2006 Ford F-150

2006 Ford F-150 Supercab

Overall

Not Rated

Front Crash

Not Rated

Side Crash

Not Rated

Rollover

★★★★☆

2006 Ford F-150 Regular Cab

Overall

Not Rated

Front Crash

Not Rated

Side Crash

Not Rated

Rollover

★★★★☆

2006 Ford F-150 Supercrew 4-DR.

Overall

Not Rated

Front Crash

Not Rated

Side Crash

Not Rated

Rollover

★★★★☆

AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE

FORD IS RECALLING CERTAIN MODEL YEAR 2004-2006 F-150 PICK UP TRUCKS AS WELL AS CERTAIN MODEL YEAR 2006 LINCOLN MARK LT VEHICLES. IF THE CLOCKSPRING JUMPER WIRE COMES IN CONTACT WITH THE DRIVER SIDE FRONTAL AIR BAG LOWER HORN PLATE, THE WIRE INSULATION MAY BECOME CHAFED, CREATING A POTENTIAL FOR A SHORT CIRCUIT. IF THIS OCCURS THE AIR BAG WARNING LAMP MAY ILLUMINATE INDICATING THAT SERVICE IS REQUIRED.

Campaign: 11V107000

EXTERIOR LIGHTING

SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Campaign: 09E012000

VISIBILITY:WINDSHIELD WIPER/WASHER:MOTOR

ON CERTAIN TRUCKS, PASSENGER CARS AND SPORT UTILITY VEHICLES, THE WINDSHIELD WIPER MOTOR MAY HAVE BEEN PRODUCED WITHOUT GREASE BEING APPLIED TO THE OUTPUT SHAFT GEAR.

Campaign: 05V520000

EXTERIOR LIGHTING:HEADLIGHTS

DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Campaign: 09E025000

EXTERIOR LIGHTING:HEADLIGHTS

CERTAIN HEADLAMP ASSEMBLIES IMPORTED AND SOLD AS AFTERMARKET EQUIPMENT BY SONAR AUTO PARTS FOR USE ON 2004-2007 FORD F150 PICKUP TRUCKS. DURING PRODUCTION, THE HEADLAMPS WERE INTERNALLY MISALIGNED AND THEY FAIL THE PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Campaign: 07E080000

EXTERIOR LIGHTING:HEADLIGHTS

CERTAIN ANZO COMBINATION HEADLAMP ASSEMBLIES SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES. SOME COMBINATION LAMPS ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS WHICH FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."

Campaign: 06E023000

TIRES:TREAD/BELT

CERTAIN CONTINENTAL CONTITRAC TR OWL, CONTITRAC TR BSW, GENERAL GRABBER TR BSW, AND CONTITRAC BSW TIRES MANUFACTURED BETWEEN MAY 29 AND JUNE 11, 2005, AND SOLD AS ORIGINAL EQUIPMENT ON CERTAIN FORD TRUCKS AND SOLD AS REPLACEMENT TIRES. THESE TIRES CAN WEAR PREMATURELY WHICH FAILS TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 119, NEW PNEUMATIC TIRES FOR VEHICLES OTHER THAN PASSENGER CARS.

Campaign: 05T022000

EXTERIOR LIGHTING

CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Campaign: 06E064000

SERVICE BRAKES, HYDRAULIC:POWER ASSIST:VACUUM:HOSES, LINES/PIPING, AND FITTINGS

FORD IS RECALLING 605,684 MY 2005-2006 F-150 AND LINCOLN MARK LT VEHICLES EQUIPPED WITH 5.4L 3-VALVE ENGINES. THE BRAKE BOOSTER VACUUM SUPPLY HOSE ATTACHED TO THE INTAKE MANIFOLD FITTING MAY SWELL OVER TIME AND LOSE RETENTION FORCE. THIS CONDITION COULD ALLOW THE HOSE TO BECOME DETACHED FROM THE FITTING DURING AN INTAKE MANIFOLD BACKFIRE. SHOULD THE HOSE DETACH FROM THE INTAKE MANIFOLD, SEVERAL BRAKE APPLICATIONS WITH POWER ASSIST WILL BE AVAILABLE BEFORE THE VACUUM RESERVE IS DEPLETED.

Campaign: 08V208000

EQUIPMENT:ELECTRICAL

CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.

Campaign: 07E066000

EXTERIOR LIGHTING

CERTAIN AAI MOTORSPORTS COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LIST PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."

Campaign: 06E060000

EXTERIOR LIGHTING:HEADLIGHTS

CERTAIN SPYDER HEADLAMP REPLACEMENT ASSEMBLIES SOLD FOR USE ON 2004 THROUGH 2007 FORD F150 PICKUP TRUCKS. DURING PRODUCTION, THE HEADLAMPS WERE INTERNALLY MISALIGNED AND THEY FAIL THE PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Campaign: 07E089000

INTERIOR LIGHTING

CERTAIN PICKUP TRUCKS FAIL TO COMPLY WITH EITHER THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD (FMVSS) NO. 105, 'HYDRAULIC AND ELECTRIC BRAKE SYSTEMS' OR FMVSS NO. 135, 'PASSENGER CAR BRAKE SYSTEMS.' THESE VEHICLES WERE BUILT WITH A SOFTWARE ERROR IN THE INSTRUMENT CLUSTER.

