2001 Ford Focus

2001 Ford Focus 2-DR.

Overall

Not Rated

Front Crash

Not Rated

Side Crash

Not Rated

Rollover

Not Rated

2001 Ford Focus 4-DR.

Overall

Not Rated

Front Crash

Not Rated

Side Crash

Not Rated

Rollover

Not Rated

EQUIPMENT

RIDE CONTROL, LLC (RIDE CONTROL) IS RECALLING CERTAIN READYMOUNT ASSEMBLIES, P/N 746641MT AND 746646MT, WITH CORRESPONDING AFTERMARKET CUSTOMER PART NUMBERS: GABRIEL G56944 AND GABRIEL G56945, AND PRIVATELY BRANDED PARTSMASTER WITH PART NUMBERS G68944 AND G68945. THE READYMOUNT ASSEMBLIES WERE SOLD AS AFTERMARKET SERVICE EQUIPMENT FOR USE ON CERTAIN 2000 THROUGH 2005 FORD FOCUS VEHICLES. THESE ASSEMBLIES WERE ASSEMBLED WITH A NUT WITHOUT THE NECESSARY WASHER. THE ABSENCE OF THE WASHER CAN ALLOW THE READYMOUNT ASSEMBLY TO PULL APART THE TOP MOUNT.

Campaign: 12E007000

EXTERIOR LIGHTING

SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Campaign: 09E012000

EXTERIOR LIGHTING:HEADLIGHTS

K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."

Campaign: 08E050000

EXTERIOR LIGHTING

CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Campaign: 06E049000

EXTERIOR LIGHTING:HEADLIGHTS

DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Campaign: 09E025000

EXTERIOR LIGHTING

CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Campaign: 06E026000

STEERING:LINKAGES

CERTAIN PASSENGER VEHICLES HAVE LOOSE PINCH BOLTS THAT SECURE THE LOWER CONTROL ARM TO THE STEERING KNUCKLE HAVE BEEN REPORTED.

Campaign: 02V289000

ELECTRICAL SYSTEM:12V/24V/48V BATTERY:CABLES

CERTAIN PASSENGER VEHICLES EQUIPPED WITH ZETEC ENGINES, LOOSE OR BROKEN ATTACHMENTS AND MISROUTED BATTERY CABLES COULD LEAD TO CABLE INSULATION DAMAGE.

Campaign: 02V288000

VISIBILITY:WINDSHIELD WIPER/WASHER:MOTOR

VEHICLE DESCRIPTION: PASSENGER CARS, SPORT UTILITY VEHICLES, AND LIGHT AND MEDIUM DUTY PICKUP TRUCKS. A SWITCH LOCATED IN THE PLASTIC COVER OF THE WIPER MOTOR GEAR CASE COULD MALFUNCTION AND OVERHEAT, POTENTIALLY RESULTING IN LOSS OF INTERMITTENT WIPER FUNCTION, LOSS OF WIPER PARK FUNCTION, COMPLETE LOSS OF WIPER FUNCTION, OR IGNITION OF THE PLASTIC COVER MATERIAL. SWITCH MALFUNCTION IS MOST LIKELY TO OCCUR WHEN THE INTERMITTENT SETTING OF THE WIPERS IS BEING USED, OR WHEN SNOW OR ICE OBSTRUCTS THE BLADES FROM RETURNING TO THE "PARKED" POSITION AT THE BOTTOM OF THE WINDSHIELD. THESE VEHICLES WERE BUILT AT THE FOLLOWING ASSEMBLY PLANTS: ATLANTA PLANT FROM 2/11/00 THROUGH 7/31/00; CHICAGO PLANT FROM 2/14/00 THROUGH 8/4/00; KANSAS CITY PLANT FROM 2/26/00 TO 9/4/00; KENTUCKY TRUCK PLANT FROM 2/18/00 TO 8/31/00; MICHIGAN TRUCK PLANT FROM 2/23/00 THROUGH 8/3/00; NORFOLK PLANT FROM 2/21/00 THROUGH 7/27/00; WAYNE STAMPING AND ASSEMBLY PLANT FROM 2/25/00 THROUGH 8/15/00; AND WIXOM PLANT FROM 2/15/00 THROUGH 8/8/00.

