2001 Ford Ev Ranger

2001 Ford EV Ranger (Electric Vehicle)

Overall

Not Rated

Front Crash

Not Rated

Side Crash

Not Rated

Rollover

Not Rated

VEHICLE SPEED CONTROL

THE "PLASTIC" WHICH COVERS THE TWO "SPEED CONTROL SWITCHES," LOCATED ON EACH SIDE OF STEERING WHEEL, BADLY MELTED OVER TIME - APPARENTLY FROM HEAT OF THE LAMPS UNDER THE COVERS. IT HAS MADE ME AFRAID TO ATTEMPT TO USE THE SPEED CONTROLS FOR FEAR OF FURTHER HEAT PROBLEMS AND/OR IMPROPER FUNCTIONING OF THE DAMAGED CONTROLS. PHOTOS OF THE DAMAGED PARTS ARE ATTACHED. I HAVE CONTACTED FORD CUSTOMER SERVICE WITH THESE COMPLAINTS AND PHOTOS AND ALL I GOT WAS A "THANKS" FOR MAKING THIS KNOWN TO THEM - NOTHING MORE.

SUSPENSION

THIS 2001 FORD RANGER TRUCK'S BODY AND INTERIOR ARE PERFECT. THE FRAME IS TOTALLY RUSTED AND NO ONE WANTS TO PASS IT FOR INSPECTION BECAUSE OF THE UNSAFE CONDITION OF THE FRAME. I FEEL THAT I SHOULD BE COMPENSATED BY FORD MOTOR COMPANY. THE TRUCK HAS 103,000 HIGHWAY MILES AND IS MECHANICALLY PERFECT. I FEEL THAT FORD MOTOR COMPANY SHOULD EITHER REPLACE THE ENTIRE FRAME OF THE TRUCK OR BUY IT BACK FROM ME. THIS TRUCK WAS MY SECOND VEHICLE AND I NEED SOMETHING DONE WITH IT.

SEAT BELTS

TL* THE CONTACT OWNS A 2001 FORD RANGER EV. WHILE DRIVING AT VARIOUS SPEEDS, THE DRIVER SIDE SEAT BELT BUCKLE WOULD ERRONEOUSLY UNLOCK. THE FAILURE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE CONTACT WAS INFORMED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 01V227001 (SEAT BELTS). THE CONTACT STATED THAT THE VEHICLE EXPERIENCED THE SAME FAILURE LISTED IN THE RECALL. THE FAILURE MILEAGE WAS 80,000.

STRUCTURE

RUSTED FRAME ON 01 4X4 RANGER . RUSTED REAR SPRING HANGERS& BRACKETS. RUSTED TAIL END OF LEFT & RIGHT FRAME . RUSTED TOP SECTION OF FUEL FILLER TUBE. RUSTED CROSS MEMBER BEHIND CAB. HAD TO REPLACE REAR BRAKE DRUM THAT RUSTED INTO (2) TWO PIECES. BOTTOM OF TRUCK BOX HAS BAD RUST HOLES. ONE AUTO TRANSMISSION FLUID LINE RUSTED IN 2 INCH AREA JUST BEFORE RADIATOR INLET. LEFT SIDE OF FRAME IS ALMOST RUSTED TO MUCH TO SAFELY USE TK. *TR

ENGINE AND ENGINE COOLING

I HAVE A 2001 FOCUS ZX3 - 5SP THAT TENDS TO STALL WHEN THE AC IS ON. BUT IT MAY NOT STALL DURING THE "INITIAL" USE PERIOD. WITHOUT WARNING, IT WILL STALL AFTER THE VEHICLE IS TURNED OFF AND THEN RESTARTED. MY SERVICE SHOP CHECKED THE COMPUTER CODES FOR A PROBLEM AND NOTHING CAME UP. YESTERDAY, IT WAS DRIVEN FOR ABOUT 30MINS WITH THE AC ON (OUTSIDE TEMPERATURE AROUND 80+ DEGREES). THE VEHICLE RAN FINE WITH THE RPMS NORMAL WHEN STOPPED. THE VEHICLE WAS TURNED OFF FOR ABOUT 90 MINS. WHEN ATTEMPTING TO RESTART IT WOULD STALL. TO GET STARTED I NEEDED TO KEEP FOOT ON GAS PEDAL (TO MAINTAIN A HIGH ENOUGH RPM TO PREVENT THE STALL). IF I DID NOT KEEP THE RPMS UP, VEHICLE WOULD STALL. WHILE DRIVING AND STOPPING, I NEEDED TO KEEP MY FOOT ON THE GAS PEDAL TO MAINTAIN THE RPMS. (THIS CAN BE CHALLENGING WITH A 5-SPD.) THE VEHICLE WAS THEN PARKED FOR OVER FOUR HOURS. IT THEN STARTED WITHOUT PROBLEM AND RAN NORMALLY. DURING THIS PERIOD I DID NOT HAVE THE AC ON. I SEE THAT THIS MAY BE A COMMON PROBLEM WITH THE FOCUS. HOWEVER, NEITHER FORD MOTOR'S CUSTOMER SERVICE LINE NOR THE LOCAL FORD DEALER ARE AWARE OF THE PROBLEM. THE VEHICLE WAS TAKEN TO A FORD DEALERSHIP (ECHELON FORD) ON 6/8/10 FOR A DIAGNOSTIC OF THE PROBLEM AND THEY COULD NOT RECREATE IT. I WAS CHARGED $108 FOR THE SHOP TIME AND STILL HAVE NO TECHNICAL ANSWER TO THIS CRITICAL AND POTENTIALLY FATAL PROBLEM... *TR

