2024 Ford Maverick Hev

2024 Ford Maverick HEV PU/CC FWD

Overall

★★★★☆

Front Crash

★★★★★

Side Crash

★★★★★

Rollover

★★★★☆

EXTERIOR LIGHTING:TURN SIGNAL:BULBS

Ford Motor Company (Ford) is recalling certain 2022-2024 Maverick vehicles. In the event that one of the rear turn signals stops working, the vehicle will not adjust the turn signal flash rate frequency to warn the driver that a turn signal is not working correctly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."

Campaign: 23V848000

FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY

Ford Motor Company (Ford) is recalling certain 2024 Maverick vehicles. The fuel tanks may have an open pinch joint between the two molds, which can allow fuel to leak.

Campaign: 24V185000

EQUIPMENT:OTHER:LABELS

Ford Motor Company (Ford) is recalling certain 2024 Maverick vehicles. The tire and loading information label may state the incorrect vehicle capacity, tire pressure, and spare tire size. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 110, "Tire Selection and Rims."

Campaign: 24V266000

EXTERIOR LIGHTING:TAIL LIGHTS

Ford Motor Company (Ford) is recalling certain 2022-2024 Maverick vehicles. The Body Control Module (BCM) may inadvertently deactivate one or both rear tail lights.

Campaign: 24V293000

POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)

Ford Motor Company (Ford) is recalling certain 2022-2024 Maverick, 2020-2022 Escape, and 2021-2022 Lincoln Corsair vehicles. The Hybrid Powertrain Control Module (HPCM) software may cause the vehicle to shift into neutral unexpectedly, causing a loss of drive power.

Campaign: 24V330000

VISIBILITY:WINDSHIELD WIPER/WASHER:MOTOR

Ford Motor Company (Ford) is recalling certain 2023-2024 Maverick, Ford Bronco Sport, and Mustang Mach-E vehicles. The front windshield wiper motor may become inoperative, causing the wipers to fail.

Campaign: 24V594000

BACK OVER PREVENTION:SOFTWARE

Ford Motor Company (Ford) is recalling certain 2022-2024 Ford Maverick vehicles equipped with Connected Touch Radios (CTR). The rearview camera image may freeze when the vehicle is in reverse.

Campaign: 24V684000

CHILD SEAT:VEHICLE TETHER ANCHOR

Ford Motor Company (Ford) is recalling certain 2024 Maverick vehicles. The second-row child seat tether anchors may not properly secure a child seat, due to incomplete thread engagement. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 225, "Child Restraint Anchorage Systems."

Campaign: 24V778000

EXTERIOR LIGHTING:TURN SIGNAL

Ford Motor Company (Ford) is recalling certain 2022-2024 Maverick vehicles previously repaired incorrectly under recall number 23V-848. In the event that one of the rear turn signals stops working, the vehicle will not adjust the turn signal flash rate frequency to warn the driver that a turn signal has failed. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."

Campaign: 25V094000

EXTERIOR LIGHTING:TAIL LIGHTS

Ford Motor Company (Ford) is recalling certain 2022-2024 Maverick vehicles previously repaired incorrectly under recall number 24V-293. The body control module (BCM) may inadvertently deactivate one or both rear tail lights.

Campaign: 25V095000

POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)

Ford Motor Company (Ford) is recalling certain 2022-2024 Maverick, 2022 Escape, and 2021-2022 Lincoln Corsair vehicles previously repaired incorrectly under recall number 24V-330. The Hybrid Powertrain Control Module (HPCM) software may cause the vehicle to shift into neutral unexpectedly, causing a loss of drive power.

Campaign: 25V133000

BACK OVER PREVENTION:SOFTWARE

Ford Motor Company (Ford) is recalling certain 2018-2022 Transit Connect, 2019-2020 MKZ, MKX, Edge, Continental, F-150, Nautilus, Fusion, 2019-2023 Ranger, Mustang, 2020-2021 EcoSport, Expedition, Navigator, 2020-2022 Escape, F-250 SD, Corsair, 2020-2023 Aviator, Transit, 2020-2024 Explorer, 2021-2024 Bronco Sport, and 2022-2024 Maverick vehicles. A software error may cause the rearview camera to display a blank image, or the image may remain on the display after the backing event has ended.

Campaign: 25V442000

EQUIPMENT:ELECTRICAL:ENGINE BLOCK HEATER

Ford Motor Company (Ford) is recalling certain 2016-2019 Lincoln MKC, 2016-2023 Explorer, 2019-2020 Fusion, 2019-2024 Ranger, 2020-2022 Lincoln Corsair, Escape, 2021-2024 Bronco, Bronco Sport, and 2022-2024 Maverick vehicles. The engine block heater may crack and develop a coolant leak, causing it to short circuit when the block heater is plugged in.

