2019 Ford F-350 Regular Cab

2019 Ford F-350 Regular Cab PU/RC 4x4

Overall

Not Rated

Front Crash

Not Rated

Side Crash

Not Rated

Rollover

Not Rated

2019 Ford F-350 Regular Cab PU/RC 4x2

Overall

Not Rated

Front Crash

Not Rated

Side Crash

Not Rated

Rollover

Not Rated

ENGINE

Ford Motor Company (Ford) is recalling certain 2015-2019 Ford F-150 and 2017-2019 Ford F-250 Super Duty, F-350 Super Duty, F-450 Super Duty, and F-550 Super Duty pick-up trucks equipped with an engine block heater. Water and contaminants may get into the block heater cable's splice connector causing corrosion and damage.

Campaign: 18V894000

SEATS:FRONT ASSEMBLY:RECLINER

Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."

Campaign: 19V633000

POWER TRAIN:AXLE ASSEMBLY

Ford Motor Company (Ford) is recalling certain 2019 F-250 and F-350, single rear wheel and dual rear wheel, 4X4 vehicles. The front axles may contain a wheel end yoke that was not properly welded to the axle tube end.

Campaign: 20V576000

POWER TRAIN:AXLE ASSEMBLY:AXLE SHAFT

Ford Motor Company (Ford) is recalling certain 2019 F-250 and F-350 vehicles equipped with electronically locking rear differentials. The passenger side rear axle shaft may fail prematurely due to a material issue.

Campaign: 19V688000

FUEL/PROPULSION SYSTEM

This model has the same Bosh CP4 high pressure fuel pump as the recalled models 2020-2022 and in fact being older the catastrophic failure risk is higher due to additional mileage. If this part fails the engine shuts off with loss of steering and braking even when pulling 15-20K pounds. The safety concern for this year is the same or greater then newer models.

STEERING,LANE DEPARTURE

A steering control module in my steering wheel failed which makes the lane keeping warning not operate correctly and the steering wheel not straight it's set at an angle to the right so when you're driving down the road you have to have it constantly turn to the right a little bit in order to go straight down the road in order to fix it you have to replace the entire steering wheel which is about 3,400 or so.

ENGINE,FUEL/PROPULSION SYSTEM

While sitting at a stop sign, the fuel supply line blue off the fuel filter under the hood. Straying diesel fuel all over. The white clip that hold the hose on had crumbled apart, It soaked the engine with fuel and we were lucky it did not start a fire. The fuel line was reattached and it then blew off again. I had to replace the entire fuel line at a cost of around $1000. Prior to the first event the filter had been on the truck and was being serviced every other oil change in line with the manufactured guidelines. When looking on line this is a major problem with the fuel line and under hood filters causing fires. This needs a repair before more people are hurt

BACK OVER PREVENTION

My rearview camera is showing a distorted image and then goes blank while in reverse creating a safety issue while backing up. The camera is doing everything listed in the following recall campaigns: 20C19/22V252 20C19/24V188 20C19/20V575 but Ford says my truck does not qualify for the recall because my VIN is not listed in the recall.

FUEL/PROPULSION SYSTEM

Failed component was the upper fuel filter/ fuel filter connecting lines located on top of the 6.7 power stroke engine broke and poured diesel all over the engine and into the valley causing the engine and engine bay to catch on fire while driving down the road. Safety was the fact that our entire truck burnt down and there was extreme risk of loss of life and ended up total loss of property. There have been multiple cases of power strokes from 2011-2026 equipped with the 6.7L power stroke diesel engine having this exact same problem due to the poor placement and inadequate materials to be used in high pressure fuel lines and filters. The vehicle was inspected by insurance and they did determine that was the cause of the fire. There were no warnings, we started smelling something and then smoke began coming through the vents. Pulled over and by then the engine bay was on fire and even the fire extinguisher could not put the diesel out and the entire truck was engulfed in flames in a matter of minutes. Ford needs to fix this issue with the placement of their upper fuel filters and should be held accountable to their customers who have suffered loss for this.

ENGINE

I have about 54000 miles on a 2019 ford super duty 350 with the Power stroke 6.7. Engine light went on and its at Willowbrook ford in Illinois. Emission problem with Particular Sensor code 22e02. The cost of repair is between 816 plus another 1259 if it is cracked. This is absolutely ridiculous. After researching this is a big Ford problem. So they sold some trucks without them and have eliminated them on their 22 models. I think Ford should be responsible for the cost.

VISIBILITY/WIPER

Rear window shattered when rear window defrost was activated.

FUEL SYSTEM, GASOLINE,ENGINE

The contact owns a 2019 Ford F-350. The contact stated that while driving at an undisclosed speed, the check engine warning light was illuminated. The contact stated that after the vehicle was parked and turned off, there was fuel leaking from the engine compartment. The contact became aware that the fuel line was inoperable, causing fuel to leak onto the engine and the exhaust system. The dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 44,000.

ELECTRICAL SYSTEM,VISIBILITY/WIPER

My back up camera is not working.

BACK OVER PREVENTION

The contact owns a 2019 Ford F-350. The contact stated that while reversing, the rearview camera failed to display a rearview image. The contact stated that the vehicle returned to normal functionality, but the failure became a regular occurrence. No warning lights were illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 25V442000 (Back Over Prevention), but the VIN was not included. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 40,000.