1997 Ford Econoline

1997 Ford Econoline

Overall

Not Rated

Front Crash

Not Rated

Side Crash

Not Rated

Rollover

Not Rated

EXTERIOR LIGHTING:HEADLIGHTS

DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Campaign: 09E025000

EXTERIOR LIGHTING

SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Campaign: 09E012000

VEHICLE SPEED CONTROL:CRUISE CONTROL

FORD IS RECALLING 225,000 MY 1992-2003 ECONOLINE, MY 1993-1995 TAURUS SHO, MY 1992-1998 CROWN VICTORIA, MY 1993 BRONCO, F-SERIES, MY 1995-1997 F-SERIES SUPER DUTY STRIPPED CHASSIS, MY 1992-1998 MERCURY GRAND MARQUIS, AND MY 1992-1995 LINCOLN TOWN CAR VEHICLES. THE AFFECTED VEHICLES WERE PREVIOUSLY REPAIRED USING A WIRING HARNESS THAT IS NOT COMPATIBLE WITH THE VEHICLE CIRCUIT POLARITY.

Campaign: 08V051000

ELECTRICAL SYSTEM:12V/24V/48V BATTERY:CABLES

THE BATTERY CABLE HARNESS DOES NOT HAVE ADEQUATE PROTECTION FROM CONTACTING AND BEING DAMAGED BY THE RIGHT ENGINE MOUNT.

Campaign: 96V193000

AIR BAGS

The contact owns a 1997 Ford E-150. The contact stated that after parking the vehicle in a parking lot, the contact leaned over to the passenger’s side to pick up the cell phone. The contact stated that after sitting back straight in the seat, the air bag deployed unintendedly and without impact. No warning lights were illuminated. The contact’s eyes and jaw were injured and required medical attention. The contact’s vision became blurry but has since started to improve. The vehicle was not taken to a local dealer. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was unknown.

STRUCTURE

The rear passenger compartment outside and inside door handles broke such that rear seating passengers cannot exit the vehicle and are trapped inside. In case of an accident, the emergency responders will have to resort to drastic time consuming measures such as ripping the doors off to save the trapped passengers. Apparently all years of Ford Econoline vans have this dangerous problem because there are numerous fix it videos all over the internet showing how to replace the cheap handle-latch failure prone plastic parts with non-breakable METAL parts.

SUSPENSION

This vehicle was made by Ford as a partially complete vehicle and converted to 4 wheel drive by Quigley Motor Company Inc. The Quigley torque arms installed appear to commonly fail from some of the earlier years and a design change has been made (from C-channel arms to tubular). The design and construction of the C-channel torque arm (connecting the front axle to the frame of the vehicle) is prone to failure from low cycle fatigue near the welds. Upon failure, the structural integrity of the vehicle is compromised which results could range from handling issues to loss of control of the vehicle (if more than one torque arm fails or failure of one leads to cascading failures in other components, the front axle could become disconnected from the vehicle while in motion leading to an accident.

TIRES

The contact owns a 1997 Ford E-150 equipped with Milestar Tires, Tire Line: Grantland, Tire Size: 235/75/R15, DOT number: TB20R028. The contact stated while driving approximately 45-50 mph, the tires were bouncing. The contact stated upon checking the tires, his son noticed that the tires were cracked and had holes. The vehicle was taken to an independent mechanic who informed the contact that the tires were defective. The tires were not replaced. The manufacturer was not made aware of the failure. The approximate vehicle mileage was 150,258. The approximate tire failure mileage was 800.

AIR BAGS,SERVICE BRAKES

AIR BAG LIGHT CAME ON AND BRAKE LIGHT CAME ON

STRUCTURE

12/11/2019

AIR BAGS

MY HUSBAND HAD JUST STARTED UP HIS E150 ECONOLINE VAN PULLING OUT OF THE DRIVEWAY AND THE AIRBAG JUST DEPLOYED. THERE WAS NO REASON HE WAS NOT IN ANY ACCIDENT HE DID NOT RUN OVER ANYTHING HE DIDN'T HIT ANYTHING. AND NO ONE CAN TELL ME WHY THIS HAPPENED. IF HE HAD BEEN ON THE INTERSTATE THAT HE DRIVES EVERY DAY HE COULD HAVE DIED OR KILLED SOMEONE.

