1994 Ford Econoline

1994 Ford Econoline

Overall

Not Rated

Front Crash

Not Rated

Side Crash

Not Rated

Rollover

Not Rated

EXTERIOR LIGHTING:HEADLIGHTS

DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Campaign: 09E025000

EXTERIOR LIGHTING

SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Campaign: 09E012000

VEHICLE SPEED CONTROL

ON CERTAIN TRUCKS EQUIPPED WITH SPEED CONTROL, GASOLINE OR NATURAL GAS ENGINES, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT.

Campaign: 06V286000

VEHICLE SPEED CONTROL:CRUISE CONTROL

FORD IS RECALLING 225,000 MY 1992-2003 ECONOLINE, MY 1993-1995 TAURUS SHO, MY 1992-1998 CROWN VICTORIA, MY 1993 BRONCO, F-SERIES, MY 1995-1997 F-SERIES SUPER DUTY STRIPPED CHASSIS, MY 1992-1998 MERCURY GRAND MARQUIS, AND MY 1992-1995 LINCOLN TOWN CAR VEHICLES. THE AFFECTED VEHICLES WERE PREVIOUSLY REPAIRED USING A WIRING HARNESS THAT IS NOT COMPATIBLE WITH THE VEHICLE CIRCUIT POLARITY.

Campaign: 08V051000

PARKING BRAKE:CONVENTIONAL

THESE VEHICLES DO NOT COMPLY WITH FMVSS 105, "HYDRAULIC BRAKE SYSTEMS." THE PARKING BRAKE APPLICATION FORCE FOR A FOOT OPERATED CONTROL SYSTEM SHOULD NOT EXCEED 125 POUNDS TO HOLD THE VEHICLE ON A 30% GRADE. INTERFERENCE BETWEEN THE PARKING BRAKE PEDAL AND A WIRE HARNESS MAY INCREASE THE NEEDED PEDAL FORCE TO GREATER THAN 125 POUNDS TO SET THE PARKING BRAKE TO HOLD THE VEHICLE ON THE 30% GRADE.

Campaign: 93V194000

INTERIOR LIGHTING

THE TRANSFORMER USED TO POWER THE NEON CENTER LIGHTBEAM CAN OVERHEAT AND CATCH ON FIRE.

Campaign: 94V128000

ENGINE,ENGINE AND ENGINE COOLING

See attached document for complaint

STEERING

The contact owns a 1994 Ford E-150. The contact stated that while driving at an undisclosed speed, the contact stated she heard an unusual noise that sounded like something broke. The contact stated she continued to drive and the failure reoccurred. The vehicle was towed to an independent mechanic. The vehicle was diagnosed with a fractured steering box. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 165,000.

SEAT BELTS,VEHICLE SPEED CONTROL,FORWARD COLLISION AVOIDANCE

seat belt not pulling out e40d trans starts out going in 3ed gear

STEERING

ON JAN 21ST 2020, WHILE MANEUVERING AT A GAS STATION, I HEARD A LOUD POP/CRACK. THINKING I HAD HIT A STANCHION, I WALKED AROUND MY VAN BUT - NO STANCHION. NOTHING TO SEE SO I GO ABOUT MY DAY. STEERING PULLED TO THE RIGHT, I CHECKED FOR LOW TIRE PRESSURE - PRESSURE, OK. 40 MILES OF FREEWAY DRIVING LATER, I TAKE THE VAN TO THE GARAGE - STEERING FEELS LOOSE. AFTER INSPECTION, THE DANGER I WAS IN, AND THE THREAT I WAS TO THOSE AROUND ME ON THE ROAD, WAS MOST APPARENT. THE STEERING GEAR BOX WAS LOOSE FROM THE FRAME, ONE BOLT HAVING SHEERED OFF. AND THE FRAME ITSELF CRACKED. IMAGINE MY SURPRISE WHEN FINDING THAT FATIGUE FAILURE AT THIS PART OF THE FRAME WAS WELL DOCUMENTED ON THE INTERNET AND YET, AS AN ORIGINAL OWNER, I HAD NOT BEEN INFORMED OF THIS KNOWN AND DANGEROUS DESIGN DEFECT BY FORD MOTOR CO OR LANDMARK FORD. HOW MANY VANS OF THE SAME VINTAGE ARE STILL ON THE ROAD ?? HOW MANY ARE SAFE TO DRIVE ALONG SIDE?? I GUESS I AM LUCKY TO BE ABLE TO WRITE THIS NOTE, COS HAD MY STEERING BOX BROKEN LOOSE WHILE DRIVING ACROSS THE GLEN JACKSON BRIDGE, (I 205), I COULD EASILY HAVE ENDED UP IN THE COLUMBIA RIVER ALONG WITH OTHER INNOCENTS. DISILLUSIONED CUSTOMER. 1994 FORD E150, 170,289 MLS, FRAME @ STEERING GEAR BOX.

