2005 Ford Excursion

2005 Ford Excursion 4-DR

Overall

Not Rated

Front Crash

Not Rated

Side Crash

Not Rated

Rollover

Not Rated

EXTERIOR LIGHTING:TAIL LIGHTS

FORD IS RECALLING CERTAIN MODEL YEAR 2011 RANGER TRUCKS BUILT FROM JANUARY 25, 2011, THROUGH APRIL 25, 2011 AT THE TWIN CITIES ASSEMBLY PLANT, AND SERVICE PARTS DISTRIBUTED TO DEALERS FOR CERTAIN 2004 THROUGH 2011 MODEL YEAR RANGER TRUCKS, 2002 THROUGH 2005 MODEL YEAR EXCURSION VEHICLES, AND 2002 THROUGH 2007 MODEL YEAR F-250, F-350, F-450, AND F-550 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE MULTI-FUNCTION SWITCH WAS SHIPPED WITH A SUBCOMPONENT (SLIDER) THAT MAY EXPERIENCE DEFORMATION. A MULTI-FUNCTION SWITCH WITH A DEFORMED SLIDER MAY MALFUNCTION CAUSING THE TURN SIGNAL, TAIL LIGHTS, HAZARD WARNING SIGNAL FLASHERS AND/OR BRAKE LIGHTS NOT TO ACTIVATE.

Campaign: 11V352000

ELECTRICAL SYSTEM:WIRING

CERTAIN PICKUP TRUCKS, SPORT UTILITY VEHICLES AND VANS EQUIPPED WITH 6.0L DIESEL ENGINES MAY EXPERIENCE STALLING WITHOUT WARNING WHILE DRIVING AND MAY OR MAY NOT RESTART.

Campaign: 05V270000

STEERING

Several times I’ll be driving and the steering wheel will jerk in one direction and wobble violently I will grab it to correct it and basically fight to keep it in the lane so I have to pull over and try again. I checked all steering components had it looked at by a mechanic and cannot figure out what could be the issue. It is very dangerous and terrifying to drive since it happens out of nowhere at random.

TIRES

LT275/65/R18 Tire developed a massive approximately 18in x 3in bubble on the inner section of tread causing significant vibration and excessive wear in that area in less than 50 miles

ELECTRICAL SYSTEM

WHILE DRIVING, THE ENGINE JUST QUITS AND LOSES ALL POWER. I HAVE TO SHIFT INTO NEUTRAL, TURN THE KEY ALL THE WAY TO OFF, AND RESTART THE ENGINE. SOMETIMES IT STARTS RIGHT UP, OTHER TIMES IT TAKES SEVERAL (MANY) TRIES TO GET THE ENGINE TO RESTART. IT CAN GO 200 MILES WITHOUT KILLING, AND THEN KILL 5 TIMES IN 5 MILES. THE ISSUE APPEARS TO BE SIMILAR TO THE RECALL 05S34 (NHTSA CAMPAIGN NUMBER: 05V270000), BUT THAT'S SPECIFIC TO DIESEL ENGINES, AND MY TRUCK HAS A GASOLINE ENGINE.

ENGINE

TL* THE CONTACT OWNS A 2005 FORD EXCURSION. WHILE UNDERGOING ROUTINE SERVICE BY AN INDEPENDENT MECHANIC, THE TECHNICIAN NOTICED THAT THE COOLANT LEAKING THROUGH THE ENGINE CYLINDER AND THE HEAD GASKETS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS NOT TAKEN TO A DEALER. THE MANUFACTURER INFORMED THE CONTACT THAT THE VIN WAS NOT INCLUDED IN A RECALL. THE APPROXIMATE FAILURE MILEAGE WAS 135,000. THE VIN WAS NOT AVAILABLE.

ENGINE

TL* THE CONTACT OWNS A 2005 FORD EXCURSION. WHILE DRIVING 65 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE CONTACT CALLED A LOCAL DEALER (CHAPMAN FORD, 9371 ROOSEVELT BLVD, PHILADELPHIA, PA 19114) AND WAS ADVISED TO SCHEDULE A SERVICE APPOINTMENT. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED AND REFERRED THE CONTACT TO NHTSA. THE FAILURE MILEAGE WAS 192,000.

