1991 Ford Ranger

1991 Ford Ranger 2-DR. 4x4

Overall

Not Rated

Front Crash

Not Rated

Side Crash

Not Rated

Rollover

Not Rated

EXTERIOR LIGHTING

CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Campaign: 06E026000

TIRES:TREAD/BELT

TIRE DESCRIPTION: FIRESTONE WILDERNESS AT, SIZE P235/75R15, PRODUCED AT THE DECATUR, ILLINOIS TIRE PLANT AND ALL FIRESTONE RADIAL ATX AND RADIAL ATX II TIRES, SIZE P235/75R15. OPERATION OF THESE TIRES AT LOW INFLATION PRESSURES, HIGH SPEED, AND IN HOT WEATHER, CAN CONTRIBUTE TO SEPARATION OF THE TIRE TREAD.

Campaign: 00T005000

TIRES:TREAD/BELT

THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. EQUIPMENT DESCRIPTION: FORD IS REPLACING ALL FIRESTONE WILDERNESS AT 15, 16, AND 17 INCH TIRES MOUNTED ON FORD TRUCKS AND SUVS. FORD REPORTS TREAD SEPARATION CAN OCCUR DUE TO A COMBINATION OF THE SENSITIVITY OF THE TIRE DESIGN TO STRESS, AGING, AND MANUFACTURING DIFFERENCES BETWEEN PLANTS. FORD IS REPLACING THESE TIRES TO PREVENT POSSIBLE PREMATURE TIRE FAILURE. VEHICLE DESCRIPTION: THE VEHICLES LISTED BELOW MAY HAVE BEEN ORIGINALLY EQUIPPED WITH FIRESTONE WILDERNESS AT TIRES OR MAY HAVE HAD WILDERNESS AT TIRES INSTALLED DURING THE FIRESTONE RECALL LAUNCHED IN AUGUST 2000. CERTAIN 1991 THROUGHT 2002 FORD EXPLORER CERTAIN 2001 THROUGHT 2002 EXPLORER SPORT, AND SPORT TRAC CERTAIN 1997 THROUGH 2002 MERCURY MOUNTAINEER CERTAIN 1991 THROUGH 2001 RANGER CERTAIN 1999 THROUGH 2001 EXPEDITION CERTAIN 1991 THROUGH 1994, AND 1997 MODEL YEAR F-SERIES CERTAIN 1991 THROUGH 1994 BRONCO NOTE: BOTH ORIGINAL EQUIPMENT AND REPLACEMENT TIRES ARE AFFECTED.

Campaign: 01X001000

SERVICE BRAKES, HYDRAULIC:POWER ASSIST:HYDRAULIC

THE STUDS WHICH ATTACH THE BRAKE MASTER CYLINDER TO THE POWER BRAKE VACUUM BOOSTER ASSEMBLY CAN DEVELOP STRESS CORROSION CRACKING AFTER BEING OPERATED FOR AN EXTENDED PERIOD OF TIME IN THE SOUTHERN CALIFORNIA LOCATION.

Campaign: 96V024001

POWER TRAIN:AUTOMATIC TRANSMISSION

WHEN THE AUTOMATIC TRANSMISSION SHIFT LEVER IS PLACED IN THE PARK POSITION, THE PARK PAWL DOES NOT ALWAYS ABUT OR ENGAGE THE PARK GEAR.

Campaign: 91V189000

SERVICE BRAKES, AIR:DISC:ROTOR

EQUIPMENT DESCRIPTION: AFTERMARKET BRAKE ROTORS FOR USE ON CERTAIN FORD AND MAZDA TRUCKS. CRACKED CASTINGS CAUSED CRACKS TO APPEAR ON THE OUTER DIAMETER OF THE ROTOR HAT OR AROUND THE STUD HOLE.

Campaign: 98E010000

ENGINE AND ENGINE COOLING,ELECTRICAL SYSTEM

TL* THE CONTACT OWNED A 1991 FORD RANGER. THE CONTACT STATED THAT THE VEHICLE WAS PARKED WHEN IT CAUGHT ON FIRE. THE FIRE DEPARTMENT WAS NOTIFIED AND NO INJURIES WERE REPORTED AT THE SCENE. THE VEHICLE WAS DESTROYED. THE DEALER WAS NOT NOTIFIED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE AND CURRENT MILEAGES WERE 150,000. UPDATED 8/23/12 *CN

SUSPENSION

TL* THE CONTACT OWNS A 1991 FORD RANGER. THE CONTACT NOTICED THAT THE FRONT PASSENGER SIDE OF THE VEHICLE HAD DROPPED APPROXIMATELY FIVE INCHES FROM THE REGULAR POSITION AND THE FRONT FENDER WAS COVERING THE TOP OF THE FRONT PASSENGER SIDE TIRE. THE VEHICLE WAS NOT TAKEN TO A DEALER FOR DIAGNOSTICS. AN INDEPENDENT MECHANIC INSPECTED THE VEHICLE AND NOTICED THAT THE PASSENGER SIDE COIL SPRING MOUNT WAS CORRODED AND NEEDED TO BE REPLACED. THE CONTACT STATED THAT A LOCAL AUTO SHOP WAS CONTACTED AND ADVISED THAT THE PART WAS NO LONGER AVAILABLE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 65,000.

