2002 Ford Econoline

2002 Ford Econoline

Overall

Not Rated

Front Crash

Not Rated

Side Crash

Not Rated

Rollover

Not Rated

EXTERIOR LIGHTING:HEADLIGHTS

DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Campaign: 09E025000

EXTERIOR LIGHTING

SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Campaign: 09E012000

VEHICLE SPEED CONTROL:CRUISE CONTROL

FORD IS RECALLING 225,000 MY 1992-2003 ECONOLINE, MY 1993-1995 TAURUS SHO, MY 1992-1998 CROWN VICTORIA, MY 1993 BRONCO, F-SERIES, MY 1995-1997 F-SERIES SUPER DUTY STRIPPED CHASSIS, MY 1992-1998 MERCURY GRAND MARQUIS, AND MY 1992-1995 LINCOLN TOWN CAR VEHICLES. THE AFFECTED VEHICLES WERE PREVIOUSLY REPAIRED USING A WIRING HARNESS THAT IS NOT COMPATIBLE WITH THE VEHICLE CIRCUIT POLARITY.

Campaign: 08V051000

FUEL SYSTEM, GASOLINE:STORAGE

ON CERTAIN CUTAWAY CHASSIS CAB WITH THE SCHOOL BUS OPTION, TWO BRACKETS AND TWO OUTRIGGER MEMBERS ARE MISSING IN THE AREA OF THE FUEL TANK.

Campaign: 03V282000

STEERING,SERVICE BRAKES

My power steering and brakes went out as I was driving. I was making a turn in town, and I almost collided with another car at the intersection. I pushed the brakes as hard as I could, but it didn't slow down, the car just eventually rolled to a stop on its own. The exact cause is unknown, but it seems like it was a failure in the power steering pump. After turning off the van and turning it back on again a minute later, it started driving normally again.

WHEELS,SERVICE BRAKES

The contact owns a 2002 Ford E-150. The contact stated while driving at approximately 75 MPH, he smelled a burning odor in the passenger cabin. The contact stated that he turned the A/C on to help clear the cabin. The contact stated that he noticed smoke was being emitted from the driver's side rear tire and wheel well. The contact stated that the tire separated from the rim and the vehicle dropped to the road. The contact stated he had not noticed any warning lights. The contact stated that he managed to pull over and saw smoke emitted from the rotor and brake pads. The contact stated that the rim was almost destroyed. The contact observed that there was fluid leaking from the rotor and brake pads and had started to burst into flames. The contact stated that he was able to smother the flames with a blanket. The contact stated that he had the vehicle towed to an independent mechanic. The vehicle was not diagnosed and was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 228,000.

STEERING

IN A PARKING LOT, I WENT TO TURN LEFT, HEARD A LOUD CLUNK AND THE VAN JUST WENT STRAIGHT. LOST ALL STEERING CONTROL. LUCKILY THIS HAPPENED IN A PARKING LOT AND NOT ON THE ROAD AT HIGHER SPEED. IF THIS HAD OCCURRED AT SPEED, I WOULD HAVE HIT ONCOMING TRAFFIC , OR GONE OFF THE ROAD INTO WHO KNOWS WHAT. TWO SEPARATE MECHANICS HAVE DIAGNOSED A COMPLETE FRAME FAILURE WIHICH ALLOWED THE STEERING BOX TO DETACH FROM THE FRAME. THE FRAME IS NOT REPAIRABLE. IF THIS IS A COMMON PROBLEM WITH THE 2002 FORD E150 FRAME PEOPLE ARE GOING TO GET HURT OR KILLED!!!

TIRES

BOTH FRONT TIRES MERELY DEVELOPED TREAD BULGES , LESS THAN 15K MILES, NEVER HAD A FLAT, BEEN OVERLOADED ,OVERINFLATED , ECT.. THEY JUST BECAME VERY POOR DRIVING AND VIBRATED BADLY TO FIND THEY BOTH HAVE BULGES IN THE TREAD. THEY SEEMED FINE ABOUT TWO WEEKS AGO AND WHEN I WENT TO DRIVE IT A COUPLE DAYS AGO THE PROBLEM BECAME APPARENT. *TR

ENGINE

HEAD ON VEHICLE STRIPPED BECAUSE OF THE WAY IT IS MADE. THERE WAS A RECALL ON REGULAR E350 BUT MINE IS AN RV. IT WAS IN MOTION WHEN THE SPARK PLUG POPPED OUT WHILE DRIVING DOWN THE HIGHWAY ON I-65 IN BIRMINGHAM ALABAMA.

