1997 Ford Probe

1997 Ford Probe 2-DR. HB.

Overall

Not Rated

Front Crash

Not Rated

Side Crash

Not Rated

Rollover

Not Rated

FUEL SYSTEM, GASOLINE

CERTAIN SPX FILTRAN FUEL FILTERS WITH A 45-DEGREE ANGLE INLET TUBE, MODEL 800F350-S1, SOLD AS REPLACEMENT FILTERS FOR 1993-1997 FORD PROBE,1993-2001 MAZDA 626 AND MX-6, AND 1983-1994 LOYAL, 3-DOOR COUPE, HATCHBACK, SEDAN, WAGON, BRAT, DL, GL, GL-10, RX, XT, AND XT6 PASSENGER VEHICLES WITH EFI OR TURBO ENGINES. THESE FILTERS ARE PACKAGED AS WIX, NAPA, AND CARQUEST BRAND FUEL FILTERS. CERTAIN SPX FILTRAN FUEL FILTERS WITH A 90-DEGREE ANGLE INLET TUBE, MODEL 800F300-S2, SOLD AS REPLACEMENT FILTERS FOR 19983-1994 SUBARU VEHICLES WITH EFI OR TURBO ENGINES. THESE FILTERS ARE PACKAGED AS WIX, NAPA, AND CARQUEST BRAND FUEL FILTERS. FUEL MAY LEAK FROM THE FILTER DUE TO NON-CONFORMING BRAZING WELDS WHERE THE INLET TUBE IS CONNECTED TO THE FILTER CAN.

Campaign: 05E065000

EXTERIOR LIGHTING

CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Campaign: 06E026000

EXTERIOR LIGHTING

CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Campaign: 06E065000

ENGINE AND ENGINE COOLING:ENGINE

VEHICLE DESCRIPTION: PASSENGER VEHICLES. AN EXTERNAL SPRING IN THE TIMING BELT TENSIONER CAN BREAK AND GET CAUGHT IN THE TIMING BELT.

Campaign: 98V206002

ENGINE AND ENGINE COOLING

INCIDENT LIKE MANY OTHERS I HAVE HAD MY 1997 FORD EXPEDITION XLT BLOW A SPARK PLUG OUT OF THE CYLINDER HEAD. THE VEHICLE WAS RUNNING FINE AND TROUBLE FREE WHEN A POP FROM UNDER THE HOOD AND A LOUD BANGING NOISE CAME FROM THE ENGINE HEAD. THE VEHICLE WAS TOWED TO THE REPAIR SHOP ; WHO IN TURN CALLED THE LOCAL FORD DEALER. THE REPLY WAS THEY NEVER HEARD OF THIS PROBLEM BEFORE. MY LOCAL SERVICE TECH SAID THE REPAIR KIT ALONE WOULD COST $1,000,00. TO REPAIR IT HE SAID THAT FORD HAD ONLY USED 3 THREADS IN THE HEAD THAT FAILED, BUT ARE NOW REPLACING THEM WITH A 7 THREAD HEAD., THIS TELLS ME THAT THEY ARE VERY AWARE OF THE PROBLEM BUT ARE WILLING TO LEAVE THEIR CUSTOMERS OUT TO DRY.. I GUESS THE SCARY PART ABOUT THAT IS I STILL HAVE 4 MORE 3 THREAD SPARK PLUG HOLES TO WORRY ABOUT BLOWING OUT,.I ABSOLUTELY FEEL THIS SHOULD BE THE RESPONSIBILITY OF FORD MOTOR COMPANY WHO IS LOOKING FOR THE AMERICAN PUBLIC TO BUY IT'S TRUCKS. DAMAGE RESULTING IT WILL COST ME AS LITTLE AS $2,500.00 TO REPAIR THE CURRENT PROBLEM ( AND NO GUARANTY IT WON'T HAPPEN AGAIN). OR UP TO $5,500.00 TO REPLACE THE BUILT TOUGH 5.4 TRITON ENGINE. *TR