FUEL SYSTEM, GASOLINE

TL* THE CONTACT OWNS A 1991 FORD RANGER. THE CONTACT STATED THAT THE FUEL TANK STRAP BECAME CORRODED AND WAS PARTIALLY FRACTURED FROM THE VEHICLE. THE CONTACT WAS CONCERNED THAT IT WOULD CAUSE THE FUEL TANK TO DETACH. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO STATED THAT THE STRAP WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT CALLED THE MANUFACTURER WHO ADVISED THAT THERE WERE NO RELATED RECALLS TO THE FAILURE AND PROVIDED NO FURTHER ASSISTANCE. THE CURRENT MILEAGE WAS APPROXIMATELY 142,800 AND THE FAILURE MILEAGE WAS APPROXIMATELY 100,000.

STRUCTURE

THE FRAME HAS HORRIBLE CORROSION. ALL THE SPRING HANGERS ARE WERE FAILING BAD. I DON'T EVEN THINK IT CAN BE WELDED BECAUSE IT IS RUSTED FROM ONE END TO ANOTHER. FORD REALLY MESSED THIS ONE UP. AND WHY DO ALL THE FUEL GAUGES QUIT WORKING? *TR

STRUCTURE

PEELING FACTORY PAINT PRIMARILY ON TOP SURFACES..I.E. HOOD, CAB ROOF, COWLING. I HAVE OWNED TRUCK SINCE 12/8/99 AND HAS HAD PROBLEM SINCE,IT HAS LOST NEARLY ALL PAINT ON ROOF , HOOD HAS ABOUT 1/3 LEFT. PRIMARILY LIFTS/PEELS WHEN WASHED OR WHEN LEFT OUT IN RAIN. HAS HAD BITS PEEL BACK AT HIGHWAY SPEEDS. MAINLY OCCURS THOUGH WITH WASHING. HAVE INQUIRED WITH DEALERS TO NO AVAIL. WAS TOLD BY ONE THAT THERE WAS A RECALL BUT THAT THE PERIOD FOR REPAIR OF CONDITION HAD PASSED. I HAVE NOT RECEIVED NOR HEARD ANYTHING FROM MFR REGARDING THIS ISSUE WHATSOEVER. *TR

ENGINE AND ENGINE COOLING

TL*THE CONTACT OWNS A 1991 FORD RANGER. WHILE DRIVING 5 MPH WITH THE DEFROSTER ACTIVATED, THE VEHICLE BEGAN TO SMOKE. THE CONTACT PULLED THE VEHICLE OVER AND NOTICED FLAMES UNDER THE HOOD. THE FIRE DEPARTMENT WAS CALLED AND STATED THAT THERE WAS A FAULTY WIRE UNDER THE HOOD THAT CAUSED THE FIRE. PRIOR TO THE FAILURE, THE CLUTCH AND POWER STEERING WERE REPAIRED AND THE GAS LINE WAS CLEANED. THE VEHICLE HAS NOT BEEN TAKEN TO A DEALER OR MECHANIC. A POLICE REPORT WAS FILED. THE CURRENT AND FAILURE MILEAGES WERE 100,000. UPDATED 062909 *BF UPDATED 07/01/09

SUSPENSION

THE CONSUMER MADE CONTACT WITH THE MANUFACTURE FOR THE FRONT END SUSPENSION PART THAT WAS DISCONTINUED. *JB

VISIBILITY

BOTH MIRRORS FOLDED UP AGAINST THE VEHICLE WHEN DRIVING. DRIVER'S SIDE WAS REPLACED THREE TIMES, AND THE PASSENGER'S SIDE TWICE. HOWEVER, DRIVER'S SIDE MIRROR MALFUNCTIONED AGAIN. *AK TRUCK IS IN GARAGE FROM 11-1 TOMAY 1. AND I STIKK ONLY GET1 YEAR TO 18 MONTHS PER MIRROR. I REALIZE THE VEHICLE IS 13 YEARS OLD AND REDESIGNING THE MIRROR IS NOT ANOPTION. HOWEVER, FORD MOTOR CORP SURELY COULD DO SOMETHING ABOUT THE PRICE! RETAIL IS CLOSRE TO $7500 PER PIECE. I KNOW REDESIGNING IS OUT OF QUESTION, BUT FOR THOSE OF US THAT INTEND ON KEEPING OUR VEHICLES, THE COMPANY COULD REDUCE THE PRICE. *AK

STRUCTURE

CONSUMER STATES THAT HIS MOTOR MOUNTS ARE RUSTING RIGHT OUT FROM THE FRAME. HE STATES HE HAS NEVER SEEN ANYTHING LIKE IT. HE STATES HE HAS NOT SEEN A RECALL FOR THIS PROBLEM, BUT HE DOES NOT THINK THIS IS NORMAL. *NM

SUSPENSION

RIGHT FRONT SPRING BRACKET RUSTED THROUGH ALLOWING BODY TO DROP ONTO FRONT TIRE, AND I NOTICED THERE ARE A LOT OF COMPLAINTS ON THIS ISSUE AND WAS WANTING TO KNOW IS FORD GOING TO FIX THIS PROBLEM OR ARE WE THE PUBLIC GOING TO GET STUCK WITH THIS PROBLEM ? *JB