2008 Ford Explorer

2008 Ford Explorer 4-DR. w/SAB

Overall

Not Rated

Front Crash

Not Rated

Side Crash

Not Rated

Rollover

★★★☆☆

VISIBILITY:GLASS, SIDE/REAR

CERTAIN CURVED TEMPERED REPLACEMENT GLASS MANUFACTURED BY HANGZHOU SAFETY GLASS LTD AND SUPPLIED TO SAFELITE BY AUTO TEMP INC., IDENTIFIED AS DOT-430, AND SOLD FOR USE ON CERTAIN DOMESTIC AND FOREIGN VEHICLES MAY NOT BREAK INTO SMALL PIECES AS EXPECTED OF TEMPERED GLASS AND FAILS TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 205, "GLAZING MATERIALS."

Campaign: 07E104000

EQUIPMENT

MARATHON IS RECALLING CERTAIN SEAT COVERS, BRAND SUPERHIDES WITH PART NUMBERS 593, 594, 578, 960, 228, 228-09, 267-08, 333, 625, AND 630, SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE SEAT COVERS ARE MADE OF HEAVIER THREAD AND ARE NOT COMPATIBLE WITH SEATS CONTAINING SIDE AIRBAGS. THE HEAVIER SEAT COVER COULD INTERFERE WITH FULL DEPLOYMENT OF THE AIRBAG IN THE EVENT OF A CRASH.

Campaign: 10E043000

POWER TRAIN:AUTOMATIC TRANSMISSION:COOLING UNIT AND LINES

ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH THE 4.6L ENGINE AND 6R TRANSMISSION, THE BOLT SECURING THE TRANSMISSION OIL COOLER LINE FITTINGS AT THE TRANSMISSION MAY NOT HAVE BEEN SUFFICIENTLY TORQUED DURING VEHICLE ASSEMBLY. AS A RESULT, THE BOLT MAY LOOSEN AND THE TRANSMISSION OIL COOLER LINES MAY DISENGAGE FROM THE TRANSMISSION, CAUSING A TRANSMISSION FLUID LEAK.

Campaign: 07V453000

POWER TRAIN

The contact owns a 2008 Ford Explorer. The contact stated that while attempting to park the vehicle, the gear shifter was shifted into park, and the vehicle rolled backwards about an inch. No warning lights were illuminated. The contact stated that the parking brake was enabled to stop the vehicle. The vehicle was taken to an independent mechanic, where it was diagnosed with possible transmission failure. The vehicle was not repaired. The contact referenced an unknown recall; however, the VIN was not associated with a recall related to the failure. The manufacturer was not made aware of the failure. The failure mileage was approximately 165,000.

ENGINE

Stalling in mid traffic. I was told it is poor quality of timing components. The vehicle has less than 200,000 miles and has had routine maintenance as it was a police investigation car

UNKNOWN OR OTHER,ENGINE

I got the car from my landlord, my husband never checked the oil or fluids even though I was on him, it died 2 months after we got it, the guy said before we purchased it that it still was under warranty for transmission, so when it died I thought ok it's covered, so the landlord said it was the motor it seized he said had no coolant and was 2qts of oil over I said well he never added anything & I said it never overheated, he said I don't know how it was done but it will cost $3800 to fix, so I was hoping that there might be a recall that can fix this or also he puts new rear in the car a week after I got it, does any of this sound like it is his side that is reliable to fix it?

Other/I am not sure

The stickers are not on properly. My childs safety wasnt put at risk. I asked a CPST to help with a fit and intall check and we noticed the defected stickers.

ELECTRICAL SYSTEM,VEHICLE SPEED CONTROL,ENGINE

Report #1 - My grandma brought this 08' Explorer back in 2014, and after she passed, my mom drove it for the next 2 years. It started having general maintenance issues, then the cats were stolen, but then, one night my mother was coming home from a relative's house, when she was trying to keep up with the flow of traffic on [XXX] , and she noticed that the vehicle was not accelerating at all and the vehicle stalled out. She had it towed home and it sat on the streetside for some time. After digging through the internet, I figured that Ford designed the throttle-body wiring to settle next to the cooling hoses, and after time, the wires rot from the hot temperatures of the hoses and crack/snap causing the vehicle to either stall, or possibly have unintended acceleration. Ford never recalled this issue! Also, it had a massive coolant leak, from which was believed to be the cheap plastic T-Stat housings that Ford never recalled, and to top it all off: the right rear turn-indicator failed from the faulty wiring harnesses... As a result, we ended up having it scrapped/junked. It was sad to see her go, but obviously Ford doesn't care about their customers safety and will find any loophole to avoid recalling a vehicle... Ford needs to get their stuff together or they need to be shut down!... INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

