2010 Ford Flex

2010 Ford Flex 4-DR. w/SAB

Overall

Not Rated

Front Crash

Not Rated

Side Crash

Not Rated

Rollover

★★★★☆

AIR BAGS:FRONTAL

Ford Motor Company (Ford) is recalling certain model year 2009-2012 Ford Flex, 2008 and 2010-2012 Ford Taurus, 2008-2009 Ford Taurus X, 2008 Mercury Sable, 2009 and 2011 Lincoln MKS vehicles. The driver frontal air bag may improperly inflate during second-stage deployment in the event of a high speed crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection."

Campaign: 16V247000

STEERING

Leaving home to go to the grocery store and as I exited my street a dash warning came on stating "Power Steering Assist" fault Steering wheel locked up making it impossible for me to steer. Fortunately this happened in a spot where there was no other traffic and I was able to just turn off the car and restart and the message was gone and my steering was restored. I am now terrified to drive my car because if this had happened in traffic there could have been a serious accident because steering capability was non existent. . In reading online this is a very common problem with my make and model and apparently there was a recall by Ford for 2011 and later cars but not 2010 even though it is a "known problem" at dealerships. For me this now seems intermittent but in calling the dealership they know of the issue. It would cost me about $2200 to fix. I am happy to provide my vehicle for inspection. Thank you so much for your help ... greatly appreciated

STEERING

On the road and power steering went out and was super hard to turn

STRUCTURE

Water ingress into rear side door latch - froze - door opened while car was in motion

STEERING

The contact owns a 2010 Ford Flex. The contact stated while driving at an undisclosed speed, there was a metal clicking and scraping sound coming from underneath the vehicle. In addition, the contact stated that the wheels felt loose. The contact stated that a nearby driver informed her that sparks were coming from underneath the vehicle. The contact drove the vehicle to the shoulder of the road. The contact stated that a nearby driver identified that the rack and pinion had detached. In addition, the power steering fluid had leaked out onto the ground. The contact was driving on a busy highway during the failure occurred. The contact stated that her grandchildren were in the vehicle when the failure occurred. The vehicle was towed to the residence. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was made aware of the failure but provided no assistance. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 119,000.

SUSPENSION

While traveling at highway speeds 75+ a loud bang and then control of vehicle was hard to keep on road, swerved left then right, left rear quarter panel hit guard rail and caused car to spin around and went sideways and backwards down a 30 ft embankment. Fortunately did not roll. left side tires came off of rims and damage to driver side door was done. Highway Patrol had car towed to holding lot, where I then got car towed to my mechanic. The left side Lateral stabilizer Rod had broken due to rusted part, causing left rear wheel to go out of alignment. The rubber boot on the rod was attached, rust was internal would never had known about a problem. Had both lateral rods replaced tires re-balanced and alignment done.

STEERING

Vehicle loses power steering intermittently upon vehicle startup as well as in motion. Vehicle is then extremely hard to control without power steering. Message " POWER STEERING ASSIST FAULT" prints to the instrument cluster above the steering wheel. Turning the vehicle off and back on may resolve problem but it returns within a couple key cycles.

SERVICE BRAKES, HYDRAULIC

The contact owns a 2010 Ford Flex. The contact stated that while driving at an undisclosed speed, the brakes seized. There was no warning light illuminated. The contact was unable to pull to the side of the road. The contact stated that the vehicle responded as needed after waiting for a while. The vehicle was taken to an independent mechanic, where the brake master cylinder, the brake booster, the vacuum pump, the brake calipers, the brake check valve, the brakes lines, and the brake pedal sensor were replaced. Additionally, the ECM was replaced and reprogrammed; however, the failure persisted. The contact stated that the failure occurred when the brake fluid was hot after driving 15-20 miles. The dealer was not notified of the failure. The vehicle was not repaired. The contact related the failure to an unknown recall. The manufacturer was notified of the failure and a case was opened. The failure mileage was approximately 102,000.

ENGINE AND ENGINE COOLING

The contact owns a 2010 Ford Flex. The contact stated while driving 50 MPH, the steering wheel became firm, and the vehicle lost motive power. The contact pulled over to the side of the road and was able to restart the vehicle after 3 attempts. No warning light was illuminated. The vehicle was taken to an independent mechanic to be diagnosed. The contact was informed that the failure was due to the oil mixing with the coolant. The manufacturer was made aware of the failure and determined that the vehicle was not under warranty. The failure mileage was approximately 148,000.

POWER TRAIN

While driving car suddenly losses power and the wrench light comes on. Loss of power with the car transmission wont move the car at all. have to pull over and turn off car about 5min then start it back up and now everything works with no codes. Happened 3 times.VERY DANGEROUS BECUASE CAR LOSSES POWER AND CARS BEHIND YOU ALMOST HITS YOU.

ENGINE

While driving at 65mph, vehicle started to accelerate funny and cel came on. was getting on the freeway and the vehicle overheated and CEL light came on. I was able to safely pull over before the vehicle died. Got vehicle towed to my home and when engine oil was checked, it was discovered that there was coolant in the oil. Took to a local shop where it was determined that the water pump had failed and dumped all of the coolant into the oil pan. Estimated cost of repair with labor is $5,000. Failure mileage was ~192,000. The oil was in good standing and gold in color 12 hours prior and was only driven ~45 miles at highway speeds before the failure happened. From what I can tell, this was a catastrophic failure of the water pump bearing seal that happened almost instantaneously. This needs to be looked into, as the repair bill does not match the issue. A water pump repair should not cost more than the vehicle.