Campaign: 06V033000

EXTERIOR LIGHTING:HEADLIGHTS

CERTAIN EAGLE EYES HEADLAMP ASSEMBLIES, P/NOS. FR390-B001L AND FR390-B001R, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THE THICKNESS IS UNSTABLE INHIBITING THE PERFORMANCE OF THE UPPER AND LOWER BEAMS WHICH FAILS TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Campaign: 07E075000

STRUCTURE

The dealership sold this vehicle to me with a rusted frame

AIR BAGS

The contact owns a 2006 Ford F-150. The contact stated that while the contact's son was driving at an undisclosed speed, there was an abnormal sound coming from the vehicle. No warning lights were illuminated. The contact's son lost control of the vehicle, and the vehicle crashed into a guardrail and landed on its side. The air bags did not deploy. The vehicle was towed to a local tow yard. A Police report was filed; the information was unavailable. No injuries were sustained. The manufacturer was not made aware of the failure. The failure mileage was approximately 200,000. The VIN was unavailable.

UNKNOWN OR OTHER

The problem is that the paint in the cargo area is peeling or fading, and I think that problem is a factory defect. That part of the cargo area is galvanized, I need to know if that is in a recall, thank you.

VISIBILITY/WIPER

Around the 1st of February 2026 the weather had turned cold around 6 degrees Fahrenheit and I had just had my vehicle inspected in January so I know everything was fine then. My wife and I had driven to her office about 2 miles from our home and I of course had the heat on and defrost on. We went into the office to clean because that a weekly job for us usually under an hour. When we came out my windshield was cracked on the passenger side starting at the bottom going straight up about 8” long. The weather stayed cold and a few days later it cracked more and then more and then more. It’s moving over towards the drivers side horizontally about eye level. There is no rock strike where the crack started, it seems to me that when heat was applied to the windshield something expanded or contracted or flexed while we were inside the office because it was cracked when we came out to leave. I haven’t taken it to a Ford dealership to have it looked at or filed an insurance claim. It’s been about two months now I need to get it fixed before the whole windshield collapses into my lap. I realize the safety issue with a cracked windshield and it could cause me and others on the road to get hurt. I’ve only driven it to doctors appointments and to pick up medication at the store a mile away. I’ve never had a vehicle that has had the windshield crack due to clod weather when it was heated up and then cooled back down. Either the glass was manufactured incorrectly or it was installed incorrectly or the framing expanded or contracted causing it to bind the glass. If you could please look into this for me it would be greatly appreciated.

AIR BAGS

I WAS RECENTLY INVOLVED IN AN ACCIDENT IN MY VEHICLE. IT WAS A HEAD ON COLLISION AND MY AIRBAG DID NOT FULLY DEPLOY. THOUGH I WAS TRAVELLING THE SPEED LIMIT, HAD I BEEN ON A FREEWAY AND GOING THE LEGAL SPEED LIMIT I THINK I MIGHT HAVE BEEN SERIOUSLY INJURED. THE LIBABLE INSURANCE COMPANY ENCOURAGED ME TO CONTACT FORD TO SEE IT THIS HAS BEEN AN ISSUE. THERE WERE NOT WARNING LIGHTS OR ANY OTHER SYMPTOMS PRIOR TO THE ACCIDENT.

ENGINE

Received notification by mail from your department about a recall on my trucks spark plugs breaking in the head .Took vehicle to local ford dealer and was told the vehicle was required to have over 100 thousand miles before the plugs would be replaced under recall . Now my vehicle has over 150 thousand miles and when I went to the same dealer I was told there wasn’t a recall on this truck . My documents I received from your department was lost during hurricane Sally. This is a well known recall every local mechanic knows about .

ELECTRICAL SYSTEM

Odometer Fraud. The contact sold a 2006 Ford F-150. The contact stated that the vehicle was sold with approximately 212,000 miles but later discovered that the buyer had relisted the vehicle for sale with an advertised mileage of 135,713. The vehicle was a private sale. Local authorities had been notified.

SERVICE BRAKES, HYDRAULIC

The contact owns a 2006 Ford F-150. The contact stated that while coming to a stop, the brake pedal was depressed but failed to function as intended. The contact stated that the vehicle failed to stop and continued rolling forward. The contact stated that the vehicle came to a stop once the brake pedal was depressed to the floorboard. No warning lights were illuminated. The contact stated that the vehicle returned to normal function afterwards. The local dealer was contacted; however, the dealer refused to diagnose the vehicle because of its age of the vehicle. The vehicle was not repaired. The contact stated that on a separate occasion, while the contact's husband was driving at a slow speed, the brake pedal was depressed but failed to function as intended. The contact stated that the vehicle failed to stop and continued rolling forward. The contact's husband stated that the vehicle came to a stop once the brake pedal was depressed to the floorboard. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline. The failure mileage was approximately 145,000.

POWER TRAIN,ELECTRICAL SYSTEM,ENGINE

while in drive, accelerating to highway speeds or cruising around 30 mph it will downshift and jump to about 4000 PMS's and not shift up into 3rd gear. It blown 1 engine and I have replaced the transmissions, taken it to a Ford dealership and they weren't able to help me. I've replaced the ECM and anti-theft modal also and the symptoms still persist. i am i in for over 11K for the new engine and transmission, and another $100 on the ECM and anti-theft modal plus the shop charges. The truck has under 190,000 miles before any of this started. I am the 2nd owner an had for less than 3k miles before any of the problems started. Now I see the 2015-2017 F-150s are having the same problems getting recalled. is there anything involving the earlier Triton's engines?

STRUCTURE

See attached document for complaint.