2002 Ford Explorer

2002 Ford Explorer 4-DR.

Overall

Not Rated

Front Crash

Not Rated

Side Crash

Not Rated

Rollover

★★★☆☆

EXTERIOR LIGHTING

CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Campaign: 06E049000

VISIBILITY:GLASS, SIDE/REAR

CERTAIN CURVED TEMPERED REPLACEMENT GLASS MANUFACTURED BY HANGZHOU SAFETY GLASS LTD AND SUPPLIED TO SAFELITE BY AUTO TEMP INC., IDENTIFIED AS DOT-430, AND SOLD FOR USE ON CERTAIN DOMESTIC AND FOREIGN VEHICLES MAY NOT BREAK INTO SMALL PIECES AS EXPECTED OF TEMPERED GLASS AND FAILS TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 205, "GLAZING MATERIALS."

Campaign: 07E104000

EXTERIOR LIGHTING:HEADLIGHTS

DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Campaign: 09E025000

VEHICLE SPEED CONTROL

FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.

Campaign: 09V399000

EXTERIOR LIGHTING

SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Campaign: 09E012000

EXTERIOR LIGHTING

CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Campaign: 06E026000

VISIBILITY:GLASS, SIDE/REAR

THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 2002 FORD EXPLORER AND MERCURY MONTAINEER SPORT UTILITY VEHICLES. THE BRACKETS CONNECTING THE LEFT CYLINDERS TO EACH SIDE OF THE LIFTGATE GLASS COULD ROTATE OUT OF POSITION IF EITHER THE URETHANE BOND OR TORQUE ARE NOT SUFFICIENT.

Campaign: 01I010000

STRUCTURE

CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE AND ROAD SALT.

Campaign: 03V094000

STRUCTURE:BODY:HATCHBACK/LIFTGATE:HINGE AND ATTACHMENTS

ON CERTAIN SPORT UTILITY VEHICLES, THE LIFTGATE GLASS STRUT MAY BECOME DISENGAGED OR THE HINGE MAY FRACTURE ALLOWING THE GLASS TO FALL AND POSSIBLY BREAK.

Campaign: 04V442000

TIRES:SIDEWALL

VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE RIGHT SIDE TIRES MAY HAVE HORIZONTAL CUTS ON THE EDGE OF THE TREAD THAT COULD HAVE OCCURRED DURING VEHICLE ASSEMBLY.

Campaign: 01V171000

SUSPENSION,WHEELS,SERVICE BRAKES

The rear toe arms came unhinged or disconnected from their placement and sank down to continuously rub a groove in the inner rim. The suspension was affected, the steering was effecting especially when turning, it made the brakes stick, and made loud crunching and rolling noises. It is quite frankly dangerous. It was through no fault of mine that this happened, just weak design. I took it to a shop and they charged me all my money, but nothing was fixed.

AIR BAGS

I was driving down the road and my airbag instantly deployed in my face without cause or notice. I became completely disoriented as it hit my hand and face with severe force and was extremely loud and shocking. I thank God that I had just let off the gas and didn't hurt anyone else. If I had panicked or was going through an intersection, experiencing a turn, coming to a stop, or someone in front of me stopped I could have struck another vehicle or object and caused death or injuries. I have not brought the vehicle anywhere to be checked out yet. My insurance refuses to cover it. There were no warning signs of this airbag deployment.

SUSPENSION,ELECTRICAL SYSTEM,UNKNOWN OR OTHER

Suspenion and or traction was and the electrical system didnt work good

STRUCTURE,UNKNOWN OR OTHER

September 2, 2023 at about 6 pm I pulled over to grab a couple water bottles from the rear of my 2002 Ford Explorer Sport cause my engine was overheating. I got out walked to the rear of my vehicle pushed my unlatch button on the tailgate and I lifted the glass part of the rear hatch. Both air hinges were not working correctly to keep it up so I gently rested the glass on my hair that was put up in a bun and just a little bit of the glass was resting on the very top of my head where my hair was slicked back for my bun so my hands were free to grab the bottles of water. (My hair was the softest of resting place's). As I reached in the back to grab the water bottles I heard the loudest bang and hundreds of little pieces of glass fell everywhere around me. I was in so much distrot that I actually thought someone had shot at me with a fire arm but missed me and hit the rear glass instead. The top of my head was stinging and it felt like I had just been smacked with a tree branch and the glass had went all over me causing a few minor cuts and scrapes as I fell to my knees in shock my heart racing faster than I had even imagined a heart could beat while histaraclly crying from the trauma that just occurred I fell to the ground and for a full 15 minutes i sat there surrounded by glass and tears in so much shock, dazed and confused before I stood up and looked around at everything that then I only realized I WASN'T shot at because there was no bullet or bullet hole nor did a vehicle drive by nor was there any people closer than a mile to me when I realized that the glass had shattered for some UNKNOWN reason ON ITS OWN that it scared me so bad it traumatized me. After that day I was pulled over multiple times by numerous police agency's (sheriff, Medford PD, Central Point PD and State Police) because I didn't have the money to fix it let alone have the knowledge that it had a recall so I could get it replaced. I have pictures but it will not allow me to upload them.

AIR BAGS

The contact owns a 2002 Ford Explorer. The contact stated that while her fiancé was driving 45 MPH, the driver’s side and passenger’s side air bags inadvertently deployed without an impact or a crash, causing the contact’s fiancé to swerve and drive down into a ditch. No warning lights were illuminated. The front bumper, windshield, and passenger’s side taillight were cracked. No injuries were sustained. A Police report was not filed. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was 118,583.

ENGINE

The contact owns a 2002 Ford Explorer. The contact stated while driving 45 MPH, the vehicle shut off. The contact was able to coast off the freeway. There were no warning lights illuminated. The contact called an independent mechanic, but the mechanic declined to service the vehicle. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was notified about the failure and opened a case. The approximate failure mileage was 88,000.

VEHICLE SPEED CONTROL

The contact owns a 2002 Ford Explorer Sport Trac. The contact stated that after parking the vehicle, the following day it was discovered that the cruise control switch located on the steering wheel had overheated and melted. The cause of the failure was not yet determined. The manufacturer was notified of the failure and the contact was informed that the VIN was not included in NHTSA Campaign Number: 09V399000 (Vehicle Speed Control). The contact stated that the vehicle had experienced the failure listed in the recall. The local dealer was not contacted. The failure mileage was 120,000.

STEERING,ENGINE

The contact owns a 2002 Ford Explorer. The contact stated that the steering wheel intermittently seized while driving at various speeds without warning. After finding a replacement part at a salvage yard, the contact had the steering wheel replaced by an independent mechanic; however, the failure persisted. The contact also stated that an abnormal ticking noise was coming from the engine with the ABS warning light illuminated. The vehicle was taken back to the same independent mechanic and the contact was informed that the engine needed to be replaced. Neither the dealer nor the manufacturer was notified of the failure. The vehicle was not repaired. The failure mileage was unknown.

LATCHES/LOCKS/LINKAGES

The contact owns a 2002 Ford Explorer. The contact stated that while driving 55 MPH, the hood latch independently released, causing the hood to strike the windshield. The contact was able to get to the side of the roadway and closed the hood. The contact had not taken the vehicle to a dealer. The vehicle had not been diagnosed or repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 137,000.

POWER TRAIN

Overdrive light flashes after driving a little bit hard shifting doesn't shift into overdrive 4x4 lights indicate that it's working when the buttons are pushed but doesn't go into 4x4