Campaign: 01V258000

LATCHES/LOCKS/LINKAGES:DOORS:LATCH

CERTAIN PASSENGER VEHICLES WITH FOUR OR FIVE DOORS AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, A BUILD-UP OF CORROSION AT THE PAWL PIVOT AREA OF THE REAR DOOR LATCH CAN CAUSE A BINDING CONDITION OF THE PAWL THAT MAY AFFECT PROPER ENGAGEMENT OF THE PAWL INTO THE CATCH. THE OCCUPANT MAY EXPERIENCE DIFFICULTY OPENING OR CLOSING A REAR DOOR, AND EVENTUALLY THE REAR DOOR MAY NOT LATCH PROPERLY.

Campaign: 05V030000

FUEL SYSTEM, GASOLINE

ON CERTAIN PASSENGER VEHICLES, CONTAMINATION OF THE FILTER IN THE FUEL DELIVERY MODULE (FDM) CAN REDUCE, AND EVENTUALLY BLOCK, THE FLOW OF FUEL TO THE ENGINE.

Campaign: 03V482000

WHEELS:LUGS/NUTS/BOLTS/STUDS

THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 2000-2001 FORD FOCUS PASSENGER VEHICLES, ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIOM, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, AND WISCONSIN. IN HIGH CORROSION AREAS, WHERE SALT IS USED ON ROADWAYS IN THE WINTER, THE REAR WHEEL BEARING SEAL RACE CAN EXPERIENCE SURFACE CORROSION. IF THIS CONDITION OCCURS, THE WHEEL BEARING SEALS COULD BECOME DAMAGED AND ALLOW CONTAMINATION TO ENTER THE WHEEL BEARINGS.

Campaign: 01I017000

SEATS:FRONT ASSEMBLY:RECLINER

PM CERTAIN SEDANS AND WAGONS, THE SEAT BACK RECLINER HANDLE SPRING COULD HAVE BEEN DAMAGED DURING AN IN-PROCESS TEST AND THE OCCUPANT MAY NOTICE A CHUCKING, OR PERCEIVED LOOSENESS OF THE FRONT SEAT BACK, OR THE SEAT BACK COULD UNEXPECTEDLY RECLINE.

Campaign: 01V108000

SEATS:FRONT ASSEMBLY:RECLINER

VEHICLE DESCRIPTION: STATION WAGONS AND 3-DOOR VEHICLES. THE SUBJECT VEHICLES HAVE A FOLDING 60/40 SECOND SEAT THAT BECOMES A LOAD FLOOR IN THE FOLDED POSITION. WHEN THE 60% PORTION OF THE SEAT IS FOLDED DOWN AND A LOAD IS APPLIED TO THE FRONT EDGE OF THE LOAD FLOOR, THE OUTBOARD HINGE PIVOT COULD DISENGAGE FROM THE HINGE.

Campaign: 00V418000

SUSPENSION,WHEELS

The contact owns a 2001 Ford Focus. The contact stated that while driving her vehicle at approximately 35 MPH, the ball joint snapped on the vehicle's passengers side. The contact stated there were no warning lights illuminated nor any indication of a failure prior to the ball joint snapping. The contact stated that when the failure happened to her vehicle it caused her to crash into a ditch. The contact stated that no injuries were sustained and the vehicle was towed to the residence where it remains currently. The contact stated that she did contact the dealer as well as the manufacturer who advised her to contact NHTSA. The failure mileage was 190,000.

AIR BAGS

The front dashboard and steering wheel airbags went off. if I was moving this could’ve ended even worse but luckily I was stopped. My hearing was affected. I was parked at a red light and my airbags went off. I did not hit anything nor was my car moving. Witnesses at a restaurant and auto repair shop say the same. My car had passed that years inspection and there was no signs of this happening. No lights, sounds, anything. It was very sudden.

ELECTRICAL SYSTEM,ENGINE,FUEL/PROPULSION SYSTEM

KEEPS SHUT OFF N OVER HEATING

ELECTRICAL SYSTEM,STRUCTURE,ELECTRONIC STABILITY CONTROL (ESC)

