2011 Honda Cr-Z

2011 Honda CR-Z 3 HB FWD

Overall

★★★☆☆

Front Crash

★★★☆☆

Side Crash

★★★☆☆

Rollover

★★★★★

AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE

Honda (American Honda Motor Co.) is recalling certain 2013 Acura ILX, 2015 RDX, 2005-2010 and 2012 RL, 2009-2014 TL, 2010 and 2012 ZDX, 2007-2011 CR-V, 2011-2013 and 2015 CR-Z, 2009-2013 Fit, 2013 Fit EV, 2010-2011 and 2013 Insight and 2007-2014 Ridgeline vehicles. These vehicles are equipped with driver frontal air bag inflators assembled as a recall remedy part or replacement service part, that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.

Campaign: 19V500000

AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE

Honda (American Honda Motor Co.) is recalling certain model year 2007-2011 Honda CR-V, 2011-2015 CR-Z, 2010-2014 FCX, and Insight, 2009-2013 Fit, 2013-2014 Fit EV, 2007-2014 Ridgeline, 2013-2016 Acura ILX, 2013-2014 Acura ILX Hybrid, 2007-2016 RDX, 2005-2012 Acura RL, 2009-2014 Acura TL, and 2010-2013 Acura ZDX vehicles. The affected vehicles are equipped with a dual-stage driver frontal air bag that may be susceptible to moisture intrusion which, over time, could cause the inflator to rupture.

Campaign: 16V061000

POWER TRAIN

HONDA IS RECALLING CERTAIN MODEL YEAR 2011 CR-Z PASSENGER CARS WITH MANUAL TRANSMISSIONS, MANUFACTURED FROM JANUARY 8, 2010, THROUGH JUNE 27, 2011. SHOULD THE ENGINE STALL WHILE THE BRAKE PEDAL IS NOT PRESSED, THERE IS A POSSIBILITY THAT THE ENGINE CONTROL UNIT (ECU) SOFTWARE MAY CAUSE THE ELECTRIC MOTOR OF THE HYBRID SYSTEM TO MOVE THE VEHICLE UNEXPECTEDLY IN THE OPPOSITE DIRECTION OF THE SELECTED GEAR.

Campaign: 11V458000

SUSPENSION,AIR BAGS

I STARTED HEARING A KNOCKING NOISE AT THE REAR OF MY CAR. I TOOK IT TO A REPAIR SHOP AND THEY SAID THAT THE TIE ROD OR END AND THE SUSPENSION SHOCK OR STRUT NEED TO BE REPLACE. CAN YOU CHECK THIS OUT FOR ME SO I WILL BE SAFE DRIVING IT. THANK YOU

VISIBILITY

The contact owns a 2011 Honda CR-Z. The contact stated that while the vehicle was parked, the trunk was opened and the windshield unexpectedly shattered. There was no impact to the windshield to cause the failure. The vehicle was not taken to be inspected or repaired. The manufacturer was informed of the failure. The failure mileage was 155,000.

POWER TRAIN

The contact owns a 2011 Honda CR-Z. The contact stated that while driving at an undisclosed speed, the vehicle lost motive power. The vehicle was towed to the dealer, who repaired the front axle. The contact related the failure to NHTSA Campaign Number: 12V256000 (Power Train) however, the VIN was not included. The manufacturer was made aware of the failure. The failure mileage was approximately 180,000. The VIN was not available.

AIR BAGS,VEHICLE SPEED CONTROL

Air bag light and speed gage are unreliable.

STEERING

On February 15 I took a short drive into Woodstock, Vt. My trip into Woodstock was without incident, except for the fact that I got a "check tire pressure" alert, probably due to the very cold weather. When I finished my business and restarted the car, there was an additional alert: "check power steering". The car previously had no issues with steering. I drove the car to another nearby parking spot. There was no power assist at all. I wrestled the car into the parking space and called AAA for a tow. The tow truck driver arrived in about an hour. He asked for the keys and started the car. The problem had disappeared. With a friend tailing me I drove to a nearby auto repair shop, asked them to investigate and told them I would pick the car up the next day. They called me the next day and informed me that they had connected the car to the computer analyzer and found no problem. They had also driven the car on the day I dropped it off and again the next day and were unable to reproduce the problem. I went online and discovered others have had similar issues: https://www.crzforum.com/threads/scary-power-steering-eps-issue.87738/ and https://www.carcomplaints.com/Honda/CR-Z/2011/steering/steering.shtml. I contacted my nearest Honda dealership as well as Honda USA. I received no substantive help from either party, although Honda USA did suggest I bring it to the dealer for repair, which I will attempt to do tomorrow. I don't know what the threshold is for generating a recall, but the possible consequences of this problem are so serious that I wanted to share my experience. My car has less than 30,000 miles.

