1993 Ford Ranger

1993 Ford Ranger 2-DR.

Overall

Not Rated

Front Crash

Not Rated

Side Crash

Not Rated

Rollover

Not Rated

EXTERIOR LIGHTING:HEADLIGHTS

DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Campaign: 09E025000

EXTERIOR LIGHTING:HEADLIGHTS

K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."

Campaign: 08E050000

EXTERIOR LIGHTING

SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Campaign: 09E012000

EXTERIOR LIGHTING

CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Campaign: 06E026000

TIRES:TREAD/BELT

TIRE DESCRIPTION: FIRESTONE WILDERNESS AT, SIZE P235/75R15, PRODUCED AT THE DECATUR, ILLINOIS TIRE PLANT AND ALL FIRESTONE RADIAL ATX AND RADIAL ATX II TIRES, SIZE P235/75R15. OPERATION OF THESE TIRES AT LOW INFLATION PRESSURES, HIGH SPEED, AND IN HOT WEATHER, CAN CONTRIBUTE TO SEPARATION OF THE TIRE TREAD.

Campaign: 00T005000

TIRES:TREAD/BELT

THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. EQUIPMENT DESCRIPTION: FORD IS REPLACING ALL FIRESTONE WILDERNESS AT 15, 16, AND 17 INCH TIRES MOUNTED ON FORD TRUCKS AND SUVS. FORD REPORTS TREAD SEPARATION CAN OCCUR DUE TO A COMBINATION OF THE SENSITIVITY OF THE TIRE DESIGN TO STRESS, AGING, AND MANUFACTURING DIFFERENCES BETWEEN PLANTS. FORD IS REPLACING THESE TIRES TO PREVENT POSSIBLE PREMATURE TIRE FAILURE. VEHICLE DESCRIPTION: THE VEHICLES LISTED BELOW MAY HAVE BEEN ORIGINALLY EQUIPPED WITH FIRESTONE WILDERNESS AT TIRES OR MAY HAVE HAD WILDERNESS AT TIRES INSTALLED DURING THE FIRESTONE RECALL LAUNCHED IN AUGUST 2000. CERTAIN 1991 THROUGHT 2002 FORD EXPLORER CERTAIN 2001 THROUGHT 2002 EXPLORER SPORT, AND SPORT TRAC CERTAIN 1997 THROUGH 2002 MERCURY MOUNTAINEER CERTAIN 1991 THROUGH 2001 RANGER CERTAIN 1999 THROUGH 2001 EXPEDITION CERTAIN 1991 THROUGH 1994, AND 1997 MODEL YEAR F-SERIES CERTAIN 1991 THROUGH 1994 BRONCO NOTE: BOTH ORIGINAL EQUIPMENT AND REPLACEMENT TIRES ARE AFFECTED.

Campaign: 01X001000

SERVICE BRAKES, HYDRAULIC:POWER ASSIST:HYDRAULIC

THE STUDS WHICH ATTACH THE BRAKE MASTER CYLINDER TO THE POWER BRAKE VACUUM BOOSTER ASSEMBLY CAN DEVELOP STRESS CORROSION CRACKING AFTER BEING OPERATED FOR AN EXTENDED PERIOD OF TIME IN THE SOUTHERN CALIFORNIA LOCATION.

Campaign: 96V024001

PARKING BRAKE:CONVENTIONAL

THE PARKING BRAKE CONTROL SELF-ADJUST PAWL DOES NOT LINE UP PROPERLY WITH THE SELF-ADJUST RACHET CAUSING THE PAWL TO SLIP OVER ONE OR MORE TEETH IN THE RACHET.

Campaign: 94V169001

VEHICLE SPEED CONTROL

DURING EXTREME COLD, NORTHERN CLIMATE WINTER CONDITIONS, ICE CAN FORM IN THE THROTTLE BODY OF THE ENGINE CAUSING THE THROTTLE PLATE TO REMAIN IN THE HIGHWAY CRUISING POSITION AFTER THE ACCELERATOR IS RELEASED OR THE SPEED CONTROL IS DEACTIVATED.