ON 9/2/2020 AROUND 10 PM IN MICHIGAN I WAS MAKING A PIZZA DELIVERY, I PULLED INTO THE SUBDIVISION WHERE I HAD TO MAKE THE DELIVERY, ALL THE SUDDEN MY CAR COMPLETELY SHUT OFF. I COULDN'T ACCELERATE OR BRAKE. I GOT MY CAR FO SAFTEY AWAY FROM THE HOUSES BECAUSE MY FIRST INSTINCT WAS SAFETY. I GRAB MY PHONE TO CALL MY BOSS, I THOUGHT MY CAR JUAT BROKE DOWN. THEN I SAW SMOKE AND SPARKS. I CALLED THE EMERGENCY SERVICES AND THE CARS SMOKE GOT DARKER AND THE FLAMES GOT BIGGER. I WAS VERY SCARED. ALL MY WINDOWS EXPLODED AND THE CAR MELTED TO GROUND. BY THE LOOKS OF MY PHOTO THE FIRE STARTED NEAR THE BATTERY AND CABLES. EVER SINCE THAT NIGHT, I'VE BEEN SCARED OF FIRES, HOT SURFACES, AND WEARY AROUND CARS. I'M LUCKY TO BE ALIVE BUT IT WAS VERY DANGEROUS AS THE FLAMES REACHED ABOUT 10 FEET HIGH. LUCKILY IT DID NOT CATCH ANYTHING NEAR BY ON FIRE.

ELECTRICAL SYSTEM,EXTERIOR LIGHTING

THERE ARE NUMEROUS ELECTRICAL PROBLEMS WITH MY REAR LIGHTS. MY LICENSE PLATE LIGHTS WILL NOT WORK AT ANYTIME AND SOMETIMES NONE OF THE REAR LIGHTS WORK AT ALL.

UNKNOWN OR OTHER

SEE COMPLAINT 11338120 I WANTED TO ADD PICTURES

SUSPENSION

WHILE I FIND RUST RECALLS FOR 2001 FOCUS FUSIONS AND WINDSTARS FORD CLAIMS THERE IS NO RECALL FOR FRAME COLLAPS FROM EXCESSIVE RUST PROBLEMS. WE PULLED OUT OF OUR DRIVE HEADED UP A BLIND HILL AND THE FRONT END TOTALLY COLLAPSED LEAVING US AS AN EASY TARGET. SEVERAL GOOD FOLKS JUMPED INTO ACTION TO HELP US GET THE MESS SAFELY OFF OF THE STATE HIGHWAY BY BLOCKING TRAFFIC AND HELPING US DRAG IT BACK INTO OUR DRIVEWAY. WE ARE IN OUR 70'S AND ONLY DRIVE THE CAR 7-8 THOUSAND MILES A YEAR. IT HAS BEEN BABIED AND MAINTAINED BY THE BOOK IT ENTIRE LIFETIME . CONVERSATIONS WITH FORD HAVE GOTTEN US NO WHERE! WHERE DO WE TURN ?

ELECTRICAL SYSTEM,ENGINE

KEEPS OVER HEATING. *TR

ENGINE

2001 FORD FOCUS ZX3 STALLS WHEN DRIVING AND ALMOST CAUSED SOMEONE TO REAR END MY CAR. NOW WONT STAY RUNNING WHEN IDLING. CAR CUTS OFF AT LIGHTS OR STOP SIGNS OR WHEN BREAKING OR ENGAGING CLUTCH.

UNKNOWN OR OTHER,SERVICE BRAKES

AFTER DRIVING FROM WORK TO HOME, ABOUT 4.6 MILES, I TURNED RIGHT INTO MY PARKING SPACE IN FRONT OF MY HOME WHEN THE BRAKES FAILED WHILE THE CAR ACCELERATED DIRECTLY INTO THE ROCK WALL THAT SERVES AS A BARRIER BETWEEN THE PARKING, WALKWAY AND BUILDING; I IMMEDIATELY PULLED UP THE EMERGENCY BRAKE, PUT IT INTO PARK AND TURNED THE CAR OFF. I HAD IT TOWED INTO MY MECHANIC AND WAS NOTIFIED THAT THEY FOUND "THROTTLE CABLE WAS BOUND UP" AND THEY "RE-ROUTED CABLE PROPERLY." I WOULD LIKE TO KNOW IF ANYONE HAS EVER HAD THIS EXPERIENCE WITH THEIR VEHICLE ACCELERATING WHEN BRAKES ARE APPLIED ON THIS MODEL. I WOULD LIKE TO KNOW HOW THE CABLES CAN BECOME BOUND UP. THIS WAS A VERY FRIGHTENING EXPERIENCE. I HAVE TAKEN VERY GOOD CARE OF THIS AUTOMOBILE AND HAVE MAINTENANCE PERFORMED ACCORDING TO MANUFACTURER SUGGESTIONS IN THEIR GUIDE BOOK.