1991 Ford Thunderbird

1991 Ford Thunderbird 2-DR.

Overall

Not Rated

Front Crash

Not Rated

Side Crash

Not Rated

Rollover

Not Rated

EXTERIOR LIGHTING

SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Campaign: 09E012000

POWER TRAIN:AUTOMATIC TRANSMISSION

THE PARK ROD ASSEMBLY CONTAINS A PARK CAM WITH INADEQUATE SURFACE HARDNESS, WHICH COULD LEAD TO PARK DISENGAGEMENT OR NO PARK ENGAGEMENT WHEN THE LEVER IS PLACED IN PARK.

Campaign: 91V048000

VISIBILITY:WINDSHIELD WIPER/WASHER:MOTOR

THE NUTS WHICH HOLD WINDSHIELD WIPER MOTOR TO THE WIPER MODULE MAY NOT HAVE BEEN SUFFICIENTLY TIGHTENED AND MAY LOOSEN OR COME OFF. THIS CAUSES CHANGED WIPER PATTERNS, OR THE WIPERS MAY JAM IF TWO OF THE THREE NUTS COME OFF.

Campaign: 91V076000

ELECTRICAL SYSTEM:IGNITION

THE IGNITION SWITCH COULD EXPERIENCE AN INTERNAL SHORT CIRCUIT.

Campaign: 96V071000

SERVICE BRAKES

LOSS OF HYDRAULIC BRAKE ASSIST ON SUPER COUPE. PEDAL BECAME HARD TO PRESS. BOTH BRAKE AND ABS ANNUNCIATORS ILLUMINATING. TROUBLESHOOTING INDICATES BRAKE PRESSURE SWITCH FAILING TO SIGNAL PUMP TO CHARGE SYSTEM OR ACCUMULATOR HAS FAILED. MASTER CYLINDER AND ABS SYSTEM ARE ORIGINAL EQUIPMENT AND THUS 24 YEARS OLD.

VEHICLE SPEED CONTROL

CRUISE CONTROL STOPPED WORKING. *TR

VEHICLE SPEED CONTROL

WHILE THE CONSUMER WAS DRIVING ON THE HIGHWAY THE ACCELERATOR BECAME STRUCK. AS A RESULT THE VEHICLE CONTINUED TO ACCELERATE UNTIL THE BRAKE PEDAL AND EMERGENCY BRAKE WERE APPLIED. *AK *NM

EXTERIOR LIGHTING

DEFECTIVE HEADLAMP CIRCUIT BREAKER CAUSES HEADLIGHTS TO FLASH OFF AND ON REPEATEDLY. FIRST FAILURE OCCURRED WHEN CAR WAS 2 YEARS OLD, SECOND FAILURE IN THE LAST YEAR. CAR HAS LESS THAN 57,000 MILES. 1991 SUPERCOUPE MODEL HAS FOGLAMPS AS DO THE 1992 AND LATER THUNDERBIRD MODELS FOR WHICH A RECALL EXISTS.*AK

VISIBILITY

PLASTIC BUSHINGS IN BOTH ENDS OF WINDSHIELD WIPER TIE-ROD COMPONENT HAVE WORN. CAUSES WIPERS TO MOVE LESS, SKIP, AND LOSE ABILITY TO CLEAR ENTIRE WINDSHIELD. TIE-ROD MAY BECOME DISCONNECTED FROM MOTOR END OR FROM WIPER END. CAR HAS LESS THAN 57000 MILES.*AK

STEERING,ENGINE AND ENGINE COOLING

3.8L V6 ENGINE OVER-HEATED DUE TO HEAD GASKET FAILURE IN #4 CYLINDER. BOTH HEADS WERE REWORKED AND GASKETS REPLACED. AFTER REPAIR ENGINE STARTED STALLING. IDLE AIR CONTROL VALVE WAS THEN REPLACED. NOW THERE IS A FLUCTUATION IN OIL PRESSURE. PRIOR TO HEAD GASKET FAILURE, POWER STEERING PUMP HAS TO BE REPLACED.*AK

ENGINE AND ENGINE COOLING

OVERHEATING AT FIRST THEN AFTER THE HEADGASKETS WERE REPLACED THE ROD BEARINGS FAILED WHICH ADDED ANOTHER 1200.00 TO THE 1645.00 OF THE FIRST REPAIR AND THE POWER STEERING PUMP WAS REPLACED AT THE TIME OF THE FIRST REPAIR.

ENGINE AND ENGINE COOLING

HEAD GASKET FAILURE AT 73,000 ON MY 1991 TBIRD WITH THE 3.8 V6. LOOKS LIKE FORD IS TRYING TO COVER THIS UP! *NLM

EXTERIOR LIGHTING

HEADLIGHT FAILURE INTERMITTENT OPERATION. TS

VEHICLE SPEED CONTROL

PART TO REPAIR NOT AVAILABLE. DT