1991 Ford Escort

1991 Ford Escort 2-DR.

Overall

Not Rated

Front Crash

Not Rated

Side Crash

Not Rated

Rollover

Not Rated

ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:CONTROL MODULE

THE ROLL PINS SECURING THE IGNITION LOCK IN THE STEERING COLUMN HOUSING CAN SEPARATE OR MOVE OUT OF POSITION.

Campaign: 93V057000

SUSPENSION:FRONT

THE OFFSET TOE ADJUSTING PIN CAN FRACTURE UNDER CONDITIONS SUCH AS TORSIONAL LOADS, FLEXING MOTION, IMPACT LOADS, AND OVERTORQUING.

Campaign: 94E019000

VEHICLE SPEED CONTROL:ACCELERATOR PEDAL

INTERFERENCE OCCUR BETWEEN BOLT THAT SECURES A FUEL LINE SHIELD TO THE LOWER PORTION OF THE DASH PANEL AND THE ACCELERATOR PEDAL.

Campaign: 90V076000

FUEL SYSTEM, GASOLINE

FATIGUE CRACKS CAN DEVELOP IN THE SOLDER JOINT BETWEEN THE FUEL RETURN TUBE AND THE FUEL PUMP SENDING UNIT LOCATED AT THE TOP OF THE FUEL TANK.

Campaign: 92V117000

ELECTRICAL SYSTEM

AFTER FILLING UP WITH GAS AND STILL BESIDE THE GAS PUMPS I ATTEMPTED TO START THE VEHICLE IN PARK. THE CAR KEPT CRANKING BUT NOT STARTING. TURNED THE IGNITION SWITCH OFF AND CAR KEPT CRANKING. PULLED THE KEY OUT AND CAR KEPT CRANKING. PUT THE KEY BACK IN AND GOT THE VEHICLE IN DRIVE WHILE CRANKING AND IT STOPPED. TURNED KEY AND VEHICLE STARTED (IN DRIVE MODE). VEHICLE WOULD NOT STOP CRANKING IN PARK OR NEUTRAL MODES BUT WILL IN DRIVE MODE. WITH NO KEY VEHICLE TRIES TO START IN BOTH PARK AND NEUTRAL. MAJOR SAFETY ISSUE. I WAS SCARED WHEN IT KEPT CRANKING BESIDE THE GAS STATION TANKS THINKING I WAS GOING TO END UP BLOWING UP THE STATION. *TR

ENGINE AND ENGINE COOLING,VEHICLE SPEED CONTROL

THE ACCELERATOR STUCK TO THE FLOOR CAUSING THE VEHICLE TO BE IN FULL THROTTLE. THIS OCCURRED WHILE STOPPED AT A TRAFFIC LIGHT. FORTUNATELY IT WAS A MANUAL TRANSMISSION AND OUT OF GEAR WHEN THE INCIDENT HAPPENED. I HAD STOMPED ON THE GAS PEDAL BY MISTAKE. I SEARCHED THE FLOOR AND ENGINE COMPARTMENT FOR ANYTHING THAT MAY HAVE PREVENTED THE ACCELERATOR FROM DISENGAGING AND FOUND NO APPARENT REASON FOR THE PHENOMENON. *TR

FUEL SYSTEM, GASOLINE

TL* THE CONTACT OWNS A 1991 FORD ESCORT. FATIGUE CRACKS HAVE DEVELOPED IN THE SOLDER JOINT BETWEEN THE FUEL RETURN TUBE AND THE FUEL PUMP SENDING UNIT LOCATED AT THE TOP OF THE FUEL TANK. THERE MUST HAVE BEEN AN INTERNAL FIRE CAUSED BY THE FAILURE, BECAUSE THE WIRING HARNESS HAD MELTED. THE VEHICLE IDENTIFICATION NUMBER WAS EXCLUDED FROM RECALL # 92V117000 (FUEL SYSTEM, GASOLINE). THE MANUFACTURER AND THE DEALER WAS NOTIFIED, BUT NO ASSISTANCE WAS PROVIDED. NO REPAIRS WERE MADE. THE FAILURE AND CURRENT MILEAGES WERE 151000.