ELECTRICAL SYSTEM,AIR BAGS,SEAT BELTS

THIS YEAR BOTH THE AIRBAGS IN MY 1997 FORD E350 VAN HAVE SPONTANEOUSLY DEPLOYED ON TWO SEPARATE OCCASIONS--EACH OCCURRING WHILE THE VAN WAS IN 'PARK'. ON 1/31/18 THE DRIVER'S BAG DEPLOYED WHEN THE VAN WAS WARMING UP IN A PARKING LOT. MY ADULT DAUGHTER STARTED THE VAN, PLUGGED HER PHONE INTO THE TOP CAR ADAPTER, AND ABOUT A MINUTE LATER (THE VAN WAS STILL PARKED) THERE WAS A BIG 'BOOM' FROM UNDER HER SEAT AND HER SEATBELT TIGHTENED. WITH THE SEATBELT STILL ON, SHE LEANED TO HER RIGHT TO SEE WHAT WAS CAUSING THE SMOKE FROM UNDER HER SEAT WHEN SUDDENLY THE DRIVER'S STEERING WHEEL AIRBAG DEPLOYED. THANKFULLY SHE WAS SPARED ANY INJURY. SHE HAD THE VAN TOWED TO A FORD DEALERSHIP, BUT THEY COULD NOT DIAGNOSE THE ROOT OF THE PROBLEM SO I DID NOT HAVE THEM DO ANY WORK ON IT [THEY WANTED TO REPLACE THE AIRBAG AND A FEW OTHER THINGS WHICH I FELT WAS A 'BAND-AID' SOLUTION SINCE THEY ADMITTED THEY WERE GUESSING]. WE DROVE THE CAR HOME. ON 4/13/18 MY ADULT DAUGHTER WAS SITTING IN THE FIRST BENCH ROW IN THE VAN TO HAVE A QUIET PLACE TO TALK ON THE PHONE. AFTER A WHILE ON THE PHONE, SHE PLUGGED HER PHONE INTO THE SAME CHARGER AND LESS THAN A MINUTE LATER THE PASSENGER AIRBAG EXPLODED. THIS OCCURRED IN MY DRIVEWAY WHEN THERE WAS NO KEY IN THE IGNITION AND NO ONE WAS SITTING IN EITHER FRONT SEAT! AGAIN, MY DAUGHTER ESCAPED INJURY, BUT NOW THE VAN WILL NOT EVEN START. AT THIS POINT, MY LOCAL FORD DEALERSHIP (A DIFFERENT ONE) AND MY PERSONAL REPAIR SHOP ARE REFUSING TO TOUCH THE VAN BECAUSE OF POTENTIAL LIABILITY REGARDING THIS KIND OF MALFUNCTION. MY INSURANCE CAN'T HELP BECAUSE THE VAN WAS NOT IN AN ACCIDENT WHEN THE AIRBAGS DEPLOYED AND "ELECTRICAL AND MECHANICAL MALFUNCTIONS ARE EXCLUDED FROM COMPREHENSIVE COVERAGE." FORD CUSTOMER CARE SERVICE HAS TOLD ME REPEATEDLY THAT THEY DON'T HAVE A PROTOCOL FOR THIS AND THERE IS NOTHING THEY CAN DO TO HELP ME.

