2003 Ford Ranger

2003 Ford Ranger Regular Cab

Overall

Not Rated

Front Crash

Not Rated

Side Crash

Not Rated

Rollover

★★☆☆☆

2003 Ford Ranger Supercab

Overall

Not Rated

Front Crash

Not Rated

Side Crash

Not Rated

Rollover

★★☆☆☆

EXTERIOR LIGHTING

CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Campaign: 06E049000

EXTERIOR LIGHTING:HEADLIGHTS

DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Campaign: 09E025000

VEHICLE SPEED CONTROL

FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.

Campaign: 09V399000

EXTERIOR LIGHTING

SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Campaign: 09E012000

EXTERIOR LIGHTING

CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Campaign: 06E065000

POWER TRAIN

Ford knows about the problems with the dual clutch and they are refusing to fix them. I have been giving the run around om trying to get my car fixed. I am a disabled veteran and all I get is they can't help. I just found out about these cars have this problem and ford has know about his problem for years.. they need to fix this. They again to be held according selling bad products to the public.

STRUCTURE,WHEELS,SERVICE BRAKES

Truck has no spare tire, totally missing the assembly and bracket originally used to hold the tire (have a junk one in the bed). The crossmember under the truck is about 50% intact is getting ready to fall off. Brake lines and rocker panals rotted out as well. Holes in the frame starting and a patch was already needed on the frame (drivers side rear). As well as a loose bed. The truck is very clean on top but underneath is rotting away like it has 200000 miles on it(truck is at 77,000). I want to remove the rust and coat it but im scared of punching through cause spots are brittle.

SUSPENSION,STRUCTURE

The frame of my truck has rotted through. The strap that holds the gas tank has nothing to connect to, i think the tank could fall to the ground under the right circumstances. The frame has a large whole in it and i fear it will break very soon. I had to remove the spare tire because i feared it would fall off the truck. I had to replace both connectors that held the leaf springs to the frame,and was told there wasn't much left to connect them to.

ELECTRICAL SYSTEM,AIR BAGS,UNKNOWN OR OTHER

Airbag warning light always on.

STRUCTURE

The contact owns a 2003 Ford Ranger. The contact stated that while driving at 65 MPH, an abnormal, rattling noise began to emit from the rear of the vehicle without warning. Upon inspection, the contact discovered that the rear cross members had rotted out due to severe corrosion. The contact also stated that the fuel tank was no longer being supported due to the failure. An independent mechanic inspected the vehicle and deemed the vehicle unsafe to drive. The dealer nor the manufacturer had yet to be notified of the failure. The vehicle had yet to be repaired. The failure mileage was approximately 79,000.

SUSPENSION

I had been noticing some squeaking form the rear of my 2003 Ford Ranger. I thought it was my breaks. It turned out that the mounts for the rear springs had rusted out. My mechanic also noticed a hole, in the frame, resulting from rust. The hole is located on the inside surface of the frame on the passenger side just forward of the passenger compartment. Since the hole was discovered I stopped using the Ranger due to safety concerns.

STRUCTURE

THE CONTACT OWNS A 2003 FORD RANGER. THE CONTACT STATED WHILE HER HUSBAND WAS DRIVING AT AN UNDISCLOSED SPEED, THE SPARE TIRE DETACHED FROM UNDERNEATH THE VEHICLE. THE VEHICLE WAS DRIVEN BACK TO THE RESIDENCE AND INSPECTED. THE DRIVER NOTICED THAT THE UNDERCARRIAGE AND SUB-FRAME WERE SEVERELY CORRODED. THE CONTACT TOOK THE VEHICLE TO THE LOCAL DEALER TO BE DIAGNOSED. THE MECHANIC STATED THAT THE SUB-FRAME HAD RUSTED OUT AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT YET REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 131,000

ENGINE,FUEL/PROPULSION SYSTEM

WHEN AT STOP LIGHT ENGINE RPMS GO UP HIGH WHERE IT IS HARD TO HOLD VEHICLE STILL WITH BRAKES.

SUSPENSION,ELECTRICAL SYSTEM,STRUCTURE

BODY, FRAME AND SUSPENSION HAVE ALL BEEN RUSTED OUT. BUMPER RECENTLY JUST FELL OFF DUE TO RUST (WHILE PARKED). DOORS WON'T SHUT COMPLETELY DUE TO RUST, WHICH HAS LED TO THE INTERIOR LIGHT REMAINING ON OR PERIODICALLY TURNING ON THROUGHOUT THE DAY/NIGHT AND KILLING THE BATTERY. ENTIRE TRUCK IS ONE BIG PILE OF RUST ON WHEELS.

SUSPENSION

CHASSIS ROTTING OUT. LOST SPARE TIRE CARRIER AND REAR FRAME SUPPORT. SPRING PERCH ROTTED OFF CHASSIS. OTHER AREAS ARE BEGINNING TO ROT OUT ON FRAME RAILS! THINGS CAME APART IN MOTION BUT WAS ABLE TO SAFELY REMOVE UPON STOPPING