WOULD BLEED THE BRAKES MANUALLY. *TR

STRUCTURE

FORD DOOR LATCH RECALLS - OUR FORD F150 ECO BOOST (YEAR 2011) HAS A DOOR LATCH PAWL SPRING THAT IS DEFECTED. ONE OF MY KIDS RECENTLY WAS INJURED WHEN THE SPRING BROKE ON THEM WHEN TRYING TO SHUT THE DOOR CLOSE ON THE GAS STATION (VEHICLE WAS STATIONARY BUT TURNED ON) WHEN THE LIGHT CAME ON INDICATING PASSENGER FRONT DOOR WAS OPEN, SHE WAS HAVING TROUBLE OPENING THE DOOR TO HAVE IT SHUT, WHEN ALL OF A SUDDEN THE SPRING BROKE CAUSING DOOR HANDLE TO CRACK AND BREAK ON HER. SHE WAS CUT BY THE DOOR HANDLE UPON THE IMPACT OF THE SPRING RELEASING.

STEERING

TL* THE CONTACT OWNS A 2011 FORD E-150. WHILE TURNING THE VEHICLE AT 40 MPH, THE POWER STEERING FAILED AND THE STEERING WHEEL SEIZED. THE POWER STEERING ASSIST FAULT WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, BUT WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 100,000. THE VIN WAS NOT AVAILABLE.