POWER TRAIN

I HAVE A 1997 FORD PROBE GT 6 CYLINDER. THE OVER DRIVE LIGHT KEEP FLICKERING OVER DRIVE OFF AND THEN CHECK ENGINE LIGHT STAYS ON FOR DAYS. I HAD THIS CHECKED OUT AND THE TPS THROTTLE POSITION SENSOR CHECK OUT BAD SO I HAD THIS REPLACED. THIS PROBLEM STILL EXIST. I WENT TO SEVERAL SERVICE STATIONS THEY ALL SAY I DON'T KNOW. I WOULD JUST IGNORE THIS BUT THE SLOWS DOWN TO LOWER GEAR THIS IS SCARY. I LOVE THIS FORD PROBE IS THERE ANYTHING I CAN DO. I FOUND A SIGHT ON THE INTERNET AND RELAYED A INTERCOOLING FOR THE TRANS, IS THIS CORRECT!!! *NM

STEERING

DRIVER SIDE TIE-ROD SEPERATION '97 FORD EXPEDITION WHILE DRIVING AT 50 MPH ON HIGHWAY. LOSE OF STEERING CONTROL. SERIOUS ACCIDENT AVOIDED ONLY BECAUSE OF EMERGENCY BRAKING.

ELECTRICAL SYSTEM

1997 EXPEDITION SPONTANEOUSLY CAUGHT FIRE IN THE DRIVEWAY 45 MINUTES AFTER IT HAD BEEN DRIVEN. THE FIRE DEPARTMENT AND POLICE CAME AND PUT OUT WHAT WAS ALMOST A CATASTROPHIC HOUSE FIRE. THE TRUCK WAS A TOTAL LOSS. TO REPLACE IT WITH SOMETHING COMPARABLE WE BOUGHT A 99 EXPEDITION. WE WERE OUT $8000 IN THE TRADE. THE OLDER EXPEDITION HAD ONE CAR PAYMENT LEFT ON IT BEFORE THE FIRE. NOW I AM HORRIFIED THAT WE HAVE ANOTHER ON IN THE DRIVEWAY.*AK

POWER TRAIN

THE AUTOMATIC TRANSMISSION (CD4E) HAS BEEN ACTING UP, OVERDRIVE LIGHT ON DASH STARTS FLASHING WHIH THEN CAUSES HARSH SHIFTING AND POWER LOSS IN TRANNY AND ENGINE. I HAVE READ HUNDREDS OF COMPLAINTS ABOUT THESE TRANSMISSIONS AND BELIEVE IT SHOULD BE THE RESPONSIBILITY OF THE MANUFACTURER TO TAKE CARE OF THESE PROBLEMS. *AK

AIR BAGS

LTR REQUEST A COPY OF THE NHTSA REPORT RE AN AIRBAG PROBE OF THE 1997 FORD ESCORT. ATTY REPRESENTING CLIENT INJURED WHEN AIRBAG DID NOT DEPLOY IN A 1997 FORD ESCORT. *MR *NM

ELECTRICAL SYSTEM

I HAVE HAD TO REPLACE THE DISTRUBUTOR WHICH CAUSED IT TURN OVER, BUT NOT START, AND CLUTCH WITH IN ONE MONTH. ALSO MY CHECK ENGINE LIGHT KEEPS COMING ON AN DTHEY CAN'T FIGURE OUT WHY, AND MY CRUISE CONTROL DOES NOT WORK. *AK

SERVICE BRAKES, HYDRAULIC

PROBLEMS WITH RUBBER HOSE, RUST AND CORROSION TO THE METALLIC BRAKE LINES.*MR *CB

ENGINE AND ENGINE COOLING

CONSUMER STATES THERE IS A PROBLEM ,WHILE DRIVING THE VEHICLE SHUT DOWN, FORCING THE CONSUMER TO PULL OUT OF THE ROAD. *AK

AIR BAGS

INVOLVED IN AUTOMOBILE ACCIDENT IN LEXINGTON KY APPROXIMATE SPEED AT 20 MPH CRASHED THE FRONT OF VEHICLE AND THE AIRBAGS DID NOT DEPLOYED FRONT OF VEHICLE SUSTAINED MAJOR DAMAGE. *NLM