2020 Ford F-250 Supercab

2020 Ford F-250 Supercab PU/EC 4WD

Overall

Not Rated

Front Crash

★★★★☆

Side Crash

Not Rated

Rollover

★★★☆☆

2020 Ford F-250 Supercab PU/EC 2WD

Overall

Not Rated

Front Crash

★★★★☆

Side Crash

Not Rated

Rollover

★★★★☆

SEATS:FRONT ASSEMBLY:RECLINER

Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."

Campaign: 19V633000

POWER TRAIN

10r140 paired with 6.7 powerstroke in a 2020 f250 build date 11/19 at the Kentucky plant. My truck specs and build date and location is in the timeframe of the planetary gear recall, ford has also issued tsb’s about the cdf bushing that should have been a recall because it is a design flaw on every 2020-2022 model truck. It’s not fair that we should have to pay for a tsb bc we don’t have warranty left. My truck has 84,000 miles but is out of the 5 years warranty period. Symptoms I am having with my transmission are: Harsh engaging to drive and reverse Flair shifts bad sometimes almost like it goes into neutral between changing gears Has shifted from 4th to 1st instead of 4th to 5th or 6th, then it started shifting normal right after. Had my factory 3250rpm limiter not been moved to 4500rpm the truck would have locked the rear wheels up and possible caused driveline damage or other damaged. Also had a car been behind me when this happened I would have been in a wreck because it slammed to a low speed and the car would have rear ended me. Slips in 4th and 7th gear the most but sometimes in other gears Bumps when it shifts a lot of the gears Sometimes shudders and shakes and will almost make like a pop noise Will clunk on downshift from 5-3 Sometimes clunks when upshifting 3-5 I have had the truck looked at by an independent diesel mechanic I use and he said there is a problem somewhere in the transmission, it’s either planetary gear or cdf bushing has moved or the drum itself has cracked. The component itself has not been inspected because the only was to inspect this is to tear the transmission down. The pan has been dropped and had a lot of metal material on the magnet. No codes on the dash but my mechanic said I had dtcs stored for the transmission. I have created a case claim with Ford trying to see if they will extend the recall for the known issue but I have had zero luck with them. I have videos of the issues but can’t upload them on here.

POWER TRAIN

The contact owns a 2020 Ford F-250. The contact received notification for NHTSA Campaign Number: 22V256000 (Power Train); however, the recall repair could not be completed. The vehicle was taken to a dealer where it was diagnosed that a thrust washer was missing from the output planetary assembly and had disintegrated, contaminating the transmission case, transfer case, torque converter, cooling lines, and radiator. The missing washer caused the planetary gear to shift and damage the transmission case. The manufacturer was notified of the failure, and a complaint was filed. The failure mileage was 80,256.

AIR BAGS,SEAT BELTS,SEATS

Left rear seat belt buckle or system failed causing a fault in the Airbag/Restraint system. The fault initially happened in June of 2025 with about 50k miles on the vehicle. I took it to a dealer who told me the buckle was not available and the whole system needed to be replaced for over $1500. Vehicle seldom has anyone in the back seat but that is where my children sit. Looking at posts on the internet, this seems to be a common enough problem that this should be taken care of under recall or customer service warranty.

FUEL SYSTEM, DIESEL,POWER TRAIN

The contact owns a 2020 Ford F-250. The contact received notification of NHTSA Campaign Number 24V957000 (Fuel System, Diesel); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact stated that the vehicle had become inoperable due to a transmission failure. The contact associated the transmission failure with the recall; however, the dealer advised that the transmission repair would be at the owner's expense. The approximate failure mileage was 60,000.

STEERING

The contact owns a 2020 FORD F-250. The contact received notification of NHTSA Campaign Number: (25V626000 (STEERING) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.

FUEL SYSTEM, DIESEL

The contact owns a 2020 Ford F-250. The contact stated that he received NHTSA Campaign Number: 24V957000 (Fuel System, Diesel). The local dealer was contact who confirmed there were metal shaving in the fuel injectors. The vehilce was not repaired. The manufacture was not contacted. The failure mileage was approximately 30,000.

UNKNOWN OR OTHER

Vehicle: 2020 Ford F‑250 Super Duty VIN: [XXX] Issue: Front / CHMSL camera intermittent or inoperative Ford CSP 20B39 applies CSP cannot be completed due to Gateway Module failure Ford has not responded despite multiple written requests I have personally sent emails to them on: Sent April 6 Sent April 9 Sent April 16 4/29 - Called and asked for coordination. Received no acknowledgment RE: Request for Coordination With Dealer to Complete Recall 20B39 [XXX] [XXX] > Thu, Apr 16, 11:59 AM (13 days ago) to crcfmc, [XXX] , [XXX] , [XXX] Dear Ford Customer Relationship Center, I'm writing to follow up again on my previous emails of April 6 and April 9 regarding my 2020 Ford F-250 Super Duty (VIN: [XXX] ). I have not received any response or confirmation of receipt. I want to correct my earlier characterization — after further research, I understand that 20B39 is a Customer Satisfaction Program, not a safety recall. That said, the core issue and my position remain the same, and I want to lay out where things stand clearly. The situation: - My vehicle is covered under CSP 20B39 (Front View and CHMSL Camera — PCB conductivity issue causing intermittent camera operation) - The program is in effect through November 30, 2030 or 150,000 miles, and the repair is to be performed at no charge to the vehicle owner - My servicing dealer, Santa Margarita Ford, attempted to complete the CSP work but could not because the vehicle's Gateway Module is not communicating properly - The dealer has advised that the Gateway Module must be replaced before the camera work under XXX can be completed My position: Ford issued CSP XXX and committed to completing this repair at no charge. If the Gateway Module must be functional in order for Ford's own program to be executed, then resolving the Gateway Module issue is Ford's prerequisite to meet — not an out-of-pocket cost to push to the customer. I'm not asking for anything beyond INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

STEERING,SUSPENSION

While driving at speeds above 30mph truck will have the death wobble. We will lose complete control in direction of steering. Have to try to stop and then turn the wheel right and left before the truck will regain normal travel. Is a huge safety issue and has almost caused us to wreck. Has happened multiple times and we have been unable to determine what has caused the issue. We have had the steering column recall fixed and have even changed the tie rod ends with no change.

SERVICE BRAKES

This vehicle was delivered yesterday to my son through Autonation Sanford [XXX] . The CARFAX report stated a pre delivery inspection was done prior. On the way home he experienced loud screeching from the front wheels. Turns out $1650 later he needed new brakes and rotors. That is negligence, and fraud, especially with a commercial vehicle intended on towing a fishing boat. This was underhanded and a disgusting pattern of behavior. In addition, the open fixable recall was NOT completed as we just found out from searching the VIN on your website. The managers name is [XXX] , I have reached out to him to rectify this situation, and no call back. Truly grotesque, taking advantage of a [XXX] kid. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

ENGINE,FUEL/PROPULSION SYSTEM

Vehicle experienced loss of power while in travel down a mountain. After inspection by a mechanic, CP4 pump had a catastrophic failure sending metal shards throughout the fuel system. This was less than a month after Fords SAFETY RECALL 24S78 that failed to remedy the problem, but before recall Number26V158 was issued.