1996 Ford Econoline

1996 Ford Econoline

Overall

Not Rated

Front Crash

Not Rated

Side Crash

Not Rated

Rollover

Not Rated

EXTERIOR LIGHTING:HEADLIGHTS

DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Campaign: 09E025000

EXTERIOR LIGHTING

SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Campaign: 09E012000

VEHICLE SPEED CONTROL

ON CERTAIN TRUCKS EQUIPPED WITH SPEED CONTROL, GASOLINE OR NATURAL GAS ENGINES, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT.

Campaign: 06V286000

VEHICLE SPEED CONTROL:CRUISE CONTROL

FORD IS RECALLING 225,000 MY 1992-2003 ECONOLINE, MY 1993-1995 TAURUS SHO, MY 1992-1998 CROWN VICTORIA, MY 1993 BRONCO, F-SERIES, MY 1995-1997 F-SERIES SUPER DUTY STRIPPED CHASSIS, MY 1992-1998 MERCURY GRAND MARQUIS, AND MY 1992-1995 LINCOLN TOWN CAR VEHICLES. THE AFFECTED VEHICLES WERE PREVIOUSLY REPAIRED USING A WIRING HARNESS THAT IS NOT COMPATIBLE WITH THE VEHICLE CIRCUIT POLARITY.

Campaign: 08V051000

PARKING BRAKE:CONVENTIONAL

THE PARKING BRAKE SYSTEMS MAY NOT HOLD THE VEHICLES ON A 20% GRADE WITH FOOT PEDAL EFFORTS OF 125 POUNDS OR LESS. THIS DOES NOT MEET THE REQUIREMENTS OF FMVSS NO. 105, "HYDRAULIC BRAKE SYSTEMS."

Campaign: 96V214000

FUEL/PROPULSION SYSTEM

APPROXIMATELY 6 TIMES ON A 800 MILE ROAD TRIP WHEN IT WAS 90 DEGREES OR HOTTER IN THE AFTERNOON MY 1996 E350 MOTORHOME WOULD STOP RUNNING AT HIGHWAY SPEED STRANDING US IN A DANGEROUS SITUATION ON I40. AFTER SITTING IDLE FOR 30-60 MINUTES IT WOULD START AND RUN MAYBE 30 MILES AND STOP. IN THE COOL OF THE EVENING OR MORNING IT WOULD RUN AS LONG AS NEEDED. THE PROBLEM IS AN INADEQUATE FUEL PUMP WHICH IS WELL DOCUMENTED ON MANY INTERNET BLOGS. IN MID YEAR 1996 FORD UPGRADED TO A TURBINE FUEL PUMP WHICH I HAVE NOW PAID $450 TO INSTALL. THIS UPGRADE SOLVES THE PROBLEM. I WAS ALSO STRANDED AT MAJOR INTERSECTIONS ALSO. I READ THERE MIGHT HAVE BEEN A RECALL FOR THIS PROBLEM WHICH I CANNOT FIND. MY UNDERSTANDING OF THE PROBLEM IS THAT THE ORIGINAL FUEL PUMP WAS A GEROTOR WHICH CAUSED CAVITATION OF FUEL WHICH CAUSED AIR TO REACH THE FUEL RAIL CAUSING THE VAPOR LOCK LIKE PROBLEM.

SERVICE BRAKES

ABS SPORADICALLY CAUSES DIFFICULTY IN PRESSING THE BREAK PEDAL WHILE RHYTHMICALLY PULLING HARD RIGHT. HIGHWAY OR SURFACE SPEEDS. GOOGLE HAS MANY WITH THE SAME PROBLEM AND NO FIX. NO CODES ARE THROWN. DEALERS ARE NO HELP. MUST DISABLE THE ABS BY PULLING THE 60AMP FUSE.

ELECTRICAL SYSTEM,VEHICLE SPEED CONTROL,SERVICE BRAKES

MY VEHICLE ACCORDING THE NHTSA HAS RECALL #09V399000 FOR THE BRAKE SYSTEM SPEED CONTROL WHICH CAN CATCH ON FIRE EVEN IN THE GARAGE WITH THE VEHICLE OFF. I ASKED FORD TO REPAIR THIS BECAUSE I JUST BOUGHT THIS VEHICLE AND THEY CLAIM THERE ARE NO RECALLS ON THIS VEHICLE, AND I KNOW THERE IS AND I KNOW THE RECALL HASN'T BEEN INSTALLED ON MY VEHICLE. ARE THEY SAYING THIS BECAUSE TIME RAN OUT TO HAVE THIS DONE BECAUSE I JUST BOUGHT THIS VEHICLE OR DO THEY JUST NOT WANT TO? THANKS FOR YOUR HELP. *JS

FUEL SYSTEM, DIESEL,ENGINE

THIS ISSUE WAS ON A 1996 FORD F350 AMBULANCE ON ROUTE TO EMERGENCY CALL WHEN ENGINE SHUT DOWN AND LOST ALL POWER LIKE IT WAS OUT OF FUEL 7.3 LITER DIESEL AND TANK WAS FULL. HAD UNIT TOWED TO CROSS WOOD FORD IN KERNERSVILLE NC AND $2700.00 LATER AFTER NEW FUEL TANK FUEL PUMP 6 INJECTORS AND TURBO DUE TO LINER INSIDE OF TANK CAME OFF AND CLOGGED THE FUEL SYSTEM AND ENGINE FORD MOTOR COMPANY WAS NO HELP AND SAID SINCE THE VEHICLE WAS OUT OF WARRANTY THEY WOULD NOT DO ANYTHING TO RESOLVE THE COST ISSUES. *TR