VEHICLE SPEED CONTROL

The wiring harness going into the back of what I believe is the throttle position sensor has a 180° turn in the wiring in a very short distance. There are four wires involved in that portion of the wiring harness. The wiring is also next to the hot, cooling system hoses coming out of the firewall. These factors caused the wiring to crack prematurely creating surges in the idle and the vehicle speed to be uncontrollable due to shorts/arcing in the electrical wiring. An extremely dangerous situation. My daughter ran into a bullard because she started the vehicle, put it in drive, and it took off on her. Vehicle would drive at 20 to 25 miles per hour on its own without stepping on the gas pedal. After two or three attempts, I was able to satisfactorily fix the wiring. Please note that the attached pictures do not show the original condition of the wiring. I attempted to use liquid electrical tape on one of my first attempts but that soon cracked as well. You will see that in one of the photos. I may have original pictures of the electrical wiring on my desktop computer and will gladly submit those at a later time if I can find them. This failure in the wiring should be easy to identify in any 2008 Ford Explorer.

POWER TRAIN,ELECTRICAL SYSTEM,BACK OVER PREVENTION

AN ORANGE WRENCH LIGHT COMES ON ON MY DASHBOARD AND I CAN'T PICK UP SPEED. I'VE HAD IT LOOKED AT A FEW TIMES AND NO ONE CAN FIGURE OUT THE PROBLEM. THERE'S BEEN MANY PEOPLE ON YOUTUBE COMPLAINING OF THE SAMETHING. THIS IS VERY DANGEROUS AND SHOULD BE INVESTIGATED IMMEDIATELY, LUCKILY THE INTERSTATE WASN'T BUSY WHEN MY TRUCK LOST ITS ABILITY TO ACCELERATE. I COULD'VE CAUSE A CAR PILE UP AND THERE COULD'VE BEEN MANY LIVES LOST

ELECTRICAL SYSTEM

MY 2008 FORD EXPLORER HAS BEEN HAVING ISSUES RECENTLY WHERE IT TURNS OVER AND WILL NOT START, THEN WILL START. TODAY WHILE DRIVING ON THE FREEWAY AT 65 MPH MY CHECK ENGINE LIGHT CAME ON WITH THE SERVICE WRENCH AND THE CAR LOST ALL POWER AND THE STEERING STIFFENED UP AND WAS HARD TO STEER AT ALL ALMOST CAUSING ME TO WRECK ON THE FREEWAY. I LOST ALL POWER AND CONTROL AT THE GAS PEDAL AND THEN THE CHECK CHARGING SYSTEM ICON CAME ON ALSO. I HAD TO COMPLETELY PULL OVER TO THE SHOULDER AND PUT IT IN PARK THEN SHUT OFF THE CAR. I THEN HAD TO RESTART THE CAR WHICH STARTED RIGHT AWAY AND STARTED TO DRIVE FINE AGAIN. THIS HAPPENS MORE THAN ONCE A DAY, MY FRIEND HAS CHECKED THE CHARGING SYSTEM AND CLEANED THE BATTERY CABLES AND HAS OVER 14 VOLTS CHARGING FROM ALTERNATOR TO BATTERY AND STILL HAPPENS. THE DTC CODE WAS PULLED AND WAS A P0607. CONTROL MODULE FAILURE OR CORRUPT.

VEHICLE SPEED CONTROL,ENGINE

ENGINE LIGHT AND TRACTION CONTROL LIGHT AND WRENCH LIGHT ALL CAME ON AND CAR WENT TO IDLE AND WOULD NOT REV UP LIKE IT WAS STUCK OM IDLE--THIS HAPPENED WHILE DRIVING 60 MILES PER HOUR IN HEAVY TRAFFIC AND I WAS ALMOST REARENDED OVER IT.

POWER TRAIN,WHEELS

TRANSMISSION ON MY FORD EXPLORER V8 4.6 LIMITED NOT CHANGING INTO LAST GEAR. WHEN COMING TO A COMPLETE STOP TRANSMISSION JERKS SLIGHTLY. AT 61000 MILES NOW ..... I DIDN'T EXPECT TRANSMISSION PROBLEMS. FRONT WHEEL BEARINGS ARE HUMMING..... I HAD THIS WHEEL BEARING PROBLEM BEFORE ON MY OTHER 2008 FORD EXPLORER XLT 6 CYLINDER 4.0