2007 Ford Focus

2007 Ford Focus 4-DR.

Overall

Not Rated

Front Crash

Not Rated

Side Crash

Not Rated

Rollover

Not Rated

2007 Ford Focus 2-DR. Hatchback

Overall

Not Rated

Front Crash

Not Rated

Side Crash

Not Rated

Rollover

Not Rated

EXTERIOR LIGHTING:HEADLIGHTS

K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."

Campaign: 08E050000

FUEL SYSTEM, GASOLINE

CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.

Campaign: 06E056000

TIRES

Tire completely blew out under normal driving conditions on [XXX] between [XXX] in Roseville California. The tire was size 205 /45 r17 one of a matching installed set from America's Tires in Antelope California. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

STEERING

The contact owns a 2007 Ford Focus. The contact stated that on several occasions while driving at an undisclosed speed and turning, the steering wheel became stiff, and the contact heard scraping sounds emanating from the engine compartment. The vehicle was taken to the residence and inspected. The contact observed condensation on top of the power steering pump and the ground underneath the vehicle. The vehicle was inspected, and a power steering fluid was added to the vehicle. The vehicle was then taken to three independent mechanics where it was diagnosed twice that the power steering pump needed to be replaced. The vehicle was repaired but the failure persisted. The manufacturer was notified of the failure. The failure mileage was approximately 198,000.

AIR BAGS

The contact owns a 2007 Ford Focus. The contact stated that while stopped at a traffic light, a vehicle crashed into the front of the contact’s vehicle. Additionally, two other vehicles crashed into the side and rear of the contact's vehicle; however, the air bags failed to deploy. No warning lights were illuminated. The contact and the passenger sustained injuries and received medical attention. A police report was filed. The vehicle was not totaled. The manufacturer was not made aware of the failure. The approximate failure mileage was 104,000.

AIR BAGS

The driver airbag light keeps going off and on. I went to ford dealer shop to fix it. Only shortly after it came back on. I tried different tricks online and they dont last long. This is a common issue among ford focus owners. The connection plug from airbag to the steering wheel is bad and it just loses connection from time to time. Focus owners cant just DIY sensitive parts like airbag to temporarly fix it nor can we spend big bucks to visit dealersshop everytime. They charged me $140 just look at my car. And told me $700 for airbag replacement, when all that needs replacing is the faulty connecting plug. Ford knows this but is getting away with jeopordizing with customers lives for money. Please make this recall issue so ford will fix for all focus owners before people dies from this well known focus issue because the driverside airbag failes to deploy. Please.

SUSPENSION,EXTERIOR LIGHTING

The contact stated that her mother-in-law owns a 2007 Ford Focus. The contact stated that while her mother-in-law was driving at an unknown speed, the front passenger’s side wheel detached from the vehicle. The vehicle was towed to the independent mechanic who diagnosed the failure as a control arm failure. The contact stated that the vehicle was repaired. The contact stated that 2 weeks later the driver’s side wheel detached. The vehicle was towed back to the independent mechanic who stated that the control arm had detached from the vehicle. The vehicle was repaired. The contact stated that 3 months later while stopped at a traffic light, the driver was unable to control the vehicle as the front passenger’s side wheel detached from the vehicle as well as the transmission slid into the engine. The transmission observation was by the tow truck company. The vehicle was towed to the owner's residence. The failure cause was not diagnosed by the dealer or an independent mechanic. The contact stated that the tow company informed her that the vehicle was unable to be towed on the flatbed due to the fact that the front end of the vehicle might detach. The contact stated that the headlights would also flicker on and off while driving. The contact stated that the independent mechanic replaced the light bulbs however, the failure continued. The manufacturer was not made aware of the failure. The failure mileage was unknown.

SERVICE BRAKES

Had a car stop suddenly in front of me and I had to apply the brakes hard. The ABS system made a strange sound and the pedal went to the floor. I missed the car in front of me, but now my brakes aren't working properly and there is fluid all over the ABS module assembly.

SERVICE BRAKES

The contact owned a 2006 Ford Focus. The contact stated that while driving at 20 MPH and depressing the brake pedal, the vehicle failed to stop and as a result, the contact rear-ended another vehicle. The contact mentioned that when he would depress the brake pedal the faster the vehicle increased in speed. The air bag failed to deploy. The contact’s face was covered in blood, shoulder and hip injuries. The contact received medical attention via ambulance to the hospital. The other driver did not sustain any known injuries. A police report was not filed. The vehicle was towed to a tow yard. The vehicle was destroyed. The manufacturer was not made aware of the failure. The failure mileage was approximately 140,000. The VIN was not available

POWER TRAIN,UNKNOWN OR OTHER

Console transmission shift lever detents not noticeable in any positon including Park (mushy shifter) and I am unable to remove ignition key in any position, on, off or lock. Therefore the car can be easily stolen by anyone (minor or adult) by simply breaking the window, reaching the unlock and driving off. Shifter, steering column, and key removal malfunction.

ELECTRICAL SYSTEM

The contact owns a 2007 Ford Focus. The contact stated that the key ceased in the ignition when the vehicle was turned off. The vehicle was not taken to the dealer to be diagnosed nor repaired. The contact took the vehicle to a certified mechanic who replaced the ignition switch. The key fob was replaced however, the failure persisted. The manufacturer was made aware of the failure. The contact was informed that the Vin was not under recall. The manufacturer referred the contact to the NHTSA for assistance. The approximate failure mileage was 195,000.

SUSPENSION

Noticed small hole in front control arm while servicing brakes. Stamped sheet metal control arm rusted through and was failing. Very poor designe that was discontinued for apparent reasons the following model year.