ELECTRICAL SYSTEM,SERVICE BRAKES

VEHICLE WAS PARKED, AND UPON ENTERING NOTICED THE SMELL OF AN ELECTRICAL FIRE. STARTED THE VEHICLE, ODOMETER WAS INOPERABLE AND VEHICLE WOULD NOT SHIFT OUT OF PARK. UPON FURTHER INSPECTION, FOUND A BLOWN 15 AMP FUSE IN THE FUSE PANEL. REPLACED FUSE, ODOMETER CAME BACK ON AND VEHICLE SHIFTED OUT OF PARK. APPROXIMATELY 10 SECONDS LATER, THE SMELL OF BURNING WIRING WAS EVIDENT, AS WAS SMOKE FROM UNDER THE HOOD. PULLED THE FUSE BACK OUT, OPENED THE HOOD TO FIND THE BRAKE PRESSURE SWITCH ON FIRE, WHICH MELTED THE BRAKE FLUID RESERVOIR AS WELL AS THE BATTERY CASING ALSO. *TR

SEAT BELTS

DRIVERS SIDE SEAT BELT LATCH DOES NOT LOCK. *TR

LATCHES/LOCKS/LINKAGES

TL* THE CONTACT OWNS A 1996 FORD ECONOLINE. THE CONTACT STATED THE DOOR LATCH WOULD NOT RELEASE OPEN IN ORDER TO GAIN ACCESS OR EXIT THE VEHICLE DUE TO THE FAULTY DOOR CABLE. THE FAILURE INVOLVED BOTH SIDE DOORS AND REAR DOOR. THE CONTACT PURCHASED THE DOOR CABLE KIT AND PERFORMED THE REPAIR HIMSELF. THE MANUFACTURER WAS NOTIFIED OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 50,000. UPDATED 01/20/12*LJ THE CONSUMER STATED THERE WAS A FLAW IN THE MECHANICS THAT OPERATES THE DOORS THAT CAN BECOME INOPERABLE WITHOUT WARNING. THE CABLES OPERATING THE LATCHES CAN AND DO FAIL BECAUSE THEY ARE MADE OF VINYL AND IN TIME FAIL. UPDATED 01/20/12

STRUCTURE

A CHROME COLOR GRILLE ABOUT 2.5 FEET WIDE AND 6" TALL FLEW OFF THE FRONT OF OUR 1996 F150 FORD VAN WHILE WE WERE DRIVING AT HIGHWAY SPEED. I NOTICED OTHER SIMILAR FORD VANS THAT HAVE ALSO LOST THE SAME FRONT GRILL PART. WE WERE GOING 55 MPH DOWN A 2 LANE HIGHWAY AND A LARGE TRUCK WAS GOING THE OTHER WAY. THE GUST OF AIR FROM THE PASSING TRUCK WAS SUFFICIENT TO TEAR OFF THE GRILL PART AND CAUSE IT TO FLY OVER THE TOP OF OUR VAN. *TR

SERVICE BRAKES, HYDRAULIC

DISCOVERY OF CRACKED FRONT ROTORS ON MY 1996 E-350 MOTORHOME. FIRST CRACKED ROTOR FOUND IN MAY 2007 WITH 35,000 MILES ON VEHICLE. SECOND CRACKED ROTOR FOUND IN SEPTEMBER 2009 WITH 41,000 MILES ON VEHICLE. *TR

SERVICE BRAKES, HYDRAULIC,ENGINE AND ENGINE COOLING,VEHICLE SPEED CONTROL

TL*THE CONTACT OWNS A 1996 FORD E-150. WHENEVER THE CONTACT STARTS THE ENGINE AND DEPRESSES THE ACCELERATOR PEDAL, THE ENGINE BECOMES STUCK AT A HIGH RPM AND WILL NOT RETURN TO THE IDLE POSITION. THE FAILURE CAUSES THE VEHICLE TO EITHER SURGE FORWARD OR BACKWARDS DEPENDING ON WHAT GEAR IT IS IN AT THE TIME. THE ENGINE HAS TO BE TURNED OFF IN ORDER TO RESTORE THE VEHICLE TO A PROPER SPEED. IN ADDITION, THE BRAKES DO NOT HOLD OR STOP THE VEHICLE WHEN THEY ARE ENGAGED. THE FIRST TIME THIS FAILURE OCCURRED, THE VEHICLE CRASHED INTO A TREE AT 10 MPH. THERE WERE NO INJURIES; HOWEVER, THE REAR WINDOW WAS DAMAGED. THROUGH RESEARCH, THE CONTACT FOUND NUMEROUS ISSUES WITH THIS DEFECT ON THE SAME MAKE AND MODEL VEHICLES. THE VEHICLE WAS TAKEN TO A REPAIR SHOP TWICE. DURING THE FIRST VISIT, THE MECHANIC CLEANED OUT THE ENGINE, ENGINE THROTTLE, AND CABLES. THE FAILURE WAS CORRECTED FOR TWO MONTHS BEFORE IT RECURRED AGAIN. DURING THE SECOND VISIT, THE VEHICLE WAS TOWED TO THE SHOP AND THE MECHANIC CHECKED TO MAKE SURE THAT EVERYTHING WAS LUBRICATED PROPERLY. THE SHOP DID NOT GUARANTEE THAT THE FAILURE WOULD NOT RECUR. THE CONTACT BELIEVES THAT A RECALL SHOULD BE ISSUED. THE FAILURE MILEAGE WAS 150,000 AND CURRENT MILEAGE WAS 152,000.