STEERING

VERY WOBBLY LOOSE STEERING. SCARY TO DRIVE BECAUSE THE STEERING ISN'T RELIABLE. FEELS LIKE IT WILL JUST GO OFF THE ROAD OR INTO ONCOMING TRAFFIC WHILE DRIVING DOWN THE ROAD. HAVENT DRIVEN IT MUCH SINCE.

SERVICE BRAKES

REAR ABS MODULE FAILED. CAUSING OVER PRESSURIZATION OF FRONT BRAKES RESULTING IN PASSENGER SIDE BRAKE HOSE SEPARATION. SO NO REAR OR FRONT BRAKES! THANK GOD IT HAPPENED NEAR MY DRIVEWAY OTHERWISE PEOPLE COULD DIE. I HAD JUST REENTERED DRIVERS SEAT AND RELEASED PARKING BRAKE AND ENGAGED BRAKE PEDAL WITH 1 FOOT. VEHICLE WAS STATIONARY POINTED IN A STRAIGHT LINE.

STEERING

TL* THE CONTACT OWNS A 1994 FORD E-150. THE CONTACT STATED THAT ONE OF THE THREE BOLTS HAD BECOME LOOSELY CONNECTED ASSOCIATED WITH THE STEERING. THE CONTACT TIGHTENED THE WASHER AS AN INTERIM REPAIR TO PREVENT A POWER STEERING FAILURE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 135,000.

STEERING

I WAS DRIVING AND CAME THRU THE TUNNEL,AND STOP BY MALL TO GET SOMETHING TO EAT.WHILE PARKING MY STEERING GEAR BOX BROKE AWAY FROM THE FRAME,CAUSING ME TO HAVE NO STEERING.IF THIS WOULD HAVE HAPPEN 10 MINUTES EARLIER OR AFTER I WOULD HAVE LEFT THE MALL GOING THRU THE TWO LANE MIDTOWN TUNNEL I WOULD HAVE HAD A HEAD ON COLLISION WHICH WOULD HAVE BEEN DEADLY.IS THIS SOMETHING FORD KNEW ABOUT AND DID NO RECALL.THE BOLTS ARE BAD AND I RESEARCHED AND IT HAPPEN TO ALOT OF PEOPLE'S DRIVING THAT TYPE.MY VAN IN THE SHOP AND I DO THINK FORD SHOULD FOOT THE REPAIR BILL.I LOVE MY VAN.HAVE A MUSTANG TOO IT'S JUST THE IDEA I COULD HAVE KILLED SOME ONE OR MYSELF.PLEASE IF I CAN HAVE SOME FEED BACK ON THIS ISSUE OR EVEN WHO ELSE I COULD CONTACT REGARDING THIS ISSUE.

STEERING,STRUCTURE

WHILE PULLING OUT OF A PARKING SPACE TURN WHEEL TO LEFT HARD AT LOUD CRACKING SOUND AS IF SOMETHING WAS BREAKING. STOPPED GOT OUT AND LOOKED UNDER AND NOTICED A BOLT PULLED THROUGH AND BROKE THE FRAME WHERE THE BOTTOM BOLT WAS. GRABBED THE OTHER TWO AND THEY PULLED RIGHT OUT AND WE'RE SNAPPED OFF. HAD TO GET ANOTHER GEARBOX PUT ON WITH ALL THREE BOLTS AND 4 DAYS LATER WHILE PULLING OUT OF PARKING LOT HARD LOUD POP AND LOOKED AND TOP RIGHT BOLT WAS SNAPPED OFF COMPLETELY. STEERING WAS WAY LOOSER AND MADE IT TO MY DESTINATION. NEXT MORNING TRIED TO PULL OUT OF PARKING SPACE AND LOUD POP ONCE AGAIN. THIS TIME THE GEARBOX WAS HANGING ALL THE WAY OFF. STEERING WHEEL JUST KEPT TURNING BUT WHEELS WERE NOT. COULDN'T PARK IT BACK OUT OF STREET BECAUSE OTHERS CARS WERE CLOSE HAD TO LEAVE IT HALFWAY HANGING OUT IN STREET TILL PEOPLE GOT OFF WORK AND MOVED OTHER CARS AWAY SO I COULD GET IT BACK TO CURB. NOW I'M AT A LOST HOW DID THIS HAPPEN TWICE. OR EVEN HAPPEN AT ALL. *TR

EXTERIOR LIGHTING

TL* THE CONTACT OWNS A 1994 FORD ECONOLINE. THE CONTACT STATED THAT THE EXTERIOR LIGHTING FAILED TO ILLUMINATE. THE DEALER STATED THAT THE MULTI-FUNCTION TURN SIGNAL SWITCH NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 22,000. UPDATED 10/8/14*CN UPDATED 3/24/2015 *JS