FUEL SYSTEM, GASOLINE

1. MY 1991 FORD ESCORT LX STATION WAGON DEVELOPED A FUEL LEAK AROUND THE FUEL TANK. 2. IT OCCURS EVERY TIME I ADD FUEL TO THE TANK. 3. I REPORTED THE PROBLEM TO FORD, INCLUDING THE EXISTENCE OF A RECALL NOTICE (NHTSA ACTION NUMBER EA92012; NHTSA CAMPAIGN ID NUMBER: 92V117000)). FORD HAS IGNORED THE RECALL LETTER, CLAIMING THERE IS NO SUCH RECALL LETTER, AND ... IN GENERAL GIVING ME THE RUNAROUND. FRANKLY, I'M MAD AS '!@#$%. THIS PROBLEM IS A FIRE HAZARD, AND FORD IS REFUSING TO ADDRESS IT!!!!! WHAT CAN I DO?? THANKS! KES *TR

STEERING,ELECTRICAL SYSTEM

TL*THE CONTACT OWNS A 1991 FORD ESCORT LX. THE CONTACT POURED BRAKE FLUID INTO THE POWER STEERING RESERVOIR. SHE TOOK HER VEHICLE TO A MECHANIC TO HAVE THE VEHICLE BLED. THE MECHANIC REPLACED THE POWER STEERING PUMP WITHOUT AUTHORIZATION, AND NOW THE VEHICLE IS SPEWING FORTH POWER STEERING FLUID. THE ALTERNATOR WAS LOPSIDED AND ITS SCREWS WERE MISSING. THE MOTOR MOUNT WAS REMOVED AND THE CONTACT DOES NOT KNOW THE REASON. WHEN SHE ARRIVED HOME AND TURNED OFF THE VEHICLE, IT FAILED TO RESTART AFTER MANY ATTEMPTS. THE MECHANIC STATED THAT HE WOULD SEND A TOW, BUT ONE NEVER ARRIVED. THE FAILURE MILEAGE WAS 101,000.

SEAT BELTS

MOTORIZED SEAT BELTS INOPERATIVE. LAP BELT DOES NOT RESTRAIN. *TR

SEAT BELTS

LOST CONTROL ON WET ROAD HIT TREE HEAD-ON AND SEAT BELT CAME OUT OF TRACK ALLOWED DRIVER TO BE DECAPITATED. *NM

FUEL SYSTEM, GASOLINE

DT: THE CONTACT STATES THERE IS A NHTSA RECALL CAMPAIGN 92V117000 CONCERNING FUEL PUMP SENDING ASSEMBLY. THIS CONSUMER IS EXPERIENCING THE SAME PROBLEMS AS INDICATED IN THE RECALL, BUT IS NOT INCLUDED IN THE RECALL DUE TO VIN. THE CONTACT REPAIRED THE VEHICLE AT HIS OWN EXPENSE. *AK UPDATD 01/25/06. *JB

EXTERIOR LIGHTING

DT: 1991, FORD, ESCORT HATCHBACK. CONSUMER'S WIFE CAME HOME YESTERDAY, AND SAID SHE SMELLED SMOKE. CONSUMER CHECKED VEHICLE AND FOUND OUT THAT THIRD BRAKE LIGHT LOCATED AT TOP OF REAR WINDOW SMOKED WHEN BRAKE WAS PRESSED. CONSUMER TOOK LIGHT APART, AND FOUND SAME PART AT A JUNK YARD. CONSUMER REPLACED HEAT SHIELD AND HALOGEN BULB WITH ONE FROM JUNK YARD. CONSUMER CALLED FORD AND GAVE FORD INFORMATION ABOUT THE INCIDENT. FORD TOLD CONSUMER THERE WERE NO RECALLS, BUT THEY WERE GOING TO TURN IT IN TO ENGINEERING. CONSUMER BELIEVED THAT A LOWER WATT, COOLER BULB WOULD KEEP LIGHT FROM CAUSING FIRE.*AK BULB HOUSING HAD HOLE MELTED THROUGH IT. REPLACED HOUSING WITH GOOD HEAT SHIELD (ORIGINAL HEAT SHIELD HAD BURNED OFF CAUSING THE PROBLEM).*SB

ELECTRICAL SYSTEM

WHEN YOU TURN IGNITION OFF RADIO CONTINUES TO PLAY FOR ABOUT 10 MINUTES OR UNTIL YOU MANUALLY SHUT IT OFF, REPLACED IGNITION AND STILL HAS SAME PROBLEM.*AK