STEERING,STRUCTURE

TL* THE CONTACT OWNS A 2002 FORD E-150. THE CONTACT STATED THAT THE FRAME EXPERIENCED SEVERE CORROSION. AS A RESULT, THE VEHICLE LOST STEERING ABILITY BECAUSE THE BOLTS CONNECTED TO THE GEAR BOX, WHICH WERE ALL CONNECTED TO THE FRAME, DETACHED FROM THE VEHICLE. THE CONTACT WAS ABLE TO SAFELY MANEUVER THE VEHICLE TO THE SIDE OF THE ROAD. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND ADVISED THE CONTACT TO TAKE THE VEHICLE TO A DEALER FOR DIAGNOSTIC TESTING. THE VEHICLE WAS TAKEN TO LES STUMPF FORD (3030 W COLLEGE AVE, APPLETON, WI) WHERE THE FAILURE WAS CONFIRMED; HOWEVER, NO FURTHER ASSISTANCE WAS OFFERED BECAUSE THE VIN WAS NOT INCLUDED IN A RECALL. THE FAILURE MILEAGE WAS APPROXIMATELY 86,000.

ENGINE

LEFT HOUSE FOR VACATION, GOT 75 MILES AWAY AT 60 MPH ON THE FREEWAY, AND ENGINE STARTED MAKING A POPPING SOUND. PULLED OFF ROAD AND CALLED A NEARBY MOBILE REPAIR COMPANY. THEY SENT OUT A MECHANIC, HE DIAGNOSED A BLOWN OUT SPARK PLUG, AND SAID THIS WAS COMMON FOR THE FORD V-10. MADE IT TO HIS SHOP, AND THAT'S WHERE IT SITS. ESTIMATES ARE OVER $4000 TO REPAIR.

SUSPENSION,UNKNOWN OR OTHER,ENGINE

THIS 350 ECONOLINE, 8CYL., EXTENDED BODY VAN WAS PURCHASED NEW, AND I AM THE ORIGINAL OWNER. THE VEHICLE HAS ONLY 120K MILES ON IT SINCE 2002. BEGINNING SEVERAL YEARS AGO, MY MECHANIC COMPLAINED OF SEVERE FRAME EROSION, HAVING HAD TO REINFORCE AND RE-WELD SEVERAL PARTS BACK ONTO THE FRAME, INCLUDING BUT NOT LIMITED TO THE BRACKETS WHICH SUPPORT THE REAR LEAF SPRINGS. (TWO OCURRANCES-- LEFT AND RIGHT SIDES). LAST WEEK, MY EMPLOYEE COMPLAINED OF SOME REAR END SWAYING AT MODERATE SPEED CORNERING. WE DISCOVERED A CROSS-TIE CONNECTION BETWEEN THE SIDE RAILS AT THE REAR OF THE VEHICLE'S FRAME HAD ROTTED AWAY, THUS CAUSING SOME UNWANTED FRAME MOVEMENT. IF IT WEREN'T FOR A HEAVY-DUTY TOWING PACKAGE I HAD PURCHASED WITH THE VEHICLE IN 2002, I BELIEVE THE LEFT AND RIGHT SIDES OF THE VEHICLE'S UNDER-FRAMING WOULD HAVE TWISTED AND SEPARATED FROM THE BODY YEARS AGO ! ALSO BEGINNING A FEW YEARS AGO, WAS THE DECAY OF THE VEHICLE'S ENGINE BLOCK, AS THREE SEPARATELY TIMED SPARK PLUGS HAD LITERATELY 'BLOWN' OUT OF THE THREADED WELLS OF THE ENGINE BLOCK. MY MECHANIC HAD TO ADAPT HELI-COIL KITS INTO RE-BORED HOLES IN THE VEHICLE'S SPARK PLUG WELLS. IT'S ONLY A MATTER OF TIME BEFORE THESE KITS COME LOOSE, AND BLOW -OUT AGAIN. I'M ALREADY EXPERIENCING A PAINFULLY OMINOUS COMPRESSION LOSS IN ONE (OR MORE) OF THE CYLINDERS. COULD FORD HAVE PURCHASED SOME INFERIOR METALS, THUS PRODUCING A LINE OF JUNK VEHICLES?

UNKNOWN OR OTHER,FUEL/PROPULSION SYSTEM

BLOWING OUT SPARK PLUGES.

ENGINE

SPARK PLUG BLEW OUT OF ENGINE BLOCK. I WAS GOING IN REVERSE WHEN THIS HAPPENED.