1996 Ford F-150

1996 Ford F-150

Overall

Not Rated

Front Crash

Not Rated

Side Crash

Not Rated

Rollover

Not Rated

EXTERIOR LIGHTING

SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Campaign: 09E012000

EXTERIOR LIGHTING

CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Campaign: 06E026000

VEHICLE SPEED CONTROL

ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH SPEED CONTROL, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT, SMOKE, OR BURN.

Campaign: 05V388000

EXTERIOR LIGHTING:HEADLIGHTS

DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Campaign: 09E025000

EXTERIOR LIGHTING

CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Campaign: 06E049000

SEATS

THE SEAT RECLINER TO SEAT FRAME ATTACHING BOLTS ON THESE VEHICLES COULD LOOSEN, FATIGUE AND FRACTURE, ALLOWING THE SEAT BACK TO SUDDENLY RECLINE.

Campaign: 96E010000

EQUIPMENT:OTHER:LABELS

THE CERTIFICATION LABELS ON THE INVOLVED VEHICLES HAS INCORRECT REAR TIRE INFLATION PRESSURE DESIGNATIONS. THIS DOES NOT COMPLY WITH FMVSS NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS."

Campaign: 96V161000

VEHICLE SPEED CONTROL

The contact owned a 1996 Ford F-150. The contact received notification of NHTSA Campaign Number: 05V017000 (Vehicle Speed Control). The contact stated that while parked in the driveway, she observed fire between the finder and the hood. The heat from the fire rippled the front of the garage causing property damage. The vehicle was not diagnosed and the origin of the fire was not determined. The fire was extinguished by the fire department. The vehicle was towed to an unknown impound lot. It was unknown if a police report or fire department report was filed. The manufacturer was notified of the failure. The failure mileage was approximately 75,000.

ELECTRICAL SYSTEM

The contact owns a 1996 Ford F-150. The contact stated that while driving at unknown speeds, the speedometer became inoperable. The driver was unable to accurately determine the speed. There were no warning lights illuminated. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 218,000.

ELECTRICAL SYSTEM,UNKNOWN OR OTHER,ENGINE

I am unsure of what happened. This truck was sitting in my driveway and caught fire. While on fire it kept trying to start even though no one was in it and the keys were no where near it. The fire truck was called out due to the trucks proximity to the home and the fire was put out. There has not been any insoection done on the vehicle since it is burnt to a crisp.

FUEL SYSTEM, GASOLINE,ENGINE

The contact owns a 1996 Ford F-150. The contact stated while driving 45 MPH, the vehicle started to shutoff and restart independently. The check engine warning light was illuminated. The vehicle was diagnosed by an independent mechanic. The mechanic informed the contact that the rear tank’s fuel pump needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and confirmed that there was no open recall associated with the VIN for the failure. The failure mileage was approximately 130,000. The contact stated there is an issue with the front fuel tank feeding fuel into the rear tank when the rear tank pump is not operational and having to switch the fuel supply over to the front tank. When the rear tank is full from the front tank feed, it spills over out of the rear tank fill spout, and runs out on the ground.

FUEL/PROPULSION SYSTEM

The front fuel tank is overflowing when I run the vehicle with the rear tank. The return fuel is always to the front tank causing it to overflow its a hazardous situation.

ELECTRICAL SYSTEM,SERVICE BRAKES,FORWARD COLLISION AVOIDANCE

The brake fluid pressure sensor is leaking on to the electrical main computer wires its also leaking from the electrical harness coming from the brake fluid pressure sensor causing the brake tail lights to fail intermittently during vehicle operation

SEAT BELTS

TL* THE CONTACT OWNS A 1996 FORD F-150. THE CONTACT STATED THAT THE DRIVER'S SIDE SEAT BEAT ANCHOR RUSTED AND DETACHED RESULTING IN THE SEAT BELT DRAGGING ON THE GROUND. THE VEHICLE WAS NOT TAKEN TO THE LOCAL DEALER. THE VEHICLE WAS NOT YET REPAIRED. THE MANUFACTURER WAS INFORMED OF THE FAILURE BUT OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 151,000.

FUEL/PROPULSION SYSTEM

FUEL FROM REAR TANK FILLS FRONT TANK.IT CAN OVERFLOW CAUSING A FIRE.

AIR BAGS

ABOUT 10 YEARS AGO, KELLY FORD IN EMMAUS, PA REMOVED MY DRIVERS AIRBAG AND TOLD ME IT WOULD BE REPLACED. IT WAS NEVER REPLACED. KELLY SOLD THE DEALERSHIP AND I NEVER HEARD ANOTHER THING ABOUT IT.

UNKNOWN OR OTHER

A SMALL CHIP IN THE WINDSHIELD RESULTED IN A BIG CRACK AFTER THE WEATHERS TEMPERATURE DROPPED TO FREEZING.