Campaign: 25V685000

ELECTRICAL SYSTEM: INTEGRATED TRAILER BRAKE CONTROL

Ford Motor Company (Ford) is recalling certain 2021-2026 F-150, 2022-2026 F-250 SD, F-350 SD, F-450 SD, F-550 SD, Maverick, 2024-2026 Ranger, 2023-2026 F-600 SD, 2022-2027 Lincoln Navigator, Expedition, and 2026 E-Transit vehicles. When towing a trailer, the integrated trailer module (ITRM) may lose communication with the vehicle, possibly causing a loss of brake and turn signal lights, or a loss of brake function. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, " Lamps, Reflective Devices, and Associated Equipment."

Campaign: 26V104000

SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT

Ford Motor Company (Ford) is recalling certain 2021-2026 Bronco Sport and 2022-2026 Maverick vehicles. The front lower control arm ball joints may have been incorrectly installed or incorrectly repaired at the vehicle assembly plant, allowing the control arm to disconnect from the front wheel knuckle.

Campaign: 26V340000

POWER TRAIN

I am reporting a recurring shudder/vibration condition in my 2024 Ford Maverick XL Hybrid. The vehicle currently has approximately 62,241 miles. The problem occurs during acceleration, generally between approximately 15 and 60 mph and started at just over 60,000 miles. The vehicle develops a pronounced shudder/vibration that feels similar to driving over a rough road or a rumble strip. The condition is repeatable and occurs during normal driving and acceleration. There are currently no warning lights illuminated and, to my knowledge, no diagnostic trouble codes have been identified. I am concerned that this may represent a drivetrain or transmission-related defect that could affect the safe operation of the vehicle, particularly if the condition worsens or results in a loss of smooth or predictable acceleration. I have become aware of Ford SSM 54797, which was issued in 2026 and addresses 2022–2026 Ford Maverick vehicles equipped with the 8F35 transmission. The service message states that affected vehicles may exhibit a shudder condition, most noticeable at speeds below 60 mph, with no relevant diagnostic trouble codes stored in the powertrain control module. It identifies the torque converter as a possible cause and provides a repair procedure involving the torque converter and related transmission components. The symptoms I am experiencing appear similar to the condition described in this Ford service communication. The vehicle is now just outside its applicable warranty coverage, which also makes it important to me that the condition be documented with NHTSA. I am requesting that NHTSA record this complaint and consider whether similar complaints involving the 2022–2026 Ford Maverick indicate a broader safety-related defect or trend.

VEHICLE SPEED CONTROL,UNKNOWN OR OTHER,SERVICE BRAKES

1. 50% of my braking results in grinding stop where it jumps and doesn’t stop all the way at first, this is even driving at slow speeds of 25 mph. 2. When my truck was set on cruise control approx 70mph and all of a sudden started decelerating on its own and nothing I did made it accelerate. I had to coast/slow brake to pull over, cut the car off and then restart it to begin driving again.

STRUCTURE

Defective spot welds of interior door hinges bind resulting in destruction of 3 remaining spot welds making door inoperable, not closing correctly, damaging other hinge and locking mechanisms. Local and corporate denied. out of warranty at 42645 miles.

SERVICE BRAKES,FORWARD COLLISION AVOIDANCE

I was driving at approx. 40 to 45 mph and in the process of braking for slowing traffic and the vehicle slammed on the brakes and left a short skid mark. I was about 50 feet behind the vehicle and braking when this occurred. I was lucky that the car behind did not rear end me. The collision alert did come on the dash at the same time it slammed on the brakes.