POWER TRAIN,ENGINE

TL* THE CONTACT OWNS A 2005 FORD EXCURSION. WHILE DRIVING AT AN UNKNOWN SPEED, THE VEHICLE STALLED, SHUT OFF, AND THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE DEALER WAS CONTACTED (BUSS FORD, IN MCHENRY, IL) WHO STATED THAT THERE WAS NO RECALL. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THERE WAS NO RECALL. THE FAILURE WAS NOT DIAGNOSED. THE FAILURE MILEAGE WAS APPROXIMATELY 120,000.

AIR BAGS

DURING A SINGLE VEHICLE ACCIDENT DUE TO LOSING CONTROL AT, ACCORDING TO THE POLICE REPORT, 65 MPH AND RUNNING FRONT-END FIRST IN TO A ROCKY MOUNTAIN BANK THEN BOUNCING OFF SAID BANK ROTATING THE VEHICLE, AGAIN ACCORDING TO THE ACCIDENT REPORT, ROUGHLY 120-DEGREES THE FACTORY AIRBAG FAILED TO DEPLOY. EVEN WITH THE SEATBELT ON MY CHEST, STERNUM AND RIBS STILL MANAGED TO EITHER BE INJURED BY THE SEATBELT (NO VISIBLE SEATBELT MARKS OR TRAUMA) OR BY IMPACTING THE STEERING WHEEL. BASED ON THE FRONT END DAMAGE, DAMAGE TO THE FRONT SUSPENSION SPRINGS AND THE TRANSFER CASE ALONG WITH THE FRONT AND REAR DRIVESHAFTS COMPLETELY DETACHING THE WRECKER/TOW COMPANY ALSO QUESTIONED WHY THE AIRBAG DID NOT DEPLOY. SAID VEHICLE HAS NOW BEEN ACQUIRED BY COPART AT THE REQUEST OF MY INSURANCE COMPANY DUE TO THE VEHICLE BEING TOTALED. PEOPLE REPOT IS AVAILABLE THOUGH THERE IS NO MENTION OF AIRBAG DEPLOYMENT OR NON-DEPLOYMENT.

ELECTRICAL SYSTEM,FUEL/PROPULSION SYSTEM

WHILE DRIVING THE TRUCK THE ACCELERATOR BECOMES NONRESPONSIVE AND SOON AFTER THE TRUCK SHUTS DOWN, COMPLETE POWER LOSS. VERY DIFFICULT TO STEER AND BRAKE. IT WILL START BACK UP MOST OF THE TIME, BUT ON OCCASION IT WILL TAKE 20 TO 30 MINUTES TO RE-START. FORD HAS A RECALL FOR THIS # 05S34. MY VIN INDICATES THAT MY EXCURSION ISN'T UNDER THIS RECALL, BUT THIS IS EXACTLY WHAT IS HAPPENING. THIS EVENT HAPPENS ON CITY STREETS AND HIGHWAYS, WHILE DRIVING OR SITTING AT A STOP SIGN OR STOP LIGHT. THIS EVENT HAS BECOME MORE FREQUENT AS MY WIFE WILL NO LONGER DRIVE IT DO TO THE VEHICLES HANDLING/BREAKING ISSUES WITHOUT POWER SO I ONLY DRIVE IT ON WEEKENDS. IT HAPPENS AT LEAST ONCE A DAY SOMETIMES REPEATEDLY WITHIN SECONDS AFTER RESTARTING AND SOMETIMES NEVER AGAIN DURING THE WEEKEND. IT ALSO IS NOT TIME OR DISTANCE RELATED. IT HAS HAPPENED LEAVING OUR HOUSE AND IT HAS HAPPENED 20 MINUTES INTO A DRIVE. VERY SPORADIC

EXTERIOR LIGHTING

TL* THE CONTACT OWNS A 2005 FORD EXCURSION. THE CONTACT STATED THAT THE EXTERIOR LIGHTS WOULD NOT FUNCTION. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER 11V352000 (EXTERIOR LIGHTING). THE FAILURE MILEAGE WAS APPROXIMATELY 130,000.

ELECTRICAL SYSTEM

TL* THE CONTACT OWNS A 2005 FORD EXCURSION. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 10 MPH, THE VEHICLE STALLED WITHOUT WARNING AND THE STEERING WHEEL BECAME DIFFICULT TO MANEUVER. THE VEHICLE WAS ABLE TO START ON THE FIRST ATTEMPT. THE FAILURE RECURRED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE INSTRUMENT PANEL AND THE FUEL INJECTION CONTROL MODULE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT INCLUDED IN THE NHTSA CAMPAIGN NUMBER: 05V270000 (ELECTRICAL SYSTEM). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 70,000.