AIR BAGS,SEAT BELTS

MY VEHICLE HAD BEEN PARKED FOR ABOUT THREE OR FOUR WEEKS AND I WENT TO START IT UP TO RUN THE ENGINE AND CHARGE THE BATTERIES AS I DID NOT PLAN TO USE IT FOR ANOTHER FEW WEEKS. WHEN I TURNED THE KEY THE DRIVER SIDE AIRBAG DEPLOYED AND HIT ME HARD. ALSO THE PASSENGER SIDE SEAT BELT BUCKLE PRETENSIONER FIRED OFF BREAKING THE HOUSING. THE VEHICLE WAS STATIONARY BEFORE, DURING, AND AFTER THE INCIDENT. THERE HAS NEVER BEEN AN ACCIDENT AND I CAN SEE NO DAMAGE TO THE OUTSIDE AT ALL. I HAVE CONTACTED FORD AND THEY WILL NOT ASSIGN A CASE NUMBER UNTIL IT IS INSPECTED AND CHECKED BY A FORD DEALER. THE CLOSEST FORD DEALER THAT SAID THEY WERE CAPABLE OF DOING THIS IS BOOKED UP AND CAN NOT LOOK AT IT FOR TWO WEEKS AND THEY DID MAKE AN APPOINTMENT FOR 10/25/17. THE DEALERSHIP IS ABOUT 35 MILES AND I WILL HAVE TO DRIVE IT THERE WITH THE AIRBAG HANGING OUT OF THE STEERING WHEEL. I AM SO THANKFUL THIS HAPPENED WHILE PARKED IN STORAGE AND NOT ON THE HIGHWAY AS I THE RESULT MAY HAVE BEEN FATAL TO MY SELF AND/OR OTHERS. MY INJURIES ARE SOME BRUISING, HEADACHES, AND A SORE NECK. THE MILES I ENTERED ARE APPROXIMATE, I WILL VERIFY THE EXACT NUMBER LATER. *TT CONSUMER'S STATEMENT "MY UNDERSTANDING IS THE SENSORS CHECK GOOD WITH NO OPEN CIRCUITS. THE ONLY OPEN CIRCUITS ARE THE ITEMS THAT DEPLOYED, THE DRIVER SIDE AIRBAG AND THE PASSENGER SIDE BELT TENSIONER. UPDATED 7/25/18*JB

STEERING

WHILE BACKING OUT OF TIGHT PARKING SPOT 9/1/17, WITH MULTIPLE TURNS OF THE WHEEL, TURNED WHEEL ONE LAST TIME TO PULL FORWARD INTO PARKING SPOT DRIVE AREA BUT AT THAT POINT, HEARD A CLUNK AND ALL STEERING CONTROL WAS GONE. CALLED FOR A TOW. TOW TRUCK DRIVE ASSISTED IN THE DIAGNOSIS NOTING THAT THE STEERING BOX HAD DISCONNECTED FROM VAN FRAME RENDERING STEERING WHEEL CONNECTION LINES USELESS. HAD VAN TOWED HOME. AFTER ONLINE READ, LOOKED AT FRAME THROUGH LEFT FRONT TIRE ACCESS AND SAW THE 3 BOLTS WE READ ABOUT. GRABBED THE TOP BOLT AND IT CAME RIGHT OUT. SAME WITH SECOND BOLT. LAST (THIRD) BOLT WAS A BIT JAMMED DUE TO THE STEERING BOX DROP, BUT ALL 3 BOLTS HAD SHEARED AND ALL STEERING WAS LOST. HAD WE NOT STOPPED AT A STORE FOR LABOR DAY HOLIDAY SUPPLIES ON OUR WAY TO CAMPSITE, WOULD HAVE LOST STEERING SOMEWHERE ELSE, LIKE ON THE FREEWAY, POSSIBLY DURING A SIMILAR TURN SITUATION. WE COULD HAVE KILLED OTHERS OR OURSELVES. FOUND THAT THIS FORD E150 STEERING BOLT ISSUE HAS ALREADY BEEN DOCUMENTED. WHY WHEN WE HAD THE VAN SERVICED AND SAID THE STEERING HAD FELT "LOOSE", WHY DIDN'T ANY MECHANIC FIND THIS POTENTIAL?? UN-EXCUSABLE SITUATION. OUR PARENTS, CHILDREN AND GRANDCHILDREN ARE CURRENTLY DEPENDENT ON US. HAD WE DIED DUE TO LOSS OF STEERING, WHAT A NIGHTMARE THAT WOULD HAVE BEEN. GRANTED, THE 20-YR-OLD VAN IS RUSTY, BUT WE DIDN'T KNOW TO LOOK UNDER THE LEFT FRONT TIRE AREA AND APPARENTLY, MULTIPLE (NON-FORD DEALERSHIPS) MECHANICS DIDN'T EITHER !!