ELECTRICAL SYSTEM,UNKNOWN OR OTHER

"This is a formal complaint for an Inadequate Recall Remedy and severe Consequential Damage regarding NHTSA Campaign #24V684000 (Ford Recall 24S59) on my 2024 Ford Maverick XL (65,000 miles, VIN: [XXX]).The official safety recall update was originally performed at 30,000 miles by a Ford mobile service unit, but the remedy completely failed. The Audio Control Module software remains corrupted, causing a severe intermittent parasitic drain. The radio frequently locks up, and roughly once a week, it remains actively powered on for 10 minutes after the ignition is turned off, keys are removed, and doors are locked. This has permanently destroyed my 12-volt battery, forcing me to rely on a trickle charger daily.On XXX, I took the truck to Mt. Orab Ford (Ohio) under Invoice #XXX for a separate recall (Ford 26C10). They completed the hitch recall but explicitly refused to address the failed safety recall 24S59 or the resulting battery damage. The official invoice they handed me falsely logs line item B as 'GBATT BATTERY TESTED GREEN AT THIS TIME.' However, I forced the Service Manager, Kevin Wilmoth, to physically verify the battery in the parking lot. The handheld tester printout he handed me directly contradicts their official invoice, explicitly stating 'GOOD RECHARGE' with a resting voltage of only 12.16V and a 45% State of Charge. A healthy 12V battery should rest between 12.6V and 12.8V; at 12.16V with a 45% charge, the system is severely drained and starved for power. The dealership printed 'Tested Green' on the invoice before actually testing it, and Kevin Wilmoth has since refused my email request for copies of the vehicle's OASIS history and FDRS global diagnostic logs to withhold the electronic record of these faults.Contacted Ford Corp., given a claim #, promised call back in 24hrs.completely failed to respond, leaving me stranded with a severe, un-remedied safety hazard. Requesting into Ford's failure to provide a free, functioning saf INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

SERVICE BRAKES, ELECTRIC

See attached letter for petition

SERVICE BRAKES

My 2024 Ford Maverick Hybrid rolled backward while in park. I push-started the truck and then turned on the A/C to start cooling the cabin. I left the driver’s side door open as I stepped out to begin loading my 8-month-old baby’s stroller. The open door bumped my back, so I quickly jumped back into the vehicle to press the brake. The truck eventually stopped, but not before the door folded out and scraped the entire side of a parked car. I called the police to make a report.

SERVICE BRAKES

This is a corrected supplement to my prior NHTSA complaints #XXX and #XXX for the 2024 Ford Maverick Hybrid, VIN [XXX]. It corrects the mileage in # XXX: the odometer at the XXX collision was approximately 68,000 miles (a current reading was auto-populated into the incident field on the prior form), and the vehicle's current odometer is 119,379 miles. I request that the Office of Defects Investigation open a Preliminary Evaluation of the Maverick Hybrid braking/ABS system. I first reported a braking concern to the selling Ford dealer in spring 2025 at approximately 35,000 miles, while the vehicle was still under the 3-year/36,000-mile warranty; Ford's applicable service bulletin (MC-XXX) was not applied. Ford's OASIS system later confirmed active fault codes C052E and U0418 when the vehicle was returned to me unrepaired on XXX6. The defect has persisted through four repair attempts and more than 50 days out of service. On XXX, another vehicle crossed multiple lanes of traffic across my path. I applied the brakes and the vehicle did not stop as it should have, and I struck the crossing vehicle (APD Crash Report # XXX; I was assigned no driver error). This loss of stopping capability is the same failure mode I have experienced repeatedly and that remains unrepaired. Ford's own recall record documents its knowledge of Maverick braking-system defects: Recall 22V-730 addressed the Maverick ABS module transmitting an incorrect signal; Recall 25V-124 was a follow-up after Ford determined the earlier software remedy had not been correctly installed even though dealer records showed the repair completed, and Ford disclosed to NHTSA in December 2024 that dealer software-repair records could be inaccurate. Ford issued Recall 25V-488 for loss of power brake assist on several model-year-2025 vehicles but did not include the Maverick, and issued a limited Maverick Electronic Brake Booster recall des INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

SERVICE BRAKES

While driving, the red "BRAKE" light remains illuminated on the dashboard, and a "service brakes" warning message appears on the screen. This can be dismissed and the vehicle drives normally, except under sudden/heavy braking conditions. Under these conditions, the brakes make a grinding, thumping noise and the vehicle does not brake adequately. I suspect power braking was lost. I had to stop suddenly for a stoplight a few times, and the vehicle continued into the intersection before making a complete stop despite very heavy braking pressure applied to the pedal. The dealership replaced the brake booster, which they said was a "known issue". This was fixed at my expense.

POWER TRAIN,ELECTRICAL SYSTEM,VEHICLE SPEED CONTROL

While driving at highway speed on I-275with cruise control engaged on afternoon of June 11 the truck suddenly began slowing down. I couldn't get it to accelerate. I ultimately had to get over two lanes and still had enough momentum to get off an exit ramp. At the end of the ramp, I noticed I was unable to get the truck to accelerate from a stopped position either. Only then did I notice the dial transmission had moved to N from D. I did not initiate this move while I was on the highway, nor was I aware of it, nor do I believe I bumped the dial. This is the second time this has happened. Previously it occurred some time in late 2025 in a store parking lot. At highway speeds, this is extremely dangerous.