POWER TRAIN

As I was pulling away from a stop sign, the right-hand CV shaft snapped in the middle. Fortunately, I had just enough speed to coast into a parking lot, so I was not a traffic obstacle. On closer inspection, the failure occurred underneath the rubber/metal dynamic damper clamped to the center of the CV shaft. It looks like the dynamic damper was not adequately sealed and trapped salt and water until enough corrosion happened, causing the failure of the CV shaft.

STEERING,POWER TRAIN,ELECTRICAL SYSTEM

2011 CR-Z PASSENGER CARS WITH AUTOMATIC TRANSMISSIONS THE ENGINE STALL WHILE THE BRAKE PEDAL IS NOT PRESSED, THERE IS A POSSIBILITY THAT THE ENGINE CONTROL UNIT (ECU) SOFTWARE MAY CAUSE THE ELECTRIC MOTOR OF THE HYBRID SYSTEM TO MOVE THE VEHICLE UNEXPECTEDLY IN THE OPPOSITE DIRECTION OF THE SELECTED GEAR. ADDITIONALLY THE ELECTRIC POWER STEERING IS DRAINING NEW 12V BATTERIES WITH LESS THAN A 6 MONTHS USE (SEE ATTACHMENT). VEHICLE MOVEMENT CAUSED BY ENGINE STALL AND LACK OF POWER STEERING COULD INCREASE THE RISK OF A CRASH OR PERSONAL INJURY TO THE PERSONS IN THE PATH OF THE MOVING VEHICLE. THERE HAS ALREADY BEEN A RECALL ON 2011 HONDA CRZ MANUAL TRANS FOR THE ISSUE MENTIONED ABOVE.

ELECTRICAL SYSTEM,UNKNOWN OR OTHER,ENGINE

ON 09/04/2018 MY HONDA CR-Z IMA LIGHT CAME ON, I TOOK IT TO THE HONDA DEALERSHIP THEY SAID THEY NEVER HAD AN IMA LIGHT COME ON WITHOUT THE CHECK ENGINE LIGHT BE ON. THEY TOOK IT FOR DIAGNOSTICS, AND CAME TO THE CONCLUSION THAT MY CLUTCH SENSOR IS BAD AND THAT IS WHATS CAUSING THE IMA LIGHT TO BE ON. THE PERSON WHO I SPOKE TO AT HONDA SAID THAT THEY DIAGNOSE ABOUT FORTY CARS A DAY FOR SEVEN YEARS AND NEVER RAN INTO THAT ISSUE. THEY SAID THAT I WOULD BE GOOD DRIVING IT AND WOULD EXPERIENCE MORE PROBLEMS IN ABOUT A YEAR IF I DON'T FIX THE CLUTCH SENSOR ON 9/07/2018 MY CAR HAD A LIGHT COME ON THAT SAID CHECK FUEL CAP WHICH I'M GUESSING MY FUEL SENSOR IS OUT NOW, BUT HONDA IS NO HELP WILL NOT HELP ME OUT CLAIMS THE CAR IS NOT UNDER WARRANTY WHEN IT HAS LESS THAN 100,000 MILES ON IT.THIS CAN BE A BIG SAFETY ISSUE DUE TO THE FACT THAT IF MY IMA BATTERY FAILS ON ME MY LIFE CAN BE IN DANGER ALONG WITH THE OTHERS AROUND ME. ALSO FOR A COMPANY TO CLAIM THEY HAD NEVER RAN INTO THESE ISSUES THEY DO NOT SHOW MUCH INTEREST IN FIXING IT.

STRUCTURE

DRIVER DOOR WILL NO LONGER OPEN FROM OUTSIDE. PROBLEM STARTED WHEN VEHICLE WAS PARKED IN DIRECT SUNLIGHT, THEN GOT WORSE SO THAT THE DOOR WILL NO LONGER OPEN FROM THE OUTSIDE NO MATTER WHAT. USING PASSENGER DOOR NOW TO GET IN, AND IT IS NOW FAILING IN DIRECT SUNLIGHT, AND I EXPECT I WILL SOON NEED TO ENTER THROUGH THE REAR HATCH. ONLINE SEARCH INDICATES THIS IS A COMMON FAILURE ON 2011 HONDA CRZ'S.

ELECTRICAL SYSTEM,STRUCTURE

DOOR LOCKS ON DRIVER AND PASSENGER SIDE WILL NOT LOCK OR UNLOCK WHILE USING INTERIOR DOOR LOCK BUTTON OR KEY FOB. PARKING LIGHTS WILL FLASH WHEN KEY FOB BUTTON IS PRESSED. PROBLEM STARTED WITH PASSENGER DOOR FIRST THEN 2 WEEKS LATER DRIVER DOOR STOPPED. DEALERSHIP DIAGNOSED THE PROBLEM AS FAILED LOCK ACTUATORS.