SUSPENSION

I WAS PULLING OUT THE DRIVEWAY WHEN THE REAR AXLE SNAPPED IN TWO. THIS IS GOING TO KILL SOMEONE. *TR

POWER TRAIN

TL*THE CONTACT OWNS A 2001 FORD RANGER EV. WHILE DRIVING 25 MPH, THE OVERDRIVE LIGHT BEGAN BLINKING, BUT THE VEHICLE CONTINUED TO DRIVE AT A NORMAL EXPECTANCY. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR SHOP AND INSPECTED BY A TECHNICIAN, WHO DETERMINED THAT THE VALVE BODY TSB MODIFICATION AND SHIFT SOLENOID FAILED. THE VEHICLE WAS REPAIRED AT THE COST OF $612.38. THE CONTACT CALLED THE MANUFACTURER AND WAS INFORMED THAT THE FAILURE WAS NOT UNDER RECALL; THEREFORE, NO COMPENSATION WOULD BE PROVIDED. THE FAILURE MILEAGE WAS 55,000 AND CURRENT MILEAGE WAS 57,980.

ENGINE AND ENGINE COOLING

2001 FORD HAS AN OIL LEAK ON THE TOP OF THE ENGINE. CONSUMER STATES THAT FORD FEEL THAT THE LEAK IS NORMAL AND THAT THERE IS NO RESPONSIBILITY FOR THEM. *NJ THE CONSUMER STATED THE OIL LEAK WAS CAUSED BY METAL CHIP DEBRIS OR DAMAGE TO THE SEALING SURFACE THAT OCCURRED DURING THE MANUFACTURING PROCESS. IN ORDER TO REPAIR THE PROBLEM, THE ENGINE MUST BE PULLED OUT OF THE VEHICLE. *JB UPDATED 03/01/10

WHEELS

WE HAVE HAD THREE INCIDENTS INVOLVING TWO VEHICLES IN WHICH WHEELS HAVE COME OFF OF FORD F-550 VEHICLES DUE TO SHEARED LUG BOLTS. THE WEIGHTS OF ALL OF OUR VEHICLES HAVE BEEN RECORDED AND FALL BELOW THE MANUFACTURERS GVWR. PER A TIRE COMPANY'S RECOMMENDATION, WE HAVE ISSUED A MANDATE THAT ALL SIMILAR VEHICLES HAVE THEIR WHEELS RE-TORQUED, TO MEET THE MANUFACTURERS SPECIFICATIONS AFTER DRIVING, AFTER TRAVELING 50 MILES FOLLOWING ANY WORK DONE ON THE WHEELS. WE HAVE HAD THE WHEELS ON VEHICLE THAT DID NOT COME OFF INSPECTED AND CHECKED TO PROPER TORQUE FOLLOWING ALL INCIDENTS AND THEY HAVE BEEN TORQUED APPROPRIATELY. THE INCIDENT DATES WERE, 12/29/07 ,02/15/08, AND 07/17/08 . ON 12/29/07 AN EMPLOYEE WAS DRIVING UP A ROAD AT APPROXIMATELY 20 M.P.H. WHEN THE DRIVER SIDE BACK DUAL WHEELS CAME OFF DUE TO BROKEN LUG BOLTS. THIS WAS A NORMAL USE OF THE VEHICLE ON A WELL-MAINTAINED DIRT ROAD. ON 02/15/08 TWO EMPLOYEES WERE DRIVING ON INTERSTATE 84 TRAVELING AT APPROXIMATELY 60 M.P.H. WHEN THE REAR PASSENGER WHEELS CAME OFF THE VEHICLE AND PASSED THE VEHICLE ON THE HIGHWAY TRAVELING MILE. THE STUDS WERE ALSO SHEARED OFF IN THIS INSTANCE. THE INTERSTATE WAS IN GOOD CONDITION AT THE TIME OF THE ACCIDENT. IT WAS VERY FORTUNATE THAT THE TIRES DID NOT STRIKE ANOTHER VEHICLE. ON 07/17/08 AN EMPLOYEE WAS DRIVING ON OREGON STATE HIGHWAY 82 AT APPROXIMATELY 55 M.P.H. WHEN THE DRIVER SIDE REAR WHEELS CAME OFF. THE WHEELS STRUCK ANOTHER VEHICLE DAMAGING THAT VEHICLE?S BRAKE SYSTEM. IN THIS CASE, A FATALITY COULD HAVE EASILY OCCURRED TO THE OTHER DRIVER. THAT DRIVER?S NAME IS: KEITH CULIVER - 740 11TH AVENUE NORTH, PAYETTE, ID (WORKING FOR TNT FOREST PRODUCTS). WE HAVE REPLACED THE LUG BOLTS ON ALL OF OUR FIVE VEHICLES IN THIS CLASSIFICATION AS AN ATTEMPT TO AVOID FURTHER PROBLEMS. HOWEVER, ONE ACCIDENT OCCURRED FOLLOWING THIS REPLACEMENT. *TR

VEHICLE SPEED CONTROL

THE CRUISE CONTROL WAS DISCONNECTED BY FORD DEALERSHIP IN OCTOBER OF 2007 BECAUSE OF RECALL. THEY SAID IN DECEMBER THAT I SHOULD HAVE NEW PARTS READY FOR INSTALL ON MY 2001 FORD VAN. THIS IS MARCH OF 2008 AND NO ONE CAN TELL WHEN THIS PART WILL BE REPLACED. I FELL LIKE I HAVE PAID FOR THE COMFORT OF CRUISE CONTROL AND DO NOT HAVE IT. I FELL LIKE I CANT SELL VAN WITH A DEFECTIVE PART OR CRUISE UNPLUGGED. HOW LONG DOES FORD HAVE TO REPAIR THIS PART. *TR