Campaign: 95V231001

SERVICE BRAKES, AIR:DISC:ROTOR

EQUIPMENT DESCRIPTION: AFTERMARKET BRAKE ROTORS FOR USE ON CERTAIN FORD AND MAZDA TRUCKS. CRACKED CASTINGS CAUSED CRACKS TO APPEAR ON THE OUTER DIAMETER OF THE ROTOR HAT OR AROUND THE STUD HOLE.

Campaign: 98E010000

POWER TRAIN,VEHICLE SPEED CONTROL,ENGINE

THROTTLE STUCK AT HIGH RPMS AND GAS PEDAL STUCK TO THE FLOOR HAD TO TURN OFF THE IGNITION BEFORE IT BLEW UP MY TRUCK. THIS WAS SUPPOSED TO HAVE BEEN REPAIRED IN JANUARY BY FORD IN VENTURA AND NOW IT IS HAPPENING AGAIN THIS HAS HAPPENED TO SO MANY RANGERS AND ONE OF US OWNERS OF WILL WIND UP KILLED. FIX THIS PLEASE

POWER TRAIN,FUEL/PROPULSION SYSTEM

GAS TANK CRACKED AT 86000 MILES CAN'T HOLD MORE THEN HALF A TANK. TRANSMISSION WEARING OUT AND DRIVEN LIGHTLY NEVER USED THE BED OF TRUCK TO CARRY THINGS MAINLY FREEWAY MILES

SUSPENSION,STRUCTURE

HOW CAN THE FRAME OF MY TRUCK RUST OUT FASTER THAN THE BED OR CAB. THE CAB MOUNTS ARE GONE. THE SHACKLES OF THE LEAF SPRINGS ARE PAPER THIN AND READY TO COLLAPSE. WHEN I DRIVE DOWN THE ROAD AND HIT A BUMP IT SOUNDS LIKE THE CAB IS GOING FALL TO THE GROUND. I AM AFRAID ONE OF THESE DAYS , I'LL GET IN AN ACCIDENT AND THE ENTIRE CAB IS GOING TO FLY OFF THE TRUCK. THE MOTOR HAS OUTLASTED THE FRAME. MAKE LAUGH.

SUSPENSION

1993 FORD RANGER SEVERE FRAME / SUSPENSION RUST. ON THE REAR LEAF SPRING HAVE HAD TO REPLACE FRONT AND REAR HANGERS / SHACKLES. THE OEM ONES RUSTED COMPLETELY THROUGH AND LET THE LEAF SPRINGS BREAK LOOSE. ONLY CONTACT WAS ON THE SPRING EYELET HITTING THE BOTTOM FOR THE TRUCK BED. HAVE ALSO HAD TO REPLACE THE CAB MOUNTS, ALSO RUSTED COMPLETELY THROUGH SO THAT THE REAR OF THE CAB WAS SITTING ON THE FRAME. THE FRAME IS ALSO SHOWING SEVERE CORROSION. THE FARTHER BACK THE WORSE IT IS.

STEERING

TL* THE CONTACT OWNS A 1993 FORD RANGER. THE CONTACT STATED THAT WHILE THE VEHICLE WAS BEING SERVICED, THE MECHANIC NOTICED THAT THE STEERING COUPLER WAS FRACTURED IN MULTIPLE PLACES AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 176,000.

VEHICLE SPEED CONTROL

THE GOVERNOR FOR THE 90 MPH GOVERNOR WAS RECALLED BY THE CONSUMER AGENCY RESPONSIBLE FOR RECALLS. THE PROBLEM WAS THAT IT WAS A POTENTIAL FIRE HAZARD. I CALLED UPON FORD SEVERAL TIMES OVER A PERIOD OF YEARS, AS WELL AS WENT BY THE FORD SHOP AND WAS TOLD THAT IT WAS NOT PERTAINING TO MY 1993 FORD RANGER. NOT UNTIL AFTER THE TRUCK BROKE AND WOULD NOT SHIFT DID FORD PRETEND TO FIX THE PROBLEM AS A RECALL, BUT, ALSO CHARGED 1000 DOLLARS. THE TRUCK DID NOT FILL LIKE IT WAS FIXED PROPERLY I APPROACHED THE LANDERS FORD COLLIERVILLE OF COLLIERVILLE TENNESSEE AND HE STATED IT WAS FIXED. THEY THEN TRIED TO SELL ME ANOTHER TRUCK. ANY WAY THE TRUCK DID NOT GO ANOTHER 500 MILES BEFORE BREAKING AND GETTING REAR ACCIDENT BY A HIT AND RUN DRIVER. FORD TOOK MY 1000 DOLLARS AND DID NOT FIX MY TRUCK AND ARE STILL IGNORANT TO THE DAY ABOUT MY TRUCK AND RECALL. I AM A COMMERCIAL TRUCK DRIVER AND IN THE PERIOD OF 11 YEARS HAVE NOT PUT BUT 57000 MILES AND DO NOT NEED A NEW TRUCK FROM FORD THEN OR NOW OR EVER WITH SUCH BUSINESS TACTICS. *TR

TIRES

TL* THE CONTACT OWNS A 1993 FORD RANGER WITH FIRESTONE TIRES, SIZE: P225/70/R14. THE CONTACT STATED THAT WHILE DRIVING 70 MPH, THE REAR DRIVER SIDE TIRE TREAD SEPARATED FROM THE TIRE, CAUSING THE CONTACT TO CRASH INTO A HIGHWAY DIVIDER. THE CONTACT STATED THAT THE VEHICLE WAS DESTROYED AND THE CONTACT SUSTAINED INJURIES. A POLICE REPORT WAS FILED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 93,000. THE VIN WAS UNAVAILABLE.

POWER TRAIN

WAS DRIVING AROUND 50 TO 55 MPH WHEN I SEEN SMOKE COMING FROM TRUCK SO I PULLED OVER TO SEE WHAT WAS WRONG AND SEEN TRANSMISSION FLUID POURING OUT OF TRANSMISSION ONTO EXHAUST PIPE THIS HAS HAPPEN TWICE NOW DON,T KNOW WHY COMING FROM FRONT OF TRANSMISSION AUTO 3.0 ENGINE ONLY WHEN I KICK IT IN OVERDRIVE IT HAPPENS. *TR

STRUCTURE

THE FRAME HAS RUSTED UNTIL THE TRUCK IS NO LONGER DRIVABLE. IT IS FOUR WHEEL DRIVE AND I HAVE ALREADY REPLACED THE REAR SPRING SHACKLES WHEN THEY RUSTED OUT IN 2006. I BOLTED A PIECE OF ANGLE TO THE TRANSMISSION SUPPORT TO REPAIR IT AFTER IT RUSTED INTO AND DROPPED THE TRANSMISSIOM AND TWISTED THE DRIVE SHAFT INTO WHILE DRIVING DOWN THE ROAD I TOOK IT UP ON 2/9/2012 TO GET A NEW EXHAUST PUT ON IT AND AND GOT A CALL FROM THE SERVICE GARAGE TO COME LOOK AT THE UNDER CARRAIGE OF THE TRUCK. THE BED HAS A RUSTED OUT SUPPORT, THE TRANSMISSION SUPPORT CROSSMEMBER IS RUSTED INTO ON THE OTHER SIDE FROM WHERE I REPAIRED IT BEFORE AND THE FRONT SUPPORT CROSSMEMBER UNDER THE RADIATOR IS RUSTED OUT. THE SUPPORT FOR THE SPARE TIRE RUSTER OUT YEARS AGO. THE ENGINE AND DRIVE TRAIN WORK GREAT BUT THE TRUCK IS SCRAP NOW BECAUSE THERE IS NOTHING LEFT OF THE FRAME AND BODY SUPPORTS. *TR

SERVICE BRAKES, HYDRAULIC,POWER TRAIN,STRUCTURE

ON MY 1993 FORD RANGER,MY BRAKE & CLUTCH MOUNTING BRACKET FAILED DUE TO STRESS FRACTURE OF WELDS. THIS CAUSED LOSE OF BRAKES AND USE OF CLUTCH. FORD HAS A RECALL ON FAILURE OF STUDS ON THE POWER BRAKE BOOSTER THAT IS MOUNTED ON THIS BRACKET, BUT NOTHING ON THE FAILURE